maintenance HONDA ACCORD 2004 CL7 / 7.G Owner's Guide

µµ
Always use Honda Power Steering
Fluid. You may use another power
steering f luid as an emergency
replacement, but have the power
steering system f lushed and ref illed
with Honda PSF as soon as possible.
A low power steering f luid level can
indicate a leak in the system. Check
the f luid level f requently, and have
the system inspected as soon as
possible.
The timing belt should be replaced
at the intervals shown in the
maintenance schedule.
Replace these belts at 60,000 miles
(U.S.) or 100,000 km (Canada) if you
regularly drive your vehicle in one or
more of these conditions:
In very high temperatures
(over 110°F, 43°C).
In very low temperatures
(under 20°F, 29°C). Clean the hood latch assembly with a mild cleaner, then lubricate it with a
multipurpose grease. Lubricate all
the moving parts (as shown),
including the pivot. Follow the time
and distance recommendations in
the Maintenance Schedule. If you
are not sure how to clean and grease
the latch, contact your Honda dealer.
6-cylinder models only
Power Steering Fluid, Timing Belt
Maint enance
T iming Belt Hood L atch
227
LATCH ASSEMBLYPIVOTS
T urning the steering wheel to f ull lef t
or right lock and holding it there can
damage the power steering pump.
 — — y
 y
(
 y  y

Keeping the tires properly inf lated
provides the best combination of
handling, tread lif e, and riding
comf ort.Underinf lated tires wear unevenly,
adversely affect handling and fuel
economy, and are more likely to
fail from being overheated.
Overinf lated tires can make your
vehicleridemoreharshly,are
more prone to damage f rom road
hazards, and wear unevenly.
We recommend that you visually
check your tires every day. If you
think a tire might be low, check it
immediately with a tire gauge.
To saf ely operate your vehicle, your
tires must be the proper type and
size, in good condition with adequate
tread, and correctly inf lated.
The f ollowing pages give more
detailed inf ormation on how to take
care of your tires and what to do
when they need to be replaced.
For convenience, the recommended
tire sizes and cold air pressures are
on a label on the driver’s doorjamb.
For additional technical information,
see page .
Use a gauge to measure the air
pressure at least once a month. Even
tires that are in good condition may
lose one to two psi (10 to 20 kPa, 0.1
to 0.2 kgf /cm ) per month.
Remember to check the spare tire at
thesametime.276
Tires
Maint enance
Inf lation
238
Using tires that are excessively
worn or improperly inflated can
cause a crash in which you can
be seriously hurt or killed.
Follow all instructions in this
owner’s manual regarding tire
inflation and maintenance.
 — — y
  y
(
 y 
y

Every time you check inf lation, you
should also examine the tires f or
damage, f oreign objects, and wear.
Youshouldlookfor:Your vehicle’s tires have wear
indicators molded into the tread.
When the tread wears down to that
point, you will see a 1/2 inch (12.7
mm) wide band running across the
tread. This shows there is less than
1/16 inch (1.6 mm) of tread lef t on
the tire. A tire that is this worn gives
very little traction on wet roads. You
should replace the tire if you can see
the tread wear indicator in three or
more places around the tire.
Have your dealer check the tires if
you f eel a consistent vibration while
driving. A tire should always be
rebalanced if it is removed f rom the
wheel. When you have new tires
installed, make sure they are
balanced. This increases riding
comf ort and tire lif e. For best results,
have the installer perform a dynamic
balance.
In addition to proper inf lation,
correct wheel alignment helps to
decrease tire wear. If you f ind a tire
is worn unevenly, have your dealer
check the wheel alignment.
Excessive tread wear.
Cuts, splits, or cracks in the side
of the tire. Replace the tire if you
can see f abric or cord.
Bumps or bulges in the tread or
side of the tire. Replace the tire if
youfindeitherortheseconditions.
U.S. LX, EX and EX-V6 models
Tires
Maint enance
Tire Inspection
Tire Maintenance
240
NOTICE:
INDICATOR LOCATION MARKS
TREAD WEAR INDICATORS
Improper wheel weights can
damage your vehicle’s aluminum
wheels. Use only genuine Honda
wheels weights f or balancing.
 — — y
y
(
 y y

