coolant temperature HONDA CIVIC 2002 7.G Owners Manual

This shows the temperature of the
engine’s coolant. During normal
operation, the pointer should rise
from the bottom white mark to about
the middle of the gauge. In severe
driving conditions, such as very hot
weather or a long period of uphill
driving, the pointer may rise to the
upper zone. If it reaches the red
(Hot) mark, pull saf ely to the side of
the road. Turn to page for
instructions and precautions on
checking the engine’s cooling
system.276
Gauges
Inst rument s and Cont rols
Temperature Gauge
68

This section covers how to set up the
system controls f or ventilation,
heating, cooling, dehumidif ying, and
def rosting.
The engine must be running f or the
heater and air conditioning to
generate hot and cold air. The heater
uses engine coolant to warm the air.
If the engine is cold, it will be several
minutes bef ore you f eel warm air
coming from the system.
The air conditioning does not rely on
engine temperature.
The vents in the corners of the
dashboard can be opened and closed
with the dials underneath them.
The direction of air f low f rom the
vents in the center and each side of
the dashboard is adjustable.
To adjust the air flow from each vent,
move the vent up-and-down and
move the tab side-to-side.
Heating and Cooling
Comf ort and Convenience Feat ures
Vent Controls
How to Use the System
108
SSIIDDEEVVEENNTT
OOppeennCClloossee
TTAABB
CCEENNTTEERRVVEENNTTSS

When the interior has cooled down
to a more comf ortable temperature,
close the windows and set the
controls as described f or normal
cooling.Air conditioning places an extra load
on the engine. Watch the engine
coolant temperature gauge (see page
) when driving in stop-and-go
traf f ic or climbing a long, steep hill.
If it moves near the red zone, turn
of f the A/C until the gauge reads
normally.
If the interior is very warm f rom
beingparkedinthesun,youcancool
it down more rapidly by setting up
the controls this way: Turn on the A/C by pressing the
button. The light in the button
comesonwhenafanspeedis
selected.
Make sure the temperature
control dial is all the way to the left.
Select .
If the outside air is humid, select
Recirculation mode. If the outside
air is dry, select Fresh Air mode.
Set the f an to the desired speed.
Start the engine.
Turn on the A/C by pressing the
button. Make sure the tempera-
ture control dial is turned all the
way to the left.
Set the f an to maximum speed.
Open the windows partially. Select
and Fresh Air mode.
1.2. 3. 4.
1. 2. 3. 4. 5.
68
Comf ort and Convenience Feat ures
Heating and Cooling
T o Cool wit h A /C
110
AAIIRRCCOONNDDIITTIIOONNIINNGGBBUUTTTTOONN
MMOODDEECCOONNTTRROOLLDDIIAALL
TTEEMMPPEERRAATTUURREECCOONNTTRROOLLDDIIAALL
FFAANNCCOONNTTRROOLLDDIIAALL
RREECCIIRRCCUULLAATTIIOONNBBUUTTTTOONN
RREEAARRWWIINNDDOOWWDDEEFFOOGGGGEERRBBUUTTTTOONN

For saf ety, make sure you have a
clear view through all the windows
bef ore driving away.You should shut the system
completely of f only f or the f irst f ew
minutes of driving in cold weather,
until the engine coolant warms up
enough to operate the heater. Keep
the fan on at all other times so stale
air does not build up in the interior.
To shut of f the system temporarily,
turn the fan speed and temperature
control dials all the way to the lef t.
These settings direct all the air f low
to the defroster vents at the base of
the windshield and the side window
def roster vents. The air f low will get
warmer and clear the windows faster
as the engine warms up. You can
close the side vents with the dial
underneath each vent. This will send
more warm air to the windshield
defroster vents.
Heating and Cooling
Comf ort and Convenience Feat ures
To Turn Everything Of f
113

