engine FORD EXPEDITION 1998 1.G Manual PDF

complete refill of Ford
Traction-Lok rear axles.
ENGINE DATA
Engine 4.6L engine 5.4L engine
Cubic inches 281 330
Horsepower 215 @ 4400 rpm 230 @ 4250 rpm
Torque 290 lb. ft. @ 3250 rpm 325 lb. ft. @ 3000 rpm
Required fuel grade 87 octane 87 octane
Firing order 1-3-7-2-6-5-4-8 1-3-7-2-6-5-4-8
Spark plug gap 1.3-1.4 mm
(0.052-.056 inch)1.3-1.4 mm
(0.052-.056 inch)
Ignition system EDIS Coil on plug
Compression ratio 9.0:1 9.0:1
VEHICLE DIMENSIONS
Dimensions mm (in.)
(1) Overall length 5 196 (204.6)
(2) Overall width 2 027 (79.8)
(3) Maximum height 4x2/4x4 1 969.8 (77.6)/2 043 (80.4)
(4) Wheelbase 3 023 (119.0)
(5) Front track 1 661 (65.4)
Capacities and specifications
204

IDENTIFYING YOUR VEHICLE
Safety compliance label
The National Highway Traffic
Safety Administration Regulations
require that a Safety Compliance
Certification Label be affixed to a
vehicle and prescribe where the
Safety Compliance Certification
Label may be located. The Safety
Compliance Certification Label is
located on the front door latch
pillar on the driver's side.
Vehicle identification number
The vehicle identification number
is attached to a metal tag and is
located on the driver side
instrument panel.
Engine number
The engine number (the last eight
numbers of the vehicle
identification number) is stamped
on the engine block, transmission,
frame and transfer case (if so
equipped).
MFD. BY FORD MOTOR CO. IN U.S.A.
EXT PNT: XXXXXX XXXXXX RC: XX DSO: XXXX F0000
BAR INT TR TP/PS R AXLE TR SPR T0000
X XX XXX X XX X XXXX
UTC
ÑFOHT-15294A10-GA
MAXIMUM LOAD=OCCUPANTS + LUGGAGE=XXXKG/XXXXLB
OCCUPANTS: X TOTAL X FR X 2ND X RR OCCUPANTS LUGGAGE
XX XXXKG/XXXXLB
TIRE: XXXX/XXXXX XXX X XXXKG/XXXXLB
PRESSURE (FR) XXX kPa/33 PSI COLD
PRESSURE (RR) XXX kPa/33 PSI COLD
TRAILER TOWING - SEE OWNER GUIDE
DATE: XXXXX GVWR:XXXXX LB/ XXXXX KG
VIN: XXXXXXXXXXXXXXXXX TYPE: XXXXXXXXXXXXXXX FGAWR: XXXXXX/XXXXXXX RGAWR: XXXXXXX/XXXXXXX
THIS VEHICLE CONFORMS TO ALL APPLICABLE FEDERAL
MOTOR VEHICLE SAFETY STANDARDS IN EFFECT ON THE
DATE OF MANUFACTURE SHOWN ABOVE.
XXXXXXXXXXXXXXXXX
AIR BAG
Capacities and specifications
206

