coolant HONDA ODYSSEY 1996 User Guide

Cooling System

Do not add any rust inhibitors or
other additives to your car's cooling
system. They may not be compatible
with the coolant or engine compo-
nents.

Replacing Engine Coolant

The cooling system should be completely drained and refilled with
new coolant according to the time
and distance recommendations in
the maintenance schedule. Only use recommended antifreeze.
Draining the coolant requires access
to the underside of the car. Unless
you have the tools and knowledge,
you should have this maintenance done by a skilled mechanic. 1. Start the engine. Turn the heater
temperature control dial to
maximum heat and turn off the
engine. Open the hood. Make sure
the engine and radiator are cool to
the touch.
2. Remove the radiator cap. 3. Loosen the drain plug on the
bottom of the radiator. The
coolant will drain through the
splash guard. Remove the drain
bolt from the engine block.
Maintenance DRAIN BOLT
DRAIN PLUGProCarManuals.comMain Menu s t Table of Contents

Cooling System

RESERVE TANK
RESERVE

TANK CAP

HOLDER

4. Remove the reserve tank from its holder by pulling it straight up.
Drain the coolant, then put the tank back in its holder.
5. When the coolant stops draining, tighten the drain plug in the
bottom of the radiator. Apply non-hardening sealant to the drain bolt
threads and reinstall the bolt in
the engine block. Tighten it securely.
FILLER NECK

Fill up to here
6. Mix the recommended antifreeze with an equal amount of purified
or distilled water in a clean
container. The cooling system

capacity is:6.3 (1.66 US gal, 1.39 Imp gal)

7. Pour coolant into the radiator up
to the base of the filler neck. BLEEDER BOLT
8. Loosen the bleeder bolt on top of the engine. Tighten it again when
coolant comes out in a steady
stream with no bubbles.
9. Refill the radiator to the base of the filler neck. Put the cap on the
radiator, only tighten it to the first
stop. Start the engine and let it run
until it warms up (the radiator
cooling fan comes on at least
twice).
MaintenanceCONTINUED
ProCarManuals.comMain Menu s t Table of Contents

Cooling System, Windshield Washers

10.Turn off the engine. Check the
level in the radiator, add coolant if

needed. Install the radiator cap,

tighten it fully.

11.Fill the reserve tank to the MAX
mark. Install the reserve tank cap.
Windshield Washers

Check the level in the windshield
washer reservoir at least monthly during normal usage. In bad weather,
when you use the washers often, check the level every time you stop

for fuel.

The windshield washer reservoir is located behind the left headlight.Check the reservoir's fluid level by
removing the cap and looking at the
level gauge attached to the cap.
Fill the reservoir with a good-quality
windshield washer fluid. This increases the cleaning capability andprevents freezing in cold weather.
Do not use engine antifreeze or a vinegar/water solution in the wind-
shield washer reservoir.
LEVEL GAUGE

Antifreeze can damage your car's pain while a vinegar/water solution can
damage the windshield washer pump.
Use only commercially-available

windshield washer fluid.

Maintenance
RESERVE TANK

NOTICEProCarManuals.comMain Menu s t Table of Contents

If Your Engine Overheats

The pointer of your car's tempera-
ture gauge should stay in the mid-

range under most conditions. It may

go higher if you are driving up a long
steep hill on a very hot day. If it

climbs to the red mark, you should
determine the reason.

Driving with the temperature gauge
pointer at the red mark can cause serious damage to your engine.
Your car can overheat for several

reasons, such as lack of coolant or a

mechanical problem. The only

indication may be the temperature

gauge climbing to or above the red

mark. Or you may see steam or
spray coming from under the hood.

