warning GMC SAVANA 2003 Owner's Guide

Appearance Care
Remember, cleaning products can be hazardous.
Some are toxic. Others can burst intoflames if you
strike a match or get them on a hot part of the vehicle.
Some are dangerous if you breathe their fumes in a
closed space. When you use anything from a container to
clean your vehicle, be sure to follow the manufacturer’s
warnings and instructions. And always open your doors
or windows when you’re cleaning the inside.
Neveruse these to clean your vehicle:
•Gasoline
•Benzene
•Naphtha
•Carbon Tetrachloride
•Acetone
•Paint Thinner
•Turpentine
•Lacquer Thinner
•Nail Polish Remover
They can all be hazardous–some more than
others–and they can all damage your vehicle, too.Don’t use any of these unless this manual says you
can. In many uses, these will damage your vehicle:
•Alcohol
•Laundry Soap
•Bleach
•Reducing Agents
Cleaning the Inside of Your Vehicle
Use a vacuum cleaner often to get rid of dust and
loose dirt. Wipe vinyl, leather, plastic and painted
surfaces with a clean, damp cloth.
Fabric/Carpet
Your dealer has cleaners for the cleaning of fabric
and carpet. They will clean normal spots and stains
very well.
You can get GM-approved cleaning products from your
dealer. SeeGM Vehicle Care/Appearance Materials
on page 5-89.
5-82
2003 - Savana OM

A
Accessory Power Outlets.................................3-16
Adding Equipment to Your Air Bag-Equipped
Vehicle.......................................................1-75
Adding Washer Fluid.......................................5-36
Additional Program Information........................... 7-9
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-91
Add-On Equipment..........................................4-31
Adjusting the Speakers
(Balance/Fade)....................3-44, 3-47, 3-51, 3-62
Air Bag
Off Light.....................................................3-28
Readiness Light..........................................3-27
Air Bag System..............................................1-63
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-75
Air Bag Off Switch.......................................1-71
How Does an Air Bag Restrain?....................1-69
Servicing Your Air Bag-Equipped Vehicle.........1-74
What Makes an Air Bag Inflate?....................1-69
What Will You See After an
Air Bag Inflates?......................................1-70
When Should an Air Bag Inflate?...................1-67
Where Are the Air Bags?..............................1-66
Air Bag Systems.............................................1-69Air Cleaner/Filter, Engine.................................5-17
All Overseas Locations...................................... 7-5
All-Wheel Drive...............................................5-46
All-Wheel Drive (AWD) System.........................2-26
Aluminum Wheels...........................................5-87
AM ...............................................................3-74
AM-FM Radio.................................................3-42
Antenna, Fixed Mast.......................................3-76
Anti-lock Brake System..................................... 4-7
Anti-Lock Brake, System Warning Light..............3-32
Appearance Care............................................5-82
Care of Safety Belts....................................5-85
Chemical Paint Spotting...............................5-88
Cleaning the Inside of Your Vehicle................5-82
Cleaning the Outside of Your Vehicle..............5-85
Finish Damage............................................5-88
GM Vehicle Care/Appearance Materials..........5-89
Sheet Metal Damage...................................5-87
Underbody Maintenance...............................5-88
Weatherstrips..............................................5-85
Ashtrays........................................................3-16
Audio System(s).............................................3-41
AM-FM Radio.............................................3-42
Care of Your Cassette Tape Player................3-74
Care of Your CD Player...............................3-76
Care of Your CDs ........................................3-76
Chime Level Adjustment...............................3-76
1
2003 - Savana OM

Audio System(s) (cont.)
Fixed Mast Antenna.....................................3-76
Radio with Cassette and CD.........................3-49
Radio with CD............................................3-45
Radio with Six-Disc CD................................3-60
Rear Seat Audio (RSA)................................3-71
Setting the Time for Radios with Radio
Data Systems (RDS)................................3-41
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-41
Theft-Deterrent Feature................................3-73
Understanding Radio Reception.....................3-74
Automatic Transmission
Fluid..........................................................5-19
Operation...................................................2-24
Automatic Transmission Check..........................6-13
Automatic Transmission Shift Lock Control
System Check.............................................6-14
B
Backing Up....................................................4-43
Battery..........................................................5-40
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-15
Before Leaving on a Long Trip.........................4-21
Body Lubrication Service..................................6-13Brake
Parking......................................................2-26
System Inspection.......................................6-17
System Warning Light..................................3-31
Brake Adjustment............................................5-39
Brake Fluid....................................................5-37
Brake Pedal Travel.........................................5-39
Brake Wear...................................................5-39
Brakes..........................................................5-37
Braking........................................................... 4-6
Braking in Emergencies..................................... 4-9
Break-In, New Vehicle.....................................2-20
Bulb Replacement...........................................5-50
Front Turn Signal, Sidemarker and
Parking Lamps.........................................5-52
Halogen Bulbs............................................5-50
Headlamps.................................................5-50
Replacement Bulbs......................................5-54
Taillamps....................................................5-52
Buying New Tires...........................................5-61C
California Fuel.................................................. 5-5
Canada........................................................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
2
2003 - Savana OM

