power steering FORD FIESTA 2007 Workshop Manual

303-01 B-I17 Engine - 2.OL Duratec-HE (M14) 303-01 B-117
INSTALLATION
37. Using the special tool, connect the steering
Connect the clutch slave cylinder supply
gear to power steering fluid reservoir return
line.
I I line to the power steering fluid reservoir. Install the spring clip.
38.
Attach the steering gear to power steering 41. Connect the reversing lamp switch
fluid reservoir return line support bracket
electrical connector.
to the generator.
42. Lower the vehicle.
39. Connect the A/C low pressure switch
connector. 43. Install the coolant expansion tank.
40a &AUTION:I~ brake fluid is spilt on the
paintwork, the affected area must be
immediately washed down with cold water.
N0TE:Make sure the spring clip is correctly seated.
2006.0 Fiesta 1212006 ~451291 en
procarmanuals.com

303-01 B-I 18 Engine - 2.OL Duratec-HE (M14) 303-01 B-118
INSTALLATION
44. Attach the power steering high-pressure 47.
Connect the catalyst monitor sensor
line retaining bracket to the transaxle. electrical
connector.
//
45. Install the engine wiring harness bracket. 48.
Connect the power steering pump switch
electrical connector.
46. Connect the engine wiring harness
electrical connector.
49. Install the battery tray support bracket.
2006.0 Fiesta 1212006 G451291 en
procarmanuals.com

Fuel Charging and Controls - 1.25L
Duratec-1 6V (Sigma)llI4L Duratec-1 6V
(Sigma)ll .6L Duratec-1 6V (Sigma)
SPECIFICATIONS
General Specifications
I Maximum idle increase for high generator load I I00 rpm I
Condition
Regulated fuel pressure
l~ir conditioning idle upspeed at low ambient temperatures I 100 rpm I
Specification
380 kpa (55 psi)
I Air conditioning idle upspeed at high ambient temperatures I 150 rpm I
I Power steering idle speed upspeed I 50 rpm I
Toraue S~ecifications
Description Nm I b-ft Ib-in
I Throttle body retaining bolts I 10 1 - I 89 I
I Fuel pressure regulator retaining bolts I 10 I - I 89 I
I Fuel injection supply manifold retaining bolts I 15 I 11 I - I
2006.0 Fiesta 1212006 GI 46265en
procarmanuals.com

Fuel Charging and Controls - 2.OL
303-048-1 0 Duratec-HE (M14) 303-04B-10
DIAGNOSIS AND TESTING
Symptom Possible Sources Action
Fuel rail fuel pressure sensor. Carry out a full engine
diagnosis using the guided
diagnostic menu in WDS.
Fuel injectors. INSPECT
the fuel injectors.
CLEAN the fuel injectors or
INSTALL a new set of injectors
as required only after the
checks have been carried out.
I Incorrect valve timing. I CHECK the valve timing. I
Poor starting
Low cylinder compression.
Low fuel system pressure.
TEST the cylinder compres-
sion.
Check the fuel system pres-
sure.
REFER to: Fuel System Pres-
sure Check (31
0-OOA,
General Procedures).
Fuel system leak. CHECK the system for fuel
leak(s). REPAIR the system as
necessary.
Fuel system restriction. INSPECT the
fuel system.
INSTALL new components as
necessary. TEST the system
for normal operation.
I Fuel filter blocked. I INSTALL a new fuel filter. I
lncorrect engine oil.
Air
cleaner element blocked.
INSTALL a new engine oil filter
and engine oil.
INSTALL a new air cleaner
element.
lncorrect power steering fluid. DRAIN and REFILL the
power
steering system with the correct
fluid.
REFER to: Power Steering
System Flushing
- Vehicles
With: Electro-Hydraulic Power
Steering (EHPS) (21 1-00,
General Procedures).
2006.0 Fiesta 1212006 GI 65371 en
CKP sensor.
Engine coolant temperature
(ECT) sensor. Carry out a
full engine
diagnosis using the guided
diagnostic menu in WDS.
Carry out a full engine
diagnosis using the guided
diagnostic menu in WDS.
procarmanuals.com

