automatic transmission HONDA CIVIC 1991 User Guide

RESERVE TANKIf the level is below the MAX
mark, but still visible, add a 50/50
solution of antifreeze and water
to bring it up to MAX. If there is no coolant in the re-
serve tank, the cooling system should be checked for leaks and
repaired if necessary. Coolant

must then be added to the radi-

ator.

CAUTION:

Radiator coolant will damage paint. Quickly rinse any spilled
coolant from painted surfaces.
Wait until the engine is cool, then turn the radiator cap counterclock- wise until it stops. DO NOT PRESS DOWN WHILE TURNING THECAP. After any remaining pressure has been relieved, remove the
cap by pressing down and again turning it counterclockwise. Add
enough coolant to fill the radiator, and reinstall the cap. Be sure to
tighten it securely. Fill the reserve tank up to the MAX mark with
the engine cold.

Maintenance
1. Check the freeze protection level of the coolant with a hydrome- ter.
2. Keep the front of the radiator free of dirt and debris.
3. Check hoses and hose clamps regularly.
Replacing Coolant Replace coolant at 36 months or 45,000 miles (72,000 km), which-
ever comes first. Thereafter, replace every 2 years or 30,000 miles (48,000 km), whichever comes first.

(cont'd)

MAX
MIN

RADIATOR COOLANT

REFILL CAPACITY:
(excluding reserve tank) 0.4 (0.11 US gal, 0.09 Imp gal)
Manual transmission 4.0 (1.06 US gal ,0.88 Imp gal)

4.1 (1.08 US gal,0.90 Imp gal)*

Automatic transmission 4.0 (1.06 US gal,0.88 Imp gal)*
4.5 (1.19 US gal,0.99 Imp gal)

* : DX Hatchback and DX/LX Sedan
ProCarManuals.comMain Menu s t

Power Steering
The Sedan (except DX with manual transmission) and DX Hatch- back with automatic transmission are equipped with power steering.
The power steering on your car provides easy handling while parking and maneuvering in traffic, without loss of road "feel" at
highway speeds. An engine-driven hydraulic pump provides full
power assist at low speeds and decreasing assist as the car goes

faster.

CAUTION:

If the power steering system should fail, or if the engine should
stall, the car can still be steered. However, much greater effort
will be required, particularly in sharp turns at low speed.

NOTE:

You may feel a slight clunk or knock when turning the wheel with
the engine off. This is a normal condition due to the design of the

system.

RESERVOIR CAP

UPPER
LOWER

Power Steering Fluid
Check the power steering fluid level
with the engine cold and the car
parked on level ground. Make sure
the fluid level is between the upper and lower marks on the reservoir. If
the level has dropped close to or below the lower mark, check for
leaks before adding fluid to theupper mark. Do not overfill.

CAUTION:

Use only genuine Honda power steering fluid. The use of other
fluids such as A.T.F. or other manufacturer's power steering fluid will damage the system.ProCarManuals.comMain Menu s t

Changing a Flat Tire
Do not attempt to change a tire unless the car is on firm, level
ground and well out of the flow of traffic.
Park the car on a firm, level surface, apply the parking brake, turn
on the hazard warning switch and put the transmission in gear (Park

for automatic).

1. Remove the jack, lug wrench/jack handle and jack handle extension (in the tool bag) from the location shown.

NOTE:

To remove the jack, release its tension against the mount by turning

the screw counterclockwise.

JACK TOOL BAG
Follow tire changing preparations and procedures carefully to reduce the possibility of injury. The jack is designed for changing
tires only. STAND CLEAR, DO NOT get under the car and DO NOT run the engine when the car is supported only by the jack.
5. Place the jack under the jack point nearest the wheel you are removing; align the jack head so the car frame will fit in the recess
as you raise the jack.

Hatchback

SPARE TIRE COVER
Sedan

TOOL BAG SPARE TIRE COVER
JACK
COMPACT SPARE COMPACT SPARE
2. Remove the spare tire.
3. Place blocks in front and back of the wheel diagonally opposite the tire you are changing.
4. Use the lug wrench/jack handle to loosen the wheel lug nuts counterclockwise one-half turn.ProCarManuals.comMain Menu s t

If towing is necessary, contact a professional towing service. Your
authorized Honda dealer can assist you with detailed towing

instructions.

