engine FORD MUSTANG 1996 4.G Owners Manual

300
*
[SV54550( ALL)09/95]
NOTE: Rear axle lube quantities must be
replaced every 100,000 miles
(160,000 km) or if the axle has been
submerged in water. Otherwise, the
lube should not be checked or changed
unless a leak is suspected or repair
required.
%*
[SV54600( ALL)10/95]
Motorcraft Parts
[SV54700(M )03/95]
fourteen pica chart:0010451-M[SV55000( ALL)09/94]
If a spark plug is removed for examination, it
must be reinstalled in the same cylinder.
[SV55025(MBC )05/94]
For 3.8L engines:
[SV55050(MBC )03/95]
Cylinders #1, #2, #3 have an EG suffix.
[SV55075(MBC )03/95]
Cylinders #4, #5, #6 have an E suffix.
[SV55100( ALL)05/95]
For 4.6L (2V) engines:
[SV55125( ALL)05/95]
Cylinders #1, #2, #3, #4 have a PG suffix.
[SV55150( ALL)05/95]
Cylinders #5, #6, #7, #8 have a P suffix.
[SV55200( ALL)03/95]
If a spark plug needs to be replaced, use only
spark plugs with the service number suffix letter
as shown on the engine decal.
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

303
*
[SV57600( ALL)01/95]
Body
*
[SV57700( ALL)01/95]
q
Wash vehicle thoroughly to remove dirt,
grease, oil, tar or mud from exterior surfaces,
rear wheel housing and underside of front
fenders.
*
[SV57800( ALL)01/95]
q
Periodically wash vehicles stored in exposed
locations.
*
[SV57900( ALL)01/95]
q
Touch-up raw or primed metal to prevent
rust.
*
[SV58000( ALL)01/95]
q
Cover chrome and stainless steel parts with a
thick coat of auto wax to prevent
discoloration. Re-wax as necessary when the
vehicle is washed.
*
[SV58100( ALL)04/95]
q
Lubricate all hood, door and trunk lid hinges
and latches with a light grade oil.
*
[SV58200( ALL)01/95]
q
Cover interior soft trim to prevent fading.
*
[SV58300( ALL)01/95]
q
Keep all rubber parts free from oil and
solvents.
%*
[SV58350( ALL)01/95]
Engine
*
[SV58400( ALL)01/95]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[SV58500( ALL)01/95]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[SV58600( ALL)01/95]
Fuel system
%*
[SV58700( ALL)07/94]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[SV58900( ALL)03/95]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

314 [QI01200(M )10/95]
full page art:0011106-E3.8L Engine Compartment
File:16rcqim.ex
Update:Wed Mar 27 13:23:08 1996

315 [QI01300(M )05/95]
full page art:0011348-A
4.6L (2V) Engine Compartment Ð GT Models Only
File:16rcqim.ex
Update:Wed Mar 27 13:23:08 1996

Index 317
Index
A
ABS warning light
(see Anti-lock brake system)....... 65
Accessory position on the ignition..... 49
Accessory power source,
power point outlet.......... 130
Additives, engine oil.......... 249
Air bag supplemental restraint system
and child safety seats........ 24,30
description............... 22
disposal................ 28
driver air bag........... 22,25
indicator light............. 67
operation............... 25
passenger air bag............ 25
proper seating............. 23
service and information labels...... 25
tone generator............. 28
wearing safety belts........... 22
Air cleaner filter
location............... 239
specifications............. 299
Air conditioning, manual heating and air
conditioning system........... 80
Alarm, activating remote personal.... 111
Alcohol, in fuel............. 244
Antenna, radio (see Electronic
sound system)..........141, 173
Antifreeze (see Engine coolant)...... 252
Anti-lock brake system (ABS)
description.............. 186
see also Brake............ 186
warning light.............. 65
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

Index 321
Cleaning your vehicle (continued)
engine compartment......... 242
exterior............... 5±6
exterior lamps............. 86
fabric................ 125
headlamps............... 86
instrument panel............ 80
instrument panel lens.......... 89
interior............... 125
interior lamps............. 89
mirrors............... 127
plastic parts.............. 7
polishing................ 6
rustproofing.............. 7
safety belts............... 21
tail lamps............... 86
upholstery and interior trim...... 125
washing............... 5±6
waxing................ 6
wheels................ 269
Climate control system
air conditioning............ 80
heating................ 80
heating only system........... 82
Clock.................. 89
Clutch
adjusting............... 272
fluid................. 272
fluid reservoir............ 272
operation while driving........ 182
recommended shift speeds....... 184
shifting the gears........... 183
specifications............. 300
Cold engine starting............ 53
Combination lap and shoulder belts . . . 9, 11
Compact disc player (see Electronic sound
system)............... 155
Console, description........... 129
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