303-05-1 Accessory Drive 303-05-1
SECTION 303-05 Accessory Drive
VEHICLE APPLICATION:2006.0 Fiesta
CONTENTS
PAGE
SPECIFICATIONS
Specifications.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 303-05-2
DESCRIPTION AND OPERATION
Accessory Drive - 1.4L Duratec-1 6V (Sigma)/l .6L Duratec-1 6V (Sigma) ....................... 303-05-3
Accessory Drive
- 2.OL Duratec-HE (M14) ........................................................................\
303-05-4
2.OL Duratec HE (M14) engine ........................................................................\
................... 303-05-4
DIAGNOSIS AND TESTING
Accessory Drive.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 303-05-5
Inspection and Verification
........................................................................\
.......................... 303-05-5
Accessory Drive Belt Concerns
........................................................................\
............ 303-05-5
Symptom Chart
.... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 303-05-1 0
Component Tests..
.. .. .. .. .... .. ....... . . . . . . . .. .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 303-05-1 6
REMOVAL AND INSTALLATION
Accessory Drive Belt - 1.4L Duratec-16V (Sigma)/l.GL Duratec-1 6V (Sigma),
Vehicles With: Air Conditioning
..... . .. . . . . .. . . .. ........ .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (21 567 0) 303-05-1 8
Accessory Drive Belt - 1.4L Duratec-16V (Sigma)/l .6L Duratec-1 6V (Sigma),
Vehicles Without: Air Conditioning..
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (21 567 0) 303-05-2
1
Power Steering Pump Belt
- 1.4L Duratec-1 6V (Sigma)/l .6L Duratec-16V
(Sigma), Vehicles With: Air Conditioning
...... .. .. . . . . . . .. .. .. ...... . . . . . . . . . . . . . . . . . . . (21 567 0) 303-05-24
Accessory Drive Belt
- 2.OL Duratec-HE (M14) ...... . . . . . . . . . . . . .. .... .. ...... . .. . . . . . . (21 567 0) 303-05-26
procarmanuals.com

303-05-3 Accessory Drive 303-05-3
DESCRIPTION AND OPERATION
Accessory Drive - 1.4L Duratec-1 6V (Sigma)/l .6L Duratec-1 6V
(Sigma)
Overview
I B I Vehicles with air conditioning I
l tern Description Both versions are elastic multi-ribbed belts and do
I 1 I Crankshaft pulley I
A
- -
1 2 1Coolant pump I
Vehicles without air conditioning
1 3 1 Generator I
not need a tensioning pulley. Re-tensioning is not
required.
1 4 1 Power steering pump I
1 5 1 Air conditioning compressor I
Vehicles without air conditioning have one drive
belt, which drives the generator, the coolant pump
and the power steering pump.
Vehicles with air conditioning have two drive belts,
the longer of which drives the generator, the
coolant pump and the air conditioning compressor.
The shorter drive belt drives only the power
steering pump.
2006.0 Fiesta 1212006 GI 63301 en
procarmanuals.com

303-0514 Accessory Drive . 303-05-4
DESCRIPTION AND OPERATION
Accessory Drive - 2.OL Duratec-HE (M14)
2.OL Duratec HE (M14) engine
,
Item Description
I 1 I Accessory drive belt 1
1 2 1 Power steering pump pulley I
1 3 1 Coolant pump pulley I
1 4 1 Air conditioning (AIC) compressor pulley I
1 5 1 Crankshaft pulley I
1 6 1 Accessory drive belt tensioner pulley I
1 7 1 Generator pulley I
2006.0 Fiesta 1212006 G421383en
8
---
Accessorydrivebeltidlerpulley
procarmanuals.com