Capacities......................................................5-98
Capacities and Specifications............................5-97
Carbon Monoxide...........................4-24, 4-31, 2-30
Care of
Safety Belts................................................5-85
Your Cassette Tape Player............................3-74
Your CD Player...........................................3-76
Your CDs ...................................................3-76
Cargo Door Relocking....................................... 2-9
Cargo Vans and Cab and Chassis Models
with an Air Bag Off Switch............................1-48
Cargo Vans and Cab and Chassis Models
without an Air Bag Off Switch........................1-47
Cargo Vans with a Passenger Air Bag and
an Air Bag Off Switch, Passenger Vans and
Cab and Chassis Models..............................1-36
Cargo Vans with a Passenger Air Bag and
without an Air Bag Off Switch........................1-39
Cassette Tape Messages.................................3-57
Cassette Tape Player Service...........................6-12
CD Adapter Kits.............................................3-57
Center High Mounted Stoplamp
(CHMSL) ............................................3-14, 5-54
Center Passenger Position,
Safety Belts........................................1-23, 1-24
Chains, Tires..................................................5-65
Charging System Light....................................3-29Check
Engine Light...............................................3-33
Gages Warning Light...................................3-39
Check Engine Light.........................................3-33
Checking Brake Fluid......................................5-38
Checking Coolant............................................5-24
Checking Engine Oil........................................5-13
Checking Things Under the Hood....................... 5-9
Checking Your Restraint Systems......................1-75
Chemical Paint Spotting...................................5-88
Child Restraints
Child Restraint Systems...............................1-42
Infants and Young Children...........................1-36
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-52
Older Children.............................................1-33
Securing a Child Restraint Designed for
the LATCH System...................................1-54
Securing a Child Restraint in a Center
Seat Position...................................1-56, 1-57
Securing a Child Restraint in a Rear
Outside Seat Position...............................1-54
Securing a Child Restraint in the Right
Front Seat Position...................................1-58
Top Strap...................................................1-49
Top Strap Anchor Location............................1-50
Where to Put the Restraint...........................1-45
3
2003 - Savana OM

Chime Level Adjustment..................................3-76
Cigarette Lighter.............................................3-16
Cleaning
Inside of Your Vehicle..................................5-82
Outside of Your Vehicle................................5-85
Underbody Maintenance...............................5-88
Weatherstrips..............................................5-85
Cleaning Exterior Lamps/Lenses.......................5-86
Climate Control System...................................3-17
Rear Air Conditioning and Heating System......3-19
Rear Heating System...................................3-18
Compact Disc Messages.................3-48, 3-59, 3-71
Control of a Vehicle.......................................... 4-6
Coolant
Engine Temperature Gage............................3-32
Heater, Engine............................................2-23
Low Warning Light.......................................3-33
Cooling System..............................................5-28
Cruise Control.................................................. 3-9
Cruise Control Light........................................3-38
Current and Past Model Order Forms................7-11
Customer Assistance Information
Courtesy Transportation.................................. 7-7
Customer Assistance for Text
Telephone (TTY) Users............................... 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2Customer Assistance Information (cont.)
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to General Motors....7-10
Reporting Safety Defects to the Canadian
Government............................................7-10
Reporting Safety Defects to the United States
Government.............................................. 7-9
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information........7-10
D
Daytime Running Lamps..................................3-13
Daytime Running Lamps Indicator Light.............3-39
Defensive Driving............................................. 4-2
Defogging and Defrosting.................................3-21
Directing the Airflow ........................................3-20
Doing Your Own Service Work........................... 5-3
Dome Lamp Override......................................3-14
Dome Lamps .................................................3-15
Door
60/40 Swing-Out Side Door...........................2-13
Cargo Door Relocking.................................... 2-9
Locks.......................................................... 2-8
Power Door Locks......................................... 2-9
4
2003 - Savana OM