322 Index
Controls
instrument panel............ 79
mirrors................ 125
steering column............. 91
Convertible
cleaning............... 138
installation of the boot......... 134
lowering the convertible top...... 132
raising the convertible top....... 137
Coolant (see Engine coolant)
checking and adding......... 252
drain and flush............ 257
preparing for storage......... 303
proper solution............ 255
refill capacities............ 298
specifications............. 300
temperature gauge........... 73
warnings............... 252
Cooling fan............... 236
Crankcase emission filter......... 299
Cruise control (see Speed control)...... 97
Customer Assistance Center, Ford (U.S.) . . 217
Customer Assistance Centre,
Ford of Canada..........217, 223
D
Dashboard (see Instrument panel)...... 79
Daytime running light system....... 84
Defects, reporting............ 222
Defrost
rear window.............. 83
windshield............... 82
Dipstick
automatic transmission fluid....269, 271
engine oil.............. 249
power steering fluid.......... 274
Disabled vehicle (see Towing)...... 213
Dispute Settlement Board........ 218
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

Index 323
Doors................. 103
lubricant specifications........ 300
Driving under special conditions
bad weather............. 190
heavy load.............. 192
high water.............. 191
slippery roads............ 190
tips for safe driving.......... 190
towing a trailer............ 194
E
Electrical system
circuit breakers............ 287
fuses..............278, 286
operating when the engine is off..... 49
power point outlet.......... 130
Electronic sound system
radio reception............ 173
tuning the radio.........142, 163
warranty and service information . . . 175
Electronic stereo cassette radio
(see Electronic sound system)..... 142
Emergencies, roadside
assistance.............. 215
battery acid spills........... 199
fuel................. 245
jump-starting............. 199
towing................ 213
Emergency brake (parking brake) . . . 187±188
Emission control system
catalytic converter.......... 293
emissions warranty......... 4,293
Engine
check engine warning light....... 70
does not start........... 54,57
fuel injected engine, starting..... 51,53
fuel pump shut-off switch........ 57
preparing to start..........51±52
refill capacities............ 298
service points............ 239
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

324 Index
Engine (continued)
starting............... 49,53
starting after a collision......... 57
storing your vehicle........301±302
Engine block heater............ 55
Engine coolant
checking and adding......... 252
checking hoses............ 254
disposal.........236, 251, 256, 271
drain and flush............ 257
low coolant warning light........ 68
preparing for storage......... 303
proper solution............ 255
recovery reservoir.........239, 252
refill capacities............ 298
specifications............. 300
temperature gauge........... 73
Engine coolant temperature gauge
description............... 73
mechanical.............73±74
Engine fan............... 236
Engine knocking............. 244
Engine oil
changing oil and oil filter.....249, 251
checking and adding......... 249
dipstick............... 249
disposal.........236, 251, 256, 271
engine oil pressure gauge........ 77
filter, specifications.......... 299
low oil warning light.......... 65
refill capacities............ 298
specifications...........248, 300
synthetic oil...........248±249
ªbreak-inº oils............. 5
viscosity.............248±249
Entry system, remote.......... 110
Exhaust fumes.............. 56
Extended Service Plan, Ford........ 4
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

Index 325
F
Fan
engine fan, avoiding injury...... 236
Federal Communications Commission . . . 174
Flashers, hazard.............. 94
Flashing the lights............. 92
Flat tire................ 205
Floor mats............... 139
Fluid refill capacities.......... 298
Foglamps................. 86
Ford Customer Assistance Center..... 217
Ford Dispute Settlement Board...... 218
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 223
Ford of Canada Customer
Assistance Centre........... 223
Foreign registration........... 224
French owner guides, how to obtain.... 3
Fuel
capacity............... 298
choosing the right fuel........ 243
filling your vehicle with fuel...... 242
filter, specifications.......... 299
fuel filler door release lever...... 242
fuel gauge............... 72
octane rating...........243±244
quality................ 243
running out of fuel.......... 246
safety information relating to
automotive fuels.......... 245
storing your vehicle.......... 302
treating emergencies......... 245
Fuel cap
removing.............. 242
replacing.............242±243
Fuel filler door
remote release............ 242
Fuel filter, specifications......... 299
Fuel gauge................ 72
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996