Coolant system HONDA CR-V 2004 RD4-RD7 / 2.G Owners Manual
[x] Cancel search | Manufacturer: HONDA, Model Year: 2004, Model line: CR-V, Model: HONDA CR-V 2004 RD4-RD7 / 2.GPages: 256, PDF Size: 2.96 MB
Page 66 of 256
¶µµµµ
µ µµµ
This shows the temperature of the
engine’s coolant. During normal
operation, the pointer should rise to
about the middle of the gauge. In
severe driving conditions, the pointer
may rise to the upper zone. If it
reaches the red (Hot) mark, pull
safely to the side of the road. Turn to
page f or instructions and
precautions on checking the engine’s
cooling system.
The temperature sensor is in the
f ront bumper. Theref ore, the
temperature reading can be af f ected
by heat ref lection f rom the road
surf ace, engine heat, and the
exhaust f rom surrounding traf f ic.
This can cause an incorrect
temperature reading when your
speed is under 30 km/h.If the outside temperature is
incorrectly displayed, you can adjust
it up to 3°C warmer or cooler.
NOTE: The temperature must be
stabilized bef ore doing this
procedure.
Select the outside temperature
display, then press the Select/Reset
knob f or ten seconds. The f ollowing
sequence will appear f or one second
each:0,1,2,3,4,5, 5, 4, 3, 2,
1, 0, 1 (0, 1, 2, 3, 3, 2, 1, 0, 1).
When it reaches the desired value,
release the Select/Reset knob. You
should see the new outside
temperature displayed.
In certain weather conditions,
temperature readings near f reezing 0
°Ccouldmeanthaticeisformingon
the road surface.
This light displays the outside
temperature Centigrade.
211
Canadian models only
Temperature Gauge
Outside Temperature Indicator
Gauges
Inst rument s and Cont rols62
OUTSIDE TEMPERATURE INDICATOR
Page 104 of 256
Air f lows f rom the def roster
vents at the base of the windshield.
When you select or ,
the system automatically switches to
Fresh Air mode and turns on the
A/C. The A/C indicator does not
come on.
The f low-through ventilation system
draws in outside air, circulates it
through the interior, then exhausts it
through vents near the tailgate.
Turn the temperature control dial
all the way to the lef t.
Make sure the A/C is of f .
Select and Fresh Air mode.
Set the f an to the desired speed.
The heater uses engine coolant to
warm the air. If the engine is cold, it
will be several minutes bef ore you
f eel warm air coming f rom the system.
Select and Fresh Air mode.
Set the f an to the desired speed.
Adjust the warmth of the air with
the temperature control dial.
Air conditioning places an extra load
on the engine. Watch the engine
coolant temperature gauge (see page ). If it moves near the red zone,
turn of f the A/C until the gauge
reads normally.
Turn on the A/C by pressing the
button. The light in the button
comesonwhenafanspeedis
selected.
Make sure the temperature
control dial is all the way to the left.
Select .
If the outside air is humid, select
Recirculation mode. If the outside
air is dry, select Fresh Air mode.
Set the f an to the desired speed. To cool the interior with MAX A/C:
Set the mode control dial to MAX
A/C.
The system automatically turns on
the A/C, selects and
switches to Recirculation mode.
Make sure the temperature
control dial is all the way to the left.
Set the f an to the desired speed. you can
cool it down more rapidly by partially
opening the windows, turning on the
A/C, and setting the fan to
maximum speed in Fresh Air mode.
1.
2.
3.
4. 1.
2.
3.
1.
2.
3.
1.
2.
3.
4.
5. 62
If the interior is very warm,
Ventilation
Using the Heater Using the A /C
Vents, Heating, and A/C
Comf ort and Convenience Feat ures100
Page 172 of 256
ÎÌ
Ì
Ì
Î
Follow the Normal Maintenance
Schedule if the severe driving
conditions specif ied in the Severe
Conditions Maintenance Schedule on
the next page do not apply.
NOT E: If you only OCCASIONALLY
drive under ‘‘severe’’ conditions, you
should f ollow the Normal Conditions
Maintenance Schedule.
Maint enance
168
miles x 1,000
km x 1,000
Service the items listed at the indicated distance (or time, if given).
Every 3 years (independent of mileage)
( (O
O r
re
ev
ve
er
ry
y 6
6y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
(
(
O
O t
th
h e
er
rw
w i
is
se e a
ad
d j
ju
u s
stt o
o n
nl
ly
y i
if
f n
n o
oi
is
sy y )
)
Every 10,000 miles (16,000 km)(
(O
O r
re
ev
ve
er
ry
y 1
1y
ye
ea
ar
r,
, w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
Check inflation and condition once a month Check oil and coolant at each fuel stop
10
16
20
3230
4840
6450
8060
9670
112 80
128
( ( O
O r
re
ev
ve
er
ry
y 2
2y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
Replace at 120,000 miles (192,000 km) or 6 years, then every 90,000 miles (144,000 km) or 5 years.
