warning light FORD RANGER 2009 2.G Service Manual

•Normally, adding 1 gallon (3.8L) of fuel is enough to restart the
engine. If the vehicle is out of fuel and on a steep grade, more than
1 gallon (3.8L) may be required.
•TheService engine soon
indicator may come on. For more
information on theService engine soon
indicator, refer to
Warning lights and chimesin theInstrument Clusterchapter.
ESSENTIALS OF GOOD FUEL ECONOMY
Measuring techniques
Your best source of information about actual fuel economy is you, the
driver. You must gather information as accurately and consistently as
possible. Fuel expense, frequency of fill-ups or fuel gauge readings are
NOT accurate as a measure of fuel economy. We do not recommend
taking fuel economy measurements during the first 1,000 miles
(1,600 km) of driving (engine break-in period). You will get a more
accurate measurement after 2,000 miles–3,000 miles (3,000 km–5,000
km).
Filling the tank
The advertised fuel capacity of the fuel tank on your vehicle is equal to
the rated refill capacity of the fuel tank as listed in theMaintenance
product specifications and capacitiessection of this chapter.
The advertised capacity is the amount of the indicated capacity and the
empty reserve combined. Indicated capacity is the difference in the
amount of fuel in a full tank and a tank when the fuel gauge indicates
empty. Empty reserve is the small amount of fuel remaining in the fuel
tank after the fuel gauge indicates empty.
The amount of usable fuel in the empty reserve varies and should
not be relied upon to increase driving range. When refueling your
vehicle after the fuel gauge indicates empty, you might not be
able to refuel the full amount of the advertised capacity of the
fuel tank due to the empty reserve still present in the tank.
For consistent results when filling the fuel tank:
•Turn the engine/ignition switch to the off position prior to refueling,
an error in the reading will result if the engine is left running.
•Use the same filling rate setting (low — medium — high) each time
the tank is filled.
•Allow no more than two automatic click-offs when filling.
2009 Ranger(ran)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
247

Illumination of theService engine soonindicator, charging system
warning light or the temperature warning light, fluid leaks, strange odors,
smoke or loss of engine power could indicate that the emission control
system is not working properly.
An improperly operating or damaged exhaust system may allow exhaust
to enter the vehicle. Have a damaged or improperly operating exhaust
system inspected and repaired immediately.
WARNING:Exhaust leaks may result in entry of harmful and
potentially lethal fumes into the passenger compartment.
Do not make any unauthorized changes to your vehicle or engine. By
law, vehicle owners and anyone who manufactures, repairs, services,
sells, leases, trades vehicles, or supervises a fleet of vehicles are not
permitted to intentionally remove an emission control device or prevent
it from working. Information about your vehicle’s emission system is on
the Vehicle Emission Control Information Decal located on or near the
engine. This decal also lists engine displacement.
Please consult yourWarranty Guide/Customer Information Guidefor
complete emission warranty information.
On board diagnostics (OBD-II)
Your vehicle is equipped with a computer that monitors the engine’s
emission control system. This system is commonly known as the On
Board Diagnostics System (OBD-II). The OBD-II system protects the
environment by ensuring that your vehicle continues to meet
government emission standards. The OBD-II system also assists your
authorized dealer in properly servicing your vehicle. When theService
engine soon
indicator illuminates, the OBD-II system has detected
a malfunction. Temporary malfunctions may cause theService engine
soon
indicator to illuminate. Examples are:
1. The vehicle has run out of fuel—the engine may misfire or run poorly.
2. Poor fuel quality or water in the fuel—the engine may misfire or run
poorly.
3. The fuel cap may not have been securely tightened. SeeFuel filler
capin this chapter.
4. Driving through deep water—the electrical system may be wet.
These temporary malfunctions can be corrected by filling the fuel tank
with good quality fuel, properly tightening the fuel cap or letting the
2009 Ranger(ran)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
251

A
ABS (see Brakes) .....................159
Air cleaner filter ...............258–259
Airbag supplemental restraint
system ..........................................89
and child safety seats ..............91
description ................................89
disposal ......................................94
driver airbag ........................89, 92
indicator light ...........................93
operation .............................89, 92
passenger airbag .................89, 92
Ambulance packages ....................8
Antifreeze (see Engine
coolant) .....................................236
Anti-lock brake system
(see Brakes) ......................159–160
Anti-theft system ........................67
Audio system
(see Radio) ......................19, 21, 26
Automatic transmission ............163
driving an automatic
overdrive .................................165
fluid, refill capacities ..............260
fluid, specification ..................260
Auxiliary input jack (Line in) ....32
Auxiliary power point .................55
Axle
lubricant specifications ..........260
refill capacities ........................260
B
Battery .......................................234
acid, treating emergencies .....234
jumping a disabled battery ....200
maintenance-free ....................234replacement, specifications ...259
servicing ..................................234
Belt-Minder
...............................84
Booster seats .............................110
Brakes ........................................159
anti-lock ...........................159–160
anti-lock brake system (ABS)
warning light ...........................160
fluid, checking and adding ....254
fluid, refill capacities ..............260
fluid, specifications .................260
lubricant specifications ..........260
parking ....................................161
shift interlock ..........................163
Bulbs ............................................48
C
Capacities for refilling fluids ....260
Cargo cage ...................................61
Cell phone use ..............................8
Changing a tire .........................191
Child safety seats ......................102
attaching with tether straps ..107
in front seat ............................103
in rear seat ......................103, 106
LATCH .....................................106
recommendations ...................100
Child safety seats - booster
seats ...........................................110
Cleaning your vehicle
engine compartment ..............218
instrument panel ....................220
interior .....................................221
plastic parts ............................219
safety belts ..............................221
washing ....................................216
waxing .....................................217
wheels ......................................217
2009 Ranger(ran)
Owners Guide, 1st Printing
USA(fus)
Index
269

