engine coolant HONDA INSIGHT 2001 1.G Owners Manual

This shows how much f uel you have.
It is most accurate when the car is on
level ground. It may show slightly
more or less than the actual amount
whenyouaredrivingoncurvyor
hilly roads.This shows the temperature of the
engine’s coolant. During normal
operation, the reading should be in
the middle of the gauge. In severe
driving conditions, such as very hot
weather or a long period of uphill
driving, the reading may reach near
the red mark. If it reaches the red
mark, pull saf ely to the side of the
road. Turn to page for
instructions and precautions on
checking the engine’s cooling
system.
The tachometer shows the engine
speed in revolutions per minute
(rpm). To protect the engine f rom
damage, never drive with the
tachometerreadingintheredzone.
226
Temperature Gauge
Fuel Gauge T achometer
Gauges
Inst rument s and Cont rols
58
TTAACCHHOOMMEETTEERR
FFUUEELLGGAAUUGGEE
MMAAIINNTTEENNAANNCCEERREEQQUUIIRREEDDIINNDDIICCAATTOORR
TTRRIIPPBBUUTTTTOONNTTEEMMPPEERRAATTUURREEGGAAUUGGEE
DDIISSPPLLAAYYCCHHAANNGGEEBBUUTTTTOONN
TTRRIIPPMMEETTEERR//OODDOOMMEETTEERR
SSPPEEEEDDOOMMEETTEERR

CONT INUED
The f low-through ventilation system
draws in outside air, circulates it
through the interior, then exhausts it
through vents near the rear window.Turn the temperature control dial
all the way to the lef t.
Select and Fresh Air mode.
Set the f an to the desired speed.
The outside air intakes f or the
heating system are at the base of the
windshield. Keep these clear of
leaves and other debris.
This section covers how to set up the
system controls f or ventilation,
heating, and def rosting.
The engine must be running f or the
heater to generate hot air. The
heater uses engine coolant to warm
the air. If the engine is cold, it will be
several minutes bef ore you f eel
warm air coming f rom the system.
The air conditioning does not rely on
engine temperature.
It is best to leave the system in Fresh
Air mode under almost all conditions.
Keeping the system in Recirculation
mode can cause the windows to f og
up. Switch to Recirculation mode
when you are driving through smoky
or dusty conditions, then switch back
to Fresh Air mode when the
condition clears.
1. 2. 3.
Comf ort and Convenience Feat ures
Vent ilat ion
How to Use the System
Heating
87
RREECCIIRRCCUULLAATTIIOONNBBUUTTTTOONNFFAANNCCOONNTTRROOLLBBUUTTTTOONNSS
MMOODDEEBBUUTTTTOONNTTEEMMPPEERRAATTUURREECCOONNTTRROOLLDDIIAALL

These settings direct all the air f low
to the defroster vents at the base of
the windshield and the side window
def roster vents. The air f low will get
warmer and clear the windows faster
as the engine warms up. You can
close the side vents with the dial
underneath each vent. This will send
more warm air to the windshield
defroster vents.
For saf ety, make sure you have a
clear view through all the windows
bef ore driving away.To shut of f the system temporarily,
stop the fan and turn the
temperature control dial all the way
to the left.
You should shut the system
completely of f only f or the f irst f ew
minutes of driving in cold weather,
until the engine coolant warms up
enough to operate the heater. Keep
the fan on at all other times so stale
air does not build up in the interior.
Heating
Comf ort and Convenience Feat ures
To Turn Everything Of f
89

Bef ore you begin driving your Honda,
youshouldknowwhatgasolineto
use, and how to check the levels of
important f luids. You also need to
know how to properly store luggage
or packages. The inf ormation in this
section will help you. If you plan to
add any accessories to your car,
please read the inf ormation in this
section f irst..............................
Break-in Period . 120
.........................................
Gasoline . 120
.........
Service Station Procedures . 121
................
Filling the Fuel Tank . 121
....................
Opening the Hood . 122
...............................
Oil Check . 124
.........
Engine Coolant Check . 125
...............................
Fuel Economy . 126
.....................
Vehicle Condition . 126
...........................
Driving Habits . 126
...
Accessories and Modif ications . 128
.............................
Carrying Cargo . 130
.................................
Load Limit . 131
Bef ore Driving
Bef ore Driving 119

Remove the dipstick again and
check the level. It should be
between the upper and lower
marks.Look at the coolant level in the
radiator reserve tank. Make sure it is
between the MAX and MIN lines. If
it is below the MIN line, see
on page f or
inf ormation on adding the proper
coolant.
If it is near or below the lower mark,
see on page . Refer to
on page f or inf ormation
on checking other items in your
Honda.
4. 167 171165
A dding
Engine Coolant
A dding Oil Owner Maintenance
Checks
Engine Coolant Check
Service Station Procedures
Bef ore Driving 125
MMAAXX
RREESSEERRVVEETTAANNKK
MMIINNUUPPPPEERRMMAARRKK
LLOOWWEERRMMAARRKK

