FORD GT 2020 Warranty Guide

EMISSIONS DEFECT WARRANTY COVERAGE
During the warranty coverage period, Ford Motor Company
warrants that:
• your vehicle or engine is designed, built, and equipped to meet- at the time it is sold - the emissions regulations of the U.S.
Environmental Protection Agency (EPA).
• your vehicle or engine is free from emission-related defects in factory-supplied materials or workmanship, which are defects
that could prevent the vehicle or engine from conforming with
applicable EPA regulations.
• you will not be charged for diagnosis, repair, replacement, or adjustment of parts containing an emissions-related defect.
Applicable parts are listed under What is Covered?on
pages 22-23.
The warranty coverage period for:
• Passenger cars, light duty trucks (applies to vehicles up to 8,500 pounds GVWR)
— The emission warranty coverage period is 8 years or 80,000 miles (whichever occurs first) for catalytic converters,
electronic emission control units, and onboard emissions
diagnostic devices.
—
All other parts covered under your emissions warranty are warranted for 3 years or 36,000 miles whichever comes first.
20

EMISSIONS PERFORMANCE WARRANTY COVERAGE
Under Emissions Performance Warranty Coverage, Ford Motor
Company will repair, replace, or adjust - with no charge for labor,
diagnosis, or parts - any emissions control device or system, if
you meet all of the following conditions:
• You have maintained and operated your vehicle according tothe instructions on proper care in the Owner’s Manualand this
booklet.
•
Your vehicle fails to conform, during the warranty coverage
period, to the applicable national EPA standards, as determined
by an EPA approved inspection and maintenance program.
•You are subject to a penalty or sanction under local, state, or
federal law because your vehicle has failed to conform to the
emissions standards. (A penalty or sanction can include being
denied the right to use your vehicle.)
• Your vehicle has not been tampered with, misused, or abused.
The warranty coverage period for:
• Passenger cars, light duty trucks (applies to vehicles up to 8,500 pounds GVWR)
— 8 years or 80,000 miles (whichever occurs first) for catalytic converter, electronic emissions control unit, and onboard
emissions diagnostic devices.
— 2 years or 24,000 miles (whichever occurs first) for all other covered parts .
See WHAT IS COVERED for list of covered parts.
Note that the warranty period begins on the Warranty Start Date
as specified on page 5 of this booklet.
21

WHAT IS COVERED?
For your vehicle if these parts contain an emissions-related
defect, they are covered by both the Emissions Defect Warranty
and the Emissions Performance Warranty.
• Air Flow Sensor
• Air/Fuel Feedback ControlSystem and Sensors
• Air Induction System
• Catalytic Converters
• Electronic Engine Control Sensors and Switches
• Powertrain Control Module (PCM)/ Engine Control
Module (ECM)*
• Evaporative Emission Control System
• Exhaust Manifold
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• Fuel Tank Pressure Control Valve
• Ignition Coil and/or Control Module • Intake Manifold
• Intercooler Assemblies -
Engine Charger
• Malfunction Indicator Lamp (MIL)/ On-Board Diagnostic
(OBD) System
• PCV system and Oil Filler Cap
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Control Module (TCM)
• Turbocharger Assemblies
• Vacuum Distribution System
* Includes hardware and emissions related software changes
only
22

Important Information About List of Parts
Also covered by the two emissions warranties are all
emissions-related bulbs, hoses, clamps, brackets, tubes, gaskets,
seals, belts, connectors, non-diesel fuel lines, sensors, and wiring
harnesses that are used with components on the list of parts,
above.
Concerning parts that should be replaced on a certain
maintenance schedule: these parts remain under warranty until :
(a) the first replacement time that is specified in yourOwner’s
Manual; or (b) the time or mileage limits of the Federal Defect
and Performance Warranties (whichever occurs first). Your Ford
GT Service dealer maintains a complete list of parts covered by
emissions warranties. For more details about the specific parts
covered by the Emissions Defect Warranty, contact your Ford GT
Service dealer.
WHAT IS NOT COVERED?
Ford Motor Company may deny you emissions warranty coverage
if your vehicle or a part does not contain an emissions-related
defect or has failed because of abuse, neglect, improper
maintenance, unapproved modifications, or any items included in
What Is Not Covered?, pages 13-17.
If you need more information about getting service under the
Federal Emissions Performance Warranty, or if you want to
report what you believe to be violations of the terms of this
warranty, you may contact:
Manager, Certification and Compliance Division
(6405J)
Warranty Claims
Environmental Protection Agency
Ariel Rios building
1200 Pennsylvania Avenue, N.W.
Washington, D.C. 20460
23

