fuel filter location FORD TRANSIT 2015 5.G Owners Manual

•
Sustained high-speed driving at Gross
Vehicle Weight Rating (maximum
loaded weight for vehicle operation).
• Sustained use of diesel fuel other than
ultra-low sulfur diesel (ULSD). Resetting the Oil Life Monitoring
System The indicator lamp will
illuminate when the engine oil
and oil filter requires changing.
To reset the Oil Life Monitoring System, switch the ignition on, do not start the
engine and scroll to: Action and Description
Message
Fully press the accelerator and brake pedals. Keep both
pedals fully pressed.
Oil change required
The information display will show this message after a short
period of time.
Oil reset in prog.
The information display will show this message after a short
period of time.
Oil reset complete
Release the accelerator and brake pedals and switch the
ignition off.
ENGINE COOLANT CHECK
Checking the Engine Coolant
When the engine is cold, check the
concentration and level of the engine
coolant at the intervals listed in the
scheduled maintenance information. See
Scheduled Maintenance (page 433).
Note: Make sure that the level is between
the MIN and MAX marks on the coolant
reservoir.
Note: Coolant expands when it is hot. The
level may extend beyond the MAX mark.
Note: If the level is at the MIN mark, below
the MIN mark, or empty, add coolant
immediately. See
Adding Engine Coolant
in this chapter.
The coolant concentration should be
maintained within 48% to 50%, which
equates to a freeze point between -29.2°F
(-34°C)
and -34.5°F (-37°C). Note:
For best results, coolant
concentration should be tested with a
refractometer, for example Robinair®
coolant and battery refractometer 75240.
We do not recommend the use of
hydrometers or coolant test strips for
measuring coolant concentrations.
Note: Automotive fluids are not
interchangeable. Do not use engine coolant,
antifreeze or windshield washer fluid outside
of its specified function and vehicle location.
Adding Engine Coolant WARNINGS
Do not add engine coolant when the
engine is hot. Steam and scalding
liquids released from a hot cooling
system can burn you badly. Also, spilling
coolant on hot engine parts can burn you. Do not put engine coolant in the
windshield washer fluid reservoir. If
sprayed on the windshield, engine
coolant could make it difficult to see
through the windshield.
206 Transit (TTH) Canada/United States of America, enUSA, Edition date: 03/2014 Maintenance

Alloy wheels and wheel covers are coated
with a clear coat paint finish. To maintain
their condition we recommend that you:
•
Clean the wheels weekly using
Motorcraft Wheel and Tire Cleaner.
Apply using manufacturer's
instructions.
• Use a sponge to remove heavy
deposits of dirt and brake dust
accumulation.
• Rinse thoroughly with a strong stream
of water when you have completed the
cleaning process.
• To remove tar and grease, use
Motorcraft Bug and Tar Remover.
VEHICLE STORAGE
If you plan on storing your vehicle for 30
days or more, read the following
maintenance recommendations to make
sure your vehicle stays in good operating
condition.
We engineer and test all motor vehicles
and their components for reliable, regular
driving. Under various conditions,
long-term storage may lead to degraded
engine performance or failure unless you
use specific precautions to preserve engine
components.
General
• Store all vehicles in a dry, ventilated
place.
• Protect from sunlight, if possible.
• If vehicles are stored outside, they
require regular maintenance to protect
against rust and damage. Body
•
Wash your vehicle thoroughly to
remove dirt, grease, oil, tar or mud from
exterior surfaces, rear-wheel housing
and the underside of front fenders.
• Periodically wash your vehicle if it is
stored in exposed locations.
• Touch-up exposed or primed metal to
prevent rust.
• Cover chrome and stainless steel parts
with a thick coat of auto wax to prevent
discoloration. Re-wax as necessary
when you wash your vehicle.
• Lubricate all hood, door and trunk lid
hinges, and latches with a light grade
oil.
• Cover interior trim to prevent fading.
• Keep all rubber parts free from oil and
solvents.
Engine
• The engine oil and filter should be
changed prior to storage because used
engine oil contains contaminates that
may cause engine damage.
• Start the engine every 15 days for a
minimum of 15 minutes. Run at fast idle
with the climate controls set to defrost
until the engine reaches normal
operating temperature.
• With your foot on the brake, shift
through all the gears while the engine
is running.
• We recommend that you change the
engine oil before you use your vehicle
again.
Fuel system
• Fill the fuel tank with high-quality fuel
until the first automatic shutoff of the
fuel pump nozzle.
231 Transit (TTH) Canada/United States of America, enUSA, Edition date: 03/2014 Vehicle Care

