checking oil FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS 2011 12.G Owners Manual
[x] Cancel search | Manufacturer: FORD, Model Year: 2011, Model line: F SERIES MOTORHOME AND COMMERCIAL CHASSIS, Model: FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS 2011 12.GPages: 156, PDF Size: 1.21 MB
Page 93 of 156
6.8L V10 engine (commercial stripped chassis)
1. Engine coolant reservoir
2. Engine oil filler cap
3. Automatic transmission fluid dipstick
4. Power distribution box
5. Engine oil dipstick
6. Brake fluid reservoir
7. Air filter assembly
8. Power steering fluid reservoir
ENGINE OIL
Checking the engine oil
Refer toscheduled maintenance informationfor the appropriate
intervals for checking the engine oil.
1. Make sure the vehicle is on level ground.
2. Turn the engine off and wait 15 minutes for the oil to drain into the
oil pan.
13425786
Maintenance and Specifications
93
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)
Page 94 of 156
3. Set the parking brake and ensure the gearshift is securely latched in P
(Park).
4. Open the hood. Protect yourself from engine heat.
5. Locate and carefully remove the
engine oil level dipstick.
6. Wipe the dipstick clean. Insert the dipstick fully, then remove it again.
•If the oil level iswithin the lower and upper holes,the oil level is
acceptable.DO NOT ADD OIL.
•If the oil level isbelow the lower hole,engine oil must be added to
raise the level within the normal operating range.
•Do not overfill the engine with oil. Oil levels above the upper
hole mark may cause engine damage.If the engine is overfilled,
some oil must be removed from the engine by an authorized dealer.
7. Put the dipstick back in and ensure it is fully seated.
Adding engine oil
1. Check the engine oil. For instructions, refer toChecking the engine
oilin this chapter.
2. If the engine oil level is not within the normal operating range, add
only certified engine oil of the recommended viscosity. Remove the
engine oil filler cap and use a funnel to pour the engine oil into the
opening.
3. Recheck the engine oil level. Make sure the oil level is not above the
normal operating range on the engine oil level dipstick.
4. Install the dipstick and ensure it is fully seated.
Maintenance and Specifications
94
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)
Page 98 of 156
•If you do not allow the engine to relearn its idle trim, the idle
quality of your vehicle may be adversely affected until the idle
trim is eventually relearned.
If the battery has been disconnected or a new battery has been installed,
the clock and the preset radio stations must be reset once the battery is
reconnected.
•Always dispose of automotive
batteries in a responsible manner.
Follow your local authorized
standards for disposal. Call your
local authorized recycling center
to find out more about recycling
automotive batteries.
ENGINE COOLANT
Checking engine coolant
The concentration and level of engine coolant should be checked at the
intervals listed inscheduled maintenance information.The coolant
concentration should be maintained at 50/50 coolant and distilled water.
Coolant concentration testing is possible with a hydrometer or antifreeze
tester. The level of coolant should be maintained at the FULL COLD
level or within the COLD FILL RANGE in the coolant reservoir. If the
level falls below, add coolant per the instructions in theAdding engine
coolantsection.
Your vehicle was factory-filled with a 50/50 engine coolant and water
concentration. If the concentration of coolant falls below 40% or above
60%, the engine parts could become damaged or not work properly.A
50/50 mixture of coolant and water provides the following:
•Improved freeze protection.
•Improved boiling protection .
•Protection against rust and other forms of corrosion.
•Proper function of calibrated gauges.
