transmission oil HONDA PILOT 2008 1.G Owners Manual
[x] Cancel search | Manufacturer: HONDA, Model Year: 2008, Model line: PILOT, Model: HONDA PILOT 2008 1.GPages: 329, PDF Size: 6.62 MB
Page 198 of 329
µµµ
µ µ
µ µ
µ
µ
The f ollowing f actors can lower your
vehicle’s f uel economy:
Aggressive driving (hard
acceleration and braking)
Excessive idling, accelerating and
braking in stop-and-go traf f ic
Cold engine operation (engines
aremoreefficientwhenwarmed
up)
Driving with a heavy load or the
air conditioner running
Improperly inf lated tires
A properly maintained vehicle
maximizes f uel economy. Poor
maintenance can signif icantly reduce
f uel economy. Always maintain your
vehicle according to the maintenance
messages displayed on the
inf ormation display (see on page ).
For example: An under-inf lated tire increases
‘‘rolling resistance,’’ which reduces
f uel economy.
It puts a heavier
load on the engine, increasing f uel
consumption. In
particular, a build-up of snow or
mud on your vehicle’s underside
adds weight and rolling resistance.
Frequent cleaning helps your f uel
economy.
Rapid
acceleration, abrupt cornering,
and hard braking increase fuel
consumption. Aerodynamic drag has a big ef f ect
on f uel mileage at speeds above 45
mph (75 km/h). Reduce your
speed and you reduce the drag.
Trailers, car top carriers, roof
racks and bike racks are also big
contributors to increased drag.
If your vehicle has a
manual transmission, you can
boost your f uel economy by up
shif ting as early as possible. Idling
results in 0 miles per gallon.
The A/C
puts an extra load on the engine
which makes it use more f uel. Use
the f resh-air ventilation when
possible.
Combine several short trips into
one. A warmed-up engine is more
f uel ef f icient than a cold one.
242
Fuel Economy Factors
Improving Fuel Economy
Owner’s
Maintenance Checks Use the recommended viscosity
motor oil, displaying the A PI
Certif ication Seal (see page
).
Maintain proper tire inf lation
A void carrying excess weight in
your vehicle
K eep your vehicle clean
Drive moderately Observe the speed limit
Always drive in the highest gear
possible
Avoid excessive idling
Minimize the use of the air
conditioning system
Plan and combine trips
245
Fuel Economy
Vehicle Maint enance
Drive Ef f icient ly
194
\f—\f—\fy
y
(+\fy\f
y
2008 Pilot
Page 239 of 329
This section explains why it is
important to keep your vehicle well
maintained and how to f ollow basic
maintenance saf ety precautions.
This section also includes
instructions on how to read the
maintenance messages in the
inf ormation display, and instructions
for simple maintenance tasks you
may want to take care of yourself.
If you have the skills and tools to
perf orm more complex maintenance
tasks on your vehicle, you may want
to purchase the service manual. See
page f or inf ormation on how to
obtain a copy, or see your dealer.......................
Maintenance Saf ety .236
....................
Maintenance Minder .237
..............................
Fluid Locations .244
........................
Adding Engine Oil .245
Changing the Engine Oil and
...........................................
Filter .246
..............................
Engine Coolant .248
....................
Windshield Washers .249
....
Automatic Transmission Fluid .250
..............................
Dif f erential Oil .251
.............
Transf er Assembly Fluid .251
....................................
Timing Belt .252
....................................
Brake Fluid .252
....................
Power Steering Fluid .253
.............................................
Lights .254
.....................................
Floor Mats .260
.......................
Cleaning Seat Belts .260
.................................
Wiper Blades .261
...........................................
Wheels .263
...............................................
Tires .263
...................
Checking the Battery .269
.............................
Vehicle Storage .270
311
Maintenance
Maint enance
235
\f—\f—\fy
\f\fy
(+\fy\f\fy
2008 Pilot
Page 246 of 329
µµµ
µ
µ
µ
Ì Engine oil level Check every
time you fill the fuel tank. See
page .
Engine coolant level Check the
radiator reserve tank every time
you f ill the f uel tank. See page .
Automatic transmission Check
the f luid level monthly. See page
.
Brakes Check the f luid level
monthly. See page .
Tires Check the tire pressure
monthly. Examine the tread f or
wear and foreign objects. See page .
Lights Check the operation of
the headlights, parking lights,
taillights, high-mount brake light,
turn signals, brake lights, and
license plate light monthly. See
page .
Youshouldcheckthefollowing
items at the specif ied intervals. If
you are unsure of how to perf orm
any check, turn to the appropriate
page listed.