Engine Compartment Fuse Block......................5-94
Engine Coolant Level Check.............................6-12
Engine Oil Additives........................................5-15
Engine Oil Level Check...................................6-12
Entry Lighting.................................................3-15
Exit Lighting...................................................3-15
Extender, Safety Belt.......................................1-32
Exterior Lamps...............................................3-12
F
Fabric/Carpet.................................................5-82
Filter
Engine Air Cleaner......................................5-17
Finding a PTY Station.............................3-52, 3-63
Finding a Station....................3-42, 3-45, 3-50, 3-61
Finish Care....................................................5-86
Finish Damage...............................................5-88
Fixed Mast Antenna........................................3-76
Flash-To-Pass Feature....................................... 3-7
Flat Tire........................................................5-65
Flat Tire, Changing.........................................5-66
Floor Console Fuse Block................................5-92
Fluid
Automatic Transmission................................5-19
Power Steering...........................................5-35
Windshield Washer......................................5-36FM ...............................................................3-74
Following Distance..........................................4-43
Footnotes........................................................ 6-5
Front Axle......................................................5-48
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage .........................................................3-40
Gasoline Octane........................................... 5-4
Gasoline Specifications.................................. 5-5
System Inspection.......................................6-16
Fuel Regulator................................................2-22
Fuses
Fuses and Circuit Breakers...........................5-92
Windshield Wiper.........................................5-91
G
Gage
Check Gages Warning Light..........................3-39
Engine Coolant Temperature.........................3-32
Fuel..........................................................3-40
Oil Pressure...............................................3-36
Speedometer..............................................3-25
Voltmeter Gage...........................................3-30
6
2003 - Savana OM

Gasoline
Octane........................................................ 5-4
Specifications............................................... 5-5
Glass Surfaces...............................................5-84
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-4
Headlamp High/Low Beam Changer.................... 3-7
Headlamp Wiring............................................5-91
Headlamps....................................................5-50
Bulb Replacement.......................................5-50
Front Turn Signal, Sidemarker and
Parking Lamps.........................................5-52
Halogen Bulbs............................................5-50
Highway Hypnosis...........................................4-22
Hill and Mountain Roads..................................4-22
Hitches..........................................................4-41
Hood
Checking Things Under.................................. 5-9
Release.....................................................5-10
Horn ............................................................... 3-5
How to Add Coolant to the Coolant
Recovery Tank............................................5-29How to Add Coolant to the Radiator..................5-31
How to Add Fluid............................................5-22
How to Check........................................5-19, 5-57
How to Check Lubricant...................................5-47
How to Check Power Steering Fluid..................5-35
How to Inspect the Engine Air Cleaner/Filter..........5-18
How to Reset the CHANGE ENGINE OIL Light......5-16
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-14
Hydroplaning..................................................4-18
I
If No Steam Is Coming From Your Engine..........5-27
If Steam Is Coming From Your Engine...............5-26
If the Light Is Flashing.....................................3-34
If the Light Is On Steady.................................3-35
If You Are Stuck in Sand, Mud, Ice or Snow.......4-28
If You Do Decide To Pull A Trailer.....................4-32
If You’re Caught in a Blizzard...........................4-26
Ignition Positions.............................................2-21
Ignition Transmission Lock Check......................6-15
Infants and Young Children, Restraints...............1-36
Inflation–Tire Pressure...................................5-57
Inside Day/Night Rearview Mirror......................2-32
7
2003 - Savana OM

