fuel HONDA CIVIC 1991 User Guide

Engine Oil and Filter (cont'd)
Fuel Efficient Oil For the best fuel economy from your car, it is recommended that
you use a fuel efficient SG grade oil. This oil is usually identified by
the words such as: "Energy Conserving II," "Gas Saving," and "Fuel Saving," etc.
Changing Oil and Filter
Engine oil and filter should be changed together every 6 months or
7,500 miles (12,000 km), whichever comes first. The filter is located
on the engine block, below the intake manifold. A special "cap
type" oil filter wrench is required (available from your Honda dealer). Use only a genuine Honda filter or its equivalent.

CAUTION:

The oil filter cannot easily be removed from above the engine. For
this reason it is recommended that the oil filter change be done by a skilled mechanic.
1. Start the car to warm up the engine, then shut it off.
2. Remove the engine oil filler cap and drain bolt, and drain the oil.
A warmed-up engine and the oil in
it are hot; be careful not to burn yourself.
3. Remove the oil filter and let the remaining oil drain out.
4. Install a new filter according to
the instructions on or with the

filter.

5. Reinstall the drain bolt with a new washer and tighten it securely.Refill the engine with the recom-
mended oil, to the upper mark on

the dipstick.

ENGINE OIL CAPACITY (including filter):
3.5
(3.7 US qt, 3.1 Imp qt)

OIL FILTER

ENGINE OIL
DRAIN BOLTProCarManuals.comMain Menu s t

Air and Fuel Filters
Air Filter Replace the air filter every 24 months or 30,000 miles (48,000 km),
whichever comes first (more often in extremely dusty conditions).

Replacement
Remove the four screws holding the air filter cover halves together.
Remove the top half of the air fitter cover. Replace the filter. Reinstall the cover and screws securely.
SCREWS
FILTER

Fuel Filters

The fuel filter is located in the engine compartment, on the right center of the lower dashboard. It should be replaced at 60,000 miles (96,000 km) or 48 months whichever comes first, or any time you
suspect contaminated gas may have clogged it.

CAUTION:

Because the fuel system is under pressure, the filter should be

replaced only by a qualified Honda technician.ProCarManuals.comMain Menu s t

Emission Controls

Sources of Emissions
The combustion process produces carbon monoxide, oxides of nitrogen and hydrocarbons. The evaporation of fuel in the fuel tank
also produces hydrocarbons. Control of oxides of nitrogen andhydrocarbons is very important since, under certain conditions,
when subjected to sunlight, they react to form photochemical smog. Carbon monoxide does not react to form smog, but it is toxic.Honda Motor Co., Ltd. has developed a number of systems which
are highly effective in reducing carbon monoxide, oxides of nitrogen
and hydrocarbons.
The Clean Air Act The Clean Air Act requires all vehicle manufacturers to explain in
writing, the operation and maintenance of their emission control

systems.

Maintenance instructions are included on pages 68 — 73 ; the
operation of each system is explained on the following.

Replacement Parts

The emission control systems on your new Honda were designed, built and certified to conform with the Federal regulations
implementing the Clean Air Act. Honda recommends only the use of
new, genuine Honda parts or their equivalent. The use of otherreplacement parts which are not of equivalent quality may impair
the effectiveness of your car's emission control systems.

Crankcase Emission Control System

To prevent crankcase emissions, your car is equipped with a Positive Crankcase Ventilation (PCV) System which routes blowby
gases from the crankcase, through the PCV valve and intakemanifold, into the combustion chamber.ProCarManuals.comMain Menu s t

Evaporative Emission Control System
The Evaporative Emission Control System is designed to prevent
fuel vapors from escaping into the atmosphere. Fuel vapors from the fuel tank are directed into the charcoal
canister where they are adsorbed and stored while the engine is stopped or idling. When the coolant temperature rises to a certain
value, the vapors are drawn into the engine through the throttlebody and the intake manifold during normal engine operation.
Engine Exhaust Emission Controls
The engine exhaust emission control systems are designed to control combustion during idle, acceleration, cruise, and deceleration.
These systems are entirely separate from the crankcase and evaporative emission control systems described previously.
HONDA PGM-FI System
The PGM-FI system consists of three independent sub-systems; Air Intake, Electronic Control and Fuel Control, thus allowing moreaccurate control of air/fuel ratios under all operating conditions.
The Electronic Control Unit (ECU) detects the amount of air
drawn into the cylinders and determines the amount of fuel to be injected to provide the optimum air/fuel ratio for all engine needs.
Ignition Timing Control System
This system automatically controls the ignition timing to reduce
the amount of HC and NOx.
Catalytic Converter
Three Way Catalyst
The catalyst is used to convert hydrocarbons (HC), carbon monoxide (CO) and oxides of nitrogen (NOx) in the exhaust gas,

to carbon dioxide (CO 2
), dinitrogen (N 2
) and water vapor.

Exhaust Gas Recirculation (EGR) (California automatic models except EX Sedan)
The EGR system is designed to control the formation of oxides of nitrogen (NOx) caused when fuel mixture burns at high
temperature. It works by recirculating exhaust gas through the EGR valve and intake manifold into the combustion chambers
where it reduces peak temperature by diluting the air/fuel mixture.ProCarManuals.comMain Menu s t

Catalytic Converter

A catalytic converter is installed in the exhaust system to help
clean-up the harmful exhaust gases that can cause air pollution.
To be effective, the converter must work at high temperature, so don't park your car over dry grass, leaves or anything else that

could burn easily.

To stay effective, the converter must not be contaminated by

leaded gasoline; use only unleaded gas as explained on page 54.

