engine FORD TAURUS 2012 6.G Owners Manual

NORMAL SCHEDULED MAINTENANCE AND LOG
Intelligent Oil Life Monitor™
Your vehicle is equipped with an Intelligent Oil Life Monitor™ that
determines when the engine oil should be changed based on how your
vehicles is used. By using several important factors in its calculations,
the monitor helps reduce the cost of owning your vehicle and reduce
environmental waste at the same time. This means you won’t have to
remember to change the oil on a mileage-based schedule; the vehicle lets
you know when an oil change is due by displaying ENGINE OIL
CHANGE DUE or OIL CHANGE REQUIRED in the message center. The
following table is intended to provide examples of vehicle use and its
impact on engine oil change intervals; it is provided as a guideline only.
Actual engine oil change intervals will depend on several factors and will
generally decrease with severity of use.
When to expect the OIL CHANGE REQUIRED message
Miles (km) Vehicle use and examples
7500-10000
(12000-16000)Normal
– Normal commuting with highway driving
– No, or moderate, load/towing
– Flat to moderately hilly roads
– No extended idling
5000-7499
(8000-11999)Severe
– Moderate to heavy load/towing
– Mountainous or off-road conditions
– Extended idling
– Extended hot or cold operation
3000-4999
(4000-7999)Extreme
– Maximum load/towing
– Extreme hot or cold operation
Scheduled Maintenance
388
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

Normal Scheduled Maintenance
At every oil change
interval as indicated
by the message
centerChange engine oil and filter
Rotate tires, inspect tire wear and measure tread
depth
Perform multi-point inspection (recommended)
Inspect automatic transmission fluid level (if
equipped with dipstick); consult dealer for
requirements
Inspect brake pads, shoes, rotors, drums, brake
linings, hoses and parking brake
Inspect cabin air filter (if equipped)
Inspect engine cooling system strength and hoses
Inspect exhaust system and heat shields
Inspect rear axle and U-joints; lubricate if
equipped with grease fittings (AWD vehicles)
Inspect half-shaft boots (if equipped)
Inspect steering linkage, ball joints, suspension,
tie-rod ends, driveshaft and U-joints; lubricate if
equipped with grease fittings
Inspect wheels and related components for
abnormal noise, wear, looseness or drag
Reset your Intelligent Oil Life Monitor™ after each engine oil and filter
change; refer to theInstrument Clusterchapter
Do not exceed one year or 10,000 miles (16,000 km) between
service intervals
Scheduled Maintenance
389
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

Additional maintenance items
1
Miles (x 1,000) 20 30 40 60 80 90 100 120 140 150
Kilometers (x 1,000) 32 48 64 96 128 144 160 192 225 240
Replace cabin air filter (if equipped)• ••• •••
Replace climate-controlled seat filter (if equipped)•••••
Replace engine air filter•••••
Change engine coolant
2
•
Replace spark plugs•
Inspect accessory drive belt(s)••
Change automatic transmission fluid and filter•
Change manual transmission fluid•
Replace accessory drive belt(s) if not replaced within the last
100,000 miles (160,000 km)•
1Additional maintenance items can be performed within 3,000 miles (4,800 km) of the last oil change. Do not exceed
the designated distance for the interval.2Initial replacement at 6 years or 100,000 miles (160,000 km), then every 3 years or 50,000 miles (80,000 km)
Scheduled Maintenance
390
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

SPECIAL OPERATING CONDITIONS
If you operate your vehicleprimarilyin any of the following conditions,
you need to perform additional maintenance as indicated. If you
occasionallyoperate your vehicle under any of these conditions, it is
not necessary to perform the additional maintenance. For specific
recommendations, see your dealership service advisor or technician.
Towing a trailer or using a camper or car-top carrier
As required Change engine oil and filter as indicated by
message center and perform services listed in the
Normal Scheduled Maintenance chart
Inspect frequently,
service as requiredInspect and lubricate U-joints
See axle maintenance items underExceptions
Every 30,000 miles
(48,000 km)Change automatic transmission fluid (except
Focus)
Every 60,000 miles
(96,000 km)Change manual transmission fluid
Perform the services in the preceding table when specified or within
3,000 miles (4,800 km) of the OIL CHANGE REQUIRED message
appearing in the message center.
Example #1:The OIL CHANGE REQUIRED message comes on at
28,751 miles (46,270 km); perform the 30,000 mile (48,000 km)
automatic transmission fluid replacement.
Example #2:The OIL CHANGE REQUIRED message hasnotcome on
but the odometer reads 30,000 miles (48,000 km); perform the engine air
filter replacement. (i.e., Intelligent Oil Life Monitor™ was reset at
25,000 miles [40,000 km].)
Extensive idling and/or low-speed driving for long distances as
in heavy commercial use (i.e. delivery, taxi, patrol car or livery)
As required Change engine oil and filter as indicated by
message center and perform services listed in the
Normal Scheduled Maintenance chart
Inspect frequently,
service as requiredReplace cabin air filter (if equipped)
Replace engine air filter
Every 30,000 miles
(48,000 km)Change automatic transmission fluid (except
Focus)
Every 60,000 miles
(96,000 km)Replace spark plugs
Scheduled Maintenance
394
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