According to state and federal
regulations, f ailure to perf orm
maintenance on the items marked
with will not void your emissions
warranties. However, all
maintenance services should be
perf ormed in accordance with the
intervals indicated by the
inf ormation display.
However, service at a dealer is not
mandatory to keep your warranties
in effect. Maintenance may be done
by any qualif ied service f acility or
person who is skilled in this type of
automotive service. Make sure to
have the service f acility or person
reset the display as previously
described. Keep all receipts as proof
of completion, and have the person
who does the work f ill out your
Honda Service History or Canadian
Maintenance Log. Check your
warranty booklet f or more
inf ormation.
We recommend using Honda parts
and fluids whenever you have
maintenance done. These are
manuf actured to the same high
quality standards as the original
components, so you can be conf ident
of their perf ormance and durability. U.S. Vehicles:
191
192
250 252
264
254
Maintenance Minder
Owner’s Maintenance Checks
Maintenance, replacement, or
repair of emissions control
devices and systems may be done
by any automotive repair
establishment or individual using
parts that are ‘‘certif ied’’ to EPA
standards.
242
\f—\f—\fy
\f
y
(+\fy\fy
2008 Pilot
Page 247 of 329
ÌÌ
µµ
Ì
Maintenance Minder
243
Maintenance Sub Items
Rotate tires
Replace air cleaner element
Replace dust and pollen filter
Inspect drive belt
Replace transmission and transfer fluid
Replace spark plugs
Replace timing belt and inspect water pump
Inspect valve clearance
Replace engine coolant
Replace VTM-4 rear differential fluid
:
2
See information on maintenance and emissions warranty on page .
Inspect idle speed every 160,000 miles (256,000 km).
If the message ‘‘SERVICE’’ does not appear more than 12 months after the
display is reset, change the engine oil every year.
Independent of the maintenance messages in the information display,
replace the brake fluid every 3 years.
Adjust the valves during services A, B, 1, 2, or 3 if they are noisy.
NOTE: 1:
2:4WD
242
Maintenance Main Items
Replace engine oil
Replace engine oil and oil filter
Inspect front and rear brakes
Check parking brake adjustment
Inspect these items: Tie rod ends, steering gear box, and boots
Suspension components
Driveshaft boots
Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system
Fuel lines and connections
A
B
1
2
3
4
5
61
1
If you drive in dusty conditions, replace every 15,000 miles
(24,000 km).
If you drive primarily in urban areas that have high concentrations
of soot in the air from industry and from diesel-powered vehicles,
replace every 15,000 miles (24,000 km).
Driving in mountainous areas at very low vehicle speeds or trailer
towing results in higher transmission and transfer fluid
temperatures. This requires transmission and transfer fluid
changes more frequently than recommended by the Maintenance
Minder. If you regularly drive your vehicle under these conditions,
have the transmission and transfer fluid changed every 30,000
miles (48,000 km).
If you drive regularly in very high temperatures (over 110°F, 43°C),
in very low temperatures (under 20°F, 29°C), or towing a trailer,
replace every 60,000 miles (U.S.) /100,000 km (Canada).
Driving in mountainous areas at very low vehicle speeds or trailer
towing results in higher level of mechanical (shear) stress to fluid.
This requires differential fluid changes more frequently than
recommended by the Maintenance Minder. If you regularly drive
your vehicle under these conditions, have the differential fluid
changed at 7,500 miles (12,000 km), then every 15,000 miles
(24,000 km).
Symbol
Symbol
Maintenance Minder
\f—\f—\fy
\fy
(+\fy\fy
2008 Pilot
Page 248 of 329
Fluid Locations
244
ENGINE OIL DIPSTICK
(Orange loop)
WASHER FLUID
(Blue cap)ENGINE OIL FILL CAP
ENGINE COOLANT
RESERVOIR
POWER STEERING FLUID
(Red cap) BRAKE FLUID
(Gray cap)
AUTOMATIC
TRANSMISSION
FLUID DIPSTICK
(Yellow loop)
RADIATOR CAP
\f—\f—\fy
y
(+\fy\fy
2008 Pilot
Page 250 of 329
Run the engine until it reaches
normal operating temperature,
then shut it off.
Open the hood, and remove the
engine oil f ill cap. Remove the oil
drain bolt and washer f rom the
bottom of the engine. Drain the oil
into an appropriate container.
You may use a synthetic motor oil if
it meets the same requirements
given f or a conventional motor oil: it
displays the API certif ication seal,
and it is the proper weight. You must
f ollow the oil and f ilter change
intervals shown on the information
display.
Your vehicle does not require any oil
additives. Additives may adversely
af f ect the engine or transmission
perf ormance and durability.
Always change the oil and f ilter
according to the maintenance
messages shown on the inