light HONDA PILOT 2005 1.G Repair Manual

If you cannot drive the vehicle
without f ixing the problem, and you
do not have a spare fuse, take a fuse
of the same rating or a lower rating
f rom one of the other circuits. Make
sureyoucandowithoutthatcircuit
temporarily (such as the accessory
power socket or radio).
If you replace the blown f use with a
spare f use that has a lower rating, it
might blow out again. This does not
indicate anything wrong. Replace the
f use with one of the correct rating as
soon as you can.If the replacement fuse of the
same rating blows in a short time,
there is probably a serious
electrical problem with your
vehicle. Leave the blown fuse in
that circuit, and have your vehicle
checked by a qualif ied mechanic.
If a trailer light is burned out, check
if these f uses are blown when you
replace the light bulbs:
If thosefusesareOK,butthetrailer
lights still do not work, there are two
blown 7.5 amp f uses in the trailer
hitch wiring. To access the 7.5 amp
f uses:
Open the tailgate and remove the
cargo f loor lid.
Pull out the bottom of the tailgate
rubber seal.
Remove rear trim panel by pulling
up on the inside edge of the rear
trim panel, and unhooking the f our
clips and tabs.
Af ter replacing f uses, and reinstall
the rear trim panel in the reverse
order of removal. Primary under-hood f use box
fuses5,7,and24
Interior driver’s side f use box: 10
Interior passenger’s side f use box:
10
If the radio f use is removed, the
audio system will disable itself . The
nexttimeyouturnontheradioyou
will see ‘‘COdE’’ in the f requency
display. Use the preset buttons to
enter the f ive-digit code (see page ).
6.
1.
2.
3.
4.
123
On EX and EX-L model
Trailer Fuses
Fuses
240
Replacing a f use with one that has a
higher rating greatly increases the
chances of damaging the electrical
system. If you do not have a
replacement f use with the proper rating
f or the circuit, install one with a lower
rating.

µµ
No. Amps. Circuits Protected No. Circuits Protected
No. Amps. Circuits Protected No. Amps. Circuits Protected Amps.
1
2
3
4
5
6
7
8
9
10
11
12
13 20 A
30 A
20 A
15 A
15 A
20 A
20 A
20 A
40 A
40 A
30 A
40 A Spare Fuse
Spare Fuse
Right Headlight
ACG S
Hazard
Not used
Stop
Lef t Headlight
Radio
Power Window Motor
Power Seat
Rear Defroster
Back Up, ACC 14
15
16
17
18
19
20
21
22
23
24
Rear A/C
Heater Motor
Cooling Fan
Spare Fuse
Spare Fuse
Spare Fuse
Battery
Condenser Fan
MG Clutch
IGI Main
Trailer (accessory)
1
2
3
4
5
6 40 A
20 A
30 A
40 A
20 A
20 A ABS F/S Relay
VSA F/S Relay
VSA Motor
ABS Motor
4WD
Rear Accessory Socket 7
8
9
10
11 15 A
15 A
15 A
7.5 A
(15 A) ET CS
IG Coil
LAF
TPMS
(FR FOG)
30 A
40 A
30 A
7.5 A 10 A
15 A
120 A 30 A
7.5 A 50 A
Fuse Locations
T aking Care of t he Unexpect ed
241
PRIMARY UNDER-HOOD FUSE BOX
SECONDARY UNDER-HOOD FUSE BOX

µµ
Î Î
Î Î
Î
No. No.
Amps. Amps.
Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
15 A
10 A
7.5 A
7.5 A
7.5 A 15 A
7.5 A
7.5 A 10 A
7.5 A
7.5 A 30 A 20 A
20 A
20 A
20 A
10 A
20 A
20 A
15 A
15 A
10 A
20 A
7.5 A
7.5 A 20 A
20 A
Fuel Pump
SRS
Heater Control, A/C Clutch
Relay, Cooling Fan Relay
Power Mirror, VTM-4
Daytime Running Light
ECU(PCM),CruiseControl
OPDS, Rear Wiper
ACC Relay
Back-up Lights, Instrument
Lights
Turn Signals
VTM-4
Front Wiper
Not used
Driver’s Power Window
Driver’s Power Seat Reclining
Heated Seat
Driver’s Power Seat Sliding
Not used
Daytime Running Light
Driver’s side Rear Power
Window
Front Passenger’s Power
Window
Front Accessory Socket, Radio
Small Light
Interior Light, Navi
Power Door Lock
Back Up
Moonroof
Moonroof
Passenger’s Side Rear Power
Window
Canadian models
:
Canadian models
Fuse Locations
242
Driver’s Side INTERIOR FUSE BOX
Passenger’s Side
Front Front
:

