engine HONDA ACCORD 2003 CL7 / 7.G Owners Manual

The Transmission Number is on a
label on top of the transmission.
The Engine Number is stamped into
the engine block. It is on the f ront.
Identif ication Numbers
T echnical Inf ormation
4-cylinder Models 6-cylinder Models
363
AUTOMATIC TRANSMISSION NUMBER
ENGINE NUMBER
AUTOMATIC TRANSMISSION NUMBER
MANUAL
TRANSMISSION
NUMBER
ENGINE
NUMBER
——yy
(yy

µµ µµ
ÎÎ Î Î
Î Î
Î
Î Î Î
ÎÎÎ Î
Specif ications
T echnical Inf ormation364
Dimensions Capacities
Weights
Air Conditioning
Capacities 1.35 US gal (5.1
)
1.32 US gal (5.0)
1.90 US gal (7.2
)
106.9 in (2,715 mm)
61.2 in (1,555 mm)
60.4 in (1,535 mm)
4.4 US qt (4.2
)
4.2 US qt (4.0
)
5.6 US qt (5.3
)
2.0 US qt (1.9
)
2.2 US qt (2.1)
2.6 US qt (2.5
)
Excluding the oil remaining in the engine.
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity: 0.16 US gal (0.6
)
Length
Width
Height
Wheelbase
Track
Engine
coolant
Engine oil
Manual trans-
mission oilAutomatic
transmission
fluid
Windshield
washer
reservoir1.77 US gal (6.7
)
1.88 US gal (7.1
)
2.22 US gal (8.4)
4.5 US qt (4.3
)
5.3 US qt (5.0
)
3.0 US qt (2.8
)
3.1 US qt (2.9)
6.9 US qt (6.5)
7.6 US qt (7.2)
4.8 US qt (4.5
)
189.5 in (4,813 mm)
71.7 in (1,820 mm)
57.2 in (1,453 mm)
57.3 in (1,456 mm)
Gross vehicle weight rating See the certification label attached to the driver’s doorjamb.
Refrigerant type
Charge quantity
Lubricant type HFC-134a (R-134a)
25 27 oz (700 750 g)
16 18 oz (450 500 g) ND-OIL8
Fuel tank 17.09 US gal (64.7
)
Approx.
Front Rear
1:
2 : 6-cylinder models Change
ManualAutomatic
Total ManualAutomatic
Change Including
filter
Without
filter
Total
Change Total
Change Total
U.S. Cars
Canada Cars
EX and EX-V6 models
3: 4:
3 4
1
2 2 2
222 2
——y
y
(yy

µ
µ µµ µ µµµµµµµµµµµ µ µ
ÎÎ Î
Î
Î
Î
ÎÎ
CONT INUED
Specif ications
T echnical Inf ormation365
Fuses
Battery
Lights
Alignment
Engine
3.43 x 3.9 in (87.0 x 99.0 mm)143.6 cu-in (2,354 cm
)
12 V 60 W (HB3)
12 V 51 W (HB4)
12 V 24/2.2 CP
9.7 : 1
3.39 x 3.39 in (86.0 x 86.0 mm)
182.8 cu-in (2,997 cm)
10 : 1
12 V
12 V
12 V
12 V
12 V
12 V
12 V 21 W
21/5 W
3CP
21 W
21 W
3CP8W
Interior
Under-hood 52 AH/5 HR
38 AH/5 HR
12 V
12 V
Capacity 12 V
12 V
12 V
1.1 W
2CP
5W
8W8W
12 V
12 V
Headlights
Front turn signal/
Front parking lights
Rear turn signal lights
Stop/Taillights
Taillights
High-mount brake light
Back-up lights
License plate light
Ceiling light
Spotlights
Spotlights/Front ceiling lights
Trunk light
Door courtesy light
Vanity mirror lights
Toe-in
Camber Caster
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
0.00 in (0.0 mm)
0.08 in (2.0 mm)0°1°
3°15’
See page 357 or the fuse label
attached to the inside of the fuse
box door on each side of the
dashboard.
See page 356 or the fuse box
cover. See spark plug maintenance sec-
tion pages 291 and 293 .
Water cooled 4-stroke, DOHC
i-VTEC 4-cylinder, SOHC VTEC
6-cylinder (V6), gasoline engine
FrontRear
FrontRear
Front
HighLow
4-cylinder
6-cylinder
1: LX
2: EX (Amber)
3 : 6-cylinder models33
3
12
——y

