coolant HONDA INSIGHT 2006 1.G User Guide

Fluid Locations
134
ENGINE OIL
FILL CAP
WASHER FLUID
(Blue cap)
ENGINE OIL DIPSTICK
(Orange loop)BRAKE FLUID
(Gray cap)
ENGINE
COOLANT
RESERVOIR
AUTOMATIC
TRANSMISSION
FLUID DIPSTICK
(CVT)
(Yellow loop)
RADIATOR CAP CLUTCH FLUID
(Gray cap)
(Manual
Transmission
only)

If the reserve tank is completely
empty, you should also check the
coolant level in the radiator.
If the coolant level in the reserve
tank is at or below the MIN line, add
coolant to bring it up to between the
MIN and MAX lines. Inspect the
cooling system f or leaks. Always use Honda Long-Lif e
Antif reeze/Coolant Type 2. This
coolant is pre-mixed with 50 %
antif reeze and 50 % water. Never add
straight antif reeze or plain water.
If Honda antif reeze/coolant is not
available, you may use another
major-brand non-silicate coolant as a
temporaryreplacement.Makesureit
is a high-quality coolant
recommended f or aluminum engines.
Continued use of any non-Honda
coolant can result in corrosion,
causing the cooling system to
malf unction or f ail. Have the cooling
system f lushed and ref illed with
Honda antif reeze/coolant as soon as
possible.
CONT INUED
Engine Coolant
A dding Engine Coolant
Maint enance
139
RESERVE TANK
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

When the radiator and engine are
cool, relieve any pressure in the
cooling system by turning the
radiator cap counterclockwise,
without pressing down.
Remove the radiator cap by
pushing down and turning
counterclockwise.The coolant level should be up to
the base of the f iller neck. Add
coolant if it is low.Put the radiator cap back on, and
tighten it fully.
Pour coolant into the reserve tank.
Fill it to half way between the MAX
and MIN marks. Put the cap back
on the reserve tank.
Do not add any rust inhibitors or
other additives to your vehicle’s
cooling system. They may not be
compatible with the coolant or
engine components.
Pourthecoolantslowlyandcarefully
so you do not spill any. Clean up any
spilled coolant immediately; it could
damage components in the engine
compartment.
2. 3.4.
5.
1.
Engine Coolant
140
RADIATOR CAP RESERVE TANK

Open the hood.
To change the headlight bulb on
the driver’s side, remove the
engine coolant reservoir tank by
pulling it out of its holder.
Theheadlightswereproperlyaimed
when your vehicle was new. If you
regularly carry heavy items in the
cargo area, readjustment may be
required. Adjustments should be
perf ormed by your dealer or other
qualif ied mechanic.
Your vehicle has halogen headlight
bulbs. When replacing a bulb, handle
it by its steel base and protect the
glass from contact with your skin or
hard objects. If you touch the glass,
clean it with denatured alcohol and a
clean cloth.
1.
Lights
Replacing a Headlight Bulb
Headlight A iming
146
HOLDER
Halogen headlight bulbs get very hot
when lit. Oil, perspiration, or a scratch
on the glass can cause the bulb to
overheat and shatter.

CONT INUED
Remove the socket from the
headlight assembly by turning it
one-quarter turn counterclockwise.
Pull the bulb straight out of its
socket.
Install the new bulb into the
socket.
Unclip the end of the hold-down
wire f rom its slot. Pivot it out of
the way, and remove the bulb.
Insert the new bulb into the hole,
making sure the tabs are in their
slots. Pivot the hold-down wire
back in place, and clip the end into
the slot.
Install the rubber seal over the
back of the headlight assembly.
Make sure it is right side up; it is
marked ‘‘TOP’’.
Push the electrical connector onto
the tabs of the new bulb. Make
sure it locks in place.
Turn on the headlights to test the
new bulb.
(Driver’s side)
Reinstall the engine coolant
reserve tank.
Remove the electrical connector
f rom the bulb by squeezing the
connector on both sides to unlock
the tab. Pull the connector straight
off.
Remove the rubber weather seal
by pulling on the tab. 4.
5.
6.
7.
8.
1.
2.
3.
2.
3.
Lights
Replacing a Front Parking Light
Bulb
Maint enance
147
BULB
CONNECTOR WEATHER SEAL
HOLD-DOWN WIRE