Aiming headlamps ....................193
Air bag supplemental restraint
system ..........................................78
and child safety seats ..............80
description ................................79
disposal ......................................83
indicator light ...........................82
passenger air bag .....................81
Air cleaner filter .......................170
Air conditioning
auxiliary heater and air
conditioner ................................29
manual heating and air
conditioning system ..23,24,26,28
Air suspension
description ..............................102
warning light .............................11
Ambulance packages ....................3
Anti-lock brake system (ABS)
description ................................99
Battery .......................................168
voltage gauge ............................16
Brake fluid
checking and adding ..............157
Brakes ..........................................98
anti-lock .....................................98
anti-lock brake system (ABS)
warning light .............................99
fluid, checking and adding ....157
Brake-shift interlock .................104
Break-in period .............................2
Bulbs, replacing ........................186
headlamps ...............................187
rear lamps ........................191,192
Changing a tire .........................138
Child safety seats ........................86
Childproof locks ..........................50
Chime
headlamps on ............................13
Cleaning your vehicle ...............194
engine compartment ..............195
fabric ........................................197instrument panel ....................197
plastic parts ............................196
safety belts ..............................197
tail lamps .................................196
washing ....................................194
waxing .....................................194
wheels ......................................195
Compass, electronic ....................42
calibration .................................44
set zone adjustment .................43
Control trac 4WD system .........108
Controls ..................................51,52
Daytime running light system ...20
Defrost
rear window ..............................22
Driving under special
conditions ..................................111
high water ...............................112
slippery roads ..................113,114
Electronic sound system ............52
Emission control system ..........183
Engine ........................................204
check engine temperature
warning, message center .......152
service points ..........................152
Engine block heater ...................96
Engine coolant
checking and adding .......158,159
disposal ....................................161
refill capacities ........................161
Engine oil ...........................153,155
changing oil and oil filter .......156
checking and adding .......153,155
Exhaust fumes ............................96
Fail safe cooling ........................162
Floor mats ...................................53
Foglamps ...................................190
Four-Wheel Drive vehicles
control trac ........................23,108
indicator light ...........................11
special driving
instructions ......................109,110
Index
208

Fuel
calculating fuel economy .......182
improving fuel economy ........126
octane rating ...........................180
quality ......................................180
safety information relating to
automotive fuels .....................177
Fuel gauge ...................................13
Fuel pump shut-off switch .......127
Fuse panels
instrument panel ....................129
power distribution box ....133,137
Fuses ............................128,129,136
Gauges, Mechanical ....................13
engine coolant temperature
gauge .........................................14
Hazard flashers .........................127
Head restraints ...........................63
Headlamps
autolamp system .......................21
flashing ......................................39
high beam .................................39
turning on and off ....................20
Heating ........................................23
High beams
indicator light .............................9
Hood
release lever ............................152
Ignition
positions of the ignition ...........32
Instrument panel
lighting up panel and interior .21
Jump-starting your vehicle 145,147
attaching cables ......................146
disconnecting cables ..............147
Keys
key in ignition chime ...............13
Lamps
interior lamps .........................193
map lamps ...............................193
parking lamps .........................189
Liftgate ........................................53Lights, warning and indicator
air bag ..........................................8
anti-lock brakes (ABS) ..............9
anti-theft ...................................10
brake ............................................9
charging system ........................10
check engine ............................6,7
door ajar ....................................12
engine oil pressure ...................10
four-wheel drive ........................11
fuel reset ................................6,12
safety belt ...................................8
turn signal indicator ...................9
Load limits
trailer towing ..........................117
Lubricant specifications ...........202
Luggage rack .............................126
Message center ......................16,42
english/metric button ...............17
menu button .............................17
Mirrors
automatic dimming rearview
mirror ........................................46
heated ........................................51
side view mirrors (power) .......50
Moon roof ....................................42
Odometer .....................................15
Off road driving, 4-wheel drive 110
Overdrive ................................39,40
Overhead console
compass/temperature display ..40
storage compartment ...............41
Panic alarm feature, remote
entry system ................................56
Parking brake ............................100
Parts (see Motorcraft parts) ....200
Power door locks ........................48
Power steering
fluid, checking and adding ....163
Rear window
wiper ..........................................38
Refill capacities for fluids ........200
Index
209

Recommended fuel Unleaded fuel only - 87 octane
Fuel tank capacity-4x2 without air
suspension98.0L (26 gallons)
Fuel tank capacity-4x2 vehicles
with air suspension and 4x4
vehicles114.0L (30 gallons)
Engine oil (with filter change) Use Motorcraft 5W30 Super
Premium Motor Oil, Ford
Specification WSS-M2C153-G
Tire size and pressure Refer to Tire Pressure Decal on
passenger's door panel
Hood release Pull handle under the left side of
the instrument panel
Oil capacity (with filter change) 5.7L (6.0 quarts)
Coolant capacity 19.7L (20.8 quarts)
Power steering fluid capacity Fill to line in reservoir
Automatic transmission fluid
capacity-4R70W13.1L (13.9 quarts)
Automatic transmission fluid
capacity-E4OD (4x2)15.0L (15.9 quarts)
Automatic transmission fluid
capacity-E4OD (4x4)15.5L (16.4 quarts)
Filling station information
216