CONT INUED
Remove the radiator cap.
Turn the ignition ON (II). Turn
the temperature control dial to
maximum heat. Turn of f the
ignition. Open the hood. Make
sure the engine and radiator are
cool to the touch.
Draining the coolant requires access
to the underside of the car. Unless
you have the tools and knowledge,
you should have this maintenance
done by a skilled mechanic.
Thecoolingsystemshouldbe
completely drained and ref illed with
new coolant according to the time
and distance recommendations in
the maintenance schedule. Only use
Honda All Season Antif reeze/
Coolant Type 2.
Loosen the drain plug on the
bottom of the radiator. The
coolant will drain through the
splash guard. Remove the drain
bolt and washer f rom the engine
block. Drain the coolant into an
appropriate container.
1.
3.
2.
Replacing Engine Coolant
Cooling Syst em
Maint enance215
DDRRAAIINNPPLLUUGG
DDRRAAIINNBBOOLLTT

Your car can overheat f or several
reasons, such as lack of coolant or a
mechanical problem. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
In either case, you should take
immediate action.
The pointer of your car’s tempera-
ture gauge should stay in the mid-
range under most conditions. It may
go higher if you are driving up a long
steep hill on a very hot day. If it
climbs to the red mark, you should
determine the reason.
Keep the ends of the jumper cables
away from each other and any metal
on the car until all are disconnected.
Otherwise, you may cause an
electrical short. Once your car is running, discon-
nectthenegativecablefromyour
car, then from the booster battery.
Disconnect the positive cable f rom
your car, then the booster battery.
Start your car. If the starter motor
still operates slowly, check the
jumper cable connections to make
sure they have good metal-to-
metal contact.
7.
6.
T aking Care of t he Unexpect ed
Jump Starting, If Your Engine Overheats
If Your Engine Overheats
276
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to your engine.

CONT INUED
Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park, and set the parking brake.
Turn of f the heating and cooling
system and all other accessories.
Turn on the hazard warning
indicators.
If you see steam and/or spray
coming f rom under the hood, turn
of f the engine.If you do not see steam or spray,
leave the engine running and
watch the temperature gauge. If
the high heat is due to overloading
(climbing a long, steep hill on a
hot day with the A/C running, f or
example), the engine should start
to cool down almost immediately.
If it does, wait until the tempera-
ture gauge comes down to the mid-
point then continue driving.
If the temperature gauge stays at
the red mark, turn of f the engine.
Wait until you see no more signs
of steam or spray, then open thehood.Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see
on page ).
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page ). If the level is below the
MIN mark, add coolant to halfway
between the MIN and MAX marks.
1. 2.
3. 4. 5.6. 7.
290
169
T aking Care of t he Unexpect ed
If Your Engine Overheats
Emergency
Towing
277

If there was no coolant in the
reserve tank, you may also have to
add coolant to the radiator. Let the
engine cool down until the pointer
reaches the middle of the tempera-
ture gauge, or lower, bef ore check-
ing the radiator.Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.
Start the engine and set the
temperature control dial to
maximum. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .)
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
8.
9.
10. 11. 12.
290
T aking Care of t he Unexpect ed
If Your Engine Overheats
Emergency
Towing
278
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