CONT INUED
The reading on your vehicle’s
temperature gauge should stay in
the midrange. If it climbs to the red
mark, you should determine the
reason (hot day, driving up a steep
hill, etc.).
If your vehicle overheats, you should
take immediate action. The only
indicationmaybethetemperature
gauge reading reaching the red
mark. Or you may see steam or
spray coming f rom under the hood.If you see steam and/or spray
coming f rom under the hood, turn
of f the engine. Wait until you see
no more signs of steam or spray,
then open the hood.If you do not see steam or spray,
leave the engine running, and
watch the temperature gauge. If
the high heat is due to overloading,
the engine should start to cool
down almost immediately. If it
does, wait until the temperature
gauge reading comes down to the
midpoint, then continue driving.
Saf ely pull to the side of the road.
Put the transmission in neutral or
Park, and set the parking brake.
Turn of f all the accessories, and
turn on the hazard warning lights. If the temperature gauge stays at
the red mark, turn of f the engine.
Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see
on page ).
1.
2. 3.
4.
5.
183
If theEngineOverheats
Emergency
Towing
T aking Care of t he Unexpect ed
177
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
reading at the red mark can cause
serious damage to your engine.

If you do not f ind an obvious leak,
check the coolant level in the
radiator reserve tank. Add coolant
if the level is below the MIN mark.
If there was no coolant in the
reserve tank, you may need to add
coolant to the radiator. Let the
engine cool down until the reading
reaches the middle of the
temperature gauge or lower
bef ore checking the radiator.Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. Af ter the
pressure releases, push down on
the cap, and turn it until it comes
off.
Start the engine, and set the
temperature control dial to
maximum. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.Put the radiator cap back on
tightly. Run the engine, and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair (see
on page ).
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
6.
7.
8.
9.
11.10.
183
If theEngineOverheats
Emergency
Towing
178
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

ÎÎÎ
Î
Î
Î
Î
Î
Specif ications
194
Dimensions
Weights
EngineCapacities
66.7 in (1,695 mm)
53.3 in (1,355 mm)
94.5 in (2,400 mm)
56.5 in (1,435 mm)
52.2 in (1,325 mm) 10.6 US gal (40
)
155.0 in (3,938 mm)
0.61 US gal (2.3)
ILZFR5A-11 10.3 : 1 10.8 : 1
60.8 cu-in (995 cm
)
2.8x3.21in(72x81.5mm)
0.11 US gal (0.4
)
4.8 US qt (4.5
)
5.8 US qt (5.5)
3.5 US qt (3.3)
1.7 US qt (1.6
)
1.6 US qt (1.5)
3.2 US qt (3.0
)
2.4 US qt (2.3)
2.6 US qt (2.5)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating
Type
BorexStroke
Displacement
Compression ratio
Spark plugs Fuel tank
Engine
coolant
Engine oil
Manual transmission
fluid
Automatic transmission
fluid (CVT)
Windshield washer reservoir
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity:
See the certification label attached
to the driver’s doorjamb.
Water cooled 4-strokeSOHC VTEC in line
3-cylinder gasoline engine 1.06 US gal (4.0
)
1.03 US gal (3.9)
Contact your Honda dealer when replacement is necessary. Front
Rear
Approx.
U.S. model
M/T
CVT
1: 2:
3:M/T
CVT
Change
Total
Change
Without filter
Total
Change
Total
Change
Total
4 : Excluding the oil remaining in the engine.
1 32
4
Including filter

