air condition FORD WINDSTAR 1996 1.G User Guide

130
[SC02100(ALL)02/95]
To indicate a lane change to the right, push the turn signal
lever up slightly (without latching) and hold it in position. To
indicate a lane change to the left, pull the turn signal lever
down slightly (without latching) and hold it in position. The
lever will return to the OFF position when you release it.
*
[SC02200(ALL)05/94]
If the turn indicator light in the instrument panel does not
illuminate or remains on (does not flash) when you signal a
turn, the turn signaling system is malfunctioning. Have this
condition corrected as soon as possible, and use the accepted
hand signals until the turn signal system is repaired.
%*
[SC02220(ALL)03/95]
High Beams
*
[SC02226(ALL)01/93]
To turn on the high beams, turn the headlamps on and push
the turn signal lever away from you until it latches. When the
high beams are on, the high beam indicator light on the
instrument panel is illuminated.
*
[SC02230(ALL)01/93]
To return to the low beam setting, pull the turn signal lever
toward you until it latches back into the neutral position. The
high beam indicator light turns off.
*
[SC02235(ALL)11/93]
7-1/2 pica art:0040086-D
High beam and flash-to-pass operation
%*
[SC02700(ALL)05/95]
Flashing the Lights
*
[SC02800(ALL)01/93]
To flash the headlamps, pull the turn signal lever toward you
for a moment and then release it. The high beam headlamps
will flash whether the headlamps are on or off.
File:wnscs.ex
Update:Tue Mar 19 08:22:27 1996

Driving Your Windstar
251
*
[DR15500(ALL)01/93]
Payload
*
[DR15600(ALL)07/93]
Maximum payload is the combined, maximum allowable weight
of cargo, occupants and optional equipment that the vehicle is
designed to carry. It is the Gross Vehicle Weight Rating minus
the base curb weight.
*
[DR15700(ALL)01/93]
Gross Vehicle Weight (GVW)
*
[DR15800(ALL)09/93]
The Gross Vehicle Weight (GVW) is the total weight of the
passengers, cargo and all equipment.
*
[DR15900(ALL)12/93]
It is important to remember that GVW is not a limit or a
specification, but actual weight. If an owner loads up the vehicle
and weighs it, that's the GVW at that moment. If the owner
adds on more of a load and weighs it again, that becomes the
GVW.
%*
[DR16000(ALL)03/91]
Gross Vehicle Weight Rating (GVWR)
[DR16100(ALL)06/94]
To avoid overloading your vehicle, never exceed the specified
Gross Vehicle Weight Rating for your vehicle. The GVWR is the
maximum allowable weight of the vehicle when fully loaded
including passengers, cargo and all equipment.
%*
[DR16200(ALL)01/93]
Gross Axle Weight Rating (GAWR)
*
[DR16300(ALL)01/93]
We have all seen a car or a truck that is loaded down in the
rear and riding high in the front. This is a dangerous condition
that usually means that the rear suspension components are
under severe strain and that vehicle handling is impaired. There
is more to carrying a load than just payload or GVWR.
[DR16400(ALL)12/93]
Your Safety Compliance Certification Label not only gives the
GVWR, it also gives the Gross Axle Weight Rating (GAWR)
which is the maximum weight allowed on the axle system.
File:wndrs.ex
Update:Tue Mar 19 08:18:48 1996

Driving Your Windstar
259
[DR21600(ALL)10/93]
When stopped in traffic for long periods of time in hot weather,
place the gearshift selector lever in P (Park) to increase the
engine idle speed. This aids in engine cooling and air
conditioner efficiency. If the engine overheats, turn the selector
knob to select the fresh air position to stop the air conditioner
compressor. Increase the engine speed for a short time.
*
[DR21700(ALL)01/93]
Vehicles with trailers should not be parked on a grade.
However, if you must park on a grade, place wheel chocks
under the trailer's wheels as follows:
[DR21800(ALL)11/93]1.
Apply the foot service brake pedal and hold.
*
[DR21900(ALL)11/93]2.
Have another person place the wheel chocks under the
trailer wheels.
[DR22000(ALL)11/93]3.
With the chocks in place, release the foot service brake
pedal, making sure the chocks are holding.
[DR22100(ALL)11/93]4.
Apply the parking brake by pressing the service brake pedal
down firmly with your right foot while applying the parking
brake lever with your right hand.
*
[DR22200(ALL)11/93]5.
Shift the gearshift lever into P (Park).
File:wndrs.ex
Update:Tue Mar 19 08:18:48 1996

