clock FORD EXPEDITION 2005 2.G Owner's Manual

easier entry. When a door or the liftgate is opened, the system
memorizes and maintains that height until either all doors are closed or
the vehicle’s speed exceeds 15 mph (24 km/h). The air suspension
system will then raise the vehicle’s height to its normal position when the
ignition is turned on, all doors are closed and the transmission is shifted
from P (Park).
When the vehicle is in motion, the air suspension will adjust the vehicle
ride height to normal operating position to maximize your ride comfort.
If your vehicle is equipped with four-wheel drive and you shift into 4WD
LOW, the air suspension will not move to it’s lowest position; instead, the
ride height is raised above the normal ride height position (at speeds
below 35 mph [56 km/h]) to improve ground clearance.
If a load is added to, or removed from the vehicle, the load leveling
feature of the air suspension system will adjust the suspension to keep
the vehicle at a constant level.
When exiting the vehicle, the air suspension will automatically lower the
vehicle to its lowest height to provide easier exit. You may hear a buzz or
click from the air suspension system when the ignition is turned off. The
air suspension system will stay active for 40 minutes after the ignition is
turned off to accommodate any load changes. (The air compressor may
run when the vehicle is off; this is normal.)
The air suspension shut-off switch is
located behind an access panel on
the left rear quarter trim panel, near
the liftgate. To remove the panel,
turn the control counterclockwise.
On vehicles equipped with
air suspension, turn the air
suspension and the ignition switch
off prior to jacking, hoisting or
towing your vehicle.
REVIEW COPY
2005 Expedition(exd), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Driving
263

2. If the engine oil level is not within the normal range, add only certified
engine oil of the recommended viscosity. Remove the engine oil filler cap
and use a funnel to pour the engine oil into the opening.
3. Recheck the engine oil level. Make sure the oil level is not above the
MAX mark on the engine oil level indicator (dipstick).
4. Install the indicator and ensure it is fully seated.
5. Fully install the engine oil filler cap by turning the filler cap clockwise
1/4 of a turn until the cap is fully seated.
To avoid possible oil loss, DO NOT operate the vehicle with the
engine oil level indicator and/or the engine oil filler cap removed.
Engine oil and filter recommendations
Look for this certification
trademark.
Use SAE 5W-20 engine oil.
Only use oils “Certified For Gasoline Engines” by the American
Petroleum Institute (API). An oil with this trademark symbol conforms
to the current engine and emission system protection standards and fuel
economy requirements of the International Lubricant Standardization and
Approval Committee (ISLAC), comprised of U.S. and Japanese
automobile manufacturers.
To protect your engine’s warranty use Motorcraft SAE 5W-20 or an
equivalent 5W-20 oil meeting Ford specification WSS-M2C930-A.SAE
5W-20 oil provides optimum fuel economy and durability
performance meeting all requirements for your vehicle’s engine.
Do not use supplemental engine oil additives, cleaners or other engine
treatments. They are unnecessary and could lead to engine damage that
is not covered by Ford warranty.
Change your engine oil and filter according to the appropriate schedule
listed in the scheduled maintenance guide.
REVIEW COPY
2005 Expedition(exd), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
326

Because your vehicle’s engine is also electronically controlled by a
computer, some control conditions are maintained by power from the
battery. When the battery is disconnected or a new battery is installed,
the engine must relearn its idle and fuel trim strategy for optimum
driveability and performance. To begin this process:
1. With the vehicle at a complete stop, set the parking brake.
2. Put the gearshift in P (Park), turn off all accessories and start the
engine.
3. Run the engine until it reaches normal operating temperature.
4. Allow the engine to idle for at least one minute.
5. Turn the A/C on and allow the engine to idle for at least one minute.
6. With your foot on the brake pedal and with the A/C on, put the
vehicle in D (Drive) and allow the engine to idle for at least one minute.
7. Drive the vehicle to complete the relearning process.
•The vehicle may need to be driven 10 miles (16 km) or more to
relearn the idle and fuel trim strategy.
•If you do not allow the engine to relearn its idle trim, the idle
quality of your vehicle may be adversely affected until the idle
trim is eventually relearned.
If the battery has been disconnected or a new battery has been installed,
the clock and the preset radio stations must be reset once the battery is
reconnected.
•Always dispose of automotive
batteries in a responsible manner.
Follow your local authorized
standards for disposal. Call your
local authorized recycling center
to find out more about recycling
automotive batteries.
ENGINE COOLANT
Checking engine coolant
The concentration and level of engine coolant should be checked at the
mileage intervals listed in theScheduled Maintenance Guide. The
LEAD
RETURN
RECYCLE
REVIEW COPY
2005 Expedition(exd), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
329

•Do not use alcohol, methanol, brine or any engine coolants
mixed with alcohol or methanol antifreeze (coolant).Alcohol
and other liquids can cause engine damage from overheating or
freezing.
•Do not add extra inhibitors or additives to the coolant.These
can be harmful and compromise the corrosion protection of the engine
coolant.
For vehicles with overflow coolant systems with a non-pressurized cap
on the coolant recovery system, add coolant to the coolant recovery
reservoir when the engine is cool. Add the proper mixture of coolant and
water to the “FULL COLD” level. For all other vehicles which have a
coolant degas system with a pressurized cap, or if it is necessary to
remove the coolant pressure relief cap on the radiator of a vehicle with
an overflow system, follow these steps to add engine coolant.
To reduce the risk of personal injury, make sure the engine is
cool before unscrewing the coolant pressure relief cap. The
cooling system is under pressure; steam and hot liquid can come out
forcefully when the cap is loosened slightly.
1. Before you begin, turn the engine off and let it cool.
2. When the engine is cool, wrap a thick cloth around the coolant
pressure relief cap on the coolant reservoir (a translucent plastic bottle).
Slowly turn cap counterclockwise (left) until pressure begins to release.
3. Step back while the pressure releases.
4. When you are sure that all the pressure has been released, use the
cloth to turn it counterclockwise and remove the cap.
5. Fill the coolant reservoir slowly with the proper coolant mixture (see
above), to within the “COLD FILL RANGE” or the “FULL COLD” level on
the reservoir. If you removed the radiator cap in an overflow system, fill
the radiator until the coolant is visible and radiator is almost full.
6. Replace the cap. Turn until tightly installed. (Cap must be tightly
installed to prevent coolant loss.)
After any coolant has been added, check the coolant concentration (refer
toChecking engine coolant). If the concentration is not 50/50
(protection to –34° F/–36° C), drain some coolant and adjust the
concentration. It may take several drains and additions to obtain a 50/50
coolant concentration.
Whenever coolant has been added, the coolant level in the coolant
reservoir should be checked the next few times you drive the vehicle. If
REVIEW COPY
2005 Expedition(exd), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
332

When refueling always shut the engine off and never allow
sparks or open flames near the filler neck. Never smoke while
refueling. Fuel vapor is extremely hazardous under certain conditions.
Care should be taken to avoid inhaling excess fumes.
The flow of fuel through a fuel pump nozzle can produce static
electricity, which can cause a fire if fuel is pumped into an
ungrounded fuel container.
Use the following guidelines to avoid static build-up when filling an
ungrounded fuel container:
•Place approved fuel container on the ground.
•DO NOT fill a fuel container while it is in the vehicle (including the
cargo area).
•Keep the fuel pump nozzle in contact with the fuel container while
filling.
•DO NOT use a device that would hold the fuel pump handle in the fill
position.
Fuel Filler Cap
Your fuel tank filler cap has an indexed design with a 1/4 turn turn on/off
feature.
When fueling your vehicle:
1. Turn the engine off.
2. Carefully turn the filler cap counterclockwise 1/4 turn of a turn until it
stops.
3. Pull to remove the cap from the fuel filler pipe.
4. To install the cap, align the tabs on the cap with the notches on the
filler pipe.
5. Turn the filler cap clockwise 1/4 turn of a turn until at least one click
is heard.
If ”Check fuel cap” displays in the message center or the ”Service Engine
Soon” indicator (vehicle without message center) comes on and stays on
after you start the engine, the fuel filler cap may not be properly
installed. Turn off the engine, remove the fuel filler cap, align the cap
properly and reinstall it.
If you must replace the fuel filler cap, replace it with a fuel filler
cap that is designed for your vehicle. The customer warranty may
REVIEW COPY
2005 Expedition(exd), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
337