headlamps, flash to pass ..........45
instrument panel, dimming .....45
interior lamps .....................48–49
replacing bulbs .........................50
LATCH anchors .........................106
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........160
Limited-slip axle .......................162
Load limits .................................137
Loading instructions .................143
Locks
doors ..........................................63
Lubricant specifications ...........260
Lug nuts ....................................199
Lumbar support, seats .........72–73
M
Manual transmission .................167
fluid capacities ........................260
lubricant specifications ..........260
reverse .....................................168
Mirrors .........................................57
fold away ...................................58
side view mirrors
(power) ...............................57–58
Motorcraft parts ........222, 241, 259
O
Octane rating ............................246
Oil (see Engine oil) ..................229
P
Parking brake ............................161
Parts (see Motorcraft parts) ....259Passenger Occupant
Classification Sensor ...................75
Power distribution box (see
Fuses) ........................................185
Power door locks ........................63
Power mirrors .......................57–58
Power point .................................55
Power steering ..........................162
fluid, checking and adding ....253
fluid, refill capacity ................260
fluid, specifications .................260
Power Windows ...........................56
Preparing to drive your
vehicle ........................................162
R
Radio ................................19, 21, 26
Recommendations for
attaching safety restraints for
children ......................................100
Relays ........................................181
Remote entry system .................63
illuminated entry ......................66
locking/unlocking doors ...........64
panic alarm ...............................64
replacing the batteries .............65
Roadside assistance ..................179
S
Safety Belt Maintenance ..........114
Safety belts (see Safety
restraints) ............ 74, 77–78, 80–82
Safety defects, reporting ..214–215
Safety restraints .. 74, 77–78, 80–82
Belt-Minder
.............................84
2009 Ranger(ran)
Owners Guide, 1st Printing
USA(fus)
Index
272

extension assembly ..................83
for adults .......................78, 80–81
for children ...............................97
lap belt ......................................79
Occupant Classification
Sensor ........................................75
safety belt maintenance .........114
warning light and chime ....83–84
Safety restraints - LATCH
anchors ......................................106
Safety seats for children ..........102
Safety Compliance
Certification Label ....................265
Satellite Radio Information ........37
Seats ............................................70
child safety seats ....................102
SecuriLock passive anti-theft
system ..........................................67
Servicing your vehicle ..............224
Setting the clock
AM/FM stereo ...........................20
AM/FM stereo CD .....................21
Premium AM/FM stereo
CD6/MP3 ...................................27
Snowplowing .................................8
Spark plugs,
specifications .....................259, 264
Special notice
ambulance conversions ..............8
utility-type vehicles ....................8
Specification chart,
lubricants ...................................260
Speed control ..............................58
Starting your vehicle ........154–156
jump starting ..........................200
Steering wheel
tilting .........................................55T
Tilt steering wheel ......................55
Tire Pressure Monitoring
System (TPMS)
Roadside Emergencies ...........191
Tires, Wheels and Loading ....132
Tires ...........................117–119, 191
alignment ................................126
care ..........................................122
changing ..........................191, 196
checking the pressure ............122
inflating ...................................120
label .........................................131
replacing ..................................123
rotating ....................................126
safety practices .......................125
sidewall information ...............127
snow tires and chains ............137
spare tire .................................192
terminology .............................119
tire grades ...............................118
treadwear ........................118, 122
Towing .......................................143
recreational towing .................152
trailer towing ..........................143
wrecker ....................................206
Transfer case
fluid checking .........................257
Transmission
automatic operation ...............163
brake-shift interlock (BSI) ....163
fluid, checking and adding
(manual) .................................256
fluid, refill capacities ..............260
lubricant specifications ..........260
manual operation ....................167
Turn signal ..................................48
2009 Ranger(ran)
Owners Guide, 1st Printing
USA(fus)
Index
273

V
Vehicle Identification Number
(VIN) ..........................................265
Vehicle loading ..........................137
camper bodies ........................153
Ventilating your vehicle ...........157
W
Warning lights (see Lights) .......12Washer fluid ..............................228
Water, Driving through .............178
Windows
power
.........................................56
Windshield washer fluid and
wipers
..........................................54
checking and adding fluid
.....228
replacing wiper blades
...........229
Wrecker towing
.........................206
2009 Ranger(ran)
Owners Guide, 1st Printing
USA(fus)
Index
274