Servicing Your Windstar
315
*
[SV13200(ALL)01/93]
Comparisons With Environmental Protection Agency
(EPA) Fuel Economy Estimates
[SV13300(ALL)02/95]
EPA fuel economy figures are obtained from laboratory tests
under simulated road conditions and therefore are estimates
which may not reflect the actual conditions you experience. The
tests also do not exactly duplicate your personal style of
driving, including all your stops, starts, and lane changes. Other
factors that may affect fuel economy include using the air
conditioning, driving speed, vehicle load and tire inflation
pressure. The EPA fuel economy estimate is not a guarantee
that you will achieve the fuel economy shown.
%*
[SV13400(ALL)05/95]
Improving Fuel Economy
[SV13500(ALL)11/93]
You can improve the fuel economy for your vehicle in three
ways:
[SV13600(ALL)09/93]1.
Maintain your vehicle effectively. A well-tuned, properly
maintained vehicle gives you better fuel economy. Follow the
schedules for maintaining your vehicle that are in the
Maintenance Schedule and Recordbooklet.
[SV13700(ALL)02/95]2.
Drive your vehicle efficiently. Change your driving habits to
conserve fuel:
*
[SV13800(ALL)03/95]
n
Do not drive with your foot on the brake.
[SV13900(ALL)05/95]
n
Watch traffic so that you do not have to stop suddenly.
[SV14000(ALL)02/95]
n
Do not accelerate suddenly. Drive at a steady speed
whenever you can.
*
[SV14100(ALL)03/95]
n
Do not let the engine idle for a long time.
[SV14200(ALL)02/95]
n
Do not carry loads that are too heavy. To find out the limits
for the loads that your vehicle can carry, seeDriving with a
heavy loadin the Index.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

316
[SV14300(ALL)02/95]
n
Keep the tires properly inflated. To find out the
recommended tire pressure, seeChecking the pressure of the
tireslater in this chapter.
[SV14400(ALL)02/95]
n
Use your air conditioning system wisely. To find out about
fuel economy and air conditioning, seeClimate control systems
in the Index.
[SV14500(ALL)02/95]
In addition to your individual driving habits, optional
equipment, such as air conditioning, can have a significant effect
on fuel economy. Various aftermarket add-on items that increase
aerodynamic drag can also reduce fuel economy.
%*
[SV14600(ALL)03/95]
Engine Oil Recommendations
*
[SV14750(ALL)04/95]
We recommend using Motorcraft oil or an equivalent oil
meeting Ford Specification ESE-M2C153-E and displaying the
American Petroleum Institute CERTIFICATION MARK on the
front of the container.
*
[SV14800(ALL)03/95]
Use only engine oils displaying the American Petroleum
Institute CERTIFICATION MARK on the front of the container:
*
[SV14850(ALL)05/94]
10-1/2 pica
art:0001314-A
The API Certification Mark
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