µ
Check the condition of the battery
monthlybylookingatthetest
indicator window. The label on the
battery explains the test indicator’s
colors. Check the terminals f or corrosion (a
white or yellowish powder). To
remove it, cover the terminals with a
solution of baking soda and water. It
will bubble up and turn brown. When
this stops, wash it of f with plain
water. Dry off the battery with a
cloth or paper towel. Coat the
terminals with grease to help prevent
f uture corrosion.If additional battery maintenance is
needed, see your Honda dealer or a
qualif ied technician.
Battery posts,
terminals, and related accessories
contain lead and lead compounds.
If you need to connect the battery to
a charger, disconnect both cables to
prevent damaging your vehicle’s
electrical system. Always disconnect
the negative ( ) cable first, and
reconnect it last.
Checking the Battery
Maint enance
WARNING:
Wash your hands af ter handling.
244
TEST INDICATOR WINDOW
4-cylinder models TEST INDICATOR WINDOW
6-cylinder models
 — — y
 y
(
 y y

Checking the Battery
Maint enance245
The battery gives off explosive
hydrogen gas during normaloperation.
A spark or flame can cause the
battery to explode with enough
force to kill or seriously hurt you.
Wear protective clothing and a
face shield, or have a skilled
mechanic do the batterymaintenance.
 — — y
 y
(
 y y

Fill the f uel tank.
Change the engine oil and f ilter.
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc., are
completely dry.
Leave the parking brake off. Put
the transmission in Reverse
(5-speed manual) or Park
(automatic).
If you need to park your vehicle f or
an extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your vehicle back on the road. If
possible, store your vehicle indoors.
Block the rear wheels. If the vehicle is to be stored f or a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the vehicle is being stored
indoors).
Disconnect the battery.
Support the f ront wiper blade
arms with a f olded towel or rag so
they do not touch the windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and trunk seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and trunk seals.
Cover the vehicle with a
‘‘breathable’’ cover, one made
f rom a porous material such as
cotton. Non-porous materials, suchas plastic sheeting, trap moisture,
which can damage the paint.
If possible, periodically run the
engine until it reaches f ull
operating temperature (the
cooling f ans cycle on and of f
twice). Pref erably, do this once a
month.
If you store your vehicle f or 1 year or
longer, have your Honda dealer
perf orm the inspections as soon as
youtakeitoutof storage(seepages and ). The 6-cylinder model
needs the inspections called f or in
the 2 years/30,000 miles (48,000 km)
maintenance schedule (Normal
Conditions) and the 4-cylinder model
needs the inspections called f or in
the 2 years/40,000 miles (64,000 km)
maintenance schedule (Normal
Conditions). The replacements
called f or in the maintenance
schedule are not needed unless the
vehicle has actually reached that
time or mileage. 200 202
Vehicle Storage
Maint enance246
 — — y
  y
(
 y y

ÎÎIn Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured. As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx) and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas.
Your vehicle has a Positive
Crankcase Ventilation System. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The Positive Crank-case Ventilation valve routes them
from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on pages
and .
204 206
Emissions Cont rols
T echnical Inf ormation
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
282
 — — y

y
(
 y y

µµ
µ
( % ) $
%."#)
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual describes the procedures involved in the
replacement of damaged body parts.
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
292 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.
 — — y