Inspection
Brake System.............................................6-17
Engine Cooling System................................6-16
Exhaust System..........................................6-16
Fuel System...............................................6-16
Part C - Periodic Maintenance.......................6-16
Steering and Suspension..............................6-16
Throttle System...........................................6-17
Transfer Case and Front Axle
(All-Wheel Drive)......................................6-17
Instrument Panel
Cluster.......................................................3-24
Overview..................................................... 3-2
Instrument Panel Brightness Control..................3-14
Interior Lamps................................................3-14
Interior Plastic Components..............................5-84
J
Jump Starting.................................................5-41
K
Key Lock Cylinders Service..............................6-13
Keyless Entry System....................................... 2-4
Keys............................................................... 2-2
L
Lamps
Exterior......................................................3-12
Interior.......................................................3-14
Lamps On Reminder.......................................3-13
Lap Belt........................................................1-24
Lap-Shoulder Belt...........................................1-14
LATCH System
Child Restraints...........................................1-52
Securing a Child Restraint Designed for
the LATCH System...................................1-54
Leather.........................................................5-84
Leaving Your Vehicle.......................................2-11
Leaving Your Vehicle With the
Engine Running..........................................2-28
Light
Air Bag Off .................................................3-28
Air Bag Readiness.......................................3-27
Anti-Lock Brake System Warning...................3-32
Brake System Warning.................................3-31
Change Engine Oil......................................3-37
Charging System.........................................3-29
Check Gages Warning.................................3-39
Cruise Control.............................................3-38
Daytime Running Lamps Indicator..................3-39
Low Coolant Warning...................................3-33
8
2003 - Savana OM

Light (cont.)
Malfunction Indicator....................................3-33
Safety Belt Reminder...................................3-26
Security.....................................................3-38
Tow/Haul Mode ...........................................3-39
Loading Your Vehicle.......................................4-29
Locking Rear Axle............................................ 4-9
Lockout Protection..........................................2-11
Locks
Cargo Door Relocking.................................... 2-9
Door ........................................................... 2-8
Leaving Your Vehicle....................................2-11
Lockout Protection.......................................2-11
Power Door .................................................. 2-9
Rear Door Security Locks.............................2-10
Loss of Control...............................................4-13
Low Coolant Warning Light..............................3-33
M
Maintenance, Normal Replacement Parts..........5-100
Maintenance Schedule
At Each Fuel Fill.........................................6-12
At Least Once a Month................................6-12
At Least Once a Year..................................6-13
At Least Twice a Year..................................6-13Maintenance Schedule (cont.)
At the First 100, 1,000 and 6,000 Miles
(160, 1 600 and 10 000km).......................6-12
Brake System Inspection..............................6-17
Engine Cooling System Inspection.................6-16
Exhaust System Inspection...........................6-16
Fuel System Inspection................................6-16
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-12
Part C - Periodic Maintenance Inspections......6-16
PartD-Recommended Fluids and
Lubricants...............................................6-18
PartE-Maintenance Record........................6-20
Rear Axle Service........................................6-17
Scheduled Maintenance................................. 6-5
Steering and Suspension Inspection...............6-16
Throttle System Inspection............................6-17
Transfer Case and Front Axle
(All-Wheel Drive) Inspection.......................6-17
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-45
Making Turns.................................................4-43
Malfunction Indicator Light................................3-33
9
2003 - Savana OM

Manual Seats................................................... 1-2
Manual Windows............................................2-17
Matching Transmitter(s) to Your Vehicle................. 2-6
Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands)........................................ 7-5
Mirrors
Manual Rearview Mirror................................2-32
Outside Camper-Type Mirrors........................2-33
Outside Convex Mirror.................................2-34
Outside Heated Mirrors................................2-35
Outside Manual Mirror..................................2-32
Outside Power Mirrors..................................2-34
Outside Remote Control Mirror......................2-32
Model Reference................................................ vi
MyGMLink.com................................................ 7-3
N
New Vehicle Break-In......................................2-20
Noise Control System, Tampering......................5-49
Normal Maintenance Replacement Parts...........5-100
O
Off-Road Recovery..........................................4-11
Oil
Change Engine Oil Light...............................3-37
Engine.......................................................5-13
Pressure Gage............................................3-36
Older Children, Restraints................................1-33
Online Owner Center........................................ 7-3
OnStar
®Personal Calling.................................2-36
OnStar®Services............................................2-36
OnStar®System.............................................2-35
OnStar®Virtual Advisor....................................2-36
Operation Tips................................................3-22
Other Warning Devices...................................... 3-5
Outlet Adjustment............................................3-22
Outside
Camper-Type Mirrors....................................2-33
Convex Mirror.............................................2-34
Heated Mirrors............................................2-35
Manual Mirror.............................................2-32
Power Mirrors.............................................2-34
Remote Control Mirror..................................2-32
Owners, Canadian............................................... ii
Owner’s Information........................................7-11
10
2003 - Savana OM