manual transmission FORD EXPLORER 1997 2.G User Guide

could get caught in moving
parts. Take precautions with
long hair.
²Do not work on a vehicle with
the engine running in an
enclosed space, unless you are
sure you have enough
ventilation.
²Keep all lit cigarettes, open
flames and other lit material
away from the battery and all
fuel related parts.
If you disconnect the battery, the
engine must ªrelearnº its idle
conditions before your vehicle will
drive properly, as explained in
Batteryin this chapter.
Working with the engine off
²Automatic transmission:
1. Set the parking brake fully and
ensure the gearshift is securely
latched in P (Park).
2. Turn off the engine and remove
the key.
3. Block the wheels to prevent the
vehicle from moving unexpectedly.
²Manual transmission:
uno_working_off
Maintenance and care
166

²Manual transmission:
1. Set the parking brake fully, and
make sure the gearshift is securely
latched in Neutral.
2. Block the wheels to prevent the
vehicle from moving unexpectedly.
Opening the hood
To open the hood:
1. Inside the vehicle, pull the hood
release handle located under the
steering column on the instrument
panel.
2. Outside the vehicle, release the
auxiliary latch located in the grille
opening.
3. Lift the hood and secure it in
the upright position.
4. To close the hood shut it so that
the auxiliary latch and primary
latches are closed.
After closing the hood, try lifting it
to ensure that it is closed securely.
uno_opening_hood
com_engine-comp
Maintenance and care
169

IDENTIFYING COMPONENTS IN
THE ENGINE COMPARTMENT
4.0L EFI engine
1. Windshield washer fluid
reservoir
2. Engine oil fill cap
3. Transmission fluid dipstick
(automatic transmission only)
4. Engine oil dipstick
5. Power steering fluid reservoir
6. Brake fluid reservoir
7. Clutch fluid reservoir (manual
transmission only)
8. Battery
10
1235674
89
com_4.0L-ohv
Maintenance and care
170

until the level is at the correct
area on the dipstick. If an overfill
occurs, excess fluid should be
removed by a qualified technician.
Checking and adding manual
transmission fluid (if equipped)
1. Clean the filler plug.
2. Remove the filler plug and
inspect the fluid level.
²The fluid level should be at the
bottom of the opening.
3. Add enough fluid through the
filler opening so that the fluid level
is at the bottom of the opening.
Use only fluid that meets Ford
specifications. Refer to the
Capacities and specifications
chapter for more information on
manual transmission fluid.
Driveline universal joint and slip
yoke
The universal joints standard with
your vehicle do not require
lubrication. If the original
equipment universal joints are
replaced with universal joints
equipped with grease fittings,
lubrication will be necessary at the
intervals shown in theService
Guidesupplement.
Constant velocity or double
carden joint (if equipped)
This component may be fitted with
a flush-type grease fitting that
requires an adaptor to permit
proper lubrication. If replaced,
uno_manual_trans_fluid
uno_driveline1
uno_constant_velocity
Maintenance and care
187

1. Put the automatic transmission
gearshift in P (Park). Put the
manual transmission gearshift in N
(Neutral).
2. Turn off all accessories and start
the vehicle.
3. Let the engine idle for at least
one minute.
4. The relearning process will
automatically complete as you
drive the vehicle.
²If you do not allow the engine to
relearn its idle, the idle quality
of your vehicle may be adversely
affected until the idle is
eventually relearned.
²If the battery has been
disconnected or if a new battery
has been installed, the clock and
preset radio stations must be
reset once the battery is
reconnected.
1
24R3D
Maintenance and care
191

REFILL CAPACITIES
Fluid Ford Part
NameApplication Capacity-liters
(quarts)
Engine oil
(including filter
change)Motorcraft 5W30
Super Premium
Motor OilAll engines
4.7 (5.0)
Brake fluid Ford High
Performance
DOT 3 Brake
FluidAll
Fill to line in
reservoir
Power steering
fluidMotorcraft
MERCONtAT FAll Fill to line in
reservoir
Transmission
fluidMotorcraft
MERCONtAT F5-speed manual
2.6 (5.6 pints)
Motorcraft
MERCONtV
AT F4R70W
Automatic
(4x2)13.1 (13.9)
5R55E
Automatic with
4.0L SOHC
engine (4 x 2)9.25 (9.75)
5R55E
Automatic with
4.0L SOHC
engine (4 x 4)9.55 (10.0)
Transfer case Motorcraft
MERCONtAT F4WD 1.4 (1.5)
AWD 1.25 (1.3)
Engine coolant Ford Premium
Cooling System
Fluid4.0L engine
7.4 (7.8)
5.0L engine 12.1 (12.8)
Front axle fluid Motorcraft SAE
80W90 Axle
Lubricant4 x 4 vehicles
1.7 (3.5 pints)
com_explorer-refills
Capacities and specifications
223