wiper blades ............................317
Climate control (see Air
conditioning or Heating) ............96
Clock adjust
6-CD in dash .............................35
Compass, electronic ..................132
calibration ...............................133
set zone adjustment .......133, 135
Console ......................................145
overhead ..........................116–118
Controls
power seat ...............................164
steering column ......................126
Coolant
checking and adding ..............329
refill capacities ................333, 351
specifications ..................353, 356
Cruise control (see
Speed control) ..........................123
Customer Assistance ................286
Ford accessories for your
vehicle .....................................319
Ford Extended Service Plan .312
Getting assistance outside
the U.S. and Canada ..............313
Getting roadside assistance ...286
Getting the service
you need .................................306
Ordering additional
owner’s literature ...................313
The Dispute Settlement
Board .......................................308
Utilizing the Mediation/
Arbitration Program ...............311
D
Daytime running lamps
(see Lamps) ..............................103Defrost
rear window ............................101
Dipstick
automatic transmission
fluid ..........................................346
engine oil .................................324
Doors
lubricant specifications ..........353
Driveline universal joint and
slip yoke ....................................348
Driving under special
conditions ..................272, 280, 283
sand .........................................282
snow and ice ...........................284
through water .................282, 285
E
Electronic message center .......134
Emergencies, roadside
jump-starting ..........................298
Emission control system ..........343
Engine ........................................356
cleaning ...................................316
coolant .....................................329
fail-safe coolant ......................334
idle speed control ...................327
lubrication specifications ......353,
356
refill capacities ........................351
service points ..........................323
starting after a collision .........287
Engine block heater .................258
Engine oil ..................................324
change oil soon warning,
message center .......................324
checking and adding ..............324
dipstick ....................................324
filter, specifications ........326, 350
REVIEW COPY
2005 Expedition(exd), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Index
363

lighting up panel and
interior .....................................104
J
Jack ............................................220
positioning ...............................220
storage .....................................220
Jump-starting your vehicle ......298
K
Keyless entry system
programming entry code .......156
Keys ...................................157–159
positions of the ignition .........255
L
Lamps
autolamp system .....................102
bulb replacement
specifications chart ................107
daytime running light .............103
fog lamps .................................102
headlamps ...............................102
headlamps, flash to pass ........103
instrument panel, dimming ...104
interior lamps .........105–106, 108
replacing bulbs .......106, 108–111
Lane change indicator
(see Turn signal) ......................105
Liftgate ..............................146, 150
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........260
Limited-slip axle .......................264
Load limits .................................241
Loading instructions .................247Locks
childproof ................................149
doors ........................................148
Lubricant specifications ...353, 356
Lug nuts ....................................227
Lumbar support, seats .............163
M
Message center .........................134
english/metric button .............139
system check button ..............140
warning messages ...................140
Mirrors ...............................116, 121
automatic dimming rearview
mirror ......................................121
fold away .................................123
heated ......................................122
programmable memory ..151, 165
signal .......................................122
Moon roof ..................................117
Motorcraft parts ................339, 350
N
Navigation system .......................56
quick start .................................61
radio functions ..........................62
setting the clock .......................89
O
Octane rating ............................338
Oil (see Engine oil) ..................324
P
Panic alarm feature,
remote entry system ................151
Parking brake ............................261
REVIEW COPY
2005 Expedition(exd), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Index
365

Parts (see Motorcraft parts) ....350
Pedals (see Power adjustable
foot pedals) ...............................123
Power adjustable foot pedals ...123
Power distribution box
(see Fuses) ...............................290
Power door locks ......................148
Power mirrors ...........................121
Power point ...............................118
Power steering ..........................262
fluid, checking and adding ....345
fluid, refill capacity ................351
fluid, specifications .........353, 356
Power Windows .........................120
Preparing to drive
your vehicle ...............................264
R
Radio ................................18, 28, 33
Rear window defroster .............101
Relays ........................................288
Remote entry system .......149, 151
illuminated entry ....................154
locking/unlocking doors .........150
opening the trunk ...................150
panic alarm .............................151
replacement/additional
transmitters .............................153
Reverse sensing system ...........272
Roadside assistance ..................286
S
Safety Belt Maintenance ..........189
Safety belts (see
Safety restraints) ......176, 179–183Safety Canopy ...........................194
Safety defects, reporting ..........314
Safety restraints ........176, 179–183
belt minder .............................185
extension assembly ................188
for adults .........................180–182
for children .....................197–198
lap belt ....................................183
safety belt maintenance .........189
warning light and
chime ...............................184–185
Safety seats for children ..........201
Seat belts (see
Safety restraints) ......................176
Seats ..........................................161
child safety seats ....................201
memory seat ...................151, 165
SecuriLock passive
anti-theft system ...............157–159
Servicing your vehicle ..............321
Setting the clock
AM/FM/In-dash 6 CD ................35
Snowplowing .................................7
Spare tire (see
Changing the Tire) ...................221
Spark plugs, specifications ......350,
356
Special notice
utility-type vehicles ....................7
Specification chart,
lubricants ...........................353, 356
Speed control ............................123
Starting your vehicle ........255–257
jump starting ..........................298
Steering wheel
controls ....................................126
tilting .......................................116
REVIEW COPY
2005 Expedition(exd), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Index
366