303-05-5 Accessory Drive 303-05-5
DIAGNOSIS AND TESTING
Accessory Drive
lnspection and Verification
1. Verify the customer concern.
2.
Visually inspect for obvious signs of mechanical
damage.
Visual lnspection Chart
I Mechanical I
- Damaged or contaminated accessory drive
belt
- Damaged or contaminated pulley(s)
- lncorrect accessory drive belt
- lncorrect fitment of the accessory drive belt
- Accessory drive belt tensioner
- Accessory drive belt idler pulley
- Generator
- Power steering pump
- Power steering pump leakage
- Air conditioning (AIC) compressor
- Pulley(s)
- Loose hardware
3.
If an obvious cause for an observed or reported
concern is found, correct the cause (if
possible)
before proceeding to the next step.
Accessory Drive Belt Concerns
A CAUTI0N:Do not lubricate the accessory
drive belt, accessory drive belt tensioner
or idler
pulley(s) as potential damage to
the accessory drive belt material
construction, accessory drive belt
tensioner damping mechanism, accessory
drive belt tensioner pulley bearing and idler
pulley(s) bearing may occur.
Cracking
Accessory drive belts are made from rubber which
hardens with time and can
develop cracks. As the
belt runs on the back of some of the pulleys, the
cracks are opened up.
Small cracks are not
considered to be a
failure of the belt. Only if the
,crack is deep enough to reach the bottom of the
grooveto expose the cord or any chunks are found
to be missing from the
belt, is the belt condition
considered to be
unacceptable.
1. Check the accessory drive belt for cracks. If the
damage exceeds the
acceptable limit, install a
new accessory drive
belt.
REFER to: Accessory Drive Belt - 1.3L
Duratec-8V (Rocam) (303-05 Accessory Drive,
Removal and Installation).
REFER to: Accessory Drive Belt - 1.4L
Duratec-1 6V (Sigma)/l.GL Duratec-1 6V
(Sigma), Vehicles With: Air Conditioning
(303-05 Accessory Drive,
Removal and
Installation).
REFER to: Power Steering Pump Belt - 1.4L
Duratec-1 6V (Sigma)/l .6L Duratec-1 6V
(Sigma), Vehicles With: Air Conditioning
(303-05 Accessory Drive,
Removal and
Installation).
REFER to: Accessory Drive Belt - I .4L
Duratec-I 6V
(Sigma)/l .6L Duratec-I 6V
(Sigma),
Vehicles Without: Air Conditioning
(303-05 Accessory Drive,
Removal and
Installation).
REFER to: Accessory Drive Belt - 1.4L
Duratorq-TDCi (DV) Diesel (303-05 Accessory
Drive,
Removal and Installation).
REFER to: Accessory Drive Belt - 1.6L
Duratorq-TDCi (DV) Diesel (303-05 Accessory
Drive,
Removal and Installation).
REFER to: Accessory Drive Belt - 2.OL
Duratec-HE (M14) (303-05 Accessory Drive,
Removal and Installation).
Chunking
Chunking describes the condition where long
lengths of rubber become detached from the ribs
of the
belt. This is considered to be a failure of the
belt.
2006.0 Fiesta 1212006 G346263en
procarmanuals.com

303-05-6 Accessory Drive 303-05-6
DIAGNOSIS AND TESTING
2. Check the accessory drive belt for damage. If
any chunks are found to be missing, install a
new accessory drive
belt.
REFER to: Accessory Drive Belt - 1.3L
Duratec-8V (Rocam) (303-05 Accessory Drive,
Removal and Installation).
REFER to: Accessory Drive Belt - 1.4L
Duratec-1 6V (Sigma)/l .6L Duratec-1 6V
(Sigma), Vehicles With: Air Conditioning
(303-05 Accessory Drive,
Removal and
Installation).
REFER to: Power Steering Pump Belt - 1.4L
Duratec-1 6V (Sigma)/l .6L Duratec-1 6V
(Sigma), Vehicles With: Air Conditioning
(303-05 Accessory Drive,
Removal and
Installation).
REFER to: Accessory Drive Belt - 1.4L
Duratec-I 6V (Sigma)/l .6L Duratec-I 6V
(Sigma), Vehicles Without: Air Conditioning
(303-05 Accessory Drive,
Removal and
Installation).
REFER to: Accessory Drive Belt - I .4L
Duratorq-TDCi (DV)
Diesel (303-05 Accessory
Drive,
Removal and Installation).
REFER to: Accessory Drive Belt - 1.6L
Duratorq-TDCi (DV) Diesel (303-05 Accessory
Drive,
Removal and Installation).
REFER to: Accessory Drive Belt - 2.OL
Duratec-HE (M14) (303-05 Accessory Drive,
Removal and Installation).
3. Check the accessory drive belt for pilling. The (.
condition of the belt should be compared against
the
illustration.
1. Small scattered pills. Not considered a
concern. No action required.
Pilling 2. Small scattered pills. Not considered a ,
concern. No action required. Pilling is dust that forms in between the ribs of the
belt from rubber that is worn off the belt when it is
new. There may
also be loose particles left on the
belt during the manufacturing process. These are
worn off and form into
small balls of rubber that
then get trapped in the grooves of the
belt. This
condition
will usually clear itself within 4800 km -
8000 km (3000 miles - 5000 miles) of normal
driving.
2006.0 Fiesta 12/2006 G346263en
procarmanuals.com

