warning FORD FIESTA 2012 Owners Manual

Note:A fuel spillage concern may occur if overfilling the fuel tank. Do
not overfill the tank to the point that the fuel is able to bypass the fuel
filler nozzle.
If the check fuel fill inlet lamp comes on, the fuel fill inlet may not have
properly closed. The inlet may have stuck open or debris may be
preventing the inlet from fully closing. At the next opportunity, safely
pull off the road, turn off the engine, open the fuel filler door and
remove any visible debris from the fuel fill opening. Insert either the fuel
fill nozzle or the fuel fill funnel (seeRefilling with a portable fuel
containerfor funnel location) provided with the vehicle several times to
dislodge any debris and/or allow the inlet to close properly. If this action
corrects the problem, the check fuel fill inlet lamp may not reset
immediately. It may take several driving cycles for the check fuel fill inlet
lamp to turn off. A driving cycle consists of an engine start-up (after four
or more hours with the engine off) followed by city/highway driving.
Continuing to drive with the check fuel fill inlet lamp on may cause the
service engine soon lamp to turn on as well.
WARNING:The fuel system may be under pressure. If you hear
a hissing sound near the fuel filler door (Easy Fuel“no cap”
fuel system), do not refuel until the sound stops. Otherwise, fuel may
spray out, which could cause serious personal injury.
Choosing the right fuel
Use only UNLEADED fuel or UNLEADED fuel blended with a maximum
of 10% ethanol. Do not use fuel ethanol (E85), diesel, methanol, leaded
fuel or any other fuel. The use of leaded fuel is prohibited by law and
could damage your vehicle.
Your vehicle was not designed to use fuel or fuel additives with metallic
compounds, including manganese-based additives.
Note:Use of any fuel other than those recommended may cause
powertrain damage, a loss of vehicle performance, and repairs may not
be covered under warranty.
Octane Recommendations
“Regular” unleaded gasoline with a
pump (R+M)/2 octane rating of 87 is
recommended. Some stations offer
fuels posted as “Regular” with an
octane rating below 87, particularly
in high altitude areas. Fuels with octane levels below 87 are not
recommended.
87(R+M)/2 METHOD
Maintenance and Specifications
310
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

Do not be concerned if your engine sometimes knocks lightly. However, if
it knocks heavily under most driving conditions while you are using fuel
with the recommended octane rating, see your authorized dealer to
prevent any engine damage.
Fuel quality
If you are experiencing starting, rough idle or hesitation driveability
problems during a cold start, try a different brand of “Regular” unleaded
gasoline.
Do not add aftermarket fuel additive products to your fuel tank. It
should not be necessary to add any aftermarket products to your fuel
tank if you continue to use high quality fuel of the recommended octane
rating. These products have not been approved for your engine and
could cause damage to the fuel system. Repairs to correct the effects of
using an aftermarket product in your fuel may not be covered by your
warranty.
Many of the world’s automakers approved the World-Wide Fuel Charter
that recommends gasoline specifications to provide improved
performance and emission control system protection for your vehicle.
Gasolines that meet the World-Wide Fuel Charter should be used when
available. Ask your fuel supplier about gasolines that meet the
World-Wide Fuel Charter.
Cleaner air
Ford endorses the use of reformulated “cleaner-burning” gasolines to
improve air quality, per the recommendations in theChoosing the right
fuelsection.
Running out of fuel
Avoid running out of fuel because this situation may have an adverse
effect on powertrain components.
If you have run out of fuel:
•You may need to cycle the ignition from off to on several times after
refueling to allow the fuel system to pump the fuel from the tank to
the engine. On restarting, cranking time will take a few seconds longer
than normal.
•Normally, adding 1 gallon (3.8L) of fuel is enough to restart the
engine. If the vehicle is out of fuel and on a steep grade, more than
1 gallon (3.8L) may be required.
•The service engine soon
indicator may come on. For more
information on the service engine soon indicator, refer toWarning
lights and chimesin theInstrument Clusterchapter.
Maintenance and Specifications
311
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

