relay GMC C-SERIES 1999 Owners Manual

yellowblue
6-68
Electrical System
Add-On Electrical Equipment
NOTICE:
Don't add anything electrical to your vehicle
unless you check with your dealer first. Some
electrical equipment can damage your vehicle
and the damage wouldn't be covered by your
warranty. Some add
-on electrical equipment can
keep other components from working as
they should.
Headlamp Wiring
The headlamp wiring is protected by a circuit breaker in
the light switch. An electrical overload will cause the
lights to go on and off, or in some cases to remain off.
If this happens, have your headlamp wiring checked
right away.
Windshield Wiper Fuses
The windshield wiper motor is protected by a circuit
breaker inside the motor and a circuit breaker in the fuse
block. If the motor overheats, the wipers will stop until
the motor cools. If the overload is caused by an
electrical problem, be sure to get it fixed.
Fusible Links
A fusible link is a short piece of wire several gage sizes
smaller than the circuit it protects. It will melt in an
overload situation, opening the circuit.
Your starter relay and other circuits have these fusible
links. The size is printed on the insulation. If the insulation
is burned beyond recognition, consult your GM dealer for
the proper size. Replace a fusible link with one of the
same size and insulation type. Fusible link insulation is a
special purpose high
-temperature material.
The hydraulic brake booster motor feed circuit and
starter relay circuit are protected by a fusible link.
Vehicles with a diesel engine have a fusible link for the
intake heater feed circuit. Vehicles equipped with an
electronically controlled diesel engine also have a
fusible link for the engine control unit.
ProCarManuals.com

yellowblue
6-70
Name Circuits Protected
HYD BRK Brake Pump Motor Relay
HYD BRK Brake Alarm ModuleName Circuits Protected
B/U IGN3 Fuel Filter Relay, Blower Motor
Relays, ABS Power Relay,
Back
-Up Lamps, Auxiliary Wiring
Relay, IGN 3 Relay, Power
Window Relay, Vehicle Interface
Module, Transmission
Temperature Gage
STOP Stoplamps
WASH/WIPE Windshield Wipers/Washer,
Accessory Relay
DOME/PNL Dome Lamp, Radio Receiver,
Instrument Panel Lights,
A/C Controller,
Headlamp/Seatbelt Module
BLOWER Blower Motor
A/C A/C Clutch Compressor,
A/C Controller
TRN/HAZ Turn Signals, Hazard Flashers
ProCarManuals.com

yellowblue
6-71
Name Circuits Protected
CHAS Exhaust Brake, Air Suspension
Dump Valve, Air Dryer, HYD
ABS ECHU
PARK LP Auxiliary Wiring, Air Conditioner
Controls, Parking Lamps, Turn
Signals, Taillamps, Stoplamps,
Marker Lamps, Trailer Running
Lamps, Lighted Mirrors, Radio
Receiver, Mirror Clearance Lamps
HORN Horn/Diagnostic Connector
PRK BRK Parking Brake Module
FUEL Heated Fuel Filter (Diesel
Engines) or Fuel Pump
(Gasoline Engines)
AXLE Heated Mirrors, Radiator Shutters,
Tw o
-Speed Axle Motor,
Tw o
-Speed Axle Switch
MRKR LP Roof Marker Lamps,
Trailer Marker Lamps,
Marker Lamp RelayName Circuits Protected
CIG/AUX Cigarette Lighter,
Auxiliary Power Jacks
AUX Auxiliary Wiring Relay
IGN RLY/VIN Vehicle Interface Module
(Diesel Engines) or Generator,
Coil, Injectors (Gasoline Engines)
WDO Power Windows
CRNK Starter Relay
IGN SW Instrument Panel Cluster Telltales
AUX Auxiliary Wiring
RDO Radio, Auxiliary Wiring
DR LK Power Door Locks
ProCarManuals.com