Perform the services in the preceding table when specified or within
3,000 miles (4,800 km) of the OIL CHANGE REQUIRED message
appearing in the message center.
Example #1:The OIL CHANGE REQUIRED message comes on at
28,751 miles (46,270 km); perform the 30,000 mile (48,000 km)
automatic transmission fluid replacement.
Example #2:The OIL CHANGE REQUIRED message hasnotcome on
but the odometer reads 30,000 miles (48,000 km); perform the engine air
filter replacement. (i.e., Intelligent Oil Life Monitor™ was reset at
25,000 miles [40,000 km].)
Operating in dusty conditions such as unpaved or dusty roads
Inspect frequently,
service as requiredReplace cabin air filter (if equipped)
Replace engine air filter
Every 5,000 miles
(8,000 km)Inspect the wheels and related components for
abnormal noise, wear, looseness or drag
Rotate tires, inspect tires for wear and measure
tread depth
Every 5,000 miles
(8,000 km) or
6 monthsChange engine oil and filter
Every 30,000 miles
(48,000 km)Change automatic transmission fluid (except
Focus)
Every 50,000 miles
(80,000 km)Change manual transmission fluid
Reset your Intelligent Oil Life Monitor™ after each engine oil and filter
change; refer to theInstrument Clusterchapter
Exclusive use of E85 (Flex Fuel Vehicles only)
Every oil change If ran exclusively on E85, fill the fuel tank full
with regular unleaded fuel
Scheduled Maintenance
395
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

using oils defined by the American Petroleum Institute (API)
performance category of API SK or earlier (for example SJ, etc).
Edge/MKX AWD only – vehicles operating off-road in sand during high
ambient temperatures must replace the AWD PTU (All-wheel drive
Power Transfer Unit) lube every 20,000 miles (32,000 km).
Engine air filter & cabin air filter replacement:Engine air filter and
cabin air filter life is dependent on exposure to dusty and dirty
conditions. Vehicles operated in these conditions will require frequent
inspection and replacement of the engine air filter and cabin air filter.
ENGINE COOLANT CHANGE RECORD
Initial change 6 years or 100,000 miles (160,000 km)
(whichever comes first)
After initial change Every 3 years or 50,000 miles (80,000 km)
Engine coolant change log
DEALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:D
EALERVALIDATION:
P&A C
ODE:
RO#: HOURS:
DAT E:MILEAGE:
Scheduled Maintenance
399
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

A
Accessory delay ..........................84
Adaptive Cruise Control .............89
AdvanceTrac ..............................245
AdvanceTrac Sport Mode .........250
Airbag supplemental restraint
system ................171–172, 180, 182
and child safety seats ............173
description ..............172, 180, 182
disposal ....................................186
driver airbag ............174, 181, 183
indicator light .................180, 185
operation .................174, 181, 183
passenger airbag .....174, 181, 183
side airbag ...............................180
Air cleaner filter ...............363, 367
Air conditioning ....................51, 54
automatic temperature
control system ..........................57
manual heating and air
conditioning system .................51
All Wheel Drive (AWD),
driving off road .........................273
Ambient mood/lighting ...............69
Antifreeze
(see Engine coolant) ................339
Anti-lock brake system
(see Brakes) ..............................243
Anti-theft system ..............131, 136
arming the system ..................136
disarming a triggered
system .....................................136
Audio system (see Radio) .........32
Automatic transaxle
fluid, refill capacities ..............368
fluid, specification ..................368Automatic transmission
driving an automatic
overdrive .........................253, 255
fluid, adding ............................358
fluid, checking ........................358
Selectshift (SST) ....................257
Auxiliary input jack (Line in) ....42
B
Battery .......................................337
acid, treating emergencies .....337
jumping a disabled battery ....307
maintenance-free ....................337
replacement, specifications ...367
servicing ..................................337
Belt-Minder.............................167
Blind Spot Information
System .......................................267
Blind spot mirror ......................266
Booster seats .............................199
Brakes ........................................242
anti-lock ...................................243
anti-lock brake system (ABS)
warning light ...........................243
fluid, checking and adding ....358
fluid, refill capacities ..............368
fluid, specifications .................368
lubricant specifications ..........368
parking ....................................244
shift interlock ..........................251
Bulbs ............................................70
C
Capacities for refilling fluids ....368
Cargo cover ...............................101
Cargo net ...................................106
Cell phone use ..............................9
Index
400
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

