light FORD MUSTANG 1996 4.G Repair Manual

275
*
[SV35200( ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV35300( ALL)05/95]
3. Turn the engine off.
%*
[SV35400(MBC )03/94]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
*
[SV35500(MBC )07/94]
5. If the power steering fluid is low, add fluid
in small amounts, continuously checking the
level, until you reach the FULL HOT range.
Do not overfill.
*
[SV35600(MBC )03/95]
6. When you are finished, put the dipstick back
in and make sure that it fits snugly.
[SV35700(MBC )12/94]
half page art:0010485-C
The dipstick for power steering fluid
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

289
*
[SV43800(M GV)02/95]
Since the circuit breaker for the headlamps is
mounted in the headlamp switch, you must
replace the entire switch to install a new circuit
breaker.
%
*
[SV44400( ALL)03/95]
Lights and Bulb Replacement
*
[SV44500( ALL)01/95]
It is a good idea to check the operation of the
following lights frequently:
*
[SV44600( ALL)01/95]
q
headlamps
*
[SV44700( ALL)01/95]
q
tail lamps
*
[SV44800( ALL)01/95]
q
brakelamps
*
[SV44900( ALL)01/95]
q
hazard flasher
*
[SV44950( ALL)02/95]
q
high-mount brakelamp
*
[SV45000( ALL)01/95]
q
turn signals
*
[SV45200( ALL)01/95]
q
license plate lamp
[SV45400(M )08/93]
q
fog lamps (GT and Cobra models)
%*
[SV45600( ALL)01/95]
The alignment of your headlamps should be
checked if:
*
[SV45700( ALL)01/95]
q
oncoming motorists frequently signal you to
turn off your vehicle's high beams when you
do not have the high beams on
*
[SV45800( ALL)01/95]
q
the headlamps do not seem to give you
enough light to see clearly at night
*
[SV45900( ALL)01/95]
q
the headlamp beams are pointed substantially
away from a position slightly down and to
the right
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

295
those which your vehicle or engine was
originally equipped.
*
[SV53150( ALL)05/95]
Ford strongly recommends the use of genuine
Ford replacement parts. If other than Ford or
Motorcraft parts or Ford authorized
remanufactured parts are used for maintenance
replacements or for the service of components
affecting emission control, such non-Ford parts
should be equivalent to genuine Ford Motor
Company parts in performance and durability. It
is the owner's responsibility to determine the
equivalency of such parts. Please consult your
warranty booklet for complete warranty
information.
*
[SV53175( ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[SV53200( ALL)05/95]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
*
[SV53300( ALL)01/95]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[SV53400( ALL)01/95]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

302 [SV55500(M )03/95]
ten pica chart:0010581-F
*
[SV56400( ALL)09/95]
NOTE: Rear axle lube quantities must be
replaced every 100,000 miles
(160,000 km) or if the axle has been
submerged in water. Otherwise, the
lube should not be checked or changed
unless a leak is suspected or repair
required.
%
*
[SV57000( ALL)01/95]
Vehicle Storage
*
[SV57100( ALL)01/95]
Maintenance Tips
*
[SV57150( ALL)01/95]
If you plan on storing your vehicle for an
extended period of time (60 days or more), refer
to the following maintenance recommendations
to ensure your vehicle stays in good operating
condition.
*
[SV57200( ALL)01/95]
General
*
[SV57300( ALL)01/95]
q
Store all vehicles in a dry, ventilated place.
*
[SV57400( ALL)01/95]
q
Protect from sunlight, if possible.
*
[SV57500( ALL)01/95]
q
If vehicles are stored outside, they require
regular maintenance to protect against rust
and damage.
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

303
*
[SV57600( ALL)01/95]
Body
*
[SV57700( ALL)01/95]
q
Wash vehicle thoroughly to remove dirt,
grease, oil, tar or mud from exterior surfaces,
rear wheel housing and underside of front
fenders.
*
[SV57800( ALL)01/95]
q
Periodically wash vehicles stored in exposed
locations.
*
[SV57900( ALL)01/95]
q
Touch-up raw or primed metal to prevent
rust.
*
[SV58000( ALL)01/95]
q
Cover chrome and stainless steel parts with a
thick coat of auto wax to prevent
discoloration. Re-wax as necessary when the
vehicle is washed.
*
[SV58100( ALL)04/95]
q
Lubricate all hood, door and trunk lid hinges
and latches with a light grade oil.
*
[SV58200( ALL)01/95]
q
Cover interior soft trim to prevent fading.
*
[SV58300( ALL)01/95]
q
Keep all rubber parts free from oil and
solvents.
%*
[SV58350( ALL)01/95]
Engine
*
[SV58400( ALL)01/95]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[SV58500( ALL)01/95]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[SV58600( ALL)01/95]
Fuel system
%*
[SV58700( ALL)07/94]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[SV58900( ALL)03/95]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

