battery FORD F-450 2022 Warranty Guide

(5) The electrical drivetrain system of your vehicle is covered by
the Hybrid & Electric Vehicle Unique Component coverage for
eight years or 100,000 miles, whichever comes first. The
components in the electrical drivetrain system of your vehicle will
vary, depending on whether your vehicle is a hybrid, plug-in
hybrid, but you can rest assured knowing that your vehicle’s
electrical drivetrain system is covered by this comprehensive
warranty. Depending on your vehicle, electrical drivetrain system
components covered by this warranty may include, and are not
limited to: high-voltage battery, high-voltage battery connector,
battery energy control module (BECM), on-board charger,
inverter system controller (ISC), DC/DC converter, hybrid
continuously variable transmission or electric driveline motor and
transmission range sensor. If an electrical drivetrain system
component requires replacement under warranty, it may be
replaced with a new, factory remanufactured, or factory
refurbished component, at Ford’s discretion. Refurbished battery
components selected for your vehicle will align with your
vehicle’s age and mileage, and meet Ford’s stringent
requirements and standards. (see "Note: High-Voltage Battery
Gradual Capacity Loss" below).
Note: High Voltage Battery Gradual Capacity Loss
The high voltage battery will experience gradual capacity loss
with time and use, similar to all batteries, which is considered
normal wear and tear. Loss of battery capacity due to or resulting
from gradual capacity loss is NOT covered under the New Vehicle
Limited Warranty. See your Owner’s Manual for important tips on
how to maximize the life and capacity of the high voltage battery.
NOTE:Some components may also be covered by the Emissions
Warranties. For more information, see pages 22-41.
If you own or lease a 2022-model Next Generation Police
Interceptor Vehicle (NGPI), refer to the Warranty Addendum Card
that was given to you when you took delivery of your vehicle for
further explanation of Amendments to the New Vehicle Limited
Warranty. The Warranty Addendum applies only the NGPI
vehicles delivered in the State of Florida and New York.
13

Tire Wear or Damage
The New Vehicle Limited Warranty does not cover normal wear or
worn out tires. Tires will not be replaced (unless required by a
warranty repair) for wear or damage including:
• tire damage from road hazard such as cuts, snags, bruises,bulges, puncture, and impact breaks
• tire damage due to under or over inflation, tire chain use, racing, spinning (as when stuck in snow or mud), improper mounting
or dismounting, or tire repair
Other Items or Conditions Not Covered
The New Vehicle Limited Warranty does not cover:
• vehicles that have had the odometer disconnected, altered, or inoperative for an extended period of time with the result that
the actual mileage cannot be determined
• vehicles that have ever been labeled or branded as dismantled, fire, flood, junk, rebuilt, reconstructed, or salvaged; this will void
the New Vehicle Limited Warranty
• vehicles that have been determined to be a total loss by an insurance company; this will void the New Vehicle Limited
Warranty
• converted ambulances that are not equipped with the Ford Ambulance Prep Package, see important information about
ambulance conversions (page 47)
• aftermarket parts or components, sometimes installed by Ford Motor Company or an authorized Ford dealership, may not be
covered by the New Vehicle Limited Warranty. Any damage
caused to Ford components due to the failure of aftermarket
parts (other than a certified emissions part) is not covered.
• high-voltage battery replacement due to improper vehicle storage. Refer to the Owner’s Manual for the proper ways your
vehicle’s battery must be maintained in the event the vehicle is
not driven or is stored for an extended period of time.
18

• The Lithium-ion battery (EV battery) will experience gradualcapacity loss with time and use (similar to all lithium-ion
batteries), which is considered normal wear and tear. Loss of
battery capacity due to or resulting from gradual capacity loss
is NOT covered under the New Vehicle Limited Warranty. See
your Owner’s Manual for important tips on how to maximize
the life and capacity of the Lithium-ion battery.
• if the component that caused the failure is beyond coverage and damages a component with remaining coverage, the entire
repair is NOT reimbursable.
19