Î
................
DANGER, Explanation of . ii
...................................
Dashboard .4, 42
................
Daytime Running Lights . 56
Daytime Running Lights .......................................
Indicator .46
.................................
Dead Battery .175
............
Def ects, Reporting Saf ety . 206
..........................
Def og and Def rost .77
................
Def ogger, Rear Window . 58
................
Def rosting the Windows . 77
....................................
Dimensions .194
...............
Dimming the Headlights . 56
Dipstick Automatic Transmission .....................................
(CVT) .142
....................................
Engine Oil .97
..........................
Directional Signals .56
........
Disc Brake Wear Indicators . 121
.....................
Disposal of Used Oil .138
..................
Display Change Button . 49
Doors ..............
Locking and Unlocking . 62
......................
Power Door Locks .62
..........
DOT Tire Quality Grading . 196
............................
Capacities Chart .194
.............
Carbon Monoxide Hazard . 38
.............................
Carrying Cargo .102
..............
CAUTION, Explanation of . ii
...........................................
CD Care .87
.............
CD Player Error Message . 88
.........
CD Changer Error Message . 89
.........................................
CD Player .85
....................................
Ceiling Light .72
........................
Certif ication Label .192
.................................
Chains, Tires .161
....................
Charge/Assist Gauge .53
....................
Changing a Flat Tire .167
Changing Oil ........................................
How to .136
......................................
When to .129
...
Charging System Indicator . 44,180
............
Checklist, Bef ore Driving . 108
.....................................
Child Saf ety .25
..............................
Booster Seats .35
...................................
Child Seats .30
.....
Important Saf ety Reminders . 28
..........................................
Inf ants .26
............................
Large Children .34 ......................
Risks with Airbags .26
.............................
Small Children .29
.........................................
Tethers .33
.........
Where Should a Child Sit? . 25
Child Seats ................
Installing a Child Seat . 30
....................
Selecting Child Seat . 30
..........
Tether Anchorage Points . 33
................
Climate Control Sensors . 79
.................................................
Clock .91
...................................
Clutch Fluid .145
........................
CO in the Exhaust .199
............
Cold Weather, Starting in . 109
......................
Compact Spare Tire .166
...............
Consumer Inf ormation . 204
.............
Controls, Instruments and . 41
Coolant ........................................
Adding .139
......................................
Checking .98
.........................
Proper Solution .139
...................
Temperature Gauge . 49
Crankcase Emissions Control ........................................
System .199
.....................................
Cup Holders .71
.....................
Current Fuel Mileage .50
.............
Customer Service Of f ice . 204
Index
D
C
II

CONT INUED
Downshif ting, Manual.............................
Transmission .110
...........
Driver and Passenger Safety . 7
...........................................
Driving .107
......................................
Economy .99
..................
Dust and Pollen Filter . 152
................................
Economy, Fuel .99
............
Emergencies on the Road . 165
.............
Battery, Jump Starting . 175
...........
Brake System Indicator . 182
................
Changing a Flat Tire . 167
.....
Charging System Indicator . 180
..................
Checking the Fuses . 186
.............
Hazard Warning Button . 57
............................
Jump Starting .175
.....
Low Oil Pressure Indicator . 179
...
Malf unction Indicator Lamp . 180
..................
Overheated Engine . 177
.......................................
Towing .183
...........................
Emergency Brake .69
......................
Emergency Flashers .57
......................
Emergency Towing .183
.......................
Emissions Controls .199 .............
Emissions Testing, State . 202
Engine ....
Coolant Temperature Gauge . 49
......
Engine Speed Limiter . 111,116
.........................
If It Won’t Start .173
Malf unction Indicator ................................
Lamp .45, 180
........
Oil Pressure Indicator . 44,179
..............
Oil, What Kind to Use . 135
...............................
Overheating .177
............................
Specif ications .194
.......................................
Starting .109
........................
Ethanol in Gasoline .94
.
Evaporative Emissions Controls . 199
...............................
Exhaust Fumes .38
Expectant Mothers, Use of Seat ........................................
Belts by .16
.....................................
Fan, Interior .75
...........................................
Features .73
......................
Filling the Fuel Tank .95
Filter .........................
Dust and Pollen .152
...............................................
Oil .136 .............
Flashers, Hazard Warning . 57
...................
Flat Tire, Changing a . 167
Fluids Automatic Transmission .....................................
(CVT) .142
..........................................
Brake .144
.........................................
Clutch .145
..............
Manual Transmission . 143
..................
Windshield Washer . 141
FM Stereo Radio .....................................
Reception .83
..........................
Four-way Flashers .57
............................
Front Airbags .11, 21
...................................................
Fuel .94
........................
Fill Door and Cap .95
...........................................
Gauge .49
..................
Octane Requirement . 94
.................................
Oxygenated .94
........................
Reserve Indicator .46
..........................
Tank, Filling the .95
.....................
Fuses, Checking the .186
Index
INDEX
E
F
III