L
E
A
D
RETURN
RECYCLE
Maintenance and Specifications
98
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)
Page 153 of 156
A
ABS (see Brakes) .......................55
Air cleaner filter .......120–121, 124
Ambulance packages ....................5
Antifreeze
(see Engine coolant) ..................98
Anti-lock brake system
(see Brakes) ..........................55–56
Automatic transmission
driving an automatic
overdrive ...................................59
fluid, adding ............................117
fluid, checking ........................117
fluid, refill capacities ..............125
fluid, specification ..................125
Axle
lubricant specifications ..........125
refill capacities ........................125
B
Battery .........................................96
acid, treating emergencies .......96
jumping a disabled battery ......79
maintenance-free ......................96
replacement, specifications ...124
servicing ....................................96
Brakes ....................................54–55
anti-lock ...............................55–56
anti-lock brake system (ABS)
warning light .............................56
fluid, checking and
adding ..............................115, 117
fluid, refill capacities ..............125
fluid, specifications .................125
lubricant specifications ..........125
shift interlock ............................58Bulbs ............................................21
C
Capacities for refilling fluids ....125
Cell phone use ..............................7
Changing a tire ...........................73
Cleaning your vehicle
engine compartment ................90
wheels ........................................90
Coolant
checking and adding ................98
refill capacities ................101, 125
specifications ..........................125
Cruise control
(see Speed control) ....................23
Customer Assistance ..................63
Ford Extended Service
Plan ..................................130, 133
Getting assistance outside the
U.S. and Canada .......................86
Getting roadside assistance .....63
Getting the service you
need ...........................................83
Ordering additional owner’s
literature ...................................88
Utilizing the
Mediation/Arbitration
Program .....................................86
D
Daytime running lamps
(see Lamps) ................................20
Dipstick
automatic transmission
fluid ..........................................117
engine oil ...................................93
Driving under special
conditions ....................................62
through water ...........................62
Index
153
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)
Page 154 of 156
E
Electronic message center .........16
Emergencies, roadside
jump-starting ............................79
Emergency Flashers ...................64
Emission control system ..........111
Engine ........................................128
cleaning .....................................90
coolant .......................................98
fail-safe cooling .......................102
idle speed control .....................96
lubrication specifications .......125
refill capacities ........................125
service points ......................92–93
Engine oil ....................................93
checking and adding ................93
dipstick ......................................93
filter, specifications ..........95, 124
recommendations .....................95
refill capacities ........................125
specifications ..........................125
Event data recording ....................5
Exhaust fumes ............................54
F
Fail safe cooling ........................102
Fluid capacities .........................125
Fuel ............................................104
calculating fuel economy .......108
capacity ...................................125
choosing the right fuel ...........106
detergent in fuel .....................107
filling your vehicle with
fuel ...................................104, 108
filter, specifications ........104, 124
improving fuel economy ........108
octane rating ...................107, 128quality ......................................107
running out of fuel .................107
safety information relating to
automotive fuels .....................104
Fuses ............................................65
G
Gas mileage
(see Fuel economy) .................108
Gauges .........................................13
H
Hazard flashers ...........................64
Headlamps ...................................20
daytime running lights .............20
flash to pass ..............................21
high beam .................................20
turning on and off ....................20
I
Ignition .................................51, 128
Inspection/maintenance (I/M)
testing ........................................112
Instrument panel
cluster ........................................10
lighting up panel and
interior .......................................21
J
Jump-starting your vehicle ........79
K
Keys
positions of the ignition ...........51
Index
154
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)
Page 155 of 156
L
Lamps
daytime running light ...............20
headlamps .................................20
headlamps, flash to pass ..........21
instrument panel, dimming .....21
Lights, warning and indicator ....10
anti-lock brakes (ABS) ............56
Loading instructions ...................47
Load limits ...................................42
Lubricant specifications ...........125
Lug nuts ......................................78
M
Message center ...........................16
english/metric button ...............18
system check button ................18
warning messages .....................18
Motorcraftparts ......................124
O
Octane rating ............................107
Oil (see Engine oil) ....................93
P
Parking brake ..............................57
Parts
(see Motorcraftparts) ...........124
Power distribution box
(see Fuses) .................................69
Power steering
fluid, checking and adding ....114
fluid, refill capacity ................125
fluid, specifications .................125R
Relays ....................................65, 72
Roadside assistance ....................63
S
Safety defects, reporting ............89
Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............139
Servicing your vehicle ................91
Spark plugs,
specifications .....................124, 128
Special notice ................................4
Specification chart,
lubricants ...................................125
Speed control ..............................23
Starting your vehicle ............51–53
jump starting ............................79
Steering wheel
tilting .........................................22
T
Tilt steering wheel ......................22
Tires .......................................25–26
alignment ..................................35
care ............................................31
changing ..............................73, 75
checking the pressure ..............30
inflating .....................................27
replacing ..............................33, 76
rotating ......................................36
safety practices .........................34
sidewall information .................37
snow tires and chains ..............41
spare tire ...................................73
terminology ...............................26
tire grades .................................26
treadwear ............................25, 32
Index
155
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)