warning light FORD EXPLORER SPORT 2003 1.G User Guide

BRAKES
Occasional brake noise is normal. If a metal-to-metal, continuous grinding
or continuous squeal sound is present, the brake linings may be worn-out
and should be inspected by a qualified service technician. If the vehicle
has continuous vibration or shudder in the steering wheel while braking,
the vehicle should be inspected by a qualified service technician.
Four-wheel anti-lock brake system (ABS)
Your vehicle is equipped with an Anti-lock Braking System (ABS). This
system helps you maintain steering control during emergency stops by
keeping the brakes from locking. Noise from the ABS pump motor and
brake pedal pulsation may be observed during ABS braking; any
pulsations or mechanical noise you may feel or hear is normal.
ABS warning lamp
ABS
TheABSlamp in the instrument cluster momentarily illuminates when
the ignition is turned to ON. If the light does not illuminate during start
up, remains on or flashes, the ABS may be disabled and may need to be
serviced.
Even when the ABS is disabled,
normal braking is still effective. (If
your BRAKE warning lamp
illuminates with the parking brake
released, have your brake system
serviced immediately.)
Using ABS
When hard braking is required, apply continuous force on the brake
pedal; do not pump the brake pedal since this will reduce the
effectiveness of the ABS and will increase your vehicle’s stopping
distance. The ABS will be activated immediately, allowing you to retain
full steering control during hard braking and on slippery surfaces.
However, the ABS does not decrease stopping distance.
!
BRAKE
2003 U207 Explorer Sport(u27)
Owners Guide (post-2002-fmt)
USA English(fus)
Driving
98

1. Drive on an expressway or highway for at least 10 minutes.
2. Drive in stop-and-go traffic for at least 20 minutes with a minimum of
four idle periods.
The engine must warm up to its normal operating temperature. Once
started, do not turn off the engine until the above drive cycle is
complete.
Note:If your “Check Engine” light is on, your vehicle may not pass an
I/M test.
CHECKING AND ADDING POWER STEERING FLUID
Check the fluid. Refer to the
Scheduled Maintenance Guidefor
service maintenance schedules.
1. Start the engine and let it run
until it reaches normal operating
schedules.
2. Turn the steering wheel left and
right several times.
3. Turn the engine off.
4. Check the fluid level.
5. If the fluid is below the MIN line,
add fluid in small amounts until it
reaches the correct level (between
the MIN and MAX lines).
Use only MERCONAT F.
BRAKE FLUID RESERVOIR
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels below the “MAX” line
that do not trigger the brake system
warning lamp are within the normal
operating range, there is no need to
add fluid. If the fluid levels are outside of the normal operating range,
the performance of your brake system could be compromised, seek
service from your dealer immediately.
DONOTOVERFILLPOWERSTEERINGFLUID
M
AX
2003 U207 Explorer Sport(u27)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
176

A
Air bag supplemental restraint
system ....................................78–79
and child safety seats ..............80
description ................................79
disposal ......................................82
driver air bag ............................81
indicator light ...........................82
operation ...................................81
passenger air bag .....................81
Air cleaner filter .......................184
Anti-lock brake system
(see Brakes) ................................98
Audio system
Single CD ..................................16
Audio system (see Radio) ...16, 19
Automatic transmission ............100
driving an automatic
overdrive .................................102
fluid, refill capacities ..............185
fluid, specification ..................189
Auxiliary power point .................41
Axle
lubricant specifications ..187, 189
refill capacities ........................185
traction lok ..............................100
B
Battery .......................................163
acid, treating emergencies .....163
jumping a disabled battery ....136
maintenance-free ....................163
replacement, specifications ...184
servicing ..................................163
BeltMinder ...................................74
Brakes ..........................................98
anti-lock .....................................98anti-lock brake system (ABS)
warning light .............................98
fluid, checking and adding ....176
fluid, refill capacities ..............185
fluid, specifications .........187, 189
lubricant specifications ..187, 189
parking ......................................99
shift interlock ..........................100
C
Calculating load ........................114
Capacities for refilling fluids ....185
Cargo area shade ..................49–50
Cassette tape player ...................16
CD-single premium .....................19
Cell phone use ............................39
Certification Label ....................191
Child safety restraints ................83
child safety belts ......................83
Child safety seats ........................86
attaching with tether straps ....90
in front seat ..............................87
in rear seat ................................87
Cleaning your vehicle
engine compartment ..............153
instrument panel ....................155
interior .....................................155
interior trim ............................155
plastic parts ............................154
safety belts ..............................155
washing ....................................152
waxing .....................................152
wheels ......................................153
wiper blades ............................154
Clock adjust
Single CD ..................................16
2003 U207 Explorer Sport(u27)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
Index
195