ItemFord Part
NameFord Part
NumberFord
Specification
Accelerator
throttle lever
ball studPremium Long
Life GreaseXG-1-C ESA-M1C175-B
Ford
conventional and
traction lok rear
axlesMotorcraft SAE
Premium Rear
Axle LubricantXY-80W90-QL
123WSP-M2C197-A
Dana axles
(front)4x4 Gear Oil F1TZ-19580-A WSL-M2C191-A
Transfer case -
Four wheel
driveMotorcraft
MERCONt
Automatic
Transmission
FluidXT-2-QDX MERCONt
Brake and
clutch pedal
shaftPremium
Long-life GreaseXG-1-C or K ESA-M1C75-B
5-speed manual
transmissionMotorcraft
MERCON
tAutomatic
transmission
fluidXT-2-QDX MERCONt
Trnafer case
Front Output
Slip ShaftPremium
Long-Life GreaseXG-1-G or K ESA-M1C75-B
14.0 L Explorer Conventional and
Traction-lok rear axles are filled
with XY-80W90±QL, Ford
specification WSP-M2C197±A.
25.0 L Explorer Conventional and
Traction-Lok rear axles are filled
with Motorcraft Premium Synthetic
rear axle lubricant, F1TZ-19580±B,
Ford specification WSL-M2C192±A.
Capacities and specifications
227

Engine oil
changing oil and oil filter .......175
specifications ..........................173
Entry system
illumination ...............................66
Exhaust fumes ..........................112
Flashing the lights ......................45
Floor mats ..............................62,63
Foglamps .....................................27
Ford Extended Service Plan ....129
Four way head restraints ...........78
Four-Wheel Drive vehicles
control trac ........................38,128
driving off road .......................130
Fuel ............................................202
calculating fuel economy .......206
improving fuel economy ........146
octane rating ...........................204
quality ......................................205
safety information relating to
automotive fuels .....................202
Fuel gauge ...................................15
Fuel pump shut-off switch .......147
Fuses ..........................................148
Gauges, Mechanical
engine coolant temperature
gauge .........................................13
engine oil pressure gauge ........13
Hazard flashers ....................44,147
Head restraints ...........................78
Hitch ..........................................144
Hood ..........................................169
Identification Number, Vehicle
(VIN) ..........................................230
Ignition
positions of the ignition ...........39
Jack ..............................................63
Jump-starting your vehicle 160,162
attaching cables ......................161
disconnecting cables ..............162
Keyless entry system
autolock .....................................76keypad .......................................74
locking and unlocking doors ....74
programming entry code .........75
Lamps
instrument panel, dimming .....26
Liftgate ........................................57
Lights, warning and indicator
air bag ........................................11
anti-lock brakes (ABS) ............11
anti-theft .....................................9
brake ..........................................11
charging system ........................10
check engine ...............................9
door ajar ....................................10
four-wheel drive ..........................9
fuel reset ...................................10
high beam .................................11
overdrive off ................................8
safety belt .......................11,87,88
Luggage rack .............................146
Manual transmission
driving .......................121,125,127
fluid, checking and adding ....187
Message center ..16,17,18,19,20,52
air ride switch off .....................21
change oil soon .........................21
check air ride system ...............20
check charging system .............22
check engine temperature .......22
check exterior lamps ................22
door ajar ....................................24
low fuel level .............................24
low oil level ...............................24
low washer fluid .......................24
warning messages .....................20
Moon roof ....................................54
Motorcraft parts ........................222
Odometer .....................................14
Overdrive ................................45,46
Overhead console
storage compartment ...............52
Parking brake ..............................28
Index
234