µ µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Specif ications
T echnical Inf ormation
247
Battery
Fuses
Engine
Alignment
Tires
Lights
60 W/55 W
12 V
60 psi (420 kPa , 4.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm)
T155/90D16 110M P235/70R16 104S 1°88’
0°50’ 0°50’
0.00 in (0.0 mm)
0.00 in (0.0 mm) 10.0 : 1
211.8 cu-in (3,471 cm
)
3.50 x 3.66 in (89.0 x 93.0 mm)
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V 12 V
12 V
12 V
5W
27 W/8 W
5W
21 W/5 W
21 W/5 W
21 CP (18 W)
5W
18 W
6.2 W
5W
1.1 W
3.8 W
12 V 65 AH/20 HR 14 V 12 V 12.4 W 1.4 W
Capacity Interior
Under-hood
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Water cooled 4-stroke SOHC,
V6 gasoline engine
Toe-in
Camber
Caster
Size
Pressure IZFR5K-11
SKJ16DR-M11
Headlights
Front side marker lights
Front turn signal lights/
Parking lights
Rear side marker lights
Rear turn signal/hazard lights
Stop/Taillights
Backup lights
License plate lights
High-mount brake light
Individual map lights
Tailgate light
Vanity mirror light
Door (Courtesy) light
Grab rail lights
Console lights See page
242or the fuse label
attached to the dashboard.
See page 242or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 241or the fuse box
cover.
Front/Rear
Spare
Front/Rear
Spare Front
Rear
Front
Rear
Front
Driver’s side
Passenger’s side
(1157 NA)
(168)
(7443)
(7443) (921)
(168)
(921)
(204)
(HB2)
(168)
Front
Rear
Front
Rear
Front NGK:
DENSO:

ÎÎIn Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive crankcase ventilation valve routes
them from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx) and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas.
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
164
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
The Clean Air Act
Emissions Cont rols
T echnical Inf ormation
251

If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.Make sure the gas tank is nearly,
but not completely f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F.
Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Keep the vehicle in Park. Increase
the engine speed to 2,000 rpm, and
hold it there until the temperature
gauge rises to at least 1/4 of the
scale (about 3 minutes).
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D. Do not use the cruise control.
When traffic allows, drive for 90
seconds without moving the
accelerator pedal. (Vehicle speed
may vary slightly; this is okay.) If
you cannot do this f or a
continuous 90 seconds because of
traf f ic conditions, drive f or at least
30 seconds, then repeat it two
more times (for a total of 90
seconds).
T esting of Readiness Codes
St at e Emissions T est ing
254

CONT INUED
............................
Capacities Chart .246
.............
Carbon Monoxide Hazard . 53
.............................
Carrying Cargo .153
..............
CAUTION, Explanation of . ii
..........................
CD Changer .113, 114
.......................................
CD Player .111
........................
Certif ication Label .244
............................................
Chains .220
....................
Changing a Flat Tire .225
...
Accessories and Modif ications . 151
ACCESSORY (Ignition Key .......................................
Position) .77
..............
Accessory Power Sockets . 95
....................
Additives, Engine Oil . 199
.............................
Airbag (SRS) .11, 23
..........
Airbag System Components . 23
..............
Air Conditioning System . 100
.....................
Rear A/C Control .105
.......................
Air Pressure, Tires .217
......................................
Antif reeze .202
Anti-lock Brakes (ABS) ...............................
Indicator .59, 169
...................................
Operation .169
..............
Anti-thef t, Audio System . 123
.
Anti-thef t Steering Column Lock . 77
................
Audio System . 106,109,119
...
Automatic Seat Belt Tensioners . 21
.............
Automatic Speed Control . 138
..............
Automatic Transmission . 160
..........................
Capacity, Fluid .204
...............
Checking Fluid Level . 204
.......................................
Shif ting .160
.
Shif t Lever Position Indicator . 160................
Shif t Lever Positions . 161
....................
Shif t Lock Release . 163
Battery Charging System ...........................
Indicator .58, 234
............................
Jump Starting .230
..............................
Maintenance .221
............................
Specif ications .247
..............................
Bef ore Driving .145
..................................
Belts, Seat .10, 20
...........................
Beverage Holders .95
..................................
Booster Seats .50
Brakes ...........
Anti-lock System (ABS) . 169
.............
Break-in, New Linings . 146
...........................................
Fluid .206
....................
Bulb Replacement .210
.........................................
Parking .93
.................
System Indicator . 59,236
........................
Wear Indicators .168
.............................
Braking System .168
.................
Break-in, New Vehicle . 146
..
Brightness Control, Instruments . 72........................
Brights, Headlights .71
Bulb Replacement .....................
Brake Lights .210, 211
..........................
Back-up Lights .210
................
Front Parking Lights . 209
........
Front Side Marker Lights . 212
.................................
Headlights .208
........
High-mount Brake Lights . 211
.................................
Rear Bulbs .210
............................
Specif ications .247
.............
Turn Signal Light . 209,210
..............................
Bulbs, Halogen .208
Index
A
B
C
INDEX
I

..............................
Economy, Fuel .150
............
Emergencies on the Road . 223
.............
Battery, Jump Starting . 230
...........
Brake System Indicator . 236
................
Changing a Flat Tire . 225
.....
Charging System Indicator . 234
..................
Checking the Fuses . 239
.....
Low Oil Pressure Indicator . 234
...
Malf unction Indicator Lamp . 235
..................
Overheated Engine . 232
...........................
Emergency Brake .93
......................
Emergency Flashers .73
......................
Emergency Towing .237
.......................
Emissions Controls .251
.............
Emissions Testing, State . 254
Engine ....
Coolant Temperature Gauge . 67
Malf unction Indicator ................................
Lamp .58, 235
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 56
................
Daytime Running Lights . 72
Daytime Running Lights .......................................
Indicator .63
.................................
Dead Battery .230
............
Def ects, Reporting Saf ety . 260
................
Def ogger, Rear Window . 73
......
Def rosting the Windows . 101,103
....................................
Dimensions .246
...............
Dimming the Headlights . 71
Dipstick ..........
Automatic Transmission . 204
..................................
Engine Oil .149
....................
Directional Signals . 62,71
........
Disc Brake Wear Indicators . 169
.....................
Disposal of Used Oil .201
Doors ..............
Locking and Unlocking . 78
..........
DOT Tire Quality Grading . 248
...........
Driver and Passenger Safety . 7...........................................
Driving .157
....................................
Economy .150
...................................
DVD Player .125
........
DVD Player Error Message . 134
Change Oil
........................................
How to .200
.............................
When to .192, 193
...
Charging System Indicator . 58,234
............
Checklist, Bef ore Driving . 158
..................
Childproof Door Locks . 79
Child Seats .........................................
LATCH .43
..........
Tether Anchorage Points . 47
...............
Climate Control System . 104
.........................
Clock, Setting the .124
.....................
Code, Audio System .123
........................
CO in the Exhaust .251
............
Cold Weather, Starting in . 159
......................
Compact Spare Tire .224
...................
Console Compartment . 95
.................
Consumer Inf ormation . 258
.............
Controls, Instruments and . 55
Coolant ........................................
Adding .202
....................................
Checking .149
.........................
Proper Solution .202
...................
Temperature Gauge . 66
Crankcase Emissions Control ........................................
System .251
............
Cruise Control Operation . 138 ....
Customer Service Inf ormation . 258
Index
D
E
II

