maintenance schedule HONDA ODYSSEY 1996 User Guide

Maintenance Schedule (Severe Conditions)

Follow the Severe Maintenance
Schedule if you drive your
vehicle MAINLY under one ormore of the following condi-

tions:

Driving less than 8 km (5
miles) per trip or, in freezing
temperatures, driving less
than 16 km (10 miles) per trip. Driving in extremely hot [over 90°F (32°C)] conditions.
Extensive idling or long
periods of stop-and-go driving.
Trailer towing, driving with a car-top carrier, or driving in
mountainous conditions.
Driving on muddy, dusty, or
de-iced roads.

NOTE: If you only
OCCASIONALLY drive under a

"severe" condition, you should

follow the Normal Conditions Maintenance Schedule on the

previous page.

MaintenanceProCarManuals.comMain Menu s t Table of Contents

Non-Scheduled Maintenance Record
Record additional maintenance for severe driving conditions or non-scheduled maintenance on this page (see page 141).

MaintenanceProCarManuals.comMain Menu s t Table of Contents

Engine Oil
The SAE numbers tell you the oil'sviscosity or weight. Select the oil for
your car according to this chart.

Ambient Temperature

An oil with a viscosity of 5W-30 is preferred for improved fuel economy
and year-round protection in your
Honda. You may use a 10W-30 oil if
the temperature in your area never

goes below 20°F ( — 7°C).
Synthetic Oil
You may use a synthetic motor oil if it meets the same requirements
given for conventional motor oil;
energy conserving, a service
classification of SH, and the proper
weight as shown on the chart. When
using synthetic oil, you must follow
the oil and filter change intervals given in the maintenance schedule.
Additives Your Honda does not need any oil additives. Purchasing additives for
the engine or transmission will not increase your car's performance or
longevity. It only increases the cost of operating your car. Oil and Filter Changes
Always change the oil and filter according to the time and distance
recommendations in the mainte-
nance schedule. The oil and filter collect contaminants that can dam-age your engine if they are not
removed regularly.
Changing the oil and filter requires
special tools and access from
underneath the car. The car should
be raised on a service station-type
hydraulic lift for this service. Unless
you have the knowledge and proper equipment, you should have this
maintenance done by a skilled
mechanic.

1. Run the engine until it reaches normal operating temperature,
then shut it off.

MaintenanceProCarManuals.comMain Menu s t Table of Contents

Cooling System

Do not add any rust inhibitors or
other additives to your car's cooling
system. They may not be compatible
with the coolant or engine compo-
nents.

Replacing Engine Coolant

The cooling system should be completely drained and refilled with
new coolant according to the time
and distance recommendations in
the maintenance schedule. Only use recommended antifreeze.
Draining the coolant requires access
to the underside of the car. Unless
you have the tools and knowledge,
you should have this maintenance done by a skilled mechanic. 1. Start the engine. Turn the heater
temperature control dial to
maximum heat and turn off the
engine. Open the hood. Make sure
the engine and radiator are cool to
the touch.
2. Remove the radiator cap. 3. Loosen the drain plug on the
bottom of the radiator. The
coolant will drain through the
splash guard. Remove the drain
bolt from the engine block.
Maintenance DRAIN BOLT
DRAIN PLUGProCarManuals.comMain Menu s t Table of Contents

Automatic Transmission Fluid
Check the fluid level with the engine
at normal operating temperature.
1. Park the car on level ground. Shut off the engine.
2. Remove the dipstick (yellow loop) from the transmission and wipe it
with a clean cloth. UPPER MARK

3. Insert the dipstick all the way into
the transmission.

4. Remove the dipstick and check
the fluid level. It should be

between the upper and lower
marks. 5. If the level is below the lower
mark, add fluid into the tube to
bring it to the upper mark. Use
Honda Premium Formula Auto-
matic Transmission Fluid or an equivalent DEXRON ®
II Auto-
matic Transmission Fluid (ATF)
only.
6. Insert the dipstick all the way back in the transmission.
The transmission should be drained and refilled with new fluid according
to the time and distance recommen- dations in the maintenance schedule.