 y
(
 y y

CONT INUED
....................................
Accessories . 171
ACCESSORY (Ignition Key
.......................................
Position) . 82
.............
Accessory Power Socket . 107
....................
Additives, Engine Oil . 215
.....................................
Airbag (SRS) . 9
..........
Airbag System Components . 22
............................
Air Conditioning . 110
.........................................
Usage . 115
.......................
Air Pressure, Tires . 239
.......................
Alcohol in Gasoline . 280
Anti-lock Brakes (ABS)
................................
Description . 189
...............................
Indicator . 63, 190
...................................
Operation . 188
.
Anti-thef t Steering Column Lock . 82
........
Audio System . 122, 130, 132, 140
.............
Automatic Speed Control . 155
..............
Automatic Transmission . 182
..........................
Capacity, Fluid . 274
.......................................
Shif ting . 182
.
Shif t Lever Position Indicator . 182
................
Shif t Lever Positions . 182
....................
Shif t Lock Release . 185 Battery
Charging System ...........................
Indicator . 62, 260
............................
Jump Starting . 255
..............................
Maintenance . 244
............................
Specif ications . 275
..............................
Bef ore Driving . 163
..........................................
Belts, Seat . 8
.........................
Beverage Holders . 107
Brakes
...........
Anti-lock System (ABS) . 189
.............
Break-in, New Linings . 164
....................
Bulb Replacement . 233
...........................................
Fluid . 225
.......................................
Parking . 104
.........................
System Indicator . 62
........................
Wear Indicators . 188
.............................
Braking System . 188
........................
Break-in, New Car . 164
..
Brightness Control, Instruments . 76
........................
Brights, Headlights . 74
Bulb Replacement
..............................
Brake Lights . 233
................
Front Parking Lights . 231 .................................
Headlights . 228
.........
High-mount Brake Light . 234
............................
Specif ications . 275
...............................
Trunk Light . 233
....................
Turn Signal Lights . 231
..............................
Bulbs, Halogen . 228
............................
Capacities Chart . 274
.............
Carbon Monoxide Hazard . 56
.............................
Carrying Cargo . 173
..............
CAUTION, Explanation of . ii
...................................
CD Changer . 132
..............................
CD Player . 130, 131
........................
CD Pocket, Center . 106
........................
Certif ication Label . 272
............................................
Chains . 243
....................
Changing a Flat Tire . 249
Changing Oil
........................................
How to . 216
.............................
When to . 204, 206
...
Charging System Indicator . 62, 260
............
Checklist, Bef ore Driving . 178
Index
AB
C
I
 — — y

 y
(
 y y

HomeLink Universal................................
Transceiver . 158
.......................
Hood, Opening the . 166
...........................
Hydraulic Clutch . 226
...
Identif ication Number, Vehicle . 272
Ignition
..............................................
Keys . 79
...........................................
Switch . 82
............
Timing Control System . 283
........................
Immobilizer System . 81
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 61
...............................
Inf ant Restraint . 40
......................................
Inf ant Seats . 40
..........
Tether Anchorage Points . 50
...................
Inf lation, Proper Tire . 238
...................................
Inside Mirror . 98
.............................
Inspection, Tire . 240
....................
Installing a Child Seat . 45
..........
Tether Anchorage Points . 47
.............................
Using LATCH . 46
............................
Instrument Panel . 61
........
Instrument Panel Brightness . 76 ........................................
Introduction . i
.................
Jacking up the Vehicle . 250
.......................................
Jack, Tire . 250
................................
Jump Starting . 255
..................................................
Keys . 79
.......................
Label, Certif ication . 272
.................
Lane Change, Signaling . 74
..................
Lap/Shoulder Belts . 15, 19
Lights
....................
Bulb Replacement . 228
.......................................
Indicator . 61
.........................................
Parking . 74
..................................
Turn Signal . 65
......
LOCK (Ignition Key Position) . 82
Locks
.......
Anti-thef t Steering Column . 82
............................
Fuel Fill Door . 165 ..................................
Glove Box . 108
....................
Lockout Prevention . 84
.................................
Power Door . 83
...........................................
Trunk . 89
........................
Low Coolant Level . 169
...
Lower Gear, Downshif ting to a . 180
...
Low Oil Pressure Indicator . 62, 259
...
Lubricant Specif ications Chart . 274
.........................................
Luggage . 173
..................................
Maintenance . 199
...
Owner Maintenance Checks . 203
........................................
Record . 208
......................
Required Indicator . 70
..........................................
Saf ety . 200
.............................
Schedule . 204-207
.
Malf unction Indicator Lamp . 62, 260
...................
Manual Transmission . 180
........
Manual Transmission Fluid . 224
...............................
Meters, Gauges . 68
...................
Methanol in Gasoline . 280
..........................
Mirrors, Adjusting . 98
.................................
Modif ications . 172
Index
I J K L
M
IV
 — — y

 y
(
 y y