4. In addition ...
ROADSIDE SERVICE ASSISTANCE
(UNITED STATES, PUERTO RICO, AND U.S. VIRGIN ISLANDS)
Your vehicle is covered by the complimentary Ford Roadside
Assistance Program (unless you are driving a daily rental unit).
Under this program, Ford will cover:
• Towing to the nearest Ford Motor Company dealership, ortowing to your selling dealership if within 35 miles of the
disablement
• Flat tire change (vehicle must have useable spare)
• Fuel delivery (limited to two occurrences in a 12-month period up to 2 gal. gas, 5 gal. diesel)
• 12V Battery jump starts
• Lock-out assistance (replacement key cost is customer responsibility)
• Winch out services: includes pulling a vehicle within 100 feet of a paved or county maintained road. No recoveries.
The Roadside Assistance Program is separate from the New
Vehicle Limited Warranty. It begins at the warranty start date and
lasts for five years or 60,000 miles (whichever occurs first). If
you need towing beyond the five years or 60,000 miles
(whichever occurs first) period, Ford can arrange roadside
assistance and charge your credit card. If the reason for the
vehicle disablement is later found to be covered by a Ford or
Lincoln Protect extended service plan, you may seek
reimbursement for a tow charge under that plan.
For emergency roadside assistance, call 1-800-241-3673,
24 hours a day, 365 days a year.
20

EMISSIONS DEFECT WARRANTY COVERAGE
During the warranty coverage period, Ford Motor Company
warrants that:
• your vehicle or engine is designed, built, and equipped to meet- at the time it is sold - the emissions regulations of the U.S.
Environmental Protection Agency (EPA).
• your vehicle or engine is free from emission-related defects in factory-supplied materials or workmanship, which are defects
that could prevent the vehicle or engine from conforming with
applicable EPA regulations.
• you will not be charged for diagnosis, repair, replacement, or adjustment of parts containing an emissions-related defect. A
list of emission-related parts can be found in What is
Covered? on pages 26-28.
The warranty coverage period for:
• The emissions defects warranty coverage period for passenger cars and light duty trucks (applies to vehicles up through
8,500 pounds GVWR) is as follows:
— 8 years or 80,000 miles (whichever occurs first) for catalytic converters, electronic emissions control unit, and onboard
emissions diagnostic devices, including the Battery Energy
Control Module (BECM).
— 2 years or 24,000 miles (whichever occurs first) for all other covered parts. (Note: Ford’s 3-year, 36,000-mile
bumper-to-bumper coverage, as described above, surpasses
this mandatory federal coverage.)
23

WHAT IS COVERED?
For your vehicle if these parts contain an emissions-related
defect, they are covered by both the Emissions Defect Warranty
and the Emissions Performance Warranty.
• Active Air Dam (3.0L dieselF-150 only)
• Active Grill Shutters (3.0L diesel F-150 only)
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
• Brake Hydraulic/Electric Control Assembly (Plug-in
Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles
only)
• Catalytic Converters (including Selective Catalytic
Reduction and Diesel
Oxidation Catalysts)
•
Charger and Bracket
Assembly High Voltage
Battery (Hybrid and Plug-in
Hybrid vehicles only)
• Cold Start Enrichment System (diesel only)
• Controls for Deceleration (diesel only)
• Converter and Bracket Assembly High Voltage to Low Voltage (Hybrid and
Plug-in Hybrid vehicles only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System (diesel only)
• Electronic Engine Control Sensors and Switches
• Powertrain Control Module (PCM)/ Engine Control
Module (ECM)*
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
• Fuel Filler Door Sensor (Hybrid and Plug-in Hybrid
vehicles only)
• Fuel Filler Tube and Seal (non-diesel only)
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control Valve
26