In either case, you should take

immediate action.
1. Safely pull to the side of the road.
Put the transmission in neutral or
park and set the parking brake.
Turn off the heating and cooling system and all other accessories.
Turn on the hazard warning indicators.
2. If you see steam and/or spray coming from under the hood, turnoff the engine.
3. If you do not see steam or spray, leave the engine running and
watch the temperature gauge. If the high heat is due to overloading (climbing a long, steep hill on a
hot day with the A/C running, for example), the engine should start
to cool down almost immediately. If it does, wait until the tempera-
ture gauge comes down to the mid
point then continue driving.
Taking Care of the Unexpected

NOTICE

Steam and spray from an

overheated engine can

seriously scald you.

Do not open the hood if steam

is coming out.ProCarManuals.coms t Main Menu Table of Contents

If Your Engine Overheats

4. If the temperature gauge stays at the red mark, turn off the engine.
5. Wait until you see no more signs of steam or spray, then open the

hood.

6. Look for any obvious coolant leaks, such as a split radiator hose.
Everything is still extremely hot, so use caution. If you find a leak, it
must be repaired before you continue driving (see Towing on
page 213 ).
7. If you don't find an obvious leak, check the coolant level in the
radiator reserve tank (see page150 ). If the level is below the
MIN mark, add coolant to half-way
between the MIN and MAX marks.
8. If there was no coolant in the reserve tank, you may also have toadd coolant to the radiator. Let the
engine cool down until the pointer reaches the middle of the tempera-
ture gauge, or lower, before check-
ing the radiator.
9. Using gloves or a large heavy cloth, turn the radiator capcounterclockwise, without pushing
down, to the first stop. This
releases any remaining pressure in
the cooling system. After the pressure releases, push down on
the cap and turn it until it comesoff. 10.Start the engine and set the
temperature control lever tomaximum. Add coolant to the
radiator up to the base of the filler
neck. If you do not have the
proper coolant mixture available,
you can add plain water. Remember to have the coolingsystem drained and refilled with
the proper mixture as soon as you
can.

11. Put the radiator cap back on tightly. Run the engine and watch
the temperature gauge. If it goesback to the red mark, the engine
needs repair. (See Towing on
page 213.)
12.If the temperature stays normal, check the coolant level in the
radiator reserve tank. If it has gone down, add coolant to theMAX mark. Put the cap back on

tightly.

Taking Care of the Unexpected

Removing the radiator cap
while the engine is hot can
cause the coolant to spray out, seriously scalding you.
Always let the engine and radiator cool down before
removing the radiator cap.ProCarManuals.comMain Menu s t Table of Contents

Specifications

* 1 : For front A/C only
* 2 : For front and rear A/C *
1 : Including the coolant in the reserve tank and that remaining in the
engine.

Reserve tank capacity:
0.6 (0.16 US gal, 0.13 Imp gal)
* 2 : Excluding the oil remaining in the engine.

Technical InformationProCarManuals.comMain Menu s t Table of Contents

Index

Accessories
Installation.................................. 115

ACCESSORY (Ignition Key
Position)........................................ 50

Adding Automatic Transmission
Fluid........................................ 155
Brake Fluid................................. 156

Engine Coolant........................... 151

Engine Oil................................... 146

Power Steering Fluid................. 157
Windshield Washer Fluid......... 154

Additional Safety Information........ 18

Door Locks................................... 19Driving with Pets......................... 19
Head Restraint Position.............. 18
Seat-back Position........................ 18

Storing Cargo Safely................... 19

Additives, Engine Oil..................... 148
Adjustments
Mirrors.......................................... 64

Head Restraints........................... 56
Seats.............................................. 54

Steering Wheel............................ 44
Airbag (SRS).................................... 12

Air Cleaner..................................... 158

Air Conditioning............................... 74
Maintenance............................... 168

Usage............................................. 74

Air Outlets (Vents).......................... 76

Air Pressure, Tires........................ 170
Alcohol and Drugs........................... 28

Alcohol in Gasoline........................ 108
Antifreeze....................................... 150

Anti-lock Brakes (ABS)
Description................................. 220

Indicator Light..................... 35, 125

Operation.................................... 125

Anti-theft Steering Column Lock.. 49

Appearance Care........................... 183

Ashtray.............................................. 69

Audio System................................... 83

Automatic Speed Control................ 48
Automatic Transmission............... 120
Capacity, Fluid........................... 218