303-05-7 Accessory Drive 303-05-7
DIAGNOSIS AND TESTING
3. Longer pills up to 50% of the rib height. 4.
Longer pills up to 50% of the rib height.
Possible noise concern. INSTALL a new belt Possible noise
concern. INSTALL a new belt
if noise is apparent. if noise is apparent.
REFER to: Accessory Drive Belt
- 1.3L
Duratec-8V (Rocam) (303-05 Accessory
Drive, Removal and Installation)
1 Accessory Drive Belt
- 1.4L Duratec-16V
(Sigma)/l .6L Duratec-I 6V (Sigma),
Vehicles With: Air Conditioning (303-05
Accessory Drive, Removal and lnstallation)
1 Power Steering Pump Belt
- I .4L
Duratec-1
6V (Sigma)ll .6L Duratec-I 6V
(Sigma), Vehicles With: Air Conditioning
(303-05 Accessory Drive, Removal and
Installation)
1 Accessory Drive Belt
- 1.4L Duratec-I 6V
(Sigma)ll .6L Duratec-I 6V (Sigma),
Vehicles Without: Air Conditioning (303-05
Accessory Drive, Removal and Installation)
1 Accessory Drive Belt
- 1.4L Duratorq-TDCi
(DV) Diesel (303-05 Accessory Drive,
Removal and Installation)
I Accessory Drive Belt - 1.6L Duratorq-TDCi
(DV) Diesel (303-05 Accessory Drive,
Removal and Installation)
1 Accessory Drive Belt
- 2.OL Duratec-HE
(M14) (303-05 Accessory Drive, Removal
and Installation). REFER to:
Accessory Drive Belt
- I .3L
Duratec-8V
(Rocam) (303-05 Accessory
Drive, Removal and Installation)
1 Accessory Drive Belt
- I .4L Duratec-1 6V
(Sigma)ll .6L Duratec-1 6V (Sigma),
Vehicles With: Air Conditioning (303-05
Accessory Drive, Removal and lnstallation)
I Power Steering Pump Belt - I .4L
Duratec-1
6V (Sigma)ll .6L Duratec-I 6V
(Sigma), Vehicles With: Air Conditioning
(303-05 Accessory Drive, Removal and
Installation)
I Accessory Drive Belt - I .4L Duratec-I 6V
(Sigma)ll .6L Duratec-1 6V (Sigma),
Vehicles Without: Air Conditioning (303-05
Accessory Drive, Removal and lnstallation)
1 Accessory Drive Belt
- 1.4L Duratorq-TDCi
(DV) Diesel (303-05 Accessory Drive, Removal and Installation)
1 Accessory Drive Belt
- 1.6L Duratorq-TDCi
(DV) Diesel (303-05 Accessory Drive,
Removal and Installation)
1 Accessory Drive Belt
- 2.OL Duratec-HE
(M14) (303-05 Accessory Drive, Removal
and Installation).
2006.0 Fiesta 1212006 G346263en
procarmanuals.com