• Heating Element of BackWindow (3.0L diesel F-150
only)
• High Voltage Battery (Hybrid and Plug-in Hybrid vehicles
only)
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Intercooler Assembly - Engine Charger
• Inverter System Controller (Plug-in Hybrid vehicles
only)
• Jumper Assembly Charge Inlet to Charger (Hybrid and
Plug-in Hybrid vehicles only)
• Jumper Assembly DC/DC Converter to High Voltage
Panel (Hybrid and Plug-in
Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic
(OBD) System
• Module and Bracket Assembly Transmission
Inverter Control (Hybrid and
Plug-in Hybrid vehicles only) • Motor Electronics Coolant
Pump (Plug-in Hybrid
vehicles only)
• PCV system and Oil Filler Cap
• Onboard Charger (Plug-in Hybrid vehicles only)
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles
only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid
vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in
Hybrid vehicles only)
• Transmission Control Module (TCM) and
Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
27

6. California requirements for emissions warranties
QUICK REFERENCE: EMISSIONS WARRANTY COVERAGE
This chart shows the emission warranty that Ford Motor Company
provides for your vehicle under the emissions control warranty in
accordance with the regulations of the California Air Resources Board.
This coverage is in addition to Federal Emission warranties (Page 22).
* Gross Vehicle Weight Rating
** These specific parts were selected on the basis of their estimated replacement cost at the time the California Air Resources Board certified your vehicle for sale in California
(up through 14,000 pounds GVWR).
***
Refer to your Vehicle Emission Control Information label for emissions certification information.
**** Except for the high voltage battery, which is covered for 10 years or 150,000 miles (whichever occurs first).
NOTE: Fully-electric vehicles are not eligible for any emissions
warranties described in this booklet.
TRANSITIONAL ZERO EMISSION VEHICLES (TZEV)***
DEFECTS AND PERFORMANCE WARRANTY**** 15/150,000
EMISSIONS DEFECTS WARRANTY FOR
VEHICLE WITH GVWR OVER 14,000 LBS.***
(Gasoline engines)
(2021 and earlier engine
model year diesel engines)
(2022 and later engine
model year diesel engines)
EMISSIONS PERFORMANCE WARRANTY (Vehicles of 14,000 LBS.* & under)
EMISSIONS DEFECTS WARRANTY FOR
VEHICLES WITH GVWR*
OF 14,000 LBS. & UNDER
Short-Term Warranty
Long-Term Warranty**
3/50,000
3/50,000
7/70,000
5/50,000 5/100,000
5/110,000
Emissions Warranties for California Certified Vehicles
TYPE OF
COVERAGE YEARS IN
SERVICE/MILES DRIVEN
29

For Vehicles Eligible for California TZEV Emission Warranty
Coverage
Except as noted below, for 15 years or 150,000 miles (whichever
first occurs):
1. If your vehicle fails a Smog Check inspection, all necessary
repairs and adjustments will be made by Ford to ensure that your
vehicle passes the inspection. This is your emission control
system PERFORMANCE WARRANTY.
2. If any emissions-related part on your vehicle is defective, the
part will be repaired or replaced by Ford. This is your short-term
emission control system DEFECTS WARRANTY.
NOTE:The TZEV warranty period for the high-voltage battery is
10 years or 150,000 miles (whichever first occurs).
34

WHAT IS COVERED?
If the parts on the following list contains a defect that affects
emissions, they are covered by the Defects Warranties.
• Active Air Dam (3.0L dieselF-150 only)
• Active Grill Shutters (3.0L diesel F-150 only)
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
• Brake Hydraulic/Electric Control Assembly (Plug-in
Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles
only)
• Catalytic Converters (including Selective Catalytic
Reduction and Diesel
Oxidation Catalysts)
• Charger and Bracket Assembly High Voltage
Battery (Hybrid and Plug-in
Hybrid vehicles only)
• Cold Start Enrichment System (diesel only)
• Controls for Deceleration (diesel only)
• Converter and Bracket Assembly High Voltage to Low Voltage (Hybrid and
Plug-in Hybrid vehicles only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System (diesel only)
• Electronic Engine Control Sensors and Switches
• Powertrain Control Module (PCM)/Engine Control
Module (ECM)*
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
• Fuel Filler Door Sensor (Hybrid and Plug-in Hybrid
vehicles only)
• Fuel Filler Tube and Seal (non-diesel only)
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control Valve
36