clutch HONDA CIVIC 2004 7.G Owners Manual

Thecruisecontrolmaynotholdthe
set speed when you are going up and
down hills. If your speed increases
going down a hill, use the brakes to
slow down. This will cancel the
cruise control. To resume the set
speed, press the RESUME/accel
button. The CRUISE CONTROL
light on the instrument panel will
come back on.You can increase the set cruising
speed in any of these ways:
Press and hold the RESUME/
accel button. When you reach the
desired cruising speed, release the
button.
Push on the accelerator pedal.
Accelerate to the desired cruising
speed and press the SET/decel
button. You can decrease the set cruising
speed in any of these ways:
Press and hold the SET/decel
button. Release the button when
you reach the desired speed.
To increase your speed in very
small amounts, tap the RESUME/
accel button. Each time you do
this, your vehicle will speed up
about 1 mph (1.6 km/h). To slow down in very small
amounts, tap the SET/decel
button. Each time you do this,
your vehicle will slow down about
1 mph (1.6 km/h).
Tap the brake or clutch pedal
lightly with your f oot. The
CRUISE CONTROL light on the
instrument panel will go out.
When the vehicle slows to the
desired speed, press the SET/
decel button.
Cruise Control
Comf ort and Convenience Feat ures
Changing the Set Speed
108
——y
y
(y


y

Even with the cruise control turned
on, you can still use the accelerator
pedal to speed up f or passing. Af ter
completing the pass, take your foot
of f the accelerator pedal. The vehicle
will return to the set cruising speed.
Resting your f oot on the brake or
clutch pedal will cause the cruise
control to cancel.Youcancancelthecruisecontrolin
any of these ways:
Tap the brake or clutch pedal.
Push the CANCEL button on the
steering wheel.
Press the Cruise Control Master
Switch. Pressing the Cruise Control Master
Switch turns the system completely
of f and erases the previous cruising
speed.
When you push the CANCEL button,
or tap the brake or clutch pedal, the
system remembers the previously-
set cruising speed. To return to that
speed, accelerate to above 25 mph
(40 km/h) and then press and
release the RESUME/accel button.
The CRUISE CONTROL light comes
on. The vehicle will accelerate to the
same cruising speed as bef ore.
Cruise Control
Comf ort and Convenience Feat ures
Cancelling the Cruise Control
109
——y
y
(y

y

Apply the parking brake.
In cold weather, turn of f all
electrical accessories to reduce
the drain on the battery.
Push the clutch pedal down all the
way.
Make sure the shif t lever is in
Park. Press on the brake pedal.
Without touching the accelerator
pedal, turn the ignition key to the
START (III) position. Do not hold
the key in START for more than
15 seconds at a time. If the engine
does not start right away, pause
f or at least 10 seconds bef ore
trying again.If the engine does not start within
15 seconds, or starts but stalls
right away, repeat step 4 with the
accelerator pedal pressed halfway
down. If the engine starts, release
pressure on the accelerator pedal
so the engine does not race.
If the engine fails to start, press
the accelerator pedal all the way
downandholdittherewhile
starting to clear flooding. If the
engine still does not start, return
to step 5.
1. 2. 3. 4. 5.6.
Manual Transmission:
Automatic Transmission:
Starting the Engine
Driving125
NOTICE: The engine is harder to start
in cold weather. Also, the thinner air
f ound at altitudes above 8,000 f eet
(2,400 meters) adds to this problem.
——y
y
(y
y

The manual transmission is syn-
chronizedinallforwardgearsfor
smooth operation. It has a lockout so
you cannot shift directly from Fifth
to Reverse. When shif ting up or
down,makesureyoupushtheclutch
pedal down all the way, shift to the
next gear, and let the pedal up
gradually. When you are not shif ting,
do not rest your f oot on the clutch
pedal. This can cause your clutch to
wear out faster.Come to a full stop before you shift
into Reverse. You can damage the
transmission by trying to shif t into
Reverse with the vehicle moving.
Push down the clutch pedal, and
pause f or a f ew seconds bef ore
shif ting into Reverse, or shif t into
one of the f orward gears f or a
moment. This stops the gears so
they won’t ‘‘grind.’’
When slowing down, you can get
extra braking f rom the engine by
shifting to a lower gear. This extra
braking can help you maintain a safe
speed and prevent your brakes f rom
overheating while going down a
steep hill. Bef ore downshif ting,
make sure the vehicle speed is low
enough that you will not activate the
engine speed limiter in the lower
gear. On EX and LX models in the
U.S., and all models in Canada, make
sure the engine speed will not go into
the tachometer’s red zone in the
lower gear bef ore downshif ting.
5-speed Manual T ransmission
Driving126
Rapid slowing or speeding-up
can cause loss of control on
slippery surfaces. If you crash,
you can be injured.
Use extra care when driving on
slippery surfaces.
——y

