radiator cap GMC C-SERIES 1999 User Guide

yellowblue
7-21
(25) = Check thermostatically controlled air cleaner
installation to make certain that all ducts are connected and
correctly installed. Also, check valve for proper operation.
(26) = Evaporative Control System Service (if equipped):
Check all fuel and vapor lines and hoses for proper
connections and correct routing (or every 24 months,
whichever occurs first). Replace parts as needed.
(27) = Replace air cleaner filter (or every 24 months,
whichever occurs first). Replace filter more often if
driving in dusty conditions. Ask your dealer for the
proper replacement intervals for your driving conditions.
(28) = Replace spark plugs. Inspect wires for damage.
Check the wire boot and boot heat shield fit at spark
plugs and coil. Replace parts as needed.
(30) = Check the fuel tank, fuel cap and fuel lines for
damage which could cause leakage. Inspect fuel cap for
correct sealing ability and any indications of damage.
Check fuel cap gasket for even filler neck imprint.
Replace parts as needed.
(31) = Check EGR system as described in the service
manual. See ªService and Owner Publicationsº in the Index.
(32) = Inspect Electronic Vacuum Regulator Valve
(EVRV) filter for excessive contamination or plugging.
If needed, clean filter with solution of soap and water,
let dry and install.(33) = Check the PCV system for proper operation and
clean PCV valve. Replace hoses as needed.
(34) = Replace PCV valve and blow out the PCV valve
hose with compressed air. Replace hoses as needed.
(35) = Drain, flush and refill cooling system. See
ªRecommended Fluids and Lubricantsº in the Index for
what to use. Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling system and
pressure cap. For Caterpillar
 diesel engines, always refer
to the Caterpillar Diesel Engine Operation & Maintenance
Manual for coolant recommendations and change intervals.
(37) = Rear axle service: Change the lubricant. See
ªRecommended Fluids and Lubricantsº in the Index.
(38) = Front axle service: Re
-pack upper kingpin
roller bearing.
(39) = Air brake service:

Inspect brake lines and hoses for proper hook
-up,
binding, leaks, cracks, chafing, etc. Inspect drum
brake linings for wear or cracks. Inspect other brake
parts at each wheel, including drums, wheel cylinders
and piston heat shields and boots. Check brake pedal
for excessive free play or travel (or every 6 months,
whichever occurs first) and have serviced if needed.
Check brakes more often if driving habits and
conditions result in frequent braking.
ProCarManuals.com

yellowblue
7-26
Engine Cooling System Service
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed. Clean the outside
of the radiator and air conditioning condenser. To help
ensure proper operation, a pressure test of the cooling
system and pressure cap is recommended at least once
a year.
Exhaust System Check
Be alert for any changes in the sound of the exhaust
system or any smell of fumes. These are signs the
system may be leaking. Have it checked and/or repaired
at once. Refer to ªEngine Exhaustº and ªRunning Your
Engine While You're Parkedº in the Index.
Windshield Wipers and Washers Check
Check operation and condition of the wiper blades.
Check the flow of the washer spray.
Defroster Check
Move the control to the defrost symbol and the fan to HI
or the high symbol. Then check the airflow from the
ducts at the inside base of the windshield.Mirrors and Sun Visors Check
Check that friction joints hold mirrors and sun visors
in place.
Seat Adjuster Check
When adjusting a manual seat, be sure seat adjusters
latch by attempting to move the seat after latching.
Lamps Check
Check panel lighting, warning lights, indicator lights
and interior lamps. On the outside, check: license plate
lamps, sidemarker lamps, reflectors or lights on outside
mirrors, headlamps, parking lamps, identification and
clearance lamps, taillamps, brake lamps, turn signals,
backup lamps and hazard warning flashers. Have
headlamp aim checked at once if beams seem
improperly aimed.
Glass, Mirrors, Lamps and/or Reflectors
Condition Check
Look for broken, scratched, dirty or damaged glass,
mirrors, lamps or reflectors that could reduce the view
or visibility or cause injury. Replace, clean or
repair promptly.
ProCarManuals.com

yellowblue
9-7
New Vehicle ªBreak-Inº 2-5 . . . . . . . . . . . . . . . . . . . . . . . . .
Night Vision 4-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Noise Control System 6-11 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Odometer 2-53 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Recovery 4-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Engine 6-13, 6-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-23 . . . . . . . . . . . . . . . . . . . . . . .
Owner Publications Order Form 8-9 . . . . . . . . . . . . . . . . . . . .
Owner Publications, Ordering 8-8 . . . . . . . . . . . . . . . . . . . . . .
Paint Spotting, Chemical 6-65 . . . . . . . . . . . . . . . . . . . . . . . .
Parking
Brake 2
-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Check 7-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Indicator Light 2-60 . . . . . . . . . . . . . . . . . . . . . . . . . .
Over Things That Burn 2-29 . . . . . . . . . . . . . . . . . . . . . . . .
Passing 4-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power
Door Locks 2
-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Option Fuses 6-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering 4-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Fluid 6-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-31 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Take-Off (PTO) 4-31 . . . . . . . . . . . . . . . . . . . . . . . . . .
Pregnancy, Use of Safety Belts 1-21 . . . . . . . . . . . . . . . . . . . .
Pressure Caps 6-77 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Problems on the Road 5-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Publications, Service and Owner 8-8 . . . . . . . . . . . . . . . . . . . .
Radiator 5-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator Pressure Cap 6-21 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator Shutters 2-13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio Reception 3-10 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Axle 6-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Airshift Control 2-19 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Differential Lock Control 2-41 . . . . . . . . . . . . . . . . . . . . . . .
Fluid Capacity 6-76 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shift Motor 6-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tw o-Speed Electric Shift Control 2-17 . . . . . . . . . . . . . . . .
Towing 5-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recovery Tank, Coolant 5-22 . . . . . . . . . . . . . . . . . . . . . . . . . .
Refrigerants, Air Conditioning 6-77 . . . . . . . . . . . . . . . . . . . .
Releasing Air Operated Parking Brake 5-15 . . . . . . . . . . . . . .
Remote Cassette Tape Player 3-10 . . . . . . . . . . . . . . . . . . . . . .
Replacement Wheels 6-57 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Safety Belts 1-36 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reporting Safety Defects 8-6, 8-7 . . . . . . . . . . . . . . . . . . . . . .
Restraints
Checking 1
-36 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Child 1-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Head 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Parts After a Crash 1-36 . . . . . . . . . . . . . . . . . . .
System Check 7-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Right Passenger Position 1-21 . . . . . . . . . . . . . . . . . . . . . . . . .
Roadside Assistance 8-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rocking Your Vehicle 5-38 . . . . . . . . . . . . . . . . . . . . . . . . . . .
ProCarManuals.com