engine oil GMC SAVANA 1996 Owner's Manual

Cooling System Capacity
ENGINE VIN
“VORTEC” 4300 W
“VORTEC” SO00 M
“VORTEC” 5700 R
“VORTEC” 7400 J
QTY Without Rear Heater*
1 1 quarts ( 10.4 L)
17 quarts ( 16 L)
17 quarts (16 L)
23 quarts (2 1.8 L)
QTY With Rear Heater*
14 quarts (13.2 L)
20 quarts (18.9 L)
20 quarts (1 8.9 L)
26 quarts (24.6 L)
After refill, the level MUST be checked as outlined under “Engine Cooling System” in Section 5.
*All quantities are approximate.
Crankcase Capacity
ENGINE VIN
“VORTEC” 4300 W
“VORTEC” 5000 M
“VORTEC” 5700 R
“VORTEC” 7400 J
Quantity With Filter
4.5 quarts (4.3 L)
5 quarts (4.8 L)
5 quarts (4.8 L)
7 quarts (6.5 L)
All quantities are approximate.
After refill, the level
MUST be checked as outlined under “Engine Oil And Filter Recommendations” in Section 5.
*Add an aS;lditis.ad quart (1 L) for RPO 5ZI and RPO KL5 Models.
6-66
ProCarManuals.com

Fuel Tank Capacity
TYPE
Standard Tank
Cutaway Standard Tdnk
Cutaway Optional Tank
All quantities are approximate.
QUANTITY
3 I gallons (I 17.3 L)
35 gallons (132 L)
55 gallons (208.2 L)
Normal Rc --' :ermt Parts
Engine "VORTEC" 4300
VIN W
Oil Filter PFS2
Air Cleaner Filter'l'
A9 17C
PCV Valve CV789C
Spark Plugs
4 1-932
Fuel Filter GF48 1
Radiator Cap RC36 VORTEC"
5000
M
PF1218
A9 17C
cv774c
4 1-932
CF48
1
RC36
'"For severe dusty conditions, use AC Air Filter, Part No. 1236C. "VORTEC"
5700 "VORTEC" 7400
R J
PF1218
PF1218
A9 17C A917C
cv774c cv774c
4 1-932 4 1-932
GF48
1 GF48 I
RC36 RC36
6-67
ProCarManuals.com

Section 7 Maintenance Schedule
IMPORTANT.
KEEP ENGINE OIL
AT THE PROPER
LEVEL AND CHANGE AS
RECOMMENDED
This section covers the maintenance required for your
vehicle. Your vehicle needs these services to retain its
safety, dependability and emission control performance.
Have you purchased the GM Protection Plan? The Plan
supple~nents your new vehicle warranties. See your
Warranty
and Owner Assistance hooklet, or your
GM deuler for detuils.
Introduction
Your Vehicle and the Environment
Proper vehicle maintenance not only helps to keep your
vehicle
in good working condition, but also helps the
environment. All recommended maintenance procedures
are important. Improper vehicle maintenance can even
affect the quality
of the air we breathe. Improper fluid
levels or the wrong tire inflation can increase
the level
of emissions from your vehicle. To help protect our
environment, and to keep your vehicle in good
condition, please maintain your vehicle properly.
7-1
ProCarManuals.com

Maintenance Schedule
Short TripKity Definition -- Gasoline Engines i
Follow the Short Trip/City Maintenance Schedule if any
one of these conditions is true for your vehicle:
0
0
0
0
0
e
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
Most trips include extensive idling (such as frequent
driving
in stop-and-go traffic j.
Most trips are through dusty areas.
You frequently tow
a trailer or use a carrier on top of
your vehicle.
You frequently tow
a trailer or us-e a carrier on top of
your vehicle. (With some models, you should never
tow
a trailer. See “Towing a Trailer” in the Index.)
If the vehicle is used for delivery service, police, taxi
or other commercial application.
Short Trip/City Intervals -- Gasoline Engines
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change (or
3 months, whichever occurs first). Chassis
Lubrication (or
3 months, whichever occurs first).
Drive Axle Service (or
3 months, whichever
occurs first).
At 6,000 Miles (10 000 km) -- Then Every
12,000 Miles (20
000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection,
if driving in dusty conditions. Shields and
Underhood Insulation Inspection (GVWR above
8,500 Ibs. only). Thermostatically Controlled Engine
Cooling Fan Check (or every
12 months, whichever
occurs first). Front Wheel Bearing Repack (or at each
brake relining, whichever occurs first).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Filter Replacement.
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (vehicles over
8600 GVWR
or driven under severe conditions only).
7-4
ProCarManuals.com

Maintenance Schedule
I Short Trip/City Intervals -- Gasoline Engines I
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection. Fuel Tank, Cap and Lines
Inspection. Exhaust
Gas Recirculation System
Inspection. Evaporative Control System Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service
(or every 60 months, whichever occurs first).
Spark Plug Wire Inspection. Spark Plug Replacement.
Positive Crankcase Ventilation (PCV) Valve Inspection.
These intervals onlj? sumnariZe mlinterzcrnce services.
Be sure to.follow the complete nzainterzance schedule on
the jollowing pcrges.
I Long Tkip/Highway Definition -- Gasoline Engines I
Follow this maintenance schedule ordy if none of the
conditions from the Short Trip/City Maintenance
Schedule
is true.
Driviizg a vehicle with a fdly warmed engine mder
highway conditions c:a~~ses engine oil
to break
down slowe~:
7-5
ProCarManuals.com

Maintenance Schedule
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every 12 months, whichever occurs first).
Chassis Lubrication (or every 12 months, whichever
occurs first). Drive Axle Service.
At 7,500 Miles (12 500 km) -- Then Every
15,000 Miles
(25 000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Shields and
Underhood Insulation Inspection (GVWR above
8,500 lbs. only). Thermostatically Controlled Engine
Cooling Fan Check
(or every 12 months, whichever
occurs first).
Every 30,000 Miles (50 000 km): Fuel Filter
Replacement. Air Cleaner Filter Replacement.
Front Wheel Bearing Repack (or at each brake
relining, whichever occurs first).
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (vehicles over
8600 GVWR or
driven under severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection. Fuel
Tank, Cap and Lines
Inspection. Exhaust Gas Recirculation System
Inspection. Evaporative Control System Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs fist).
Spark Plug Wire Inspection. Spark
Plug Replacement.
Positive Crankcase Ventilation (PCV) Valve Inspection.
These intervals only sumnarize maintenance services.
Be sure to follow the complete maintenance schedule on
the.following pnges.
7-6
ProCarManuals.com

I Short Trip/City Maintenance Schedule -= Gasoline Engines I
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals.
Footnotes
f The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at
the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspenslon, kingpin bushings,
steering linkage and rear driveline center splines.
*:!: Drive axle service:
Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent
oil changes, check
fluid level and add fluid as needed. If driving
in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
Standard Differential -- Check fluid level and add
fluid as needed at every oil change.
If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
More frequent lubrication may be required for
heavy-duty use.
7-7
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
3,000 Miles (5 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
An Emission Control Service.
footnote ## (or every 3 months, whichever
occurs first).
as needed. **
CI Check axle fluid level and add fluid
DATE ACTUAL MILEAGE SERVICED BY
6,000 Miles (10 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Servic-e.
0 Lubricate chassis components; see footnote ##
(or every 3 months, whichever occurs first).
0 Check axle fluid level and add fluid
as needed. **
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom
of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
7-8
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines I
9,000 Miles (15 000 ks:)
CI Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
AH Emission Control Service.
footnote # (or every 3 months, whichever
occurs first).
as needed. :$*
0 Check axle fluid level and add fluid
DATE ACTUAL MILEAGE
SERVICED BY: I
12,000 Miles (20 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
I7 Lubricate chassis components; see
An Emission Control Service.
footnote # (or every 3 months, whichever
occurs first).
0 Check axle fluid level and add fluid
as needed :%:I:
DATE
SERVICED BY ACTUAL MILEAGE
7-9
ProCarManuals.com

Short TripKity Maintenance Schedule -- Gasoline Engines A
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
Arz Emission Cotltr-ol Senlice.
footnote ## (or every 3 months, whichever
occurs first).
El Inspect air cleaner filter if you are driving
in dusty conditions. Replace filter if
necessary. AFI Emission Contd Stjt-vic’o.
0 Check axle tluid level and add fluid
as needed.
**
Clean and repack the front wheel bearings
(or at each brake relining, whichever
occurs first).
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace
as required. This is Noise Emission
Control Ser\*icc_. Applicnble only to vehicles sold irz
the United Stl1te.s.
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly. 7his is CI Noise
Emission Corltrol Service. Applicddr onl~ to
\~cl~ic.lcs sold in the United Stcrtes.
DArE SERVICED BY ACTUAL MILEAGE
7-10
ProCarManuals.com