yellowblue
6-73
Name Circuits/Circuit Breakers
Protected
STP/HAZ
TURNStop Lamp, Turn Signal/Hazard
Lights, Fuel, Ignition Relay
(Gasoline Engines)
IGN SW3 Air Conditioner, Ignition Switch,
Axle, ChassisName Circuits/Circuit Breakers
Protected
INT/EXT
LIGHTSParking Lamps,
Dome/Panel Lights
HEAD LAMP Headlamps,
Daytime Running Lamps
AUX WRG Auxiliary, Park Brake
IGN SW1 Ignition Switch, Wash/Wipe,
Crank, Radio
HYD PUMP Hydraulic Brake,
Brake Pump Motor
HYD ABS EHCU
PWR
WDO/LCKSWindow, Door Locks
PARK BRK Parking Brake Motor
BLOWER
HORNBlower, Horn, Cigarette
Lighter/Auxiliary
FUEL/ENGINE Empty
ProCarManuals.com

yellowblue
7-6 12,000 Miles (20 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Lubricate door hinge pins and rollers with engine oil.

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Engine drive belts service (or every 12 months,
whichever occurs first). (18)

Clutch pedal free travel service. (10)

Throttle linkage service. (19)

Thermostatically controlled engine cooling
fan service. (4)(20)

Shields and underhood insulation service. (4)(5)(21)

Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).
15,000 Miles (25 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Steering system service. (13)

Front and rear suspension service. (14)

Spring
-to-axle U-bolts and shackle bolts service. (16)

Exhaust system service (or every 6 months,
whichever occurs first). (3)(4)(17)

Air brake service (or every 6 months, whichever
occurs first). (39)
18,000 Miles (30 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Inspect door hinge pins and bushings and replace as
necessary. Lubricate door hinge pins and rollers with
engine oil.
ProCarManuals.com

yellowblue
7-8 24,000 Miles (40 000 km) (Continued)

Evaporative Control System service (if equipped) (or
every 24 months, whichever occurs first). (3)(26)

Rear axle air shift motor service. (11)
Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).
Air brake chamber service (or every 2 months,
whichever occurs first). (41)
Trailer brake hand control valve service (or every
3 months, or 900 hours, whichever occurs first). (42)
27,000 Miles (45 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
30,000 Miles (50 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
Chassis lubrication service (or every 6 months,
whichever occurs first). (12)
Replace fuel filter(s) (or every 12 months, whichever
occurs first). (3)Air cleaner filter replacement service (or every
24 months, whichever occurs first). (3)(4)(27)
Steering system service. (13)
Front and rear suspension service. (14)
Spring
-to-axle U-bolts and shackle bolts service. (16)
Exhaust system service (or every 6 months,
whichever occurs first). (3)(4)(17)
Air brake service (or every 6 months, whichever
occurs first). (39)
Lubricate door hinge pins and rollers with engine oil.
Wheels and tires service. (15)
Hydraulic brake service (or every 6 months,
whichever occurs first). (7)
Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)
Clutch pedal free travel service. (10)
Air brake automatic slack adjuster service (or every
500 hours, whichever occurs first). (40)
33,000 Miles (55 000 km)
Engine oil and filter service. (3)(9)
Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
ProCarManuals.com

yellowblue
7-9 36,000 Miles (60 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Inspect door hinge pins and bushings and replace as
necessary. Lubricate door hinge pins and rollers with
engine oil.

Replace air conditioning filter dryer (or every
18 months, whichever occurs first, and whenever
refrigerant charge is lost for any reason).

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic brake caliper service (or every 6 months,
whichever occurs first). (22)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Engine drive belts service (or every 12 months,
whichever occurs first). (18)

Clutch pedal free travel service. (10)

Throttle linkage service. (19)

Thermostatically controlled engine cooling
fan service. (4)(20)
Shields and underhood insulation service. (4)(5)(21)

Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).

Clean air brake application valve (or every 3 months,
or every 300 hours, whichever occurs first);
lubricate linkage.
39,000 Miles (65 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
42,000 Miles (70 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Lubricate door hinge pins and rollers with engine oil.