Never use tow chains or rope to tow a car; your ability to safely
control the car may be adversely affected.
We recommend the following: Flat Bed Equipment —Entire car is winched on a flat bed vehicle.
This is the best way of transporting your Honda.
Wheel Lift Type—Tow with the front wheels off the ground.

If the car can only be towed with the front wheels on the ground:

make sure the transmission is full of fluid (see pages 78 — 79) and
tow with the transmission in neutral (N) and the ignition key in the 1
position.

CAUTION:

To avoid serious damage on automatic transmission cars, first
start the engine and shift to D4, then to N and shut the engine off. If the engine does not run or the transmission cannot be shifted
while the engine is running, the car must be transported on flat
bed equipment.
Check local regulations for towing.

CAUTION:
Do not exceed 35 mph (55 km/h) or tow for distances of more
than 50 miles (80 km).
If a sling type tow is used, the tow truck driver should position
wood spacer blocks between your car's frame and the chains
and lift straps to avoid damaging the bumper and the body. Do not use the bumpers to lift the car or to support the car's
weight while towing. TowingProCarManuals.comMain Menu s t

If Your Car Gets Stuck
If your car gets stuck in sand, mud, or snow, call a professional
towing service for assistance in getting your car out.
CAUTION: Do not rev up the engine and allow the wheels to spin freely at
high speed. Severe transmission damage may result if the wheels are allowed to spin for more than a few seconds.DO NOT try to free a car with automatic transmission from
snow, etc. by rocking the car alternately between forward and
reverse gears. Severe transmission damage may result from
shifting into gear with the wheels moving.ProCarManuals.comMain Menu s t

Identification Numbers

The Vehicle Identification Number(V.I.N.) is stamped on a plate at-
tached to
the top left side of the
dashboard.
It also appears on the Certification
label attached to the door jamb, as
well as under the hood on the body,
directly behind the engine.

NOTE:

The V.I.N. is also provided in bar code on the Certification label.

Hatchback Sedan
CERTIFICATION LABEL

AUTOMATIC
TRANSMISSION
NUMBER
CERTIFICATION
LABEL

MANUAL
TRANSMISSION NUMBER
ENGINE NUMBER

The Engine Number is stamped on the right front side of the engine
block.

The Transmission Number appears on a label on the top edge of the
transmission where it attaches to the engine.

NOTE:

Do not mistake the transmission number for the engine number.
VEHICLE

IDENTIFICATION

NUMBER
VEHICLE IDENTIFICATION
NUMBERProCarManuals.comMain Menu s t

Index

Battery
Charging System Warning Light.............................................. 30
Jump Starting ........................ 110
Maintenance............................. 89
Specification (Hatchback).... 116
Specification (Sedan)............ 119
Beeper System Fasten Seat Belt Beeper(Sedan).................................. 11

(Hatcback)............................ 15

Belts, Seat............. See "Seat Belts"
Body Repair.................................. 102
Brake Warning Light...................... 31 Brakes
Brake Failure Warning Light.... 31

Brake Fluid................................ 84

Brake System Design.............. 83
Brake Wear Indicators............. 84
Parking Brake........................... 42
Parking Brake Warning Light.. 31
Break-in Period................................. 2

Bulb
Replacement............................
92

Specification (Hatchback)....
117
Specification (Sedan)............

120
Buzzer........... See
"Beeper System"
Capacities (Hatchback)............... 115 Capacities (Sedan)....................... 118
Care and Cleaning.......................... 99
Catalytic Converter..................... 126 Certification Label....................... 121
Chains, Tires...................................

95
Check Engine
Warning Light......... 31
Child Proof Door Locks...................

5

Child Restraint
System................. 21
Cigarette Lighter............................ 44

Clock............................................... 42
Clutch Pedal Adjustment.............. 61
Compact Spare Tire.................... 104
Coolant Temperature Gauge ........

28
Cooling (with
A/C).........................

49

Cooling System..............................