See information on maintenance and emission warranty on page .
( (O
O r
re
ev
ve
er
ry
y 1
1y
ye
ea
ar
r,
, w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
(
( O
O r
re
ev
ve
er
ry
y 5
5y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
Every 160,000 miles (256,000 km)
At 120,000 miles (192,000 km) or 10 years, then every 60,000 miles (96,000 km) or 5 years 150
240
140
224
130
208
120
192
110
176
100
160
90
144
Check engine oil and coolant
Check tires
Replace engine oil
Rotate tires (follow pattern on page 193)
Replace engine oil filter
Check front and rear brakes
Check parking brake adjustment
Inspect the following items: Tie-rod ends, steering gearbox, and boots
Suspension components
Driveshaft boots
Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system
Fuel lines and connections
Inspect drive belts
Replace dust and pollen filter
Replace air cleaner element
Replace spark plugs
Inspect valve clearance
Replace automatic transmission fluid
Replace manual transmission fluid
Replace rear differential fluid
Inspect idle speed
Replace engine coolant
Replace brake fluid
1: : 166
1
Maintenance Schedule for Normal Conditions
Page 173 of 256
Î
Î
Ì Î
µ
ÌÌÎÎ
Î
Follow the Severe Maintenance
Schedule if you drive your vehicle
MAINLY under one or more of the
f ollowing conditions: Extensive idling or long periods of
stop and go driving, such as a taxi or
a delivery vehicle. Driving less than 5 miles (8 km) per
trip or, in f reezing temperatures,
driving less than 10 miles (16 km)
per trip.
Driving in extremely hot [over 90°F
(32°C)] conditions.
Follow the
Maintenance Schedule f or Severe
Conditions. Driving on muddy, dusty, or de-iced
roads. T railer towing, driving with a roof
rack, or driving in mountainous
conditions.
commercial
Canadian Owners
Maint enance
169
miles x 1,000
km x 1,000
Every 3 years (independent of mileage)
( (O
O r
re
ev
ve
er
ry
y 3
3y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
(
(
O
O t
th
h e
er
rw
w i
is
se e a
ad
d j
ju
u s
stt o
o n
nl
ly
y i
if
f n
n o
oi
is
sy y )
)
(
(
O
O r
re
ev
ve
er
ry
y 2
2y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
10
16 50
8070
112
Check oil and coolant at each fuel stop 150
240
Service the items listed at the indicated distance (or time, if given).
Every 10,000 miles (16,000 km)
Check inflation and condition once a month
Every 5,000 miles (8,000 km) or every 6 months, whichever comes first
( (O
O r
re
ev
ve
er
ry
y 1
1y
ye
ea
ar
r,
, w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
(
( O
O r
re
ev
ve
er
ry
y 1
1y
ye
ea
ar
r,
, w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
40
64
20
32 60
9680
128
30
48
Every 160,000 miles (256,000 km)
At 120,000 miles (192,000 km) or 10 years, then every 60,000 miles (96,000 km) or 5 years
( (O
O r
re
ev
ve
er
ry
y 4
4y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
Replace at 60,000 miles (96,000 km) or 3
years, then every 30,000 miles (48,000
km) or 2 years.
90
144 100
160 140
224
130
208
120
192
110
176
See dust and pollen filter on page for
replacement information under special
driving conditions.
Check engine oil and coolant
Check tires
Replace engine oil
Rotate tires (follow pattern on page
193)
Replace engine oil filter
Check front and rear brakes
Lubricate all hinges, locks and latches
Inspect the following items: Tie rod ends, steering gear box, and boots
Suspension components, Driveshaft boots
Check parking brake adjustment
Inspect the following items: Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system , Fuel lines and connections
Lights and controls/vehicle underbody
Inspect drive belts
Replace dust and pollen filter
Clean and replace air cleaner element
Replace spark plugs
Inspect valve clearance
Replace automatic transmission fluid
Replace manual transmission fluid
Replace rear differential fluid
Inspect idle speed
Replace engine coolant
Replace brake fluid Clean every 15,000 miles (24,000 km), and replace every 30,000
miles (48,000 km)
Use normal schedule except in dusty
condition.
See information on maintenance and
emission warranty on page .
1:
2:
: 188
3: 166
13
2
Maintenance Schedule for Severe Conditions
Page 180 of 256
If the coolant level in the reserve
tank is at or below the MIN line, add
coolant to bring it up to the MAX line.
Inspect the cooling system f or leaks.Always use Honda All Season
Antif reeze/Coolant Type 2. This
coolant is pre-mixed with 50 percent
antif reeze and 50 percent water.
Never add straight antifreeze or
plain water.
If Honda antif reeze/coolant is not
available, you may use another
major-brand non-silicate coolant as a
temporaryreplacement.Makesureit
is a high-quality coolant
recommended f or aluminum engines.
Continued use of any non-Honda
coolant can result in corrosion,
causing the cooling system to
malf unction or f ail. Have the cooling
system f lushed and ref illed with
Honda antif reeze/coolant as soon as
possible.If the reserve tank is completely
empty, you should also check the
coolant level in the radiator.
Engine Coolant
Maint enance
A dding Engine Coolant
176
RESERVE TANK
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.
Page 181 of 256
When the radiator and engine are
cool, relieve any pressure in the
cooling system by turning the
radiator cap counterclockwise,
without pressing down.
Remove the radiator cap by
pushing down and turning
counterclockwise.The coolant level should be up to
the base of the f iller neck. Add
coolant if it is low.
Pourthecoolantslowlyand
caref ully so you do not spill. Clean
up any spill immediately; it could
damage components in the engine
compartment.
Put the radiator cap back on and
tighten it.Pour coolant into the reserve tank.
Fill it to half way between the MAX
and MIN marks. Put the cap back
on the reserve tank.
Do not add any rust inhibitors or
other additives to your vehicle’s
cooling system. They may not be
compatible with the coolant or
engine components.
3.
4. 5.
2. 1.
Engine Coolant
Maint enance177
RADIATOR CAP RESERVE TANK
Page 216 of 256
Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (seeon page ).
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page ). Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise without pushing
down to the first stop. After the
pressure releases, push down on
the cap and turn it until it comes
off. Start the engine and set the
temperature control dial to
maximum. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.
Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair (see
on page ).
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
If there was no coolant in the
reserve tank, you may need to add
coolant to the radiator. Let the
engine cool down until the pointer
reaches the middle of the
temperature gauge or lower
bef ore checking the radiator. 9.
8.
7. 6. 5.
11. 10.
216
128
216
Emergency
Towing
Emergency
Towing
If theEngineOverheats
T aking Care of t he Unexpect ed212
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.
Page 248 of 256
Î
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 54
Daytime Running Lights .......................................
Indicator .58
.................................
Dead Battery .209
............
Def ects, Reporting Saf ety . 240
..........................
Def og and Def rost .99
................
Def ogger, Rear Window . 66
..............
Def rosting the Windows . 101
.........................
Detachable Anchor .84
....................................
Dimensions .226
...............
Dimming the Headlights . 65
Dipstick ..........
Automatic Transmission . 179
..................................
Engine Oil .127
..........................
Directional Signals .65
........
Disc Brake Wear Indicators . 148
.....................
Disposal of Used Oil .175
Doors ..............
Locking and Unlocking . 72
......................
Power Door Locks .72
..........
DOT Tire Quality Grading . 229
Downshif ting, 5-speed Manual
.............................
Transmission .139
..............................................
Cargo .132
........................
Cargo, .132
Cassette Player ............................................
Care .116
...................................
Operation .114
..............
CAUTION, Explanation of . ii
.........................................
CD Care .111
...................................
CD Changer .110
.......................
CD Error Message .112
.......
CD Changer Error Message . 113
.......................................
CD Player .109
.................................
Center Pocket .93
....................................
Center Table .94
........................
Certif ication Label .224
...................................
Chains, .194
....................
Changing a Flat Tire .200
.................................
Changing Oil .174
........................................
How to .174
......................................
When to .165
...
Charging System Indicator . 56,213
............
Checklist, Bef ore Driving . 137
.....................................
Child Saf ety .30
...................................
Child Seats .39
.......
Important Saf ety Reminder . 30
..........................................
Inf ants .36
............................
Large Children .46 .........................................
LATCH .40
...........................
Lower Anchors .41
......................
Risks with Airbags .31
.............................
Small Children .38
.........................................
Tethers .41
............
Tether Anchorage Point . 46
............
Where Should Child Sit? . 31
..................
Childproof Door Locks . 72
..............................................
Clock .118
.........................
Clock, Setting the .118
...................................
Clutch Fluid .181
........................
CO in the Exhaust .233
............
Cold Weather, Starting in . 138
...............
Consumer Inf ormation . 238
.............
Controls, Instruments and . 53
Coolant ........................................
Adding .176
....................................
Checking .128
.........................
Proper Solution .176
...................
Temperature Gauge . 62
Crankcase Emissions Control ........................................
System .231
................
Cruise Control Indicator . 58
............