Checking Fluid Level................ 155
Shifting........................................ 120
Shift Lever Positions................. 120
Shift Lock Release..................... 123 Battery
Charging System Light............... 34
Jump Starting............................. 200 Maintenance............................... 162

Specifications............................. 219

Before Driving............................... 107
Belts, Seat........................................... 5
Beverage Holder.............................. 66
Body Repair.................................... 189
Brakes Anti-lock System (ABS)............ 125Break-in, New Linings .............. 108

Fluid............................................ 156

Light, Burned-out...................... 179

Parking.......................................... 65

System Indicator.......................... 34
Wear Indicators......................... 124
Brakes, ABS Description................................. 220Operation.................................... 125
System Indicator.................. 35, 125
Braking System.............................. 124
CONTINUEDProCarManuals.comMain Menu s t

Index
Break-in, New Car......................... 108
Brightness Control, Instruments... 41
Brights, Headlights......................... 40
Bulb Replacement Back-up Lights........................... 179
Brake Lights............................... 179
Ceiling Light............................... 181
Front Parking Lights................. 178
Front Side Marker Lights......... 178
Headlights.................................. 177
License Plate Lights.................. 180 Specifications............................. 219
Turn Signal Lights..................... 178
Bulbs, Halogen............................... 177
Cables, Jump Starting With.......... 200
Capacities Chart............................. 218
Carbon Monoxide Hazard............ 29

Cargo, Loading............................... 116

Cassette Player Care............................................. 101
Operation.............................. 87, 99
CAUTION, Explanation of............. ii
CD Player................................. 90, 102 Center Pocket.................................. 68
Certification Label......................... 216
Chains............................................. 174
Change Oil How to......................................... 148

When to....................................... 140

Changing a Flat Tire..................... 193
Changing Engine Coolant............. 152 Charging System Indicator.... 34, 205
Checking Automatic Transmission
Fluid........................................ 155
Battery Condition...................... 162
Brake Fluid................................. 156
Drive Belts.................................. 169
Engine Coolant........................... 150
Engine Oil................................... 146
Fuses........................................... 209
Power Steering Fluid................. 157
Checklist, Before Driving............. 118
Child Safety...................................... 20 Childproof Door Locks................... 52
Cigarette Lighter............................. 69

Cleaner, Air.................................... 158

Cleaning
Aluminum Wheels..................... 185
Carpeting................................... 186

Exterior...................................... 184

Fabric......................................... 186

Interior....................................... 186

Seat Belts................................... 187

Vinyl........................................... 186
Window...................................... 187

CLEAN Light................................ 101

Clock, Setting the .........................
66

CO in the Exhaust........................
224

Cold Weather, Starting in............ 119

Compact Spare............................... 192

Consumer Information*................ 227

Controls, Instruments and.............. 33

Coolant
Adding........................................

151

Checking................................ 150

Proper Solution......................
150

Temperature Gauge.................. 38

Corrosion Protection.................... 188

Crankcase Emission Control
System........................................ 224

Cruise Control Operation............. 46
Customer Relations Office.......... 229ProCarManuals.comMain Menu s t

Index

DANGER, Explanation of................. ii

Dashboard........................................ 32 Dashboard Compartment............... 68
Daytime Running Lights................. 40Dead Battery, What to Do............ 200
Defects, Reporting Safety............. 232
Defogger, Rear Window................. 43 Defrosting the Windows................. 79
DEXRON® II Automatic Transmission Fluid.................... 155

Dimensions.................................... 218

Dimming the Headlights................ 40
Dipstick Automatic Transmission........... 155

Engine Oil................................... 146

Directional Signals.......................... 43

Disabled, Towing Your Car If..... 213
Disc Brake Wear Indicators......... 124
Disposal of Used Oil...................... 150Doors Locking and Unlocking............... 50
Power Door Locks....................... 50
DOT Tire Quality Grading........... 222
Drive Belts...................................... 169
Driving............................................ 117

