air conditioning GMC SIERRA 1994 User Guide

Fluid Leak Check
After the vehicle has been parked for a while, inspect the surface under the
vehicle for water, oil, fuel or other fluids. Water dripping from the air
conditioning
system after it has been used is normal. If you notice fuel leaks
or fumes, the causes should be found and corrected at once.
Lubrication
Accelerator Control System
Your maintenance schedule will tell you how often the accelerator linkage
pivot points must be lubricated. See “Recommended
Fluids and Lubricants”
in the Tndex for the proper lubricant to use.
Accelerator cables and cruise control cables should not be lubricated.
Any
cab1e.s that are worn or are hard to pull should be replaced.
Hood Latches and Hood Hinge
Your maintenance schedule will tell you how often to lubricate the hood
latch and hood hinge assembly. See “Recommended Fluids and Lubricants”
in the Index for the proper lubricant to use.
Propeller Shaft Slip Splines
See your maintenance schedule to find out how often the. slip splines must
be lubricated. See “Recommended Fluids and Lubricants”
in the Index for
the proper lubricant to use.
Constant Velocity Joints
See your mamtenance schedule to find out how often the constant velocity
joints must be lubricated. See “Recommended Flui-ds and Lubricants”
in the
Index for the proper lubricant to use.
Body
Normal use of your vehicle will cause metal to metal wear at some points on
the cab and body if they are not lubricated.
For exposed surfaces, such as door checks, door lock bolts, lock striker
plates, dovetail bumper wedges, etc., a
thin film of engine oil should be
applied.
The seat adjusters and seat track should be lubricated
with chassis grease.
Door weather strips and rubber hood bumpers should be wiped clean with
a
rubber lubricant.
6-51
ProCarManuals.com

Service Replacement Part and Filter
Recommendations
- Gas Engines
Engine
VIN
Oil Filter
Air Cleaner Filter
PCV Valve
Spark Plugs*
Fuel Filter Radiator Cap
4.3L
z
PF52
A178CW. CV789C
.CR43TS
GF48
1
RC36
5.OL
H
PF1218T A348C
cv774c
.CR43TS GF48
1
RC36
5.7L
K
PF1218t A348C
cv774c
.CR43TS GF48 1
RC36
“four Wheel Drive Vehicle -use a PF52 oil filter
*Use AC copper-cored resister type spark plugs
Service Replacement Part and Filter
Recommendations
- Diesel Engines
Engine
VIN
Oil Filter
Air Cleaner
Fuel Filter Surge Tank Cap 6.5L
P
PF1218
A9 17C
TP 1006
RC33
6.5L
S
PF1218 A917C
TP 1006
RC33
7.4L
N
PF1218 A348C
cv774c
.CR43TS GF48
1
RC36
6.5L
F*
PF1218 A917C
TP 1006
RC33
“Heavy Duty Emission Engine
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same. If the air conditioning
system in your vehicle needs refrigerant, be sure the proper refrigerant is
used.
If you’re not sure, ask your GM dealer. For additional information, see
your “Warranty and Owner Assistance Information” booklet.
Air Conditioning Refrigerant Capacity
TYPE
Refrigerant R 134A
QTY
2.25 lbs. (1.020 kg)
6-94
ProCarManuals.com

Explanation Of Scheduled Mainienance Services
Below are explanations of the services listed in the maintenance charts.
The proper fluids and lubricants to use are listed in this section. Make sure
whoever services your vehicle uses these. All parts should be replaced and
all necessary repairs done before you or anyone else drives the vehicle.
1. ENGINE OIL AND OIL FILTER CHANGE“‘ - ALWAYS USE
SJ3 ENERGY CONSERVING I1 (GASOLINE ENGINE) OR CF-4/SH
(DIESEL ENGINE) QUALITY OILS
OF THE PROPER VISCOSITY.
To determine the preferred viscosity oil for your vehicle’s engine (e.g.
SAE 5W-30 or 10W-30), see “Engine Oil”
in the Index.
2. CHASSIS LUBRICATION - Lubricate the front suspension, king
pin bushings, steering linkage, transmission, and transfer case shift
linkage, parking brake cable guides, rear driveline center splines and
front axle propshaft splines, brake pedal springs, and clutch pedal
springs at the intervals specified.
If you have a 3500
HD, lubricate the king pins and king pin bushings,
every
1,500 miles (2500 km) for Maintenance Schedule I, or every
3,000 (5000 km) for Maintenance Schedule 11.
Ball joints and king pin bushings should not be lubricated unless their
temperature
is 10” F (-12”C), or higher. When the weather is cold, let
them warm up before lubrication or
they could be damaged.
Also, be sure
to check all the vehicle fluid levels at this time.
3.
CLUTCH FORK BALL STUD LUBRICATION (5-SPEED
MANUAL TRANSMISSION WITH DEEP LOW
) - Lubricate the
clutch fork ball stud through the fitting
on the clutch housing.
Lubricant must be added “sparingly” to
the fitting, as only .0066 lb.
(.003 kg) is required to lubricate the ball stud surface. Do not add
lubricant more often than the intervals
in the Maintenance Charts. Too
much lubricant will damage the clutch assembly.
4. COOLING SYSTEM SERVICE”’? - Drain, flush and refill system
with new coolant. See “Engine Coolant” in the Index for
the proper
coolant and mixture to use
in your vehicle.
Also inspect the hoses and replace them
if they are cracked, swollen, or
deteriorated. Tighten all hose clamps (except constant tension clamps).
Remove debris and clean the outside of the radiator and air
conditioning condenser. Wash the radiator neck.
To ensure proper
operation, pressure test.
the radiator and cap.
* An Emission Control Service
?A fluid
loss in these systems may indicate a problem. Have them
inspected and repaired at once.
7-18
ProCarManuals.com