304
*
[SV59000( ALL)01/95]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
%*
[SV59200( ALL)01/95]
Cooling system
*
[SV59300( ALL)01/95]
q
Protect against freezing temperatures.
%*
[SV59400( ALL)01/95]
Battery
*
[SV59500( ALL)01/95]
q
Check and recharge as necessary.
*
[SV59600( ALL)01/95]
q
Keep connections clean and covered with a
light coat of grease.
*
[SV59650( ALL)03/95]
q
If storing your vehicle for more than 30 days
without recharging the battery, it may be
advisable to disconnect the battery cables to
ensure battery charge is maintained for quick
starting.
[SV59675( ALL)05/94]
NOTE: If battery cables are disconnected, it
will be necessary to reset memory
features.
%*
[SV59700( ALL)01/95]
Brakes
*
[SV59800( ALL)01/95]
q
Make sure brakes and parking brake are fully
released.
%*
[SV59900( ALL)01/95]
Tires
*
[SV60000( ALL)05/95]
q
Maintain recommended air pressure.
*
[SV60100( ALL)01/95]
Miscellaneous
*
[SV60200( ALL)01/95]
q
Make sure all linkages, cables, levers and
clevis pins under vehicle are covered with
grease to prevent rust.
*
[SV60300( ALL)03/95]
q
Move vehicles at least 25 feet (8 m) every 15
days to lubricate working parts and prevent
corrosion.
File:15rcsvm.ex
Update:Thu Mar 28 14:48:54 1996

Index 317
Index
A
ABS warning light
(see Anti-lock brake system)....... 65
Accessory position on the ignition..... 49
Accessory power source,
power point outlet.......... 130
Additives, engine oil.......... 249
Air bag supplemental restraint system
and child safety seats........ 24,30
description............... 22
disposal................ 28
driver air bag........... 22,25
indicator light............. 67
operation............... 25
passenger air bag............ 25
proper seating............. 23
service and information labels...... 25
tone generator............. 28
wearing safety belts........... 22
Air cleaner filter
location............... 239
specifications............. 299
Air conditioning, manual heating and air
conditioning system........... 80
Alarm, activating remote personal.... 111
Alcohol, in fuel............. 244
Antenna, radio (see Electronic
sound system)..........141, 173
Antifreeze (see Engine coolant)...... 252
Anti-lock brake system (ABS)
description.............. 186
see also Brake............ 186
warning light.............. 65
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

318 Index
Anti-theft lug nuts and key........ 212
Anti-theft system
arming the system.......... 105
description.............. 104
disarming an untriggered system.... 106
disarming a triggered system...... 107
triggering............104, 107
warning light.............. 72
Appeals (see Dispute settlement board) . . 218
Assistance (see Customer assistance).... 215
Audio system (see Electronic
sound system)............ 141
Autolamp system (see Headlamps)..... 84
Automatic transmission
driving an automatic overdrive . . . 177, 180
fluid, adding............. 271
fluid, checking............ 270
fluid, refill capacities......... 298
fluid, specification........... 300
Axle
lubricant specifications......... 300
refill capacities............ 298
traction lok.............. 185
B
Backing up.............179, 183
Basic vehicle warranty........... 4
Battery
acid, treating emergencies.....199, 260
battery saver............. 112
charging system warning light...... 68
disconnecting...........204, 260
how to service............ 259
jumping a disabled battery....... 199
maintenance-free........... 259
proper disposal, recycling....... 260
replacement, specifications....... 299
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

Index 319
Battery (continued)
servicing............... 259
voltage gauge............. 76
when storing your vehicle....... 303
Brake fluid
brake warning light........... 64
checking and adding......... 272
description.............. 272
specifications............. 300
Brakelamp, bulb replacement....... 292
Brakes
adjustment.............. 186
anti-lock............... 186
anti-lock brake system (ABS)
warning light............ 65
applying the brakes.......... 186
brake warning light........... 64
fluid, checking and adding...... 272
fluid, refill capacities.......272, 298
fluid, specifications.......... 300
front disc.............. 186
if brakes do not grip well....... 186
master cylinder............ 272
new brake linings............ 5
noise..............186±187
parking............... 188
power braking............ 186
servicing............... 272
stopping distances.......... 190
trailer................ 196
when storing your vehicle....... 303
Brake-shift interlock........... 178
Break-in period.............. 5
Brights (high beams)........... 70
Bulbs
replacing............... 288
halogen............... 289
headlamps.............. 289
specifications............. 292
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996

320 Index
C
Canada, customer assistance....... 223
Canada, warranty information....... 4
Canadian Motor Vehicle Arbitration Plan
(CAMVAP).............. 223
Capacities for refilling fluids....... 298
Carbon monoxide in exhaust........ 56
Car seats for children
(see Child safety seats)......... 30
Cassette tape player (see Electronic
sound system)......141, 145, 162, 168
Catalytic converter............ 293
CD player (see Electronic
sound system)........148, 154, 155
Chains, tires.............. 268
Changing a tire............. 205
Charging system gauge.......... 76
Charging system warning light....... 68
Child safety restraints........... 28
child safety belts............ 46
child safety seats............ 30
Child safety seats
and air bags............ 24,30
automatic locking mode
(retractor)....... 14,15,30,32,39
in front seat............ 24,30
in front seat, convertible......... 32
in front seat, coupe........... 39
in rear outboard seat........ 30,39
in rear seat............... 30
Chime
key in ignition............. 51
safety belt............... 66
Circuit breakers
checking and replacing........ 287
see also fuses............. 278
Cleaning your vehicle
CD player and discs........152, 159
chrome and aluminum parts....... 7
File:rcixm.ex
Update:Wed Mar 27 09:41:15 1996