80

Crankcase Emission Control
System................................... 124
Cruise Control Operation.................................. 39
Indicator.................................... 31

Defogger........................................ 34
Defroster........................................ 51

Doors
Child Proof Door Locks............. 5

Locks........................................... 3

Power Locks.............................. 4

Emergency
Changing a Flat Tire............... 105
Hazard Warning System ......... 37If Your Car Gets Stuck.......... 112
Jump Starting........................ 110

Shoulder Belt Buckle............. 113

Towing.................................... 111
Warning and Indicator Lights.. 29
Emission Controls........................ 124

Engine
Coolant...................................... 80

Coolant Temperature Gauge... 28
Exhaust Controls................... 125Identification Number............ 12

1
Oil and
Filter.............................. 76
OH Pressure Warning Light..... 30
Specification (Hatchback).... 116
Air Conditioner
Operation.................................. 47

Service...................................... 98

Air Filter.......................................... 86

Air Pressure, Tires......................... 94
Antifreeze.. See "Radiator Coolant" Anti-theft Steering Column Lock System ..................................... 57
Appearance Care........................ 100

Ashtrays......................................... 44

Automatic Seat Belt...................... 10

Automatic Transmission
Driving Technique.................... 66

Fluid........................................... 79

Operation.................................. 64

(cont'd)ProCarManuals.comMain Menu s t

Maintenance
Non-Scheduled MaintenanceRecord................................... 72
Scheduled Maintenance Record................................... 71

Schedule................................... 68

Severe Driving Conditions...... 72
Manual Transmission Clutch Pedal Adjustment........ 61
Maximum Allowable Speeds.. 63
Oil...............................................
78

Recommended Shift
Speeds.. 62

Shifting......................................

61

Meters, Gauges..........
See "Gauges"
Mirrors Power Mirrors.......................... 35

Rearview Mirrors..................... 35

Octane Rating, Gasoline. See "Fuel"
Odometer........................................ 28
Oil
Engine Oil.................................. 75

Fluid Locations......................... 74
Oil Pressure Warning Light..... 30
Power Steering Fluid................ 85
Transmission Oil/Fluid.............. 78
Operation In Foreign Countries..... 55
Panel Brightness Control............... 37
Parking Brake................................. 42
Passive Belt.................................... 10
PGM-FI
System.................................... 125
Power Door Locks................................. 4
Mirrors...................................... 35
Steering..................................... 85

Windows.................................. 43

Pregnant Women........................... 25
Pressures, Tire Inflation................ 94
Preventive Service...................... 102 Radiator Coolant............................ 80

Rear Seat.......................................... 8

Rearview Mirrors........................... 35
Rear Window Defogger................ 34Rear Window Wiper...................... 34Reminder Lights .................. See "Warning Lights"
Replacement
Air Filter.................................... 86

Bulb............................................ 92
Engine Oil.................................. 76

Fuel Filter.................................. 86

Fuse...........................................90
Oil Filter..................................... 76
Radiator Coolant...................... 82
Spark Plugs............................... 87

Tire............................................ 94
Wiper Blades............................. 88
Rust Prevention........................... 101
Safety Defects, Reporting.......... 128

Safety Items................................... 59

Seats
Adjustment................................. 6
Head Restraints.......................... 7
Seat Belt Reminder Light
and Beeper (Sedan).................. 14

Seat Belt Reminder Light and Beeper (Hatchback).......... 17
Seat Belts Anchor Points (Hatchback)..... 22
Anchor Points (Sedan)............ 24

Automatic Belt......................... 10

Buckling the Front Seat Belts (Sedan)............... 11
Buckling the Front Seat Belts (Hatchback)....... 15
Buckling the Rear Seat Belts .. 19
Child Restraint.......................... 21
Cleaning..................................... 25

Fasten Seat Belt Reminder Light and Beeper (Sedan).............. 14
Fasten Seat Belt Reminder Light and Beeper (Hatchback)...... 17

(cont'd)

Numbers, Identification............... 121ProCarManuals.comMain Menu s t

Index (cont'd)

Inspection................................. 25

Passive Belt.............................. 10
Pregnant Women..................... 25
Rear Center Seat Belt.............. 20
Replacement............................. 25 Shoulder Belt Buckle............. 113

Seats
Front Seat................................... 6
Head Restraints.......................... 7

