engine coolant HONDA PASSPORT 2002 2.G User Guide

219Care and Maintenance
(–36

C) to ensure protection
against corrosion and loss of
engine coolant from boiling.
This should be done even if
freezing temperatures are not
expected.
•Add ethylene glycol-based
antifreeze when antifreeze has
to be added because of engine
coolant loss or if more
protection against freezing at
temperatures lower than –33
F
(–36
C) is needed. Do not use
an alcohol-based or
methanol-based antifreeze, or
plain water. They boil at a
lower point, and do not provide
corrosion protection.
Thermostat
The engine coolant temperature is
controlled by a thermostat, which
stops engine coolant flow through
the radiator until a preset
temperature is reached. This
thermostat is installed in the
engine coolant inlet on the front
of the engine block. The same
thermostat is used in both winter
and summer.Brake Master Cylinder
Check the master cylinder fluid
level in the reservoir every time
you check the engine oil level.
The level should be between the
MAX and ADD level line. If the
level is lower than the
ADD level
line, fill to the
MAX level line
with
DOT-3 or DOT-4 fluid.
Other Required
Maintenance

223Care and Maintenance
Spark Plugs
Replace the spark plugs with the
type specified in the “Technical
Data” section.
Clutch
Check the clutch play at the pedal.
Lubricate the clutch pedal bushing
and clevis pin, at the intervals
shown in the Maintenance
Schedule, with water-resistant
chassis lubricant. If you hear a
squeaking noise coming from the
area of the bushing or clevis pin at
the clutch pedal arm when the
clutch pedal is depressed,
lubricate it with water-resistant
EP
chassis grease.
Check the fluid level in the clutch
reservoir at the interval shown in
the Maintenance Schedule. If the
fluid is low in the reservoir, it should be filled to the maximum
level line with
DOT-3 or DOT-4
fluid.
Fluid or Lubricant Levels
Check the fluid or lubricant level
in the brake master cylinder,
clutch master cylinder, power
steering reservoir, rear axle,
engine and transmission,
windshield washer reservoir and
engine coolant at specified
intervals.
Power Steering
Check the fluid level in the power
steering fluid reservoir as
recommended in the Maintenance
Schedule. The fluid level should
be between the “
MIN” and
“
MAX” marks on the reservoir.
Use only automatic transmission
fluid labeled
DEXRON III.

256
Break-in158. . . . . . . . . . . . . . .
Fluid
219. . . . . . . . . . . . . . . . . .
Parking
86. . . . . . . . . . . . . . . .
Power
161. . . . . . . . . . . . . . . . .
Wear Indicators
162. . . . . . . . .
Break-in, New Vehicle
158. . . . . .
Brightness Control, Instrument Panel. See Illumination Control
Brights, Headlights
62. . . . . . . .
Bulb Replacement Specifications
243. . . . . . . . . . . .
C
Capacity Charts235. . . . . . . . . . .
Carbon Monoxide Hazard
47. . .
Care and Maintenance
195. . . . . .
Cargo Loading
233. . . . . . . . . . . . . . .
Carrying
17 . . . . . . . . . . . . . . . Cassette Player
Care
141. . . . . . . . . . . . . . . . . .
Operation
128. . . . . . . . . . . . . .
Catalytic Converter, Three-Way
172. . . . . . . . . . . . . .
CAUTION, Explanation ofiv. . .
CD Changer131. . . . . . . . . . . . . .
Certification Label
234. . . . . . . . .
Chains, Tire
168. . . . . . . . . . . . . .
Changing Oil How to
212. . . . . . . . . . . . . . . .
When
204, 205, 211. . . . . . . . .
Changing a Flat Tire
186. . . . . . .
Lifting Points
187. . . . . . . . . . .
Changing Engine Coolant
218. . .
Charging System Indicator
62. .
Check Engine Light
63. . . . . . . .
Checklist, Before Driving
156. . . Children, Protecting
18. . . . . . . .
Child-Safe Door Locks
105. . . . .
Child Seats, General Guidelines
22. . . . . . .
Cigarette Lighter
116. . . . . . . . . .
Circuit Breaker, Checking the
108
Cleaner, Air214. . . . . . . . . . . . . .
Cleaning Exterior
224. . . . . . . . . . . . . . .
Interior
226. . . . . . . . . . . . . . . .
Seat Belts
229. . . . . . . . . . . . . .
Vinyl
229. . . . . . . . . . . . . . . . .
Clock, Setting the
153. . . . . . . . . .
Clutch Fluid
223. . . . . . . . . . . . . .
CO in the Exhaust
47, 249. . . . . .
Consumer Information
246. . . . . .
Control Locations
56. . . . . . . . .
Controls, Instruments and
55. . .