Refilling with a portable fuel container
With the Easy Fuel“no cap” fuel system, use the following directions
when filling from a portable fuel container:
WARNING:Do not insert the nozzle of portable fuel containers
or aftermarket funnels into the Easy Fuelsystem. This could
damage the fuel system and its seal, and may cause fuel to run onto
the ground instead of filling the tank, which could result in serious
personal injury.
WARNING:Do not try to pry open or push open the Easy Fuel
system with foreign objects. This could damage the fuel system
and its seal and cause injury to you or others.
When filling the vehicle’s fuel tank from a portable fuel container, use the
included funnel.
1. To locate the white plastic funnel,
lift the carpeted floor panel covering
the spare tire in the rear of the
vehicle. The funnel is visible in the
foam pod on the spare tire.
2. Slowly insert the funnel into the Easy Fuelsystem.
3. Fill the vehicle with fuel from the portable fuel container.
4. When done, clean the funnel or properly dispose of it. Extra funnels
can be purchased from your authorized dealer if you choose to dispose
of the funnel.Do notuse aftermarket funnels; they will not work with
the Easy Fuelsystem and can damage it. The included funnel has been
specially designed to work safely with your vehicle.
Maintenance and Specifications
312
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

EMISSION CONTROL SYSTEM
WARNING:Do not park, idle, or drive your vehicle in dry grass
or other dry ground cover. The emission system heats up the
engine compartment and exhaust system, which can start a fire.
WARNING:Exhaust leaks may result in entry of harmful and
potentially lethal fumes into the passenger compartment. If you
smell exhaust fumes inside your vehicle, have your dealer inspect your
vehicle immediately. Do not drive if you smell exhaust fumes.
Your vehicle is equipped with various emission control components and a
catalytic converter which will enable your vehicle to comply with
applicable exhaust emission standards. To make sure that the catalytic
converter and other emission control components continue to work
properly:
•Use only the specified fuel listed.
•Avoid running out of fuel.
•Do not turn off the ignition while your vehicle is moving, especially at
high speeds.
•Have the items listed inscheduled maintenance information
performed according to the specified schedule.
The scheduled maintenance items listed inscheduled maintenance
informationare essential to the life and performance of your vehicle
and to its emissions system.
If other than Ford, Motorcraftor Ford-authorized parts are used for
maintenance replacements or for service of components affecting
emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
Illumination of the service engine soon indicator, charging system
warning light or the temperature warning light, fluid leaks, strange odors,
smoke or loss of engine power could indicate that the emission control
system is not working properly.
An improperly operating or damaged exhaust system may allow exhaust
to enter the vehicle. Have a damaged or improperly operating exhaust
system inspected and repaired immediately.
Maintenance and Specifications
316
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transmission components.
Checking 5-speed manual transmission fluid (if equipped)
The manual transmission does not have a transmission fluid dipstick.
1. Clean the filler plug.
2. Remove the filler plug and
inspect the fluid level.
3. Fluid level should be at the
bottom of the opening.
4. Add enough fluid through the
filler opening so that the fluid level
is 5-10 mm below the bottom of the
opening.
5. Install and tighten the fill plug securely.
Use only fluid that meets Ford specifications. Refer to theMaintenance
product specifications and capacitiessection in this chapter.
AIR FILTER
Refer toscheduled maintenance informationfor the appropriate
intervals for changing the air filter element.
When changing the air filter element, use only the air filter element
listed. Refer toMotorcraftpart numbersin this chapter.
WARNING:To reduce the risk of vehicle damage and/or
personal burn injuries do not start your engine with the air
cleaner removed and do not remove it while the engine is running.
Maintenance and Specifications
320
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

