maintenance schedule GMC SAVANA 1996 Owner's Guide

Short TripKity Maintenance Schedule -- Gasoline Engines >
78,000 Miles (130 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An EI~I~SS~OII Control Service.
0 Lubricate chassis components; see footnote #
(or every 3 months, whichever occurs first).
0 Check axle fluid level and add fluid
as needed.
#’*
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During tire rotation, check brake calipers for
freedom of movement. Refer to
the
appropriate GM service manual for proper
caliper service procedures.
DATE SERVICED BY ACTUAL MILEAGE
81,000 Miles (135 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components; see
footnote
## (or every 3 months, whichever
occurs first).
as needed. ‘k*
0 Check axle fluid level and add fluid
DATE SERVICED BY ACTUAL MILEAGE
7-24
ProCarManuals.com

I Short TripKity Maintenance Schedule =- Gasoline Engines I
84,000 Miles (140 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
An Emission Control Service.
footnote # (or every 3 months, whichever
occurs first).
0 Check axle fluid level and add fluid
as needed :i: :k
DATE SERVICED BY ACTUAL MILEAGE
87,000 Miles (145 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
AI? Elnission Control Service.
footnote # (or every 3 months, whichever
occurs first).
as needed. ‘M
0 Check axle fluid level and add fluid
7-25
ProCarManuals.com

Short TriplCity Maintenance Schedule -- Gasoline Engines
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
An Em,ission Control Service.
footnote ## (or every 3 months, whichever
occurs first).
as needed.
**
(or at each brake relining, whichever
occurs first).
An Emission Control Service. -f
0 Check axle fluid level and add fluid
0 Clean and repack the front wheel bearings
0 Replace fuel filter.
17 Replace air cleaner filter.
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers
for
freedom of movement. Refer to the
appropriate GM service manual for proper
caliper service procedures.
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace
as required. This is a Noise Emission
Control Service. Applicable only to vehicles sold in
the United States.
ProCarManuals.com

I Short TripKity Maintenance Schedule =- Gasoline Engines I
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve
works properly. This is CL Noise
EIT~~SS~OII Cotm-d Service. Applicdde or1lv to
vehicles sold if1 the United StLrtes.
DATE ACTUAL MILEAGE SERVICED BY
93,000 Miles (155 000 km)
El Change engine oil and filter (or every
3 months, whichever occurs first).
Arz Emis.siou Contra[ Srl-\.~ic~e.
0 Lubricate chassis components; see
foot.note
# (or every 3 months, whichever
occurs first).
0 Check axle fluid level and add fluid
as needed :K:k
DATE SERVICED BY ACTUAL MILEAGE
7-27
ProCarManuals.com

1 Short Trip/City Maintenance Schedule -- Gasoline Engines I
96,000 Miles (160 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
AH Emission Cmtrol Service.
footnote # (or every 3 months, whichever
occurs first).
as needed. ‘H
0 Check axle fluid level and add fluid
I DATE I ACTUAL MILEAGE ISERVICED BY:(
99,000 Miles (165 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
An em is sin^^ Control Service.
footnote # (or every 3 months, whichever
occurs first).
0 Check axle fluid level and add fluid
as needed. :%:>
.
<
ACTUAL MILEAGE SERVICED BY
7-28
ProCarManuals.com

1 Short Trip/City Maintenance Schedule -- Gasoline Engines I
100,000 Miles (166 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service
whichever occurs first). See “Engine
Coolant”
in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
AI1 Emission Control Service.
0 Inspect spark plug wires.
An Ernission Control Service.
0 Replace spark plugs.
0 Change automatic transmission fluid and
An Emission Colztrol Service.
filter if the vehicle’s GVWR is over
8600 lbs. or if the vehicle is mainly driven
under one
or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90” F
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If yxt do mt use yx.tr vehicle lmder- any of
thew conditio~~s, the flL.rici md,filt6>r do not
require dhnging.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve. An Emission Cor~trol Service.
DATE SERVICED BY ACTUAL MILEAGE
7-29
ProCarManuals.com

{bong Trip/Highway Maintenance Schedule =- Gasoline Engines
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(1 66 000 km) at the same intervals.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that
the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion
of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at
the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage and rear driveline center splines.
:i: *
0
0
Drive axle service:
Locking Differential
-- Drain fluid and refill at first
engine
oil change. At subsequent oil changes, check
fluid level and add fluid as needed.
If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
Standard Differential
-- Check fluid level and add
fluid
as needed at every engine oil change. If driving
in dusty areas or towing a trailer, drain fluid and
refill every
15,000 miles (35 000 km).
More frequent lubrication may be required for
heavy-duty use.
7-30
ProCarManuals.com

I
- mg Trip/Highway Maintenance Schedule -- Gasoline Engines
7,500 Miles (12 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Elnission Con fro1 Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
Cl Check axle fluid level and add fluid
as needed. :k*
Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom of movement. R.efer to the
appropriate
GM service manual for proper
caliper service procedures.
DATE SERVICED BY ACTUAL MILEAGE
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate chassis components; see
An Emission Control Service.
footnote ## (or every 12 months, whichever
occurs first).
0 Check axle fluid level and add fluid
as needed.
Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace as required. This is a Noise Emissiou
Col7tt-ol
Servic:c. Applicclhle only to whic*les sold in
the UI7ited States.
(Continued)
7-31
ProCarManuals.com

Long TripJHighway Maintenance Schedule -- Gasoline Engines
15,000 Miles (25 000 km) (Continued)
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly. This is LZ Noise
Euzissioll
Control Service. ApplicclDle orzl~ to
vehic.1e.s sold in the United Stcrtes.
I DATE I ACTUAL MILEAGE ISERVICED BY I
22,500 Miles (37 500 km)
Change engine oil and filter (or every
12 months, whichever occurs first).
An Et~~issior? Co11tr-d Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
0 Check axle fluid level and add fluid
as needed.
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
7-32
ProCarManuals.com

Long TripMighwag Maintenance Schedule -- Gasoline Engines rn
30,000 Miles (50 000 km)
Change engine oil and filter (or every
12 months, whichever occurs first).
0 Lubricate chassis components; see
A11 Emission ColztmI Service.
footnote # (or every 12 months, whichever
occurs first).
as needed.
*:k
(or at each brake relining, whichever
occurs first).
0 Check axle fluid level and add fluid
Clean and repack the front wheel bearings
Replace fuel filter.
0 Replace air cleaner filter.
An Ernissinn Control Service. -f-
AI? Emission Control Service.
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace as required. This is a Noise Emission
Control Service. Applicable only to vehicles sold in
the United States.
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly.
This is LI Noise
Emission Corztvol Service. Applicable
only to
vehicles sold in the United States.
7-33
ProCarManuals.com