257

Controls Near
the Steering Wheel
Hazard Warning
76. . . . . . . . .
Headlights
72. . . . . . . . . . . . .
Illumination Control
73. . . . .
Rear Window Defogger
74. . .
Steering Wheel Adjustment
115
Turn Signals75. . . . . . . . . . . .
Windshield Wiper/Washer
70.
Rear Window Wiper/ Washer
74. . . . . . . . . . . .
Coolant Adding
218. . . . . . . . . . . . . . . .
Capacity
236. . . . . . . . . . . . . . .
Checking
217. . . . . . . . . . . . . .
Proper Solution
218. . . . . . . . .
Temperature Gauge
60. . . . . .
Corrosion Protection
225. . . . . . .
Courtesy Lights
112. . . . . . . . . . . Crankcase Emissions
Control System
249. . . . . . . . . .
Cruise Control Operation
147. . . .
Customer Relations Information
246. . . . . . . . . . . . .
D
DANGER, Explanation ofiv. . . .
Dashboard
56. . . . . . . . . . . . . . .
Defects, Reporting Safety
248. . .
Defogger, Rear Window
74. . . .
Defrosting the Windows
122. . . .

\b 153
\b\b\b\b\b\b\b\b\b\b\b\b\
\b\b\b
Dimensions243. . . . . . . . . . . . . .
Dimming the Headlights
72. . . .
Dipstick, Engine Oil
200, 213. . .
Directional Signals
75. . . . . . . . . Disc Brake Wear Indicators
162. .
Dome Light
111. . . . . . . . . . . . . .
Door Locks
9. . . . . . . . . . . . . . . .
Power
104. . . . . . . . . . . . . . . . .
Doors, Close and Lock
10. . . . . .
DOT Tire Quality Grading
251. . .
Downshifting, 5-Speed Manual Transmission
84. . . . .
Drive Belts
222. . . . . . . . . . . . . . .
Driving, On-Road Fuel Economy
170. . . . . . . . . .
In Bad Weather
168. . . . . . . . .
In Foreign Countries
173. . . . .
On Slippery Surfaces
162. . . . .
E
Economy, Fuel170. . . . . . . . . . . .
EGR System
250. . . . . . . . . . . . . .
Emergency Brake
86. . . . . . . . . .

258
Emergency Flashers76. . . . . . . .
Emergency, In Case of
183. . . . . .
Charging System Indicator
62
Check Engine Light63. . . . . .
Checking the Fuses
193. . . . . .
Engine Overheating
190. . . . . .
Jump Starting
184. . . . . . . . . . .
Malfunction Indicator Lamp
63
Oil Pressure Indicator65. . . .
Emissions Controls
248. . . . . . . .
Engine Belts
222. . . . . . . . . . . . . . . . . .
Break-in
158. . . . . . . . . . . . . . .
Check Light
63. . . . . . . . . . . .
Coolant Temperature Gauge
60
Identification Number232. . . .
Malfunction Indicator Lamp
63
Oil Capacity
235. . . . . . . . . . . . .
Recommendation
198. . . . . . Oil Pressure Indicator
65. . . .
Specifications
235. . . . . . . . . .
Starting
157. . . . . . . . . . . . . . .
Ethanol in Gasoline
201. . . . . . . .
Evaporative Emissions Controls
249. . . . . . .
Exhaust Fumes
47. . . . . . . . . . . .
Expectant Mothers, Use of Seat Belts by
16. . . . . .
Exterior, Cleaning the
224. . . . . .
F
Fabric, Cleaning. See Interior Cleaning
Fan Control Lever
121. . . . . . . . .
Features, Comfort and Convenience
119. .
Filling the Fuel Tank
197. . . . . . . Filters
Air
214. . . . . . . . . . . . . . . . . . .
Oil
212. . . . . . . . . . . . . . . . . . .
5-Speed Manual Transmission Checking Fluid Level
215. . . .
Shifting
83. . . . . . . . . . . . . . .
Flashers, Hazard Warning
76. . .
Flat Tire, Changing a
186. . . . . . .
Fluids Automatic Transmission
216. .
Capacity
237. . . . . . . . . . . . .
Brake
219. . . . . . . . . . . . . . . . .
Clutch
223. . . . . . . . . . . . . . . .
5-Speed Manual Transmission
215. . . . . . . . . .
Capacity
237. . . . . . . . . . . . .
Power Steering
223. . . . . . . . . .
Windshield Washer
71. . . . . .
FM Stereo Radio Reception
136. . . . . . . . .
Folding the Rear Seat
94. . . . . . .