6. California requirements for emissions warranties
QUICK REFERENCE: EMISSIONS WARRANTY COVERAGE
This chart shows the emission warranty that Ford Motor
Company provides for your vehicle under the emissions control
warranty in accordance with the regulations of the California Air
Resources Board. This coverage is in addition to Federal Emission
warranties (Page 19).
24

Vehicles Eligible for California Emission Warranty Coverage
California emission warranty coverage applies if your vehicle
meets the following two requirements:
• Your vehicle is registered in a state* that has adopted and isenforcing California emission warranty regulations applicable
for your vehicle at the time of repair, and
• Your vehicle is certified for sale in California as indicated on the vehicle emission control information label.
* Subject to change, the following states have adopted and are
enforcing California emission warranty regulations: -Passenger Car & Light-duty Trucks (up to 8,500 pounds
GVWR) - California, Connecticut, Delaware, Maine,
Maryland, Massachusetts, New Jersey, New York, Oregon,
Pennsylvania, Rhode Island, Vermont and Washington
- Medium-Duty Passenger Vehicles (up to 10,000 pounds
GVWR designed primarily for the transportation of
persons. Excludes incomplete trucks, trucks with a
seating capacity either over twelve persons total or over
nine persons rearward of the driver’s seat, or trucks with
an open cargo area of at least six feet of interior length):
California, Connecticut, Delaware, Maine, Maryland,
Massachusetts, New York, Oregon, Rhode Island, Vermont
and Washington
For full details about coverage under California requirements for
emissions control, see:
→ Defects Warranties (pages 26-31)
→ Performance Warranty (pages 26-27)
→ What Is Covered? (pages 28-30)
→ What Is Not Covered? (page 30)
25

EXPLANATION OF CALIFORNIA EMISSIONS WARRANTIES
Your Warranty Rights and Obligations
The California Air Resources Board and Ford Motor Company are
pleased to explain the emission control system warranty on your
2020-model vehicle. In California, new motor vehicles must be
designed, built, and equipped to meet the State's stringent
anti-smog standards. Ford must warrant the emission control
system on your vehicle for the periods of time listed on pages 26-27,
provided there has been no abuse, neglect, or improper maintenance
of your vehicle.
Your emission control system may include parts such as the
carburetor or fuel injection system, the ignition system, catalytic
converter, and the engine computer. Also included may be hoses,
belts, connectors, and other emissions-related assemblies.
Where a warrantable condition exists, Ford Motor Company will
repair your vehicle at no cost to you including diagnosis, parts,
and labor.
Manufacturer's Warranty Coverage
For Vehicles Eligible for California Emission Warranty Coverage
If Gross Vehicle Weight Rating is 14,000 lbs. or less:
For 3 years or 50,000 miles (whichever first occurs):
1. If your vehicle fails a Smog Check inspection, all necessary
repairs and adjustments will be made by Ford to ensure that your
vehicle passes the inspection. This is your emission control
system PERFORMANCE WARRANTY.
2. If any emissions-related part on your vehicle is defective, the
part will be repaired or replaced by Ford. This is your short-term
emission control system DEFECTS WARRANTY.
26