Changing a tire .........................290
Child safety seats ......................190
attaching with tether straps ..196
in front seat ............................190
in rear seat ..............................190
LATCH .....................................194
recommendations ...................188
Child safety seats - booster
seats ...........................................199
Cleaning your vehicle
engine compartment ..............322
instrument panel ....................325
interior .....................................326
plastic parts ............................324
washing ....................................320
waxing .....................................321
wheels ......................................321
wiper blades ............................324
Climate control
(see Air conditioning or
Heating) ...........................51, 54, 57
Clock ............................................33
Collision Warning System .........262
Compass, electronic ....................79
calibration .................................80
set zone adjustment .................79
Console
overhead ....................................78
Controls
power seat ...............................143
steering column ........................98
Coolant
checking and adding ..............339
refill capacities ................342, 368
specifications ..........................368
Cross Traffic Alert ....................267
Cruise control
(see Speed control) ....................88Cupholder(s) .............................156
Customer Assistance ................280
Ford Extended Service
Plan ..................................378, 381
Getting assistance outside the
U.S. and Canada .....................316
Getting roadside assistance ...280
Getting the service you
need .........................................312
Ordering additional owner’s
literature .................................318
Utilizing the
Mediation/Arbitration
Program ...................................316
D
Daytime running lamps
(see Lamps) ................................66
Defrost
rear window and rearview
mirrors .......................................54
windshield ...........................54, 57
Dipstick
automatic transmission
fluid ..........................................358
engine oil .................................333
Doors
central unlocking ....................116
Driving under special
conditions ..........................274, 277
sand .........................................276
snow and ice ...........................278
through water .................276, 279
E
Electronic message center .........19
Emergencies, roadside
jump-starting ..........................307
Index
401
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

running out of fuel .........306, 350
Emission control system ..........354
Engine ........................................372
cleaning ...................................322
coolant .....................................339
fail-safe cooling .......................343
idle speed control ...................337
lubrication specifications .......368
refill capacities ........................368
service points ..................330–331
Engine block heater .................241
Engine oil ..................................333
checking and adding ..............333
dipstick ....................................333
filter, specifications ................367
refill capacities ........................368
specifications ..........................368
Event data recording ....................7
Exhaust fumes ..........................240
F
Fail safe cooling ........................343
Fleet MyKey programming ......109
Floor mats .........................105–106
Fluid capacities .........................368
Four-Wheel Drive vehicles
driving off road .......................274
Fuel ............................................345
calculating fuel
economy ............................21, 351
cap ...........................................347
capacity ...................................368
choosing the right fuel ...........348
detergent in fuel .....................350
filler funnel .............................350
filling your vehicle with
fuel ...........................345, 347, 351filter, specifications ........345, 367
fuel pump shut-off ..................282
improving fuel economy ........351
octane rating ...................349, 372
quality ......................................349
running out of fuel .........306, 350
safety information relating to
automotive fuels .....................345
Fuses ..........................................282
G
Garage door opener ..................101
Gas cap (see Fuel cap) ............347
Gas mileage (see Fuel
economy) ...................................351
Gauges .........................................17
H
Hazard flashers .........................281
Headlamps ...................................62
aiming ........................................67
autolamp system .......................62
bulb specifications ....................71
daytime running lights .............66
flash to pass ..............................66
high beam .................................63
replacing bulbs .........................71
turning on and off ....................62
Heating
heating and air conditioning
system ...........................51, 54, 57
Homelink wireless control
system ........................................101
Hood ..........................................329
I
Ignition ...............................235, 372
Index
402
2012 Taurus
Owners Guide, 1st Printing
USA(fus)

O
Octane rating ............................349
Oil (see Engine oil) ..................333
Overdrive ...................................253
P
Parental MyKey
programming .............................109
Parking brake ............................244
Parts
(see Motorcraftparts) ...........367
Passenger Occupant
Classification Sensor .................159
Pedals (see Power adjustable
foot pedals) .................................87
Power adjustable foot
pedals .....................................87–88
Power distribution box
(see Fuses) ...............................287
Power door locks ......................115
Power mirrors .............................86
Power point .................................82
Power steering ..........................250
fluid, checking and adding ....357
fluid, refill capacity ................368
fluid, specifications .................368
Power Windows ...........................83
Power windows
opening using remote entry
system .....................................123
Push button start system .........238
R
Radio ............................................326-CD in dash .............................32
Rear heated seats .....................156
Rear-view camera system .........260
Recommendations for
attaching safety restraints for
children ......................................188
Relays ........................................282
Remote entry system .......121–122
illuminated entry ............127–128
locking/unlocking
doors ................................122–123
opening the trunk ...................124
opening the windows .............123
panic alarm .............................124
replacement/additional
transmitters .............................127
replacing the batteries ...........125
Reverse sensing system ...........258
Roadside assistance ..................280
S
Safety belts (see Safety
restraints) ..160, 162–163, 165–166
Safety Canopy ...........................182
Safety defects, reporting ..........319
Safety
restraints ...160, 162–163, 165–166
Belt-Minder...........................167
extension assembly ................165
for adults .................162–163, 165
for children .............................186
Occupant Classification
Sensor ......................................159
warning light and chime ........166
Safety restraints - LATCH
anchors ......................................194
Safety seats for children ..........190
Index
404
2012 Taurus
Owners Guide, 1st Printing
USA(fus)