360
*
[SV43925(ALL)05/95]
RWARNING
Exhaust leaks may result in the entry of harmful and
potentially lethal fumes into the passenger compartment.
Under extreme conditions excessive exhaust temperatures
could damage the fuel system, the interior floor covering,
or other vehicle components, possibly causing a fire.
*
[SV43950(ALL)03/95]
The Scheduled Maintenance Services listed in theMaintenance
Schedule and Recordbooklet are required because they are
considered essential to the life and performance of your vehicle
and to its emissions system.
*
[SV44000(ALL)05/95]
Watch for fluid leaks, strange odors, smoke and loss of oil
pressure. Also watch for the charge warning light, the check
engine light, or the temperature warning light. These sometimes
indicate that the emission system is not working properly.
*
[SV44100(ALL)01/95]
Do not make any unauthorized changes to your vehicle or
engine. Changes that cause more unburned fuel to reach the
exhaust system can increase the temperature of the engine or
exhaust system.
*
[SV44200(ALL)01/93]
By law, anyone who manufactures, repairs, services, sells, leases
vehicles, trades vehicles, or supervises a fleet of vehicles is not
permitted to intentionally remove an emission control device or
prevent it from working. In some of the United States and in
Canada, vehicle owners may be liable if their emission control
device is removed or is prevented from working.
%*
[SV44225(ALL)05/95]
In general, maintenance, replacement, or service of the emission
control devices or systems in your new Ford Motor Company
vehicle or engine may be performed at your expense by any
automotive repair establishment or individual using automotive
parts equivalent to those with which your vehicle or engine was
originally equipped.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Servicing Your Windstar
361
*
[SV44235(ALL)05/95]
Ford strongly recommends the use of genuine Ford replacement
parts. If other than Ford or Motorcraft parts or Ford authorized
remanufactured parts are used for maintenance replacements or
for the service of components affecting emission control, such
non-Ford parts should be equivalent to genuine Ford Motor
Company parts in performance and durability. It is the owner's
responsibility to determine the equivalency of such parts. Please
consult your warranty booklet for complete warranty
information.
*
[SV44250(ALL)02/92]
Never use a metal exhaust collector when you service your
vehicle. If the metal collector contacts any of your vehicle's
plastic trim or bumper parts they could melt or deform.
*
[SV44300(ALL)01/95]
Do not drive your vehicle if it does not operate properly. See
your dealer if the engine runs on for more than five seconds
after you shut it off or if it misfires, surges, stalls, or backfires.
*
[SV44400(ALL)11/93]
Information about your vehicle's emissions control system is on
the Vehicle Emission Control Information decal located on or
near the engine. This decal identifies engine displacement and
gives some tune-up specifications.
%*
[SV44450(ALL)05/95]
Readiness for Inspection/Maintenance Testing
*
[SV44460(ALL)05/95]
In some localities it may become a legal requirement to pass an
Inspection/Maintenance (I/M) test of the On-Board Diagnostic
(OBD) II system. If the vehicle's powertrain system or its battery
has just been serviced, the OBD II system is reset to a not ready
for I/M testing condition. To prepare for I/M testing, the law
specifies a ªneed for additional mixed city and highway driving
to complete the checkº of the OBD II system. As soon as all of
the OBD II system checks are successfully completed, the OBD
II system is set to the ready condition. The amount of driving
required to reach the ready condition varies with individual
driving patterns. To complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle defined below.
If the vehicle owner cannot or does not want to do the
additional driving required by law, a service center can perform
this drive cycle as it would any other type of repair work.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Index
381
A
ABS warning light (see Anti-lock brake system).... 69,88
Accessory position on the ignition............. 55
Additives, engine oil.................. 317
Air bag supplemental restraint system......... 19,40
and child safety seats............... 20,39
description.................... 19,21
disposal....................... 25
driver air bag................... 19,21
indicator light................... 74,85
operation....................... 21
passenger air bag................... 21
proper seating.................... 20
tone generator.................... 25
wearing safety belts.................. 19
Air conditioning, manual heating and
air conditioning system............. 108
Alarm, activating remote personal............ 152
Alcohol, in fuel.................... 312
Aluminum wheels................... 272
Antenna, radio (see Electronic sound system).....128, 195
Antifreeze (see Engine coolant)............. 319
Anti-lock brake system (ABS)
description..................... 240
noise........................ 241
see also Brake.................... 240
warning light................... 69,88
Anti-theft lug nuts and key............... 273
Anti-theft system
arming the system.................. 156
description..................... 156
disarming an untriggered system........... 157
disarming a triggered system............. 157
triggering....................156, 157
warning light.................... 104
Assistance (see Customer assistance)........... 283
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996

384
Child safety seats (continued)
automatic locking mode (retractor)........... 39
built-in child seat................... 27
in front seat..................... 39
in rear outboard seat................. 39
tether anchorage hardware............... 50
Chime
headlamps on................... 122
safety belt.................... 69,83
Cleaning your vehicle
built-in child seat................... 37
CD player and discs................. 204
chrome and aluminum parts.............. 6
exterior....................... 5
exterior lamps................... 125
fabric...................... 5,184
headlamps..................... 125
instrument panel.................. 106
instrument panel lens................ 106
interior lamps................... 128
plastic parts..................... 6
polishing....................... 5
rustproofing..................... 6
safety belts...................... 18
tail lamps..................... 125
upholstery and interior trim............. 184
washing....................... 5
wheels...................... 3,335
Climate control system
air conditioning................... 106
heating....................... 106
Clock.....................200, 216, 231
Cold engine starting................... 58
Combination lap and shoulder belts............ 9
Compact disc radio (see Electronic sound system).... 196
Console, description.................. 186
Controls
instrument panel.................. 105
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996

389
Index
GVWR (Gross Vehicle Weight Rating)
calculating..................... 253
definition...................... 251
H
Hazard flashers.................... 135
Headlamps
autolamp system.................. 123
checking alignment................. 352
cleaning...................... 125
daytime running lights................ 122
flashing...................... 130
high beam..................... 130
replacing bulbs................... 352
turning on and off................. 120
warning chime................... 122
Head restraints.................... 171
Heated mirrors.................... 190
Heating
manual heating and air conditioning system...... 106
rear seat controls.................. 116
High beams, indicator light.............. 75,90
Hitch......................... 255
Hood
latch location.................... 303
lubrication specifications............... 365
release lever.................... 303
Horn......................... 134
Hoses, checking.................... 323
I
Identification Number, Vehicle (VIN).......... 285
Idle, relearning.................... 266
Ignition
positions of the ignition................ 55
removing the key................... 56
Indicator lamp module................. 102
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996