Rear Seat.................................... 8

Shifting
Automatic................................ 64

Manual....................................... 61

Spare Tire Changing a Flat Tire............... 106
COMPACT Spara Tire........... 104
Spark Plugs Replacement............................. 87
Specifications (Hatchback) ..116Specifications (Sedan).......... 119
Speedometer.................................. 28
Starting the Engine......................... 58
Steering Anti-theft Column Lock .......... 57Power Steering......................... 85

Tilt Steering.............................. 32

Stuck Car..................................... 112

Sunroof........................................... 52
If the Sunroof Won't Close..... 53
Maintenance............................. 53
Operation.................................. 52

Sunshade.................................. 52

Tachometer.................................... 28
Temperature Gauge, Coolant....... 28 Tilt Steering.................................... 32
Tire Air Pressure............................. 94
Balancing................................... 97

Chains....................................... 95

Changing a Flat Tire............... 106COMPACT Spare.................. 104
DOT Tire Quality Grades....... 122
Inflation Pressures................... 94 Requirement............................. 96
Rotation.................................... 97
Snow Tire................................. 95
Spare Tire............................... 104
Specification (Hatchback).... 116 Specification (Sedan)............ 119
Tools............................................. 105
Towing.......................................... 111

Transmission
Capacity.................................... 79
Identification Number............ 121

Oil/Fluid..................................... 78

Shifting the Automatic............ 64

Shifting the Manual.................. 61
Transmission............................ 78
Treadwear.................................... 122

Trip Meter....................................... 28
Trunk Access From Rear Seat....... 8

Trunk Lid........................................... 5

Turn Signals.................................... 36
Warning Lights............................... 29
Warranty Service........................ 127Washer Rear Window Washer............. 34Reservoir Capacity.................. 33
Windshield Washer.................. 33
Washing........................................ 100

Waxing......................................... 101

Windows
Appearance Care................... 100
Power Windows...................... 43

Windshield Defogger..................... 51 Windshield Washer....................... 33
Windshield Wipers........................ 33
Wiper Blades ..................................
88
Wipers Rear Windo
w Wiper................ 34
Windshield Wipers................... 33
Vehicle Identification Number.... 121
Ventilation...................................... 45ProCarManuals.comMain Menu s t

AMERICAN HONDA MOTOR CO., INC.
1919 Torrance Blvd., Torrance California 90501 1991 Honda Motor Co., Ltd. - All Rights Reserved

31SH3630 CRES 10009805

00X31-SH3-6302 PRINTED IN U.S.A.
Gas Station Information

Gasoline: UNLEADED only
Pump octane of 86 or higher.
Gas Tank-Capacity: 45 l (11.9 US gal, 9.9 Imp gal)
Tire Pressure (measured cold) front/rear STD Hatchback: 240 kPa (35 psi) /220 kPa (32 psi)DX Hatchback: 220 kPa (32 psi) / 220 kPa (32 psi)
Si Hatchback: 195 kPa (28 psi) /195 kPa (28 psi)DX Sedan: 220 kPa (32 psi) / 220 kPa (32 psi)
LX Sedan: 180 kPa (26 psi) /180 kPa (26 psi)
EX Sedan: 180 kPa (26 psi) /180 kPa (26 psi)
Compact Spare: 415 kPa (60 psi)
Other Tire Information See "Tires" pages 94-97.
Hood Release Pull handle under left side of dash.
Engine Oil: Use "Energy Conserving II" SG grade oil. 5W -30 preferred (see page 75 for complete viscosityrecommendations).
Capacity (including filter):
3.5 l (3.7 US qt, 3.1 Imp qt)
Manual Transmission Oil: Use SF or SG grade oil.
10W-30 or 10W-40 preferred (see page 78 for complete
viscosity recommendations). Capacity (including differential): 1.8 l (1.9 US qt, 1.6 Imp qt)
(Oil should be up to filler bolt hole in housing beside
right axle)
Automatic Transmission Fluid:
Us
e
DEXRON® II type Automatic Transmission Fluid

(ATF). Remove
dipstick from right end of transmission,
wipe off, reinsert, remove and read fluid level - do not
force the rubber plug in when reading fluid level or replacing dipstick.
Capacity (including differential):
2.4 l (2.5 US qt, 2.1 Imp qt)
Power Steering Fluid Use only Honda power steering fluid: do not use ATF or
any other brand of power steering fluid because it will
damage the system.ProCarManuals.comMain Menu s t