light HONDA INSIGHT 2001 1.G Manual PDF

ÎÎ
ÎÎIf you must drive the car a short
distance in this condition, drive
slowly and cautiously.
Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the
longer distance needed to stop, it is
hazardous to drive the car. You
should have it towed, and repaired as
soon as possible. (See
on page .)
However, if the brake pedal does not
f eel normal, you should take
immediate action. Because of the
brake system’s dual-circuit design, a
problem in one part of the system
will still give you braking at two
wheels. You will f eel the brake pedal
go down much f arther bef ore the car
begins to slow down, and you will
have to press harder on the pedal.
The distance needed to stop will be
much longer.
If it comes on at any other time, it
indicates a problem with the car’s
brake system. In most cases, the
problem is a low f luid level in the
brake f luid reservoir. Press lightly on
the brake pedal to see if it f eels
normal. If it does, check the brake
f luid level the next time you stop at a
service station (see page ). If the
fluid level is low, take the car to your
dealer and have the brake system
inspected f or leaks or worn brake
pads.
The Brake System Indicator is a
reminder to check the parking brake.
It comes on and stays lit if you do not
f ully release the parking brake. 181
239
Emergency
Towing
Brake System Indicator
T aking Care of t he Unexpect ed
232
BBRRAAKKEESSYYSSTTEEMMIINNDDIICCAATTOORR
UU..SS..iinnddiiccaattoorrsshhoowwnn

If something electrical in your car
stops working, the f irst thing you
should check f or is a blown f use.
Determine f rom the chart on pagesand , or the diagram on the
fuse box lid, which fuse or fuses
control that component. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
not the cause. Replace any blown
f uses and check the component’s
operation.
Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box. Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Removing these f uses
requires a Phillips-head screw-
driver.
Check the smaller f uses in the
under-hood f use box and all the
fuses in the interior fuse boxes by
pulling out each f use with the f use
puller provided in the under-hood
fuse box.
3.
1. 2. 4.
235 236
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed
234
BBLLOOWWNN
FFUUSSEEPPUULLLLEERR
FFUUSSEE

Î Î
µ µ µ
Î
No. Amps. Circuits Protected Circuits Protected
No. Amps.
1 23456789
10 10 A
15 A
20 A
7.5 A
7.5 A
7.5 A 15 A
20 A
7.5 A 20 A SRS
Fuel Pump, SRS
Front Wiper
FI-ECU
Turn Light
Meter
IG Coil
Power Window, Passenger
Starter Signal
Power Window, Driver ACC Radio
ACC Socket
Not used
Not used
Small Light
Air Conditioning, R/C
Mirror
Daytime Running Light
Back Up Light
Interior Light
Radio
Daytime Running Light
Door Lock
Tailgate Lock
IMA
Not used
Rear Wiper
Back Light
111213141516 17 18192021222324252627
7.5 A
10 A
10 A
7.5 A
7.5 A
7.5 A
7.5 A 10 A
10 A
20 A
7.5 A
7.5 A
10 A
7.5 A
: Canadian model only
Fuses
T aking Care of t he Unexpect ed
236
INTERIOR FUSE BOX

µµ
No. Amps. Circuits Protected No. Amps. Circuits Protected
1 23456789
10 50 A
80 A
30 A
10 A
15 A
10 A
15 A
15 A
15 A IG1 Main
Battery
ABS Motor
Hazard
IMA
Horn Stop
Fuel Pump
Lef t Headlight
Not used
Right Headlight 1112131415161718192030 A
40 A
30 A
20 A
40 A
30 A
40 A
7.5 A 20 A Cooling Fan
Heater Motor
Rear Defroster
ABS F/S
Power Steering
Back Up, ACC
Power Window
IMA ECU
Condenser Fan
Spare Fuse
Fuses
T aking Care of t he Unexpect ed
237
UNDER-HOOD FUSE BOX