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Clutch pedal free travel service. (10)
ProCarManuals.com

yellowblue
7-10 45,000 Miles (75 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Steering system service. (13)

Front and rear suspension service. (14)

Spring
-to-axle U-bolts and shackle bolts service. (16)

Exhaust system service (or every 6 months,
whichever occurs first). (3)(4)(17)

Air brake service (or every 6 months, whichever
occurs first). (39)
48,000 Miles (80 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Lubricate door hinge pins and rollers with engine oil.

Wheel bearing (grease type) service (or every
24 months, whichever occurs first, and whenever
hubs are removed). (23)

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)
Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Engine drive belts service (or every 12 months,
whichever occurs first). (18)

Clutch pedal free travel service. (10)

Throttle linkage service. (19)

Thermostatically controlled engine cooling
fan service. (4)(20)

Shields and underhood insulation service. (4)(5)(21)

Air intake system service (or every 24 months,
whichever occurs first). (4)(5)(24)

Thermostatically controlled air cleaner service (or
every 24 months, whichever occurs first).
(3)(4)(25)

Evaporative Control System service (if equipped) (or
every 24 months, whichever occurs first). (3)(26)

Rear axle air shift motor service. (11)
Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).
Air brake chamber service (or every 2 months,
whichever occurs first). (41)
Trailer brake hand control valve service (or every
3 months, or 900 hours, whichever occurs first). (42)
ProCarManuals.com

yellowblue
7-12 60,000 Miles (100 000 km) (Continued)

Exhaust system service (or every 6 months,
whichever occurs first). (3)(4)(17)

Air brake service (or every 6 months, whichever
occurs first). (39)

Lubricate door hinge pins and rollers with engine oil.

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Engine drive belts service (or every 12 months,
whichever occurs first). (18)

Clutch pedal free travel service. (10)

Throttle linkage service. (19)

Thermostatically controlled engine cooling
fan service. (4)(20)

Shields and underhood insulation service. (4)(5)(21)

Positive Crankcase Ventilation (PCV) system service
(or every 60 months, whichever occurs first). (3)(33)

Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).

Air brake automatic slack adjuster service (or every
500 hours, whichever occurs first). (40)
63,000 Miles (105 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
66,000 Miles (110 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Lubricate door hinge pins and rollers with engine oil.

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Clutch pedal free travel service. (10)
69,000 Miles (115 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)
ProCarManuals.com

yellowblue
7-13 72,000 Miles (120 000 km)

Engine oil and filter service. (3)(9)

Check fluid levels (or every 3 months, whichever
occurs first). (1)(2)(6)

Chassis lubrication service (or every 6 months,
whichever occurs first). (12)

Inspect door hinge pins and bushings and replace as
necessary. Lubricate door hinge pins and rollers with
engine oil.

Replace air conditioning filter dryer (or every
18 months, whichever occurs first, and whenever
refrigerant charge is lost for any reason).

Wheel bearing (grease type) service (or every
24 months, whichever occurs first, and whenever
hubs are removed). (23)

Wheels and tires service. (15)

Hydraulic brake service (or every 6 months,
whichever occurs first). (7)

Hydraulic brake caliper service (or every 6 months,
whichever occurs first). (22)

Hydraulic parking brake service (or every 6 months,
whichever occurs first). (8)

Engine drive belts service (or every 12 months,
whichever occurs first). (18)

Clutch pedal free travel service. (10)
Throttle linkage service. (19)

Thermostatically controlled engine cooling
fan service. (4)(20)

Shields and underhood insulation service. (4)(5)(21)

Air intake system service (or every 24 months,
whichever occurs first). (4)(5)(24)

Thermostatically controlled air cleaner service (or
every 24 months, whichever occurs first). (3)(4)(25)

Fuel tank, fuel cap and fuel lines service (or every
72 months, whichever occurs first). (3)(30)

EGR system inspection (or every 72 months,
whichever occurs first). (3)(31)
Electronic Vacuum Regulator Valve (EVRV)
inspection (or every 72 months, whichever occurs
first). (3)(32)
Evaporative Control System Service (if equipped)
(or every 24 months, whichever occurs first).
(3)(26)

Rear axle air shift motor service. (11)
Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours,
whichever occurs first).
(Continued)
ProCarManuals.com