Owner Checks and Services
Certain basic maintenance checks and inspections should be performed
by the owner or a service technician at the intervals indicated. Service
information and supporting specifications are provided in this owner’s
guide.
Any adverse condition should be brought to the attention of your dealer
or qualified service technician as soon as possible for the proper service
advice. The owner maintenance service checks are generally not covered
by warranties so you may be charged for labor, parts or fluids used.
Engine oil/coolant change intervals
Engine oilAs indicated by the message center: do not
exceed one year or 10,000 miles (16,000 km)
Engine coolant,
initial change6 years or 100,000 miles (160,000 km)
(whichever comes first)
Engine coolant, after
initial changeEvery 3 years or 50,000 miles (80,000 km)
Check every month
Engine oil level
Function of all interior and exterior lights
Tires for wear and proper pressure, including spare
Windshield washer fluid level
Check every six months
Battery connections; clean if necessary
Body and door drain holes for obstructions; clean if necessary
Cooling system fluid level and coolant strength
Door weatherstrips for wear; lubricate if necessary
Hinges/latches/outside locks for proper operation; lubricate if necessary
Parking brake for proper operation
Safety belts and seat latches for wear and function
Safety warning lamps (brake, ABS, airbag, safety belt) for operation
Washer spray/wiper operation; clean or replace blades as necessary
Scheduled Maintenance
340
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

Multi-Point Inspection
In order to keep your vehicle running right, it is important to have the
systems on your vehicle checked regularly. This can help identify
potential issues and prevent major problems. Ford Motor Company
recommends the following multi-point inspection be performed at every
scheduled maintenance interval to help make sure your vehicle keeps
running great.
Multi-point inspection – Recommended each visit
Accessory drive belt(s) Half-shaft dust boots (if equipped)
Battery performance Horn operation
Clutch operation (if equipped) Radiator, cooler, heater and A/C hoses
Engine air filter Suspension component for leaks or
damage
Exhaust system Steering and linkage
Exterior lamps and hazard
warning system operationTires for wear and proper pressure,
including spare
Fluid levels*; fill if necessary Windshield for cracks, chips or pits
For oil and fluid leaks Washer spray and wiper operation
*Brake, coolant recovery reservoir, manual and automatic transmission
(with an underhood dipstick), power steering (if equipped) and
window washer
Be sure to ask your dealership service advisor or technician about the
multi-point vehicle inspection. It’s a comprehensive way to perform a
thorough inspection of your vehicle. It’s your checklist that gives you
immediate feedback on the overall condition of your vehicle. You’ll know
what’s been checked, what’s okay, as well as those things that may
require future or immediate attention. The multi-point vehicle inspection
is one more way to keep your vehicle running great!
Scheduled Maintenance
341
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

911 Assist™ ................................69
A
Accessing call history/phone
book during active call ...............52
Accessing your media menu
features ........................................80
Accessing your phone menu
features ........................................56
Active call menu options ...........52
Advanced menu options .......64, 86
Advanced menu options
(prompts, languages, defaults,
master reset, installing
applications) ................................64
AdvanceTrac ..............................243
Airbag supplemental restraint
system ........................170, 179, 182
and child safety seats ............172
description ..............170, 179, 182
disposal ....................................185
driver airbag ............172, 180, 183
indicator light .................179, 185
operation .................172, 180, 183
passenger airbag .....172, 180, 183
side airbag ...............................179
Air cleaner filter .......320–321, 324
Ambient mood/lighting .............109
Antifreeze (see Engine
coolant) .....................................302
Anti-lock brake system (see
Brakes) ......................................241
Anti-theft system ..............144, 146
arming the system ..........145–146
disarming a triggered
system .....................................146
triggering .................................146AppLink™ ...................................74
Armrests ....................................151
Audio system (see Radio) ...24, 29
Automatic transmission ....249, 251
driving an automatic
overdrive .................................249
fluid, adding ............................319
fluid, checking ........................319
Auxiliary input jack (Line in) ....33
Auxiliary powerpoint ................121
B
Battery .......................................300
acid, treating emergencies .....300
jumping a disabled battery ....274
maintenance-free ....................300
replacement, specifications ...324
servicing ..................................300
Belt-Minder.............................165
Blind spot mirror ......................256
Booster seats .............................200
Brakes ................................240–241
anti-lock ...................................241
anti-lock brake system (ABS)
warning light ...........................241
fluid, checking and adding ....319
fluid, refill capacities ..............325
fluid, specifications .................325
lubricant specifications ..........325
parking ....................................242
shift interlock ..........................247
Break-in period .............................5
Bulbs ..........................................110
C
Capacities for refilling fluids ....325
Index
354
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