Î
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 58
................
Daytime Running Lights . 71
............
Def ects, Reporting Saf ety . 310
........................
Def og and Def rost . 111
................
Def ogger, Rear Window . 75
..............
Def rosting the Windows . 111
....................................
Dimensions . 296
...............
Dimming the Headlights . 70
Dipstick
..........
Automatic Transmission . 220
..................................
Engine Oil . 168
..........................
Directional Signals . 72
........
Disc Brake Wear Indicators . 188
.....................
Disposal of Used Oil . 212
Doors
..............
Locking and Unlocking . 81
......................
Power Door Locks . 82
..........
DOT Tire Quality Grading . 298
............................
Capacities Chart . 296
.............
Carbon Monoxide Hazard . 54
.............................
Carrying Cargo . 173
Cassette Player
............................................
Care . 156
...................
Operation . 120, 132, 153
..............
CAUTION, Explanation of . ii
..................
CD Changer . 123, 135, 149
......................
CD Player . 123, 135, 147
..................................
Ceiling Light . 102
........................
Certif ication Label . 294
............................................
Chains . 244
....................
Changing a Flat Tire . 267
............
Changing Engine Coolant . 215
Changing Oil
........................................
How to . 211
......................................
When to . 200
...
Charging System Indicator . 62, 280
............
Checklist, Bef ore Driving . 178
.....................................
Child Saf ety . 22 Child Seats
......
LATCH Anchorage System . 43
...........................
Lower Anchors . 43
..........
Tether Anchorage Points . 42
..................
Childproof Door Locks . 86
....................
Cleaner Element, Air . 225
Cleaning
......................................
Exterior . 258
.......................................
Interior . 260
...................................
Seat Belts . 261
...........................................
Vinyl . 261
....................................
Windows . 262
.........
Clock, Setting the . 119, 131, 143
...................................
Clutch Fluid . 223
........................
CO in the Exhaust . 302
............
Cold Weather, Starting in . 179
..............................
Compact Spare . 266
...............
Consumer Inf ormation . 308
.............
Controls, Instruments and . 57
Coolant
........................................
Adding . 213
....................................
Checking . 169
.........................
Proper Solution . 213
...................................
Replacing . 215
...................
Temperature Gauge . 68
....................
Corrosion Protection . 263 Crankcase Emissions Control
........................................
System . 302
............
Cruise Control Operation . 159
..........
Customer Relations Of f ice . 308
Bulb Replacement
....................
Turn Signal Lights . 248
..............................
Bulbs, Halogen . 247
Index
C
D
II

CONT INUED
Downshif ting, 5-speed Manual.............................
Transmission . 180
.....................................
Drive Belts . 237
...........
Driver and Passenger Safety . 5
...........................................
Driving . 177
....................................
Economy . 170
.........................
In Bad Weather . 192
................
In Foreign Countries . 301
..................
Dust and Pollen Filter . 235
..............................
Economy, Fuel . 170
............
Emergencies on the Road . 265
.............
Battery, Jump Starting . 274
...........
Brake System Indicator . 283
................
Changing a Flat Tire . 267
.....
Charging System Indicator . 280
..................
Checking the Fuses . 286
.....
Low Oil Pressure Indicator . 279
...
Malf unction Indicator Lamp . 281
...
Manually Closing Moonroof . 284
..................
Overheated Engine . 276
...........................
Emergency Brake . 97
......................
Emergency Flashers . 74
......................
Emergency Towing . 290 ............
Emergency Trunk Opener . 87
.......................
Emissions Controls . 302
.............
Emissions Testing, State . 305 Engine
....
Coolant Temperature Gauge . 68
.................................
Drive Belts . 237
......
Engine Speed Limiter . 181, 185
Malf unction Indicator
................................
Lamp . 63, 281
........
Oil Pressure Indicator . 62, 279
..............
Oil, What Kind to Use . 209
...............................
Overheating . 276
............................
Specif ications . 296
.......................................
Starting . 179
......................
Ethanol in Gasoline . 300
.
Evaporative Emissions Controls . 302
...............................
Exhaust Fumes . 54
Expectant Mothers, Use of Seat
........................................
Belts by . 20
..................
Exterior, Cleaning the . 258
............................
Fabric, Cleaning . 261
...................................
Fan, Interior . 106
Features, Comfort and ..............................
Convenience . 105
....................
Filling the Fuel Tank . 165
Filters
................................
Air Cleaner . 225
.........................
Dust and pollen . 235
...............................................
Oil . 211
5-speed Manual Transmission ...............
Checking Fluid Level . 221
................................
Shif ting the . 180
.............
Flashers, Hazard Warning . 74
...................
Flat Tire, Changing a . 267
Fluids
..........
Automatic Transmission . 220
..........................................
Brake . 222
.........................................
Clutch . 223
..............
Manual Transmission . 221
..........................
Power Steering . 224
..................
Windshield Washer . 219
FM Stereo Radio ...................................
Reception . 145
...........................
Folding Rear Seat . 91
.....
Foreign Countries, Driving in . 301
..........................
Four-way Flashers . 74
............................
Front Airbags . 10, 48
Index
E
F
III