For 7 years or 70,000 miles (whichever first occurs):
If an emissions-related part listed on pages 29 and 30 with
coverage for 7 years or 70,000 miles is defective or if its failure
causes your vehicle to fail a Smog Check inspection, the part will
be repaired or replaced by Ford. This is your long-term emission
control system DEFECTS WARRANTY.
Owner's Warranty Responsibilities
As the vehicle owner, you are responsible for the performance of
the required maintenance listed in your owner's manual. Ford
Motor Company recommends that you retain all receipts
covering maintenance on your vehicle, but Ford cannot deny
warranty coverage solely for the lack of receipts or for your failure
to ensure the performance of all scheduled maintenance.
You are responsible for presenting your vehicle to a Ford Motor
Company dealer as soon as a problem exists. The warranty
repairs should be completed in a reasonable amount of time, not
to exceed 30 days.
As the vehicle owner, you should also be aware that Ford Motor
Company may deny you warranty coverage if your vehicle or a
part has failed due to abuse, neglect, improper maintenance, or
unapproved modifications.
If you have any questions regarding your warranty rights and
responsibilities, or if you want to report what you believe to be
violations of the terms of this warranty, you may contact the Ford
Customer Relationship Center at 1-800-392-3673 (FORD) or the
California Air Resources Board at:
California Air Resource Board
9528 Telstar Avenue
El Monte, CA 9173127

WHAT IS COVERED?
If the parts on the following list contains a defect that affects
emissions, they are covered by the Defects Warranties.
• Air Flow Sensor
• Air/Fuel Feedback ControlSystem and Sensors
• Air Induction System
• Catalytic Converters
• Electronic Engine Control Sensors and Switches
• Powertrain Control Module (PCM)/Engine Control
Module (ECM)*
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• Fuel Tank Pressure Control Valve • Idle Air Bypass Valve
• Ignition Coil and/or Control
Module
• Intake Manifold
• Intercooler Assemblies - Engine Charger
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic
(OBD) System
• PCV System and Oil Filler Cap
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Control Module (TCM)
• Turbocharger Assemblies
• Vacuum Distribution System
* Includes hardware and emissions related software changes
only
28

COVERAGE FOR 2020 MODEL VEHICLE (GVWR OF 14,000 LBS. OR LESS)UNDER LONG TERM DEFECTS WARRANTY
APPLICABLE ONLY TO CALIFORNIA-CERTIFIED VEHICLES REGISTERED IN A STATE THAT HAS
ADOPTED AND IS ENFORCING CALIFORNIA EMISSION WARRANTY REGULATIONS (Coverage for (Coverage for up to 7 years/70,000 miles, whichever first occurs)
Part Name GT
Catalyst X
Y-Pipe X
Cam Timing Assembly Engine Variable RH X
Housing and Valve Assembly Camshaft Variable Timing X
Cam Timing Assembly Engine Variable LH X
High Pressure Line LH, RH X
CHG Assembly Engine Exhaust Drive LH X
Intercooler LH, RH X
Transmission/Differential Assembly X
Transmission Control Unit X
Fuel Tank Assembly X
Inlet Hose Fuel Filler X
Fuel Line Filter to Flange X
Fuel System Wiring (2) X
Manifold Assembly Fuel Injection Supply X
Fuel Line Filter to Flange X
Fuel Level Sensor ASM X
Dual Pump Assembly X
Fuel Vapor Hose ASM X
High Pressure Fuel Pump Assembly X
Manifold Assembly Intake X
Manifold Exhaust RH X
Manifold Exhaust LH X
PCV Vacuum Line X
Exhaust Manifold Gasket X
Gasket, Exhaust Manifold to Turbo X
Fuel Injectors X
Air Box LH, RH X
Vapor Purge Line ASM X
Valve Assembly Fuel Vapor Purge X
Instrument Cluster (1) X
Wiring Assembly (2) X
Power Control Module X
Engine Knock Sensor X
Dash Panel and Headlight Junction Harness (2) X
Main Wiring Harness (2) X
Jumper Harness (2) X
Capless Filler Neck X
Positive Crankcase Ventilation (PCV) Hose X
Fuel Tank Filler Hose X
Fuel Filter Inlet Tube Assembly X
Direct Fuel Injector X
Fuel Sender Wiring Assembly (2) X
Transmission Harness Connector X
Oil Pump Assembly (2) X
(1) for Service Engine Soon/Malfunction Indicator Lamp (MIL) functionality concerns only
(2) for MIL illumination only
29