Exclusive use of E85 (Flex fuel vehicles only)
If ran exclusively on E85, fill the fuel tank full with regular
unleaded fuel.
Every oil change interval
Exceptions
There are several exceptions to the Normal
Schedule:
Normal vehicle axle maintenance: Rear
a
xles and power take-off units with
synthetic fluid and light-duty trucks
equipped with Ford-design axles are
lubricated for life; do not check or change
fluid unless a leak is suspected, service is
required or the assembly has been
submerged in water. During long periods
of trailer towing with outside temperatures
above
70°F (21°C) and at wide-open
throttle for long periods above 45 mph
(72 km/h), change non-synthetic rear axle
fluid every 3000 mi (4,800 km) or three
months, whichever comes first. This
interval can be waived if the axle is filled
with 75W140 synthetic gear fluid meeting
Ford specification WSL-M2C192-A; GL-5
or equivalent. Add friction modifier XL-3
EST-M2C118-A or equivalent for complete
refill of Traction-Lok rear axles. See
Capacities and Specifications
(page
265).
Police, Taxi and Livery vehicle axle
maintenance: Change rear axle fluid every
100000 mi (160,000 km). Rear axle fluid
change may be waived if the axle was filled
with 75W140 synthetic gear fluid meeting
Ford specification WSL-M2C192-A; GL-5 or equivalent. Add four ounces (118
milliliters) of additive friction modifier XL-3
EST-M2C118-A, or equivalent, for complete
refill of Traction-Lok rear axles. Change
the axle fluid anytime the axle submerges
in water.
California fuel filter replacement: If you
register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot climate oil change intervals:
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 5000 mi (8,000 km).
If the available API SM or SN oils are not
available, then the oil change interval is
3000 mi (4,800 km).
Engine air filter replacement: The life of
the engine air fil

ter is dependent on
exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter.
440 Transit (TTH) Canada/United States of America, enUSA, Edition date: 03/2014 Scheduled Maintenance

Essential Towing Checks...........................164
Before Towing a Trailer..................................... 169
Launching or Retrieving a Boat or Personal Water Craft (PWC)........................................ 170
Safety Chains....................................................... 165
Tow Hitch............................................................... 165
Trailer Brakes........................................................ 165
Trailer Lamps....................................................... 169
Trailer Towing Connector................................ 164
When Towing a Trailer...................................... 169
Event Data Recording See: Data Recording.............................................. 9
Export Unique Options...................................11
Extended Service Plan (ESP)
..................431
SERVICE PLANS (CANADA ONLY)............432
SERVICE PLANS (U.S. Only).......................... 431
Exterior Mirrors..................................................71 Fold-Away Exterior Mirrors................................. 71
Power Exterior Mirrors.......................................... 71
F
Fastening the Safety Belts.........................28 Safety Belt Extension Assembly....................30
Safety Belt Locking Modes............................... 29
Using Safety Belts During Pregnancy...........28
Floor Mats
........................................................174
Ford Credit.........................................................10
(U.S. Only)............................................................... 10
Fuel and Refueling.........................................111
Fuel C

onsumption........................................122
Calculating Fuel Economy............................... 122
Filling the Fuel Tank........................................... 122
Fuel Filter - Gasoline....................................212
Fuel Qu

ality - Diesel......................................113
Biodiesel.................................................................. 114
Diesel Fuel Additives ......................................... 115
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where
Ultra-Low Sulfur Diesel Fuel Is Not
Required ............................................................ 113
Fuel Requirements - Choosing the Right Fuel: Vehicles Operated Where
Ultra-Low Sulfur Diesel Fuel is Required
(United States/Canada/Puerto Rico/U.S.
Virgin Islands and Other Locales)............113 Fuel Quality - Gasoline................................112
Choosing the Right Fuel With a Flex Fuel
Vehicle (If Equipped)..................................... 112
Choosing the Right Fuel Without a Flex Fuel Vehicle (If Equipped)..................................... 112
Octane Recommendations............................. 112
Fuel Shutoff.....................................................177
Fuse Box Locations......................................187 Body Control Module Fuse Box..................... 187
Engine Compartment Fuse Box.................... 187
Passenger Compartment Fuse Box.............187
Pre-fuse Box......................................................... 187
Fuses.................................................................187
Fuse Specification Chart...........................188 Body Control Module......................................... 197
Engine Compartment Fuse Box................... 188
Passenger Compartment Fuse Panel.........192
Pre-fuse Box......................................................... 195
G
Gauges................................................................73 Engine Coolant Temperature Gauge.............73
Fuel Gauge.............................................................. 74
Information Display............................................. 73
Tripmeter Reset and Distance to Empty................................................................... 74
General Information on Radio Frequencies...................................................44
General Maintenance Information........433 Multi-point Inspection..................................... 435
Owner Checks and Services.......................... 434
Protecting Your Investment........................... 433
Why Maintain Your Vehicle?.......................... 433
Why Maintain Your Vehicle at Your Dealership?..................................................... 433
Getting Assistance Outside the U.S. and Canada..........................................................184
G

etting the Services You Need.................181
Away From Home................................................ 181
H
Handbrake See: Parking Brake............................................. 138
Hazard Warning Flashers...........................177
452 Transit (TTH) Canada/United States of America, enUSA, Edition date: 03/2014 Index