Inspection/maintenance (I/M)
testing ........................................318
Instrument panel
cleaning ...................................291
cluster ........................................12
lighting up panel and
interior .....................................106
Intelligent Access Key ..............132
Intelligent Access with push
button start ...............................138
J
Jack ............................................268
positioning ...............................268
storage .....................................268
Joining two calls
(multiparty/conference call) ......52
Jump-starting your vehicle ......274
K
Keyless entry system
autolock ...........................134–135
Keys ...................................131, 146
positions of the ignition .........233
L
Lamps
bulb replacement
specifications chart ................110
daytime running light .............106
headlamps ...............................105
instrument panel, dimming ...106
interior lamps .........108–109, 111
replacing bulbs .......................111
LATCH anchors .........................194
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........241Load limits .................................224
Locks
autolock ...........................134–135
childproof ................................136
Lubricant specifications ...........325
Lug nuts ....................................273
M
Manual transmission .................252
fluid capacities ........................325
lubricant specifications ..........325
reverse .....................................253
Media Bluetooth menu options
(adding, connecting, deleting,
turning on/off) ............................85
Media menu layout .....................79
Message center ...........................18
warning messages .....................20
Mirrors ...............................124–125
automatic dimming rearview
mirror ......................................124
heated ......................................125
side view mirrors (power) .....125
signal .......................................126
Moon roof ..................................128
Motorcraftparts ..............293, 324
O
Octane rating ............................310
Oil (see Engine oil) ..................298
P
Pairing other phones ..................49
Pairing your phone for the first
time ..............................................48
Index
357
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com

Parking brake ............................242
Parts (see Motorcraft
parts) .........................................324
Passenger Occupant
Classification Sensor .................157
Phone Bluetooth menu options
(adding, connecting, deleting,
turning on/off) ............................63
Phone dependent features .........47
Phone menu layout ....................55
Phone redial ................................56
Playing music (by artist,
album, genre, playlist, tracks,
similar) ........................................81
Power distribution box (see
Fuses) ........................................264
Power door locks ......................133
Power mirrors ...........................125
Powerpoint ................................121
Power steering ..................246–247
Power Windows .........................122
Privacy information ....................44
Push button start system .........236
Putting a call on/off hold ...........52
R
Radio ......................................24, 29
Receiving a text message ...........58
Recommendations for
attaching safety restraints for
children ......................................188
Relays ........................................260
Remote entry system ...............138
illuminated entry ....................144locking/unlocking doors .........140
opening the trunk ...................140
replacement/additional
transmitters .....................142, 144
replacing the batteries ...........140
Roadside assistance ..................258
S
Safety belts (see Safety
restraints) ..........159, 161–162, 164
Safety defects, reporting ..........286
Safety information ......................44
Safety
restraints ...........159, 161–162, 164
Belt-Minder...........................165
extension assembly ................164
for adults .........................161–162
for children .............................186
Occupant Classification
Sensor ......................................157
warning light and chime ........165
Safety restraints - LATCH
anchors ......................................194
Safety seats for children ..........190
Safety Compliance
Certification Label ....................328
Satellite Radio Information ........39
Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............343
Seats ..........................................147
child safety seats ....................190
heated ......................................152
SecuriLock passive anti-theft
system ........................................144
Selecting your media source
(USB, Line in, BT audio) ...........80
Index
358
2012 Fiesta(fie)
Owners Guide, 3rd Printing
USA(fus)
ProCarManuals.com