259
Foreign Countries, Operation in
173. . . . . . . . . . . . .
Fuel Filling the Fuel Tank
197. . . . .
Fuel Fill Cap
197. . . . . . . . . . .
Fuel Gauge
59. . . . . . . . . . . . .
Low Fuel Indicator
64. . . . . .
Octane Requirement
200. . . . .
Oxygenated
200. . . . . . . . . . . .
Recommendation
198. . . . . . . .
Tank Capacity
198, 237. . . . . .
Fuel Injection System
249. . . . . .
Fuses Checking the
193, 240. . . . . . .
Locations
240. . . . . . . . . . . . . .
G
Gas Mileage, Improving170. . . . Gasohol
200. . . . . . . . . . . . . . . . .
Gasoline
200. . . . . . . . . . . . . . . . .
See also Fuel
Octane Requirement
200. . . . .
Tank, Filling the
197. . . . . . . . . . . .
Gas Station Procedures
197. . . . .
Gauges Engine Coolant Temperature
60. . . . . . . . . . .
Fuel
59. . . . . . . . . . . . . . . . . .
Speedometer
58. . . . . . . . . . .
Tachometer
58. . . . . . . . . . . .
GAWR (Gross Axle
Weight Rating)
233. . . . . . . . . . .
Gearshift Lever Positions Automatic Transmission
76. .
5-Speed Transmission
83. . . .
Glass Cleaning
230. . . . . . . . . . . . Glove Box
114. . . . . . . . . . . . . . .
GVWR (Gross Vehicle
Weight Rating)
233. . . . . . . . . .
H
Halogen Headlight Bulbs243. . . .
Hazard Warning Flasher
76. . . .
Head Restraints
8, 12, 93. . . . . . .
Headlights
72. . . . . . . . . . . . . . .
High Beam Indicator
62. . . . .
High Beams
72. . . . . . . . . . . .
On, Reminder
73. . . . . . . . . .
Replacing Halogen Bulbs
243.
Turning on
72. . . . . . . . . . . . .
Heating and Cooling
120. . . . . . .
High-Low Beam Switch
72. . . .
Hood Release
109, 199. . . . . . . . .
Horn
115. . . . . . . . . . . . . . . . . . . .
Hydroplaning
168. . . . . . . . . . . . .