Economy..................................... 114

In Bad Weather.......................... 126

In Foreign Countries................. 109

Economy, Fuel............................... 114

Emergencies on the Road............. 191
Battery, Jump Starting.............. 200
Changing a Flat Tire................. 193
Charging System Indicator...... 205
Checking the Fuses................... 209
Low Oil Pressure Indicator...... 204
Malfunction Indicator Lamp.... 206
Manually Closing Sunroof........ 207
Overheated Engine................... 202

Emergency Brake............................ 65
Emergency Flashers....................... 43

Emission Controls......................... 224

Engine
Belts............................................. 169

Coolant Temperature Gauge..... 38
Malfunction Indicator
Lamp................................ 34,
206

Oil Pressur e
Indicator......... 34, 204Oil, What Kind to Use............... 147
Overheating................................ 202
Specifications............................. 219
Ethanol in Gasoline ....................... 109
Evaporative Emission Controls.... 224
Exhaust Fumes................................ 29Expectant Mothers, Use of Seat Belts by......................................... 10
Exterior, Cleaning the................... 184

Fabric, Cleaning............................. 186
Fan, Interior...................................... 74

Features, Comfort and
Convenience............................... 73

Filling the Fuel Tank..................... 110
Filter
Air................................................ 158
Oil................................................ 148

First Gear Position......................... 122
Flashers, Hazard Warning.............. 43

Flat Tire, Changing a.................... 193

CONTINUEDProCarManuals.comMain Menu s t

Index

Fluids
Automatic Transmission........... 155

Brake........................................... 156

Power Steering........................... 157

Windshield Washer................... 154

FM Stereo Radio
Reception.................................... 97

Folding the Second Seats ............... 58

Folding the Third Seats.................. 60

Foreign Countries, Driving in...... 109

Four-way Flashers......................... 43

Front End, Towing by Emergency
Wrecker.................................... 213

Fuel.................................................. 108
Fill Door and Cap....................... 110

Gauge.......................................... 38

Octane Requirement................. 108

Oxygenated................................ 108

Tank, Filling the......................... 110

Fuses, Checking the...................... 209

Gas Mileage, Improving................ 114

Gasohol........................................... 108

Gasoline.......................................... 108
Gauge.......................................... 38

Octane Requirement................. 108

Tank, Filling the......................... 110

Gas Station Procedures................. 110

Gauges Engine Coolant Temperature .... 38

Fuel.............................................. 38

Gearshift Lever Positions............. 120 Glass Cleaning............................... 187
Glove Box......................................... 53
Halogen Headlight Bulbs.............. 177
Hazard Warning Flashers............. 43

Headlights....................................... 40
Aiming......................................... 175Daytime Running Lights............. 40
High Beam Indicator................... 36High Beams, Turning on............ 40
Low Beams, Turning on............. 40
Reminder Chime.......................... 40 Replacing Halogen Bulbs ......... 177

Turning on.................................. 40

Head Restraints............................... 56
Heating and Cooling........................ 74 High Altitude, Starting at............ 119
High-Low Beam Switch............... 40

Hood, Opening the ...................... 111

Horn............................................... 39

Hot Coolant, Warning about...... 151 Hydroplaning................................ 127
Identification Number, Vehicle.. 216
If Your Car Has to be Towed..... 213Ignition
Keys............................................. 49

Switch.......................................... 49

Timing Control System............. 225
Indicator Lights, Instrument

Panel............................................. 33

Infant Restraint............................... 22 Inflation, Proper Tire .................... 170
Inside Mirror................................... 64

Inspection, Tire.............................. 171

Instrument Panel............................. 33

Instrument Panel Brightness........ 41
Interior Cleaning............................ 186
Interior Lights................................. 70

Introduction...................................... iProCarManuals.comMain Menu s t