y
(y
y

This section also includes
Maintenance Schedules f or normal
driving and severe driving conditions,
a Maintenance Record, and instruc-
tions f or simple maintenance tasks
you may want to take care of
yourself .
If you have the skills and tools to per-
f orm more complex maintenance
tasks on your Honda, you may want
to purchase the Service Manual. See
page f or inf ormation on how to
obtain a copy, or see your Honda
dealer.
This section explains why it is
important to keep your vehicle well
maintained and how to f ollow basic
maintenance saf ety precautions.
......................
Maintenance Saf ety . 136
.................
Maintenance Schedule . 137
....................
Maintenance Record . 141
..............................
Fluid Locations . 143
........................
Adding Engine Oil . 144
.........
Changing the Oil and Filter . 145
..............................
Engine Coolant . 147
....................
Windshield Washers . 148
.....
Automatic Transmission Fluid .149
........
Manual Transmission Fluid . 150
....................................
Timing Belt . 150
................
Brake and Clutch Fluid . 151
....................
Power Steering Fluid . 152
....................................
Hood Latch . 152
.............................................
Lights . 153
.......................................
Seat Belts . 159
.....................................
Floor Mats . 159
..................
Dust and Pollen Filter . 159
.................................
Wiper Blades . 160
...............................................
Tires . 161
................
Checking Your Battery . 167
.............................
Vehicle Storage . 168
211
Maintenance
Maint enance135
——y

y
(y
y

Fluid Locations
Maint enance143
RADIATOR CAP
ENGINE
COOLANT
RESERVOIR ENGINE OIL DIPSTICK
(Orange loop)
BRAKE FLUID
(Gray cap)
ENGINE OIL
FILL CAP
CLUTCH FLUID
(Manual
Transmission only)
(Gray cap)
WASHER FLUID
(Blue cap)
POWER STEERING
FLUID (Red cap)
AUTOMATIC
TRANSMISSION
FLUID DIPSTICK
(Yellow loop)
——y

y
(y
y

Check the brake f luid level in the
reservoirs monthly.
Replace it according to the time
recommendation in the maintenance
schedule.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement.
Using any non-Honda brake f luid can
cause corrosion and decrease the lif e
of the system. Have the brake
system f lushed and ref illed with
Honda Heavy Duty Brake Fluid
DOT 3 as soon as possible.The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If it is not, add
brake f luid to bring it up to that level.
Use the same fluid specified for the
brake system.
Low f luid level can indicate a leak in
the clutch system. Have this system
inspected as soon as possible.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage.
Manual Transmission only
Brake and Clutch Fluid
Maint enance
Brake System Clutch System
151
MAX
MIN
MAX
MIN
——y
y
(y
y

Diagnosing why your engine won’t
start f alls into two areas, depending
on what you hear when you turn the
key to START (III):You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run. When you turn the ignition switch to
START (III), you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Check the transmission interlock.
If you have a manual transmission,
the clutch pedal must be pushed
all the way to the f loor or the
starter will not operate. With an
automatic transmission, it must be
in Park or Neutral.
Turn the ignition switch to ON (II).
Turn on the headlights and check
their brightness. If the headlights
are very dim or don’t light at all,
the battery is discharged. See on page . Turn the ignition switch to START
(III). If the headlights do not dim,
check the condition of the f uses. If
the f uses are OK, there is
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem (see
on page ).
Check these things:
If the headlights dim noticeably or
go out when you try to start the
engine, either the battery is dis-
charged or the connections are
corroded. Check the condition of
the battery and terminal connec-
tions (see page ). You can
then try jump starting the vehicle
f rom a booster battery (see page).
178 167
190
178
If Your Engine Won’t Start
T aking Care of t he Unexpect ed
Nothing Happens or the Starter
Motor Operates Very Slowly
Jump Starting Emergency T owing
176
——y
y
(y
y