261
Low Coolant Level217. . . . . . . .
Low Oil Pressure Indicator
65. .
Lower Gear, Downshifting to a
84
Lubricant Specifications Charts
235. . . . . .
Luggage, Loading
175, 233. . . . .
Luggage Light
110. . . . . . . . . . . .
M
Maintenance195. . . . . . . . . . . . . .
Periodic Checks. See Owner Safety Checks
Record
206, 207. . . . . . . . . . . .
Safety
201. . . . . . . . . . . . . . . . .
Schedule
203, 204, 20. . . . . .
Malfunction Indicator Lamp
63.
Map Light
112. . . . . . . . . . . . . . .
Meters, Gauges
58. . . . . . . . . . . Methanol in Gasoline
201. . . . . . .
Mirror Adjusting the
105. . . . . . . . . . .
Defogger
74. . . . . . . . . . . . . .
Vanity
106. . . . . . . . . . . . . . . . .
Moonroof
112. . . . . . . . . . . . . . . .
N
Neutral Gear Position77. . . . . . .
New Vehicle Break-In
158. . . . . .
Normal Shift Speeds
84. . . . . . .
NOTICE, Explanation of
i. . . . . .
Numbers, Identifications
232. . . .
O
Octane Requirement, Gasoline
200. . . . . . . . . . . . . . . .
Odometer, Trip
58. . . . . . . . . . . . Off-Road Driving. See the
Off-Road Driving Information
booklet in your owner’s packet.
Oil ChangeHow to
212. . . . . . . . . . . . . .
When to
204, 205, 211. . . . .
Checking Engine
213. . . . . . . .
Front and Rear Axle
216. . . . .
Pressure Indicator
65. . . . . . .
Selecting Proper Viscosity Chart
213. . . . . . . .
ON (Ignition Key Position)
101. .
Opening the Hood
109. . . . . . . . .
Opening the Tailgate
108. . . . . . .
Opening the Windows
107. . . . . .
Operation in Foreign Countries
173. . . . . . . .
Ordering Service Parts
232. . . . . .
Overheating, Engine
190. . . . . . .

263
Rear Seat, Folding94. . . . . . . . .
Rear View Mirror
105. . . . . . . . . .
Rear Window Defogger
74. . . . .
Rear Window Wiper and Washer
74. . . . . . . . . . . . .
Reclining the Seat-Backs Front
11, 91, 93. . . . . . . . . . . .
Rear
97. . . . . . . . . . . . . . . . . .
Recommended Shift Speeds
84.
Reduced Power Indicator
\b 64. . .
Replacement Information Air Cleaner Element
214. . . . .
Coolant
204, 218. . . . . . . . . . .
Engine Oil and Filter
211. . . . .
Fuses
240. . . . . . . . . . . . . . . . .
Light Bulbs
243. . . . . . . . . . . .
Schedule
204. . . . . . . . . . . . . .
Spark Plugs
235. . . . . . . . . . . . Tires
166. . . . . . . . . . . . . . . . . .
Replacing Seat Belts After a Crash
43. . . . . . . . . . . .
Reporting Safety Defects
248. . . .
Reserve Tank, Coolant
217. . . . . .
Restraint, Child
18. . . . . . . . . . .
Reverse Gear Position
77. . . . . .
Rotation, Tire
166. . . . . . . . . . . . .
Rust Protection
225. . . . . . . . . . . .
S
Safety Defects, Reporting248. . .
Safety Labels, Location of
48. . .
Safety Messages
iv. . . . . . . . . . . .
Seat Belts
4, 6. . . . . . . . . . . . . . . .


\b 
 41
\b\b\b\b\b
Maintenance42. . . . . . . . .
System Components
41
\b\b\b\b
Advice for Pregnant Women16
Cleaning229. . . . . . . . . . . . . . .
Fasten and Positio
13
\b\b\b\b\b\b\b
Lap Belt42
\b\b\b\b\b\b\b\b\b\b\b\b\
\b\b\b\b\b
Lap/Shoulder Belt41
\b\b\b\b\b\b\b\b
Reminder Light6, 41, 61. . . . .
Seats
8, 89. . . . . . . . . . . . . . . . . . .
Adjusting the
90. . . . . . . . . . .
Seat-Backs
8, 91, 92, 97
\b\b\b\b\b\b\b
Self-Adjusting Brakes162. . . . . .
Serial Number
232. . . . . . . . . . . .
Service Intervals
204, 205, 206, 207. . . . .
Service Manual
253. . . . . . . . . . .
Service Station Information
197. .
Setting the Clock
153. . . . . . . . . .
Shift Lever Position Indicator
76
Shift-on-the-Fly System220. . . . .
Fluid Capacity
239. . . . . . . . . .
Side Marker Lights Bulb Replacement
243. . . . . . . .