Maintenance

DIPSTICK

LOWER MARKProCarManuals.comMain Menu s t Table of Contents

Air Cleaner
The air cleaner element should becleaned or replaced according to the
time and distance recommendationsin the maintenance schedule. Cleaning (Severe Conditions)
Clean the air cleaner element by
blowing compressed air through it in the opposite direction to normal air
flow. If you do not have access to compressed air (such as a servicestation), ask your Honda dealer to do
this service.
Follow the replacement procedure
for removal and reinstallation.
The air cleaner element is inside thebox on the passenger's side of theengine compartment.
To replace it:
1. Remove the two pins holding the air intake cover by pulling the
head on each pin. Remove the air
intake cover.
2. Remove the air duct from the air cleaner housing cover.

MaintenanceProCarManuals.comMain Menu s t Table of Contents

Storing Your Car

If you need to park your car for an
extended period (more than 1
month), there are several things you should do to prepare it for storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your car back on the road. It is
best to store your car indoors if at all

possible.
Fill the fuel tank.
Change the engine oil and filter
(see page 148). Wash and dry the exterior

completely.
Clean the interior. Make sure the
carpeting, floor mats, etc. are
completely dry.
Leave the parking brake off. Put
the transmission in Park. Block the rear wheels.
If the car is to be stored for a
longer period, it should be supported on jackstands so the
tires are off the ground.
Leave one window open slightly (if
the car is being stored indoors).
Disconnect the battery.Support the front and rear wiper
blade arms with a folded towel or
rag so they do not touch the
windshield. Apply a silicone spray lubricant to
all door and tailgate seals. Also,
apply wax to the painted surfaces
that mate with the door and
tailgate seals. Cover the car with a "breathable"
car cover, one made from a porous

material such as cotton.

Nonporous materials, such as

plastic sheeting, trap moisture
which can damage the paint. If possible, run the engine for a
while periodically (preferably once
a month).

If you store your car for 12 months or longer, have your Honda dealer
perform the inspections called for in
the 24 months/48,000 km (30,000 miles) maintenance schedule (Normal Conditions) as soon as you
take it out of storage (see page 140 )
The replacements called for in the maintenance schedule are not
needed unless the car has actually
reached that time or mileage.
MaintenanceProCarManuals.comMain Menu s t Table of Contents

Emission Controls
The burning of gasoline in your car's engine produces several byproducts.
Some of these are carbon monoxide (CO), oxides of nitrogen (NOx) and
hydrocarbons (HC). Gasoline
evaporating from the tank also
produces hydrocarbons. Controlling
the production of NOx, CO, and HC
is important to the environment. Under certain conditions of sunlight
and climate, NOx and HC react to
form photochemical "smog." Carbon monoxide does not contribute to
smog creation, but it is a poisonous

gas.
The Clean Air Act
The United States Clean Air Act* sets standards for automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emission controls
work and what to do to maintain
them. This section summarizes how the emission controls work.Scheduled maintenance is on page 140.
* In Canada, Honda vehicles comply
with the Canadian Motor Vehicle Safety Standards (CMVSS) for
Emissions valid at the time they are
manufactured. Crankcase Emission Control
System
Your car has a Positive Crankcase Ventilation System. This keeps
gasses that build up in the engine's crankcase from going into the

atmosphere. The Positive Crankcase

Ventilation valve routes them from the crankcase back to the intakemanifold. They are then drawn into
the engine and burned.
Evaporative Emission Control System
As gasoline evaporates in the fuel
tank, an evaporative emission control
canister filled with charcoal adsorbs
the vapor. It is stored in this canister
while the engine is off. After the
engine is started and warmed up, the

vapor is drawn into the engine and burned during driving.

