check engine light FORD MUSTANG 1997 4.G User Guide

231
*
[MC18000( ALL)12/95]
q
Reinstall the pressure cap securely.
*
[MC18100( ALL)12/95]
q
Check for leaks at the draincock.
*
[MC18200( ALL)12/95]
q
Recheck the engine coolant level, using the
recommended procedure, after one or two
occasions of vehicle use.
%
*
[MC18300( ALL)01/96]
Power Steering Fluid
*
[MC18400( ALL)01/96]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
%*
[MC18500( ALL)01/96]
Checking and Adding Power Steering
Fluid
[MC18650(M )04/96]
3.8L SFI engine (check warm)
*
[MC18700( ALL)04/96]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[MC18800( ALL)01/96]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[MC18900( ALL)01/96]
3. Turn the engine off.
%*
[MC19000(MBC )01/96]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
*
[MC19200(MBC )01/96]
5. If the power steering fluid is low, add fluid
in small amounts, continuously checking the
level, until you reach the FULL HOT range.
Do not overfill.
File:11rcmcm.ex
Update:Thu Apr 3 07:49:33 1997

252
*
[MC35700( ALL)12/95]
Self-Service Pointers
*
[MC35800( ALL)12/95]
If you choose to do your own fueling, you
should also perform a few simple maintenance
routines. This extra effort will save you
additional money and contribute to the driving
efficiency of your vehicle.
*
[MC35900( ALL)12/95]
The following procedures require only a tire
gauge, a rag, an oil can spout and windshield
washer fluid.
*
[MC36000( ALL)12/95]
q
Check the engine oil at every refueling stop
*
[MC36100( ALL)12/95]
q
Clean the windshield, outside mirrors and
headlights
*
[MC36200( ALL)12/95]
q
Check windshield washer fluid
*
[MC36300( ALL)12/95]
q
Check tires for excessive wear or worn edges
*
[MC36400( ALL)12/95]
q
Check the tire pressure at least monthly
%
*
[MC36500( ALL)01/96]
Emission Control System
*
[MC36600( ALL)01/96]
Your vehicle is equipped with a catalytic
converter which enables your vehicle to comply
with applicable exhaust emission requirements.
*
[MC36700( ALL)05/96]
RWARNING
Exhaust leaks may result in the entry of
harmful and potentially lethal fumes into
the passenger compartment. Under
extreme conditions excessive exhaust
temperatures could damage the fuel
system, the interior floor covering, or
other vehicle components, possibly
causing a fire.
File:11rcmcm.ex
Update:Thu Apr 3 07:49:33 1997

254
*
[MC37600( ALL)01/96]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[MC37700( ALL)01/96]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
*
[MC37800( ALL)01/96]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[MC37900( ALL)01/96]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
may be liable if their emission control device is
removed or is prevented from working.
*
[MC38000( ALL)08/95]
Never use a metal exhaust collector when you
service your vehicle. If the metal collector
contacts any of your vehicle's plastic trim or
bumper parts they could melt or deform.
*
[MC38100( ALL)01/96]
Do not drive your vehicle if it does not operate
properly. See your dealer if the engine runs on
for more than five seconds after you shut it off
or if it misfires, surges, stalls, or backfires.
File:11rcmcm.ex
Update:Thu Apr 3 07:49:33 1997

314 Index
Cold engine starting........... 151
Combination lap and shoulder belts . . 111, 114
Compact disc player (see Electronic sound
system)................. 34
Console, description............ 83
Controls, mirrors............. 77
Convenience kit in cargo area...... 193
Convertible
cleaning................ 91
installation of the boot.......... 87
lowering the convertible top....... 85
raising the convertible top........ 90
Coolant (see Engine coolant)....... 224
checking and adding......... 224
drain and flush............ 228
preparing for storage......... 270
refill capacities............ 266
specifications............. 267
temperature gauge........... 18
warnings............... 224
Cooling fan............... 210
Crankcase emission filter......... 265
Customer Assistance Center, Ford (U.S.) . . 277
Customer Assistance Centre,
Ford of Canada..........277, 283
D
Daytime running light system....... 59
Defrost
rear window.............. 58
windshield............... 57
Dipstick................ 217
automatic transmission fluid....234, 236
engine oil.............. 217
power steering fluid.......... 231
Disabled vehicle (see Towing)...... 207
Dispute Settlement Board........ 278
File:rcixm.ex
Update:Thu Apr 3 07:52:02 1997

316 Index
Engine
check engine warning light....... 17
does not start...........152, 190
fuel injected engine, starting....149±150
fuel pump shut-off switch....... 190
preparing to start........... 149
refill capacities............ 266
service points............. 213
starting................ 150
starting after a collision........ 190
storing your vehicle........268±269
Engine block heater........... 153
Engine coolant............. 224
checking and adding......... 224
checking hoses............ 226
disposal...........210, 219, 236
drain and flush............ 228
low coolant warning light........ 14
preparing for storage......... 270
proper solution........210, 219, 236
recovery reservoir.........213, 224
refill capacities............ 266
specifications............. 267
temperature gauge........... 18
Engine coolant temperature gauge..... 18
description............... 18
mechanical.............18±19
Engine coolant temperature
guage:electronic............. 18
Engine fan............... 210
Engine oil............... 216
changing oil and oil filter.....217, 219
checking and adding......... 217
dipstick............... 217
disposal...........210, 219, 236
engine oil pressure gauge........ 22
filter, specifications.......... 265
refill capacities............ 266
specifications...........216, 267
synthetic oil............. 216
File:rcixm.ex
Update:Thu Apr 3 07:52:02 1997

Index 321
J
Jack.................. 193
operation............194±195
positioning............194±196
storage............... 193
Jump-starting your vehicle
attaching cables............ 202
disconnecting cables.......... 206
K
Keys
key in ignition chime.......... 66
positions of the ignition......... 65
removing from the ignition....... 66
stuck in lock position........65±66
L
Lamps
bulb replacement specifications chart . . 260
checking............... 256
daytime running light system...... 59
dome lamps.............. 61
flashing the lamps........... 68
fog lamps............... 84
hazard flashers............. 71
headlamps............... 60
high beams.............. 68
illuminated mirrors........... 79
instrument panel, dimming....... 61
interior lamps........... 59,61
replacing bulbs............ 256
trailer................ 176
Lane change indicator (see Turn signal) . 67±68
Lights, warning and indicator
airbag................. 14
anti-lock brakes (ABS).......... 12
brake................. 11
charging system............ 15
check engine.............. 17
File:rcixm.ex
Update:Thu Apr 3 07:52:02 1997

322 Index
Lights, warning and indicator (continued)
engine oil pressure........... 22
hazard warning light.......... 71
high beam............... 16
low coolant............... 14
oil pressure............... 22
overdrive off.............. 15
safety belt............... 13
service engine soon........... 17
turn signal indicator....... 17,67±68
Load limits............... 170
GAWR................ 170
GVWR................ 170
trailer towing............. 173
Lubricant specifications......... 267
Lug nuts................ 194
anti-theft............... 199
standard............... 195
tightening sequence........194, 198
M
Maintenance schedule and record
(see separate Maintenance Schedule and
Record booklet)............. 4
Maintenance (see Servicing)....... 209
Maintenance (see servicing)........ 209
Manual transaxle
backing up (reverse).......... 168
clutch................ 167
shifting gears............. 168
shift speeds.............. 169
Manual transmission
backing up (reverse).......... 168
clutch..............167, 222
driving................ 167
fluid, checking and adding....... 237
fluid capacities............ 266
lubricant specifications......... 267
shifting gears............. 168
shift speeds.............. 169
File:rcixm.ex
Update:Thu Apr 3 07:52:02 1997

Index 327
Speedometer............... 20
Starting your vehicle
preparing to start your vehicle..... 149
starting a cold engine......... 151
starting after a collision........ 190
starting a warm engine........ 151
starting your vehicle if the
battery is disabled......... 200
Steering, power............. 161
Steering wheel
horn.................. 72
locking................ 65
tilting................. 72
Storage compartments, center console.... 83
Storing your vehicle........... 268
Sun visor................. 79
Sunvisor................. 79
Supplemental air bag readiness light.... 14
Supplemental Restraint System (SRS) . . . 124
T
Tachometer................ 21
mechanical cluster........... 21
Tail lamps
bulb replacement.........256, 260
cleaning............... 262
Temperature control (see Climate control) . . 55
Tilt steering wheel............ 72
Tires.................. 239
changing............... 191
checking the pressure......... 239
cleaning............... 264
inspection and maintenance...... 239
replacing............... 241
rotating............... 240
snow tires and chains......... 244
spare tire.............. 193
storing your vehicle.......... 271
File:rcixm.ex
Update:Thu Apr 3 07:52:02 1997