y
(yy

Î
ÎThe burning of gasoline in your car’s
engine produces several byproducts.
Some of these are carbon monoxide
(CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment.
Under certain conditions of sunlight
and climate, NOx and HC react to
f orm photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your car has a Positive Crankcase
Ventilation System. This keeps
gasses that build up in the engine’s
crankcase from going into the
atmosphere. The Positive Crankcase Ventilation valve routes them from
the crankcase back to the intake
manif old. They are then drawn into
the engine and burned.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
250
The Clean Air Act
Crankcase Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Evaporative Emissions Control
System
T echnical Inf ormation
Emissions Cont rols
371
——yy
(yy

The emissions control systems are
covered by warranties separate f rom
the rest of your car. Read your
warranty manual f or more inf orma-
tion.
The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
genuine Honda replacement parts or
their equivalent f or repairs. Using
lowerqualitypartsmayincreasethe
emissions f rom your car.
The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: Air Intake,
Engine Control, and Fuel Control.
The Engine Control Module (ECM)
or the Powertrain Control Module
(PCM) uses various sensors to
determine how much air is going
into the engine. It then controls how
much f uel to inject under all operat- ing conditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO and NOx produced.
The exhaust emissions controls
include f our systems: PGM-FI,
Ignition Timing Control, Exhaust
Gas Recirculation and Three Way
Catalytic Converter. These four
systems work together to control the
engine’s combustion and minimize
the amount of HC, CO, and NOx that
comes out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems. The Exhaust Gas Recirculation
(EGR) system takes some of the
exhaust gas and routes it back into
the intake manif old. Adding exhaust
gas to the air/f uel mixture reduces
the amount of NOx produced when
the f uel is burned.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), dinitrogen
(N ), and water vapor.
2
2
Replacement Parts
Exhaust Emissions Controls
Emissions Cont rols
T echnical Inf ormation
PGM-FI Syst em Ignit ion T iming Cont rol Syst em
Exhaust Gas Recirculat ion (EGR)Syst em
Three Way Catalytic Converter
372
——yy
(yy

Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective.
The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Honda part
or its equivalent.
The three way catalytic converter
must operate at a high temperature
for the chemical reactions to take
place. It can set on f ire any com-
bustible materials that come near it.
Park your car away f rom high grass,
dry leaves, or other f lammables.
A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your car’s three way catalytic
converter. Keep the engine tuned-up.
Have your car diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
Three Way Catalytic Converter
T echnical Inf ormation373
4-cylinder models
6-cylinder models
THREE WAY CATALYTIC CONVERTER
THREE WAY CATALYTIC CONVERTERS
——yy
(yy

Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the ambient
temperature is between 20° and
95°F.Without touching the accelerator
pedal, start the engine and let it
idle f or 20 seconds.
If you take your car for a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
Make sure the car has been
parked with the engine of f f or 8
hours or more.Keep the car in Park (automatic
transmission) or Neutral (manual
transmission). Increase the engine
speed to 2,000 rpm and hold it
there until the temperature gauge
rises to at least 1/4 of the scale
(approximately 3 minutes).
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the car re-tested within the next
two or three days, you can condition
the car for re-testing by doing the
f ollowing.
St at e Emissions T est ing
T echnical Inf ormation
T esting of Readiness Codes
374
——yy
(yy

µµ
µ
( % ) $
%."#)
This manual describes the procedures involved in the
replacement of damaged body parts.
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the Journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your car.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
382 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.
——y
y
(yy