Î
............................
Capacities Chart . 196
.............
Carbon Monoxide Hazard . 46
.............................
Carrying Cargo . 119
Cassette Player
............................................
Care . 104
...................................
Operation . 102
..............
CAUTION, Explanation of . ii
.....................................
CD Changer . 98
.........................................
CD Player . 97
....................................
Ceiling Light . 83
........................
Certif ication Label . 194
............................................
Chains . 166
....................
Changing a Flat Tire . 171
Changing Oil
........................................
How to . 145
......................................
When to . 139
...
Charging System Indicator . 55, 182
............
Checklist, Bef ore Driving . 124
.....................................
Child Saf ety . 29
Child Seats
......
LATCH Anchorage System . 37
...........................
Lower Anchors . 37
..........
Tether Anchorage Points . 41
..................
Childproof Door Locks . 70 .........................
Clock, Setting the . 106
...................................
Clutch Fluid . 151
........................
CO in the Exhaust . 202
............
Cold Weather, Starting in . 125
..............................
Compact Spare . 170
...............
Consumer Inf ormation . 208
.............
Controls, Instruments and . 49
Coolant
........................................
Adding . 147
....................................
Checking . 115
.........................
Proper Solution . 147
...................
Temperature Gauge . 60
Crankcase Emissions Control ........................................
System . 202
............
Cruise Control Operation . 107
..........
Customer Relations Of f ice . 208
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 50
................
Daytime Running Lights . 63
............
Def ects, Reporting Saf ety . 210
..........................
Def og and Def rost . 91
................
Def ogger, Rear Window . 65
................
Def rosting the Windows . 91 ....................................
Dimensions . 196
...............
Dimming the Headlights . 63
Dipstick
..........
Automatic Transmission . 149
..................................
Engine Oil . 115
..........................
Directional Signals . 63
........
Disc Brake Wear Indicators . 132
.....................
Disposal of Used Oil . 146
Doors
..............
Locking and Unlocking . 70
......................
Power Door Locks . 70
..........
DOT Tire Quality Grading . 198
Downshif ting, 5-speed Manual
.............................
Transmission . 126
...........
Driver and Passenger Safety . 5
...........................................
Driving . 123
....................................
Economy . 116
................
In Foreign Countries . 201
..................
Dust and Pollen Filter . 159
..............................
Economy, Fuel . 116
............
Emergencies on the Road . 169
.............
Battery, Jump Starting . 178
...........
Brake System Indicator . 184
Index
C
D E
II
——y
y
(y
y

CONT INUED
................
Changing a Flat Tire . 171
.....
Charging System Indicator . 182
..................
Checking the Fuses . 186
.....
Low Oil Pressure Indicator . 182
...
Malf unction Indicator Lamp . 183
...
Manually Closing Moonroof . 185
..................
Overheated Engine . 179
...........................
Emergency Brake . 82
......................
Emergency Flashers . 65
......................
Emergency Towing . 190
............
Emergency Trunk Opener . 71
.......................
Emissions Controls . 202
.............
Emissions Testing, State . 205 Engine
....
Coolant Temperature Gauge . 60
......
Engine Speed Limiter . 127, 130
Malf unction Indicator
................................
Lamp . 56, 183
........
Oil Pressure Indicator . 55, 182
..............
Oil, What Kind to Use . 144
...............................
Overheating . 179
............................
Specif ications . 196
.......................................
Starting . 125
......................
Ethanol in Gasoline . 200
.
Evaporative Emissions Controls . 202
...............................
Exhaust Fumes . 46 Expectant Mothers, Use of Seat
........................................
Belts by . 17
.....................................
Fan, Interior . 89
Features, Comfort and
................................
Convenience . 87
....................
Filling the Fuel Tank . 113
Filters
.........................
Dust and Pollen . 159
...............................................
Oil . 145
5-speed Manual Transmission ...............
Checking Fluid Level . 150
................................
Shif ting the . 126
.............
Flashers, Hazard Warning . 65
...................
Flat Tire, Changing a . 171
Fluids
..........
Automatic Transmission . 149
..........................................
Brake . 151
.........................................
Clutch . 151
..............
Manual Transmission . 150
..........................
Power Steering . 152
..................
Windshield Washer . 148
FM Stereo Radio .....................................
Reception . 95 ...........................
Folding Rear Seat . 76
.....
Foreign Countries, Driving in . 201
..........................
Four-way Flashers . 65
............................
Front Airbags . 10, 22
.................................................
Fuel . 112
......................
Fill Door and Cap . 113
...........................................
Gauge . 59
................
Octane Requirement . 112
...............................
Oxygenated . 200
........................
Reserve Indicator . 56
........................
Tank, Filling the . 113
.....................
Fuses, Checking the . 186
...............
Gas Mileage, Improving . 116
..........................................
Gasohol . 200
.........................................
Gasoline . 112
...............
Fuel Reserve Indicator . 56
...........................................
Gauge . 59
................
Octane Requirement . 112
........................
Tank, Filling the . 113
................
Gas Station Procedures . 113
Index
F
G
III
——y
y
(y
y