Cruise Control Operation . 120
.....................................
Cup Holders .92
.............
Customer Service Of f ice . 238
how to carry
tires
Index
D
II
Page 249 of 256
CONT INUED
...........................................
Driving .135
....................................
Economy .129
........................
Driving Guidelines .136
..................
Dust and Pollen Filter . 188
.....................................
Fan, Interior .98
Features, Comfort and ................................
Convenience .97
....................
Filling the Fuel Tank . 125
Filters .........................
Dust and Pollen .188
...............................................
Oil .174
5-speed Manual Transmission ...............
Checking Fluid Level . 180................................
Shif ting the .141
.............
Flashers, Hazard Warning . 66
...................
Flat Tire, Changing a . 200
Fluids ..........
Automatic Transmission . 179
..........................................
Brake .181
.........................................
Clutch .181
..............
Manual Transmission . 180
..........................
Power Steering .182
..................
Windshield Washer . 178
FM Stereo Radio ...................................
Reception .106
...........................
Folding Rear Seat .81
.....
Foreign Countries, Driving in . 232
..........................
Four-way Flashers .66
Front Seat ......................................
Adjusting .12
.........................................
Heaters .75
.........................................
Airbags .23
..............................
Economy, Fuel .129
..................................
Emergencies .199
............................
Jump Starting .209
...........
Brake System Indicator . 215
................
Changing a Flat Tire . 200
.....
Charging System Indicator . 213
..................
Checking the Fuses . 218
.........
Hazard Warning Flashers . 66
.....
Low Oil Pressure Indicator . 213
...
Malf unction Indicator Lamp . 214
...
Manually Closing Moonroof . 217
..................
Overheated Engine . 211
.......................................
Towing .216
...........................
Emergency Brake .67
......................
Emergency Flashers .66
.......................
Emissions Controls .231
.............
Emissions Testing, State . 234
Engine ....
Coolant Temperature Gauge . 62......
Engine Speed Limiter . 140,144
.............................. 208
Malf unction Indicator ................................
Lamp .56, 214
........
Oil Pressure Indicator . 56,213
..............
Oil, What Kind to Use . 173
...............................
Overheating .211
............................
Specif ications .226
.......................................
Starting .138
......................
Ethanol in Gasoline .124
.
Evaporative Emissions Controls . 231
...............................
Exhaust Fumes .50
Expectant Mothers, Use of Seat ........................................
Belts by .18
If it won’t start
Index
E
F
III
Page 250 of 256
.................................................
Fuel .123
......................
Fill Door and Cap .124
...........................................
Gauge .61
................
Octane Requirement . 124
...............................
Oxygenated .124
........................
Reserve Indicator .58
........................
Tank, Filling the .125
.....................
Fuses, Checking the .218
...............
Gas Mileage, Improving . 129
..........................................
Gasohol .124
.........................................
Gasoline .123
...............
Fuel Reserve Indicator . 58
...........................................
Gauge .61
................
Octane Requirement . 124
........................
Tank, Filling the .125
................
Gas Station Procedures . 125
Gauges ...
Engine Coolant Temperature . 62
...............................................
Fuel .61
...............................
Speedometer .61
.................................
Tachometer .61
Gearshif t Lever Positions ..........
Automatic Transmission . 1415-speed Manual
.........................
Transmission .140
........................................
Glove Box .87
.............
Halogen Headlight Bulbs . 183
.....................................
Hatch Glass .73
..............
Hazard Warning Flashers . 66
Headlights ........................................
Aiming .183
............
Daytime Running Lights . 65
..................
High Beam Indicator . 58
........................
Reminder Beeper .65
........
Replacing Halogen Bulbs . 183
...................................
Turning on .65
..............................
Head Restraints .79
.......................
Heating and Cooling .98
.................
High-Low Beam Switch . 65
....................................
Hood Latch .182
.......................
Hood, Opening the .126
..............................................
Horn .3,63
...........................
Hydraulic Clutch .181 ...
Identif ication Number, Vehicle . 224
Ignition ..............................................
Keys .69
...........................................
Switch .71
............
Timing Control System . 232
........................
Immobilizer System .70
.........
Important Safety Precautions . 6
Indicators ..............
ABS (Anti-Lock Brake) . 56
Brake (Parking and Brake ............................
System) .56, 215
........................
Charging System .56
.............................
Cruise Control .58
DRL (Daytime Running ......................................
Lights) .58
...................................
High Beam .58
........
Key (Immobilizer System) . 57
......................................
Low Fuel .58
........................
Low Oil Pressure .56
...........................
Side Airbag Of f .57
...............................................
SRS .57
Turn Signal and Hazard ...................................
Warning .58
..............................
Washer Level .59
Index
G H
I
IV