CONT INUED
.............
Halogen Headlight Bulbs . 212
.................
Hazard Warning Button . 73
........................................
Headlights .71
........................................
Aiming .208
..............
Automatic Lighting Off . 72
............
Daytime Running Lights . 72
..................
High Beam Indicator . 63
...........
High Beams, Turning on . 71
............
Low Beams, Turning on . 71
.........................
Reminder Chime .72
........
Replacing Halogen Bulbs . 208
...................................
Turning on .71
...................................
Headphones .135
..............................
Head Restraints .87
.................................
Heated Mirror .89
...................................
Fan, Interior .100
...........................................
Features .99
....................
Filling the Fuel Tank . 147
Filters ...............................................
Oil .200
.............
Flashers, Hazard Warning . 73
...................
Flat Tire, Changing a . 225
Fluids ..........
Automatic Transmission . 204
..........................................
Brake .206
..........................
Power Steering .207 ................
Windshield Washers . 203
...................
Folding the Third Seat . 85
..........................
Four-way Flashers .73
.................................................
Fuel .146
...............................
Cap Message .68
......................
Fill Door and Cap .147
...........................................
Gauge .66
................
Octane Requirement . 146
........................
Reserve Indicator .63
........................
Tank, Filling the .147
.....................
Fuses, Checking the .239
...............
Gas Mileage, Improving . 150
.........................................
Gasoline .146
...............
Fuel Reserve Indicator . 63
...........................................
Gauge .66
................
Octane Requirement . 146
........................
Tank, Filling the .147
................
Gas Station Procedures . 147
Gauges ...
Engine Coolant Temperature . 67
...............................................
Fuel .66
GAWR (Gross Axle Weight .......................................
Rating) .174 GCWR (Gross Combined Weight
.......................................
Rating) .174
............
Gearshif t Lever Positions . 160
........................................
Glove Box .96
GVWR (Gross Vehicle Weight .......................................
Rating) .174
........
Oil Pressure Indicator . 58,234
..............
Oil, What Kind to Use . 199
...............................
Overheating .232
............................
Specif ications .247
............................
Speed Limiter .162
.......................................
Starting .159
.
Evaporative Emissions Controls . 251
...............................
Exhaust Fumes .53
Exhaust Gas Recirculation ........................................
System .252
Expectant Mothers, Use of Seat ........................................
Belts by .18
Index
F GH
INDEX
III

.....................................
Heater, Seat .82
.....................
Heating and Cooling .100
.............
High Altitude, Starting at . 159
.................
High-Low Beam Switch . 71
..............
High-mount Brake Light . 211
HomeLink Universal ................................
Transceiver .140
.......................
Hood, Opening the .148
...
Identif ication Number, Vehicle . 244
Ignition ..............................................
Keys .75
...........................................
Switch .77
............
Timing Control System . 252
........................
Immobilizer System .75
...
Important Handling Inf ormation . iii
.........
Important Safety Precautions . 8
.........
Indicators, Instrument Panel . 57
...............................
Inf ant Restraint .39
......................................
Inf ant Seats .39
...................
Inf lation, Proper Tire . 216
...................................
Inside Mirror .88
.............................
Inspection, Tire .217 Installing a Child Seat
...........................................
LACH .43
..........
Tether Anchorage Points . 47
........................
Instrument Panel .5 ,57
........
Instrument Panel Brightness . 72
........................................
Introduction .i
..................................................
Keys .75
.................
Jacking up the Vehicle . 226
.......................................
Jack, Tire .225
................................
Jump Starting .230
.......................
Label, Certif ication .244
.................
Lane Change, Signaling . 71
........................
Lap/Shoulder Belts .20
...........
LATCH Anchorage System . 43
.........................................
Lights .71, 97
....................
Bulb Replacement .208
.......................................
Indicator .57 .........................................
Parking .71
..................................
Turn Signal .71
....................................
Load Limits .154
......
LOCK (Ignition Key Position) . 77
Locks .......
Anti-thef t Steering Column . 77
............................
Fuel Fill Door .147
....................................
Glove Box .96
....................
Lockout Prevention . 78
.................................
Power Door .78
........................
Low Coolant Level .149
.........................
Low Fuel Indicator .63
...
Low Oil Pressure Indicator . 58,234
.................................
Lower Anchor .43
...
Lubricant Specif ications Chart . 246
.........................................
Luggage .153
..................................
Maintenance .187
Owner’s Maintenance ...................................
Checks .191
.................................
Record .195-197
......................
Required Indicator .65
..........................................
Saf ety .188
.............................
Schedule .192-194
Index
I J
K
LM
IV