octane rating ...........................189
Fuel pump shut-off switch .......122
G
Garage door opener ....................40
Gauges .........................................13
GAWR (Gross Axle Weight
Rating) .......................................113
calculating ...............................114
definition .................................113
driving with a heavy load ......113
location ....................................113
GVWR (Gross Vehicle Weight
Rating) .......................................113
calculating .......................113–114
definition .................................113
driving with a heavy load ......113
location ....................................113
H
Hazard flashers .........................122
Head restraints ...........................66
Headlamps
aiming ........................................30
autolamp system .......................28
flash to pass ..............................29
high beam .................................29
Heating
heating and air conditioning
system .......................................26
I
Ignition .................................94, 189
Infant seats
(see Safety seats) .......................86Instrument panel
cleaning ...................................155
cluster ........................................10
J
Jump-starting your vehicle ......136
K
Keyless entry system .................56
Keys
positions of the ignition ...........94
L
Lamps
autolamp system .................28, 42
bulb replacement
specifications chart ..................32
fog lamps ...................................28
high beams ................................29
instrument panel, dimming .....29
interior lamps ...........................31
Liftgate ........................................51
Lights, warning and indicator ....10
anti-lock brakes (ABS) ............98
Load limits .................................113
GAWR ......................................113
GVWR ......................................113
trailer towing ..........................113
Loading instructions .................114
Lubricant specifications ...187, 189
M
Manual transmission .................104
fluid capacities ........................185
lubricant specifications ..........189
reverse .....................................105
2003 U207 Explorer Sport(u27)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
197

Mirrors
automatic dimming rearview
mirror ........................................43
fold away ...................................43
side view mirrors (power) .......43
Moon roof ....................................46
Motorcraft parts ........................184
P
Parking brake ..............................99
Parts (see Motorcraft parts) ....184
Power steering ............................99
fluid, checking and adding ....176
fluid, refill capacity ................185
fluid, specifications .........187, 189
Power Windows ...........................42
Preparing to drive your
vehicle ........................................100
R
Radio ......................................16, 19
Single CD ..................................16
Remote entry system .................54
locking/unlocking doors ...........53
Roadside assistance ..................121
S
Safety belts
(see Safety restraints) .........68–72
Safety defects, reporting ..........151
Safety restraints ....................68–73
belt minder ...............................74
cleaning the safety belts ..........77
extension assembly ..................77
for adults .............................69–72
for children .........................82–83warning light and chime ....73–74
Safety seats for children ............86
Seat belts
(see Safety restraints) ...............68
Seats ............................................63
child safety seats ......................86
Spark plugs,
specifications .....................184, 189
Special notice
utility-type vehicles ....................7
Specification chart,
lubricants ...........................187, 189
Speed control ..............................44
Starting your vehicle ......94–95, 97
jump starting ..........................136
Steering wheel
tilting .........................................38
Stereo
Single CD ..................................16
T
Tilt steering wheel ......................38
Tires ...........................................180
tire grades ...............................181
treadwear ................................180
Towing .......................................115
recreational towing .................119
trailer towing ..........................115
Traction-lok rear axle ...............100
Transmission
automatic operation ...............100
fluid, checking and adding
(manual) .................................178
fluid, refill capacities ..............185
lubricant specifications ..187, 189
manual operation ....................104
2003 U207 Explorer Sport(u27)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
198

Turn signal ..................................31
V
Vehicle dimensions ...................189
Vehicle Identification Number
(VIN) ..........................................191
Vehicle loading ..........................113
Ventilating your vehicle .............97W
Warning lights (see Lights) .......10
Water, Driving through .............112
Windows
power .........................................42
Windshield washer fluid and
wipers ..........................................37
replacing wiper blades .............38
2003 U207 Explorer Sport(u27)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
199