To maximize f uel economy, your
Insight has an Auto Idle Stop
f unction. Under certain conditions,
the engine will shut of f when you
come to a stop. Those conditions are:The engine coolant is nearly up to
normal operating temperature.
The vehicle’s speed is below 19
mph (30 km/h) and you are
pressing on the brake pedal to
come to a stop.
You depress the clutch pedal.
You are not pressing on the
accelerator pedal.
The IMA battery is sufficiently
charged (at least 1/3 on the
Battery Level Gauge).
The A/C is of f , or in ECON mode
(See pages ). There is adequate vacuum reserve
f or the power brakes.
When these conditions are met, the
engine will shut of f as you come to a
stop. It will start again automatically
when you depress the clutch pedal
and move this shift lever to first gear.
There is no need to start the engine
with the ignition switch.
It is recommended that you move
the shift lever to Neutral and remove
your f oot f rom the clutch pedal while
you are stopped. Sitting with the
clutch pedal depressed and the shif t
lever in gear will cause the engine to
continue running, def eating the f uel
economy benef its of the Auto Idle
Stop f unction. During Auto Stop, the IMA charge
and power brake vacuum reserve is
monitored by the system. If either
drops below a desired level, and the
shif t lever is in Neutral, the engine
will restart so it can recharge the
IMA battery or replenish the vacuum
supply.
84, 93
CONT INUED
5-speed Manual T ransmission
Driving
Auto Idle Stop
137

To maximize f uel economy, your
Insight has an Auto Idle Stop
f unction. Under certain conditions,
the engine will shut of f when you
come to a stop. Those conditions are:The engine coolant is nearly up to
normal operating temperature. During Auto Stop, the IMA charge
and power brake vacuum reserve is
monitored by the system. If the
vacuum reserve drops below an
optimal level, the engine will restart
to replenish the vacuum supply. If
the IMA charge drops below an
optimal level and the shift lever is in
Neutral, the engine will restart to
recharge the IMA battery.
The shift lever is in D or N.
You are not pressing on the
accelerator pedal.
The IMA battery is sufficiently
charged (at least 1/3 on the
Battery Level Gauge).
The A/C is of f , or in ECON mode,
and the outside temperature is
above 41°F (5°C) (See pages , ). There is adequate vacuum reserve
f or the power brakes.
When these conditions are met, the
engine will shut of f as you are
braking to a stop and the vehicle
speed goes below 5 mph (8 km/h).
The engine will start again when you
release the brake pedal. It will also
restart, even if you are still pressing
the brake pedal, under these
conditions:
You move the shif t lever f rom D
orNtoR,L,orP.
You press the accelerator pedal.
You are on an incline, and the
vehicle begins rolling.
93 84
CONT INUED
Driving
Automatic Transmission (CVT)
Auto Idle Stop
145

This section also includes
Maintenance Schedules f or normal
driving and severe driving conditions,
a Maintenance Record, and instruc-
tions f or simple maintenance tasks
you may want to take care of
yourself .
If you have the skills and tools to per-
f orm more complex maintenance
tasks on your Honda, you may want
to purchase the Service Manual. See
page f or inf ormation on how to
obtain a copy, or see your Honda
dealer.
This section explains why it is
important to keep your car well
maintained and to f ollow basic
maintenance saf ety precautions.
......................
Maintenance Saf ety . 154
.
Important Safety Precautions . 155
.................
Maintenance Schedule . 156
....................
Maintenance Record . 163
.......
Owner Maintenance Checks . 165
..............................
Fluid Locations . 166
......................................
Engine Oil . 167
..................................
Adding Oil . 167
....................
Recommended Oil . 167
..............................
Synthetic Oil . 168
....................................
Additives . 168
.....
Changing the Oil and Filter . 169
.............................
Cooling System . 171
............
Adding Engine Coolant . 171
.......
Replacing Engine Coolant . 173
....................
Windshield Washers . 177
.......................
Transmission Fluid . 178
Automatic Transmission .....................................
(CVT) . 178
5-speed Manual
.........................
Transmission . 180
................
Brake and Clutch Fluid . 181
............................
Brake System . 181
...........................
Clutch System . 182
.....................
Air Cleaner Element . 183
....................................
Hood Latch . 184 ...........................................
Battery . 185
.................................
Wiper Blades . 187
..............
Air Conditioning System . 190
..................
DustandPollenFilter .191
.....................................
Drive Belts . 191
...............................................
Tires . 192
......................................
Inf lation . 192
Recommended TirePressures f or Normal
...............................
Driving . 193
..................................
Inspection . 194
..............................
Maintenance . 194
.............................
Tire Rotation . 195
...
Replacing Tires and Wheels . 195
......................
Wheels and Tires . 196
..........................
Winter Driving . 196
.............................
Snow Tires . 197
............................
Tire Chains . 197
.............................................
Lights . 198
........................
Replacing Bulbs . 199
...........................
Storing Your Car . 206
259
Maintenance
Maint enance
153