CONT INUED
Battery......
Charging System Light . 58, 348
............................
Jump Starting . 342
..............................
Maintenance . 294
............................
Specif ications . 365
..............................
Bef ore Driving . 203
..........................................
Belts, Seat . 8
.........................
Beverage Holders . 104
...................................
Body Repair . 332
Brakes
...........
Anti-lock System (ABS) . 230
.............
Break-in, New Linings . 204
....................
Bulb Replacement . 317
...........................................
Fluid . 284
.......................................
Parking . 102 .........................
System Indicator . 58
........................
Wear Indicators . 229
.............................
Braking System . 229
........................
Break-in, New Car . 204
..
Brightness Control, Instruments . 69
........................
Brights, Headlights . 68
Bulb Replacement
..........................
Back-up Lights . 318
..............................
Brake Lights . 317
..............................
Ceiling Light . 320
................
Door Courtesy Light . 321
................
Front Parking Lights . 315
.................................
Headlights . 312
.........
High-mount Brake Light . 319
...................
License Plate Light . 319
............................
Specif ications . 365
...................................
Spotlights . 321
...............................
Trunk Light . 322
....................
Turn Signal Lights . 315
................
Vanity Mirror Lights . 321
..............................
Bulbs, Halogen . 312
...
Accessories and Modif ications . 212
................................
Accessories . 212
.
Additional Safety Precautions . 213
............................
Modif ications . 213
ACCESSORY (Ignition Key .......................................
Position) . 78
.............
Accessory Power Socket . 107
....................
Additives, Engine Oil . 270
.....................................
Airbag (SRS) . 9
.....................
Air Cleaner Element . 286
............................
Air Conditioning . 112
..............................
Maintenance . 299
.........................................
Usage . 112
.......................
Air Pressure, Tires . 304
.......................
Alcohol in Gasoline . 369
......................................
Antif reeze . 273
Anti-lock Brakes (ABS)
................................
Description . 230
...............................
Indicator . 57, 231
...................................
Operation . 230
.
Anti-thef t Steering Column Lock . 77
..........................
Appearance Care . 325
..........................................
Armrest . 103
................
Audio System . 134, 150, 169 .............
Automatic Speed Control . 195
..............
Automatic Transmission . 222
..........................
Capacity, Fluid . 364
.......
Checking Fluid Level . 280, 281
.......................................
Shif ting . 223
.
Shif t Lever Position Indicator . 223
................
Shif t Lever Positions . 223
....................
Shif t Lock Release . 226
Index
A
B
I
——yy
(yy

Î
............................
Capacities Chart . 364
.............
Carbon Monoxide Hazard . 52
.............................
Carrying Cargo . 214
..............
CAUTION, Explanation of . ii
..................
CD Changer . 142, 157, 177
.......................................
CD Player . 140
........................
CD Pocket, Center . 105
........................
Certif ication Label . 362
............................................
Chains . 308
....................
Changing a Flat Tire . 335
............
Changing Engine Coolant . 275
Changing Oil
........................................
How to . 270
......................................
When to . 250
...
Charging System Indicator . 58, 348
............
Checklist, Bef ore Driving . 218
..................
Childproof Door Locks . 84
.......................................
Child Seats . 26
..........
Tether Anchorage Points . 39
...................................
Cleaner, Air . 286
Cleaning
....................
Aluminum Wheels . 327
...................................
Carpeting . 328
......................................
Exterior . 326 .........................................
Fabric . 329
.......................................
Interior . 328
.......................................
Leather . 329
...................................
Seat Belts . 329
...........................................
Vinyl . 329
......................................
Window . 330
...............
Climate Control System . 119
.........
Clock, Setting the . 139, 156, 174
...................................
Clutch Fluid . 285
........................
CO in the Exhaust . 372
...................................
Coin Pocket . 105
............
Cold Weather, Starting in . 220
..............................
Compact Spare . 334
.................
Console Compartment . 103
...............
Consumer Inf ormation . 378
.............
Controls, Instruments and . 55
Coolant
........................................
Adding . 272
....................................
Checking . 210
.........................
Proper Solution . 267
...................
Temperature Gauge . 64
....................
Corrosion Protection . 331
Crankcase Emissions Control
........................................
System . 371
............
Cruise Control Operation . 195
..........
Customer Relations Of f ice . 378 ................
DANGER, Explanation of . ii
.......................................
Dashboard . 56
................
Daytime Running Lights . 69
............
Def ects, Reporting Saf ety . 380
................
Def ogger, Rear Window . 72
....................................
Dimensions . 364
...............
Dimming the Headlights . 68
Dipstick
.
Automatic Transmission . 280, 281
..................................
Engine Oil . 208
..........................
Directional Signals . 70
........
Disc Brake Wear Indicators . 229
.....................
Disposal of Used Oil . 272
Doors
..............
Locking and Unlocking . 78
..........
DOT Tire Quality Grading . 367
Downshif ting, 5-speed Manual
.............................
Transmission . 221
.....................................
Drive Belts . 302
...........
Driver and Passenger Safety . 5
...........................................
Driving . 217
....................................
Economy . 211
.........................
In Bad Weather . 235
................
In Foreign Countries . 370
Index
C D
II
——y
y
(yy