µµµ
µ µµµµµµµµµ µ µ
Î Î
Specif ications
T echnical Inf ormation
245
Air Conditioning
Alignment
Tires
Lights Battery
Fuses HFC-134a (R-134a)
17.6 19.4 oz (500 550 g) SP-10
12 V 60/55 W (HB2) 0.00 in (0.0 mm)
0.12 in (3.0 mm)
0°1°
2°
P165/65R14 78S
T115/70D14 88M
Refrigerant type
Charge quantity
Lubricant type
Toe-in
CamberCaster Size
Pressure
Headlights (HI/LO)
Front turn signal
Front parking light
Side marker light
Rear turn signal lights
Stop/Taillights
Back-up lights
Trunk light
License plate lights
Interior light 12 V 21 W
12 V 5 W
12 V
12 V
21/5 W
21 W
12 V 18 W
12 V
12 V 5W5W
12 V
12 V
5W
3.4 W
12V 27Ah/5HR
Capacity
Interior
Under-hood 30 Ah/5 HR
12 V
See page 235 or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 236 or the fuse box
cover. FrontRear
FrontRear
Front
Front/Rear
Spare
FrontRear
Spare
38 psi (260 kPa)
35 psi (240 kPa)
60 psi (420 kPa)
MTCVT
U.S. model

Î
Î
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
In Canada, Honda vehicles comply
with the Canadian Motor Vehicle
Saf ety Standards (CMVSS) f or
Emissions valid at the time they are
manuf actured.
The burning of gasoline in your car’s
engine produces several byproducts.
Some of these are carbon monoxide
(CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment.
Under certain conditions of sunlight
and climate, NOx and HC react to
f orm photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas.
Your car has a Positive Crankcase
Ventilation System. This keeps
gasses that build up in the engine’s
crankcase from going into the
atmosphere. The Positive Crankcase
Ventilation valve routes them fromthe crankcase back to the intake
manif old. They are then drawn into
the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
158
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
T echnical Inf ormation
250

Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your Honda dealer.
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (A/T) or 5th (M/T). When
traffic allows, drive for 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).
St at e Emissions T est ing
T echnical Inf ormation
254

CONT INUED
...
Accessories and Modif ications . 128
................................
Accessories . 128
...
Additional Safety Precaution . 129
............................
Modif ications . 129
ACCESSORY (Ignition Key .......................................
Position) . 70
...............
Accessory Power Socket . 80
....................
Additives, Engine Oil . 168
...............................
Airbag (SRS) . 9, 47
................
Air Conditioning System . 90
..............................
Maintenance . 190
............................................
Usage . 90
.........................
Air Outlets (Vents) . 90
.......................
Air Pressure, Tires . 192
.........................
Normal Driving . 192
.......................
Alcohol in Gasoline . 248
......................................
Antif reeze . 171
Anti-thef t Steering Column
..............................................
Lock . 69
..........................
Appearance Care . 207
..................................
Audio System . 98
........................
Auto Idle Stop . 137, 145
..............
Automatic Transmission . 140
..........................
Capacity, Fluid . 244 ...............
Checking Fluid Level . 178
.......................................
Shif ting . 140
.
Shif t Lever Position Indicator . 140
................
Shif t Lever Positions . 140
....................
Shif t Lock Release . 144
Battery Charging System ...........................
Indicator . 56, 229
............................
Jump Starting . 225
..............................
Maintenance . 185
............................
Specif ications . 245
..............................
Bef ore Driving . 119
..........................................
Belts, Seat . 8
.............................
Beverage Holder . 80
.................................
Body Repairs . 213
Brakes
.............
Break-in, New Linings . 120
...........................................
Fluid . 181
....................
Bulb Replacement . 203
.........................................
Parking . 79
.................
System Indicator . 46, 231
........................
Wear Indicators . 148
.............................
Braking System . 149 ........................
Break-in, New Car . 120
..
Brightness Control, Instruments . 62
........................
Brights, Headlights . 61
Bulb Replacement
..........................
Back-up Lights . 203
...............................
Brake Light . 203
................
Front Parking Lights . 201
........
Front Side Marker Lights . 201
.................................
Headlights . 200
.............................
Interior Light . 205
.................
License Plate Lights . 204
............................
Specif ications . 245
....................
Turn Signal Lights . 201
..............................
Bulbs, Halogen . 200
............................
Capacities Chart . 244
.............
Carbon Monoxide Hazard . 40
.............................
Carrying Cargo . 130
Cassette Player
............................................
Care . 118
...................................
Operation . 104
..............
CAUTION, Explanation of . ii
Index
A
B
C
I

Î
...................................
CD Changer . 114
.......................................
CD Player . 108
........................
Certif ication Label . 242
............................................
Chains . 197
....................
Charge/Assist Gauge . 57
Changing Oil
........................................
How to . 169
......................................
When to . 158
....................
Changing a Flat Tire . 195
............
Changing Engine Coolant . 173
............
Charging System Indicator . 56
............
Checklist, Bef ore Driving . 119
.....................................
Child Saf ety . 19
Child Seats
..........
Tether Anchorage Points . 33
....................
Cleaner Element, Air . 183
Cleaning
......................................
Exterior . 208
.......................................
Interior . 211
...................................
Seat Belts . 211
...........................................
Vinyl . 211
....................................
Windows . 212
.........................
Clock, Setting the . 103
...................................
Clutch Fluid . 181
........................
CO in the Exhaust . 250
............
Cold Weather, Starting in . 135 ..............................
Compact Spare . 216
...............
Consumer Inf ormation . 256
.............
Controls, Instruments and . 60
Coolant
........................................
Adding . 171
....................................
Checking . 124
.........................
Proper Solution . 175
...................................
Replacing . 177
...................
Temperature Gauge . 58
....................
Corrosion Protection . 212
Crankcase Emissions Control
........................................
System . 250
.....................
Current Fuel Mileage . 55
..........
Customer Relations Of f ice . 256
..............................
Economy, Fuel . 126
............
Emergencies on the Road . 215
.............
Battery, Jump Starting . 224
...........
Brake System Indicator . 232
................
Changing a Flat Tire . 217
................
DANGER, Explanation of . ii
...................................
Dashboard . 2, 44
................
Daytime Running Lights . 62
............
Defects, Reporting Safety . 260
..........................
Def og and Def rost . 84
................
Def ogger, Rear Window . 65
................
Defrosting the Windows . 84
....................................
Dimensions . 244
...............
Dimming the Headlights . 61 Dipstick
..................................
Engine Oil . 124
..........................
Directional Signals . 63
........
Disc Brake Wear Indicators . 148
.....................
Disposal of Used Oil . 170
..................
Display Change Button . 50
Doors
..............
Locking and Unlocking . 71
..........
DOT Tire Quality Grading . 246
Downshif ting, 5-speed Manual
.............................
Transmission . 136
.....................................
Drive Belts . 191
...........
Driver and Passenger Safety . 5
...........................................
Driving . 133
....................................
Economy . 126
.........................
In Bad Weather . 151
................
In Foreign Countries . 249
..................
DustandPollenFilter .191
Index
D
E
II

GaugesEngine Coolant ...........................
Temperature . 58
...............................................
Fuel . 58
...............................
Speedometer . 50
.................................
Tachometer . 58
Gearshif t Lever Positions
Automatic Transmission .....................................
(CVT) . 140
5-speed Manual .........................
Transmission . 136
..............................
Glass Cleaning . 212
........................................
Glove Box . 80
.............
Halogen Headlight Bulbs . 200
Hatch
.................................
Opening the . 71
...................
Open Monitor Light . 47
..............
Hazard Warning Flashers . 65
Headlights
............
Daytime Running Lights . 62
..................
High Beam Indicator . 47
........................
Reminder Beeper . 61
........
Replacing Halogen Bulbs . 200 ...................................
Turning on . 63
.............................................
Heating . 84
.............
High Altitude, Starting at . 135
.................
High-Low Beam Switch . 61
....................................
Hood Latch . 184
.......................
Hood, Opening the . 122
....................................................
Horn . 3
...........................
Hydraulic Clutch . 181
.................................
Hydroplaning . 151
...
Identif ication Number, Vehicle . 242
Ignition
..............................................
Keys . 67
...........................................
Switch . 69
............
Timing Control System . 251
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 45
Inf ant Seats
..........
Tether Anchorage Points . 41
...................
Inf lation, Proper Tire . 192
.........................
Normal Driving . 193
...................................
Inside Mirror . 78
.............................
Inspection, Tire . 194
............................
Instrument Panel . 45 ........
Instrument Panel Brightness . 62
...........................
Interior Cleaning . 211
...................................
Interior Light . 82
........................................
Introduction . i
........................
Jacking up the Car . 217
.......................................
Jack, Tire . 217
................................
Jump Starting . 224
..................................................
Keys . 67
.......................
Label, Certif ication . 242
.................
Lane Change, Signaling . 63
..........................
Lap/Shoulder Belt . 34
....................
Lif etime Fuel Mileage . 55
Lights
....................
Bulb Replacement . 203
.......................................
Indicator . 47
.........................................
Parking . 46
..................................
Turn Signal . 63
Index
H I J K L
IV