Index
A
Aircleaner ..................................................... 6-29
Air Conditioning
............................................ 3.5. 6.S0
Aircontrols
.................................................. 3-7
Low Refrigerant Change Detection
................................ 3-8
Refrigerant Capacity
...................................... 3.97, 6.94
SystemControls
............................................... 3-6
Antenna, FixedMast
............................................. 3-18
Anti-Lock Brakes (See “Brakes”)
Appearancecare
................................................ 6-80
Materials Chart ............................................... 6-87
Arbitration Program
............................................... 8-3
Audiosystems
................................................... 3-9
AMRadio ................................................... 3-10
AM-FM Stereo Audio System with Cassette Deck ................... 3-12
AM-FM Stereo Audio System with Cassette Deck and Equalizer ........ 3-16
Cassette Deck
................................................ 3-14
Cassette Tape Player Care
....................................... 3-30
Automatic Transmission
.......................................... 2-21
Fluid
....................................................... 6-30
Axle Front
....................................................... 6-37
Front Locking Feature
.......................................... 2-36
Rear
........................................................ 6-39
RearLocking
.................................................. 6-39
Battery
........................................................ 6-52
Belts (See “Safety Belts”)
Better Business Bureau Mediation
.................................... 8-3
Blizzard ....................................................... 4-35
Brakes
Anti-Lock
.................................................... 4-6
Fluid
....................................................... 6-47
Leakcheck
.................................................. 6-47
Master Cylinder
.............................................. 6-46
Parking
..................................................... 2-28
PedalTravel ................................................. 6-48
Replacing Parts
............................................... 6-49
System Warning Light
......................................... 2-70
Trailer
...................................................... 441
In Emergencies ................................................ 4-7
Break-In, New Vehicle
........................................... 2- IO
Bulb Replacement ............................................... 6-97
Replacement Chart
............................................ 6-97
Braking
......................................................... 4-5
1 ProCarManuals.com

Driving (continued) AtNight
............................................... 4-24. 4.38
BackingUp
.................................................. 4-42
Defensive
.................................................... 4-2
Downhill
.................................................... 4-19
Freeway
...................................................... 4-29
Highway Hypnosis
............................................ 4-30
Hydroplaning
................................................ 4-27
InBlizzard
................................................... 4-35
InCity
...................................................... 4-28
InRain
...................................................... 4-26
In Sand, Mud, Ice, Or Snow
........................... 2-15,4-22, 5-40
InWater
..................................................... 4-23
Nightvision
................................................. 4-25
Off-Roading
................................................. 4-13
OnGrades
................................................... 4-43
On Hill and Mountain Roads .................................... 4-31
On Off-Road Hills
............................................ 4-16
On Snow or Ice
..................................... 2-15,433, 4-55
Skidding
.................................................... 4-12
Stuck in Deep Snow
...................................... 4-40, 5-40
Throughwater
.......................................... 2-15, 4-23
Uphill
...................................................... 4-17
Winter
...................................................... 4-33
WithaTrailer
................................................ 4-41
DrunkenDriving ................................................. 4-2
E
Electronic Heating/Air Conditioning (See “Heating”) Engine Adding Coolant
..................................... 5.14.5.17. 6-41
Coolant (Block) Heater
................................ 2.19.3-4. 6.23
Cold Weather Starting (Diesel)
................................... 2-17
Coolant
...................................... 5.13.5.20.6-92. 6.98
Coolant Temperature Gage
...................................... 2-79
Diesel
.................................................. 2.16. 6-5
Crankcase .............................................. 2.96. 6.93
Exhaust
................................................ 2.33. 6.64
FanNoise
................................................... 5-25
Identification
................................................. 6-89
Oil (See “Oil”)
RunningWhileParked
......................................... 2-33
Aircleaner
.................................................. 6-29
Noise Control System
.......................................... 6-16
Overheating
.................................................. 5-11
starting ................................................ 2.12. 2.16
Equipment. Add-on
............................................. 6-68
Exhaustsystem
............................................ 2.33. 6-64
3
ProCarManuals.com