CAUTION:
The converter can be overheated and damaged if it's fed too much
unburned fuel mixture from the engine, so:
— Don't push or tow the car to start it; if the battery is dead, jump start the car as shown on page 110.
— Don't turn the key off while the engine is running above idle
speed.

— Don't change the ignition timing, or remove any emission control
parts.

— Use only the spark plugs specified in this manual. — Don't keep driving your car if it isn't running properly, or if its CHARGE warning light comes on; have it checked by your
Honda dealer.
CATALYTIC CONVERTERProCarManuals.comMain Menu s t

Index (cont'd)

Specification (Sedan)............ 119
Engine Exhaust Gas Warning........ 60
Evaporative Emission Control
System.................................... 125

Exterior Care.................................. 99
Filters

Air.............................................. 86
Engine Oil.................................. 76

Fuel........................................... .86

Fluid..................................... See "Oil"
Foreign Countries, Operation in.... 55
Front Seat
Adjustment................................. 6

Fuel
Filler Door and Cap................... 55
Fitter..........................................86
Gasohol..................................... 54

Gasoline .................................... 54

Gauge........................................ 28

Requirement............................. 54

Fuse
Checking and Replacing .......... 91Specification (Hatchback).... 116
Specification (Sedan)............ 119

Hatch................................................. 5

Hatch/Trunk-open Indicator Light
...................................................31

Hazard Warning System............... 37

Headlights
Flasher...................................... 36
High Beam Indicator................. 29High Beam/Low Beam Switch ...............................................36

Switch...................................... 36

Headlight High Beam Indicator Light
...................................................29

Head Restraints................................ 7
Heating............................................. 50 High Beam
Indicator Light.......................... 29

Switch...................................... 36

Hood Latch..................................... 41
Identification Numbers................ 121
Ignition Keys............................................ 3

Switch....................................... 57

Indicator Lights.............................. 29
Inflation Pressures, Tire................ 94 Instrument Panel............................ 26
Instrument Panel Brightness Control ................................................... 37

Interior Light................................... 37

Interior Trim Care .......................... 99
Keys
Door Locks................................. 3
Hatch/Trunk Lid Lock................ 5

Ignition....................................... 57
Keys............................................ 3
Lap/Shoulder Belts .......................... See "Seat Belts"
Light Bulb Replacement.................... 92
Fuse Replacement................... 90
Operation.................................. 36
Warning and Indicator Lights.. 29
Locks
Anti-theft Steering Column Lock...............................................57
Child Proo f
Door Locks ............. 5

Doors........................................... 3

Fuel Filler Door.......................... 55 Hatch/Trunk Lid......................... 5
Power Doors.............................. 4
Luggage Area Light........................ 38
Luggage Cover................................. 9
Gasoline............................ See "Fuel"
Gas Station Information. back cover

Gauges............................................ 28

Glove Box....................................... 42 Jack.............................................. 106
Jump Starting.............................. 110ProCarManuals.comMain Menu s t

Maintenance
Non-Scheduled MaintenanceRecord................................... 72
Scheduled Maintenance Record................................... 71

Schedule................................... 68

Severe Driving Conditions...... 72
Manual Transmission Clutch Pedal Adjustment........ 61
Maximum Allowable Speeds.. 63
Oil...............................................
78

Recommended Shift
Speeds.. 62

Shifting......................................

61

Meters, Gauges..........
See "Gauges"
Mirrors Power Mirrors.......................... 35

Rearview Mirrors..................... 35

Octane Rating, Gasoline. See "Fuel"
Odometer........................................ 28
Oil
Engine Oil.................................. 75

Fluid Locations......................... 74
Oil Pressure Warning Light..... 30
Power Steering Fluid................ 85
Transmission Oil/Fluid.............. 78
Operation In Foreign Countries..... 55
Panel Brightness Control............... 37
Parking Brake................................. 42
Passive Belt.................................... 10
PGM-FI
System.................................... 125
Power Door Locks................................. 4
Mirrors...................................... 35
Steering..................................... 85

Windows.................................. 43

Pregnant Women........................... 25
Pressures, Tire Inflation................ 94
Preventive Service...................... 102 Radiator Coolant............................ 80

Rear Seat.......................................... 8

Rearview Mirrors........................... 35
Rear Window Defogger................ 34Rear Window Wiper...................... 34Reminder Lights .................. See "Warning Lights"
Replacement
Air Filter.................................... 86

Bulb............................................ 92
Engine Oil.................................. 76

Fuel Filter.................................. 86

Fuse...........................................90
Oil Filter..................................... 76
Radiator Coolant...................... 82
Spark Plugs............................... 87

Tire............................................ 94
Wiper Blades............................. 88
Rust Prevention........................... 101
Safety Defects, Reporting.......... 128

Safety Items................................... 59

Seats
Adjustment................................. 6
Head Restraints.......................... 7
Seat Belt Reminder Light
and Beeper (Sedan).................. 14

Seat Belt Reminder Light and Beeper (Hatchback).......... 17
Seat Belts Anchor Points (Hatchback)..... 22
Anchor Points (Sedan)............ 24

Automatic Belt......................... 10

Buckling the Front Seat Belts (Sedan)............... 11
Buckling the Front Seat Belts (Hatchback)....... 15
Buckling the Rear Seat Belts .. 19
Child Restraint.......................... 21
Cleaning..................................... 25

Fasten Seat Belt Reminder Light and Beeper (Sedan).............. 14
Fasten Seat Belt Reminder Light and Beeper (Hatchback)...... 17

(cont'd)

Numbers, Identification............... 121ProCarManuals.comMain Menu s t