Technical InformationProCarManuals.comMain Menu s t Table of Contents

Index
Jacking up the Car......................... 195

Jack, Tire........................................ 193
Jump Starting................................. 200
Keys................................................... 49
Label, Certification........................ 216
Lane Change, Signaling.................. 41Lap Belt............................................... 7
Lap/Shoulder Belts........................... 6
Leaking of Exhaust into Car.......... 29
Lighter, Cigarette............................ 69
Lights Headlight Aiming...................... 175Bulb Replacement..................... 177

Indicator........................................ 33

Parking.......................................... 40
Turn Signal................................... 41
Loading Cargo................................ 116
LOCK (Ignition Key Position)....... 50 Locks
Anti-theft Steering Column........ 49
Fuel Fill Door............................. 110Glove Box..................................... 53
Power Door.................................. 50
Tailgate......................................... 52
Low Coolant Level......................... 150 Low Oil Pressure Indicator.... 34, 204
Lubricant Specifications Chart.... 218
Luggage.......................................... 116
Maintenance................................... 135 Periodic Items............................ 144

Record.................................. 142-143

Required Indicator....................... 38
Safety........................................... 136Schedule.............................. 138-141
Malfunction Indicator Lamp.. 34, 206 Maximum Speeds.......................... 123
Meters, Gauges................................ 37
Methanol in Gasoline.................... 109

Mirrors, Adjusting...........................
64

Neutral Gea r
Position.................... 122
New Vehicle Break-in ................... 108
NOTICE, Explanation of................... ii
Numbers, Identification................ 216

Occupant Protection System............ 4
Octane Requirement, Gasoline.... 108

Odometer.......................................... 37

Odometer, Trip................................ 37

Oil Change, How to......................... 148

Change, When to....................... 140

Checking Engine....................... 146
Pressure Indicator....................... 34

Selecting Proper Viscosity
Chart....................................... 148

ON (Ignition Key Position)............ 50

Opening the Hood......................... 111

Operation in Foreign Countries... 109

CONTINUEDProCarManuals.comMain Menu s t

Index

Outside Mirrors............................... 64
Overheating, Engine..................... 202
Panel Brightness Control............... 41

Park Gear Position......................... 121

Parking Brake.................................. 65

Parking Lights.................................. 40

Parking Over Things that Burn... 226

PGM-FI System.............................. 225

Polishing and Waxing................... 184

Power
Door Locks................................... 50

Mirrors.......................................... 64

Steering....................................... 157

Windows....................................... 62

Pregnancy, Using Seat Belts.......... 10
Proper Seat Belt Usage..................... 7

Radiator Overheating.................... 202
Radio/Cassette Sound System....... 83
Rear A/C Unit.................................. 82
Rear End Towing........................... 213 Rear Lights, Bulb Replacement... 179
Rear View Mirror............................. 64
Rear Window Defogger.................. 43
Rear Window Wiper and Washer.. 43
Reclining the Seat Backs................ 55
Reclining the Second Seats............ 59
Reminder Lights.............................. 33
Remote Transmitter........................ 51
Removing the Second Seats........... 57
Replacement Information Air Cleaner................................. 158Coolant........................................ 152
Engine Oil and Filter................. 148
Fuses........................................... 209

Light Bulbs................................. 177

Schedule..................................... 138

Spark Plugs................................. 160

Tires............................................ 172

Wiper Blades.............................. 165
Replacing Seat Belts After a
Crash............................................. 11

Reserve Tank, Coolant.................. 150

Restraint, Child................................ 20

Reverse Gear Position................... 121

Rotation, Tire................................. 172
Safety Belts....................................... 5

Safety Defects, Reporting*.......... 232

Safety Labels, Location of............. 30

Safely Messages .............................. ii
Seat Belts ......................................... 5

Advice for Pregnant Women...... 10Cleaning...................................... 187
Frayed or Torn............................ 11

Maintenance............................... 11

Reminder Light and Beeper....... 34
Replacement................................ 11

System Components.................... 6
Tether Attachment Points........ 26 Use During Pregnancy................ 10
Wearing a Lap/Shoulder Belt..... 7
Wearing the Lap Belt................... 9

Seats................................................. 54
Adjustments ................................ 54
Driver's Seat Power
Height Adjustment................
55

Folding th e
Second Seats..........

58

Folding th
e
Third Seats............ 60

Head Restraints .......................... 56
Passenger Seating......................

54
ProCarManuals.comMain Menu s t