µ
Ì ÎÌ Ì Î
Follow the Normal Conditions
Maintenance Schedule if the
severe driving conditions
specif ied in the Severe
Conditions Maintenance
Schedule do not apply.
NOTE: If you only
drive under a
‘‘severe’’ condition, you should
f ollow the Normal Conditions
Maintenance Schedule.
Follow the Maintenance
Schedule f or Severe Conditions.
OCCASIONALLY
U.S. Owners
Canadian Owners
Maint enance
158 Visually inspect the following items:
Service at the indicated
distance or time whichever
comes first.
miles x 1,000
km x 1,000
months
Replace every 7,500 miles (12,000 km) or 12 months
Check oil and coolant at each fuel stop
At 120,000 miles (192,000 km) or 120 months,
then every 60,000 miles (96,000 km) or 60 months Every 120,000 miles (192,000 km) or 72 months
Every 36 months (independent of mileage)Rotate tires every 7,500 miles (12,000 km)
Tie rod ends, steering gear box, and boots
Suspension components
Driveshaft boots
Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Cooling system hoses and connections Exhaust system
Fuel lines and connections 152412
304824 609648
457236 75
120 60 90
144
72 105168
84 120192
96
See information on maintenance and emissions warranty, last column, page .
Replace engine oil
Replace engine oil filter
Check engine oil and coolant
Replace air cleaner element
Inspect valve clearance
Replace spark plugs
Inspect and adjust drive belts
Inspect idle speed
Replace engine coolant
Replace transmission fluid
Inspect front and rear brakes
Replace brake fluid
Check parking brake adjustment
Replace dust and pollen filter
Rotate tires (Check tire inflation and condition
at least once per month)
Adjust only if noisy
MTCVT
U.S. model 157
::
Maintenance Schedule for Normal Conditions

ØØ Ø Ø ØØ ØØØØØØØØØ Ø ØØØØØØØ
Î ÌÌ
Ì
Î
Maint enance159
Canadian owners:
A, B, C, D
A B C D
Follow the schedule for Severe Conditions.
Service at the indicated distance or time, whichever comes first. Do the items in as required for each distance/time interval. Follow this
schedule if the severe driving conditions described in the Severe Conditions Schedule on the next page do not apply.
7,500 mi/12,000 km
15,000 mi/24,000 km/1 yrs
22,500 mi/36,000 km
30,000 mi/48,000 km/2 yrs
37,500 mi/60,000 km
45,000 mi/72,000 km/3 yrs
52,500 mi/84,000 km
60,000 mi/96,000 km/4 yrs
67,500 mi/108,000 km
75,000 mi/120,000 km/5 yrs
82,500 mi/132,000 km
90,000 mi/144,000 km/6 yrs
97,500 mi/156,000 km
105,000 mi/168,000 km/7 yrs
112,500 mi/180,000 km
120,000 mi/192,000 km/6 yrs
120,000 mi/192,000 km/8 yrs
120,000 mi/192,000 km/10 yrs
then every 60,000 miles
(96,000 km) or 60 months Do items in A.
Do items in A, B.
Do items in A.
DoitemsinA,B,C.
Do items in A.
DoitemsinA,B,D.
Do items in A.
DoitemsinA,B,C.
Do items in A.
Do items in A, B.
Do items in A.
DoitemsinA,B,C,D.
Do items in A.
Replace spark plugs. Inspect valve clearance.
Check idle speed.
Do items in A, B.
Do items in A. Replace transmission fluid (MT) .
DoitemsinA,B,C. Replace engine coolant. Replace engine oil.
Rotate tires (follow pattern on page 185 ).
Replace engine oil filter.
Inspect front and rear brakes.
Check parking brake adjustment.
Inspect tie rod ends, steering gearbox and boots.
Inspect suspension components.
Inspect driveshaft boots.
Inspect brake hoses and lines (including ABS).
Check all fluid levels, condition of fluids, and check
for leaks.
Inspect cooling system hoses and connections.
Inspect exhaust system.
Inspect fuel lines and connections.
Replace air cleaner element.
Replace dust and pollen filter.
Replace transmission fluid (CVT).
Inspect and adjust drive belts.
Replace brake fluid every 3 years (independent ofmileage).
Replace every 120,000 miles (192,000 km) or 72 months.
See information on maintenance and emissions warranty, last
column, page .
Check engine oil and coolant at each fuel stop.
Check and adjust valve clearance, cold engine, only if noisy. :
··
NOTE: :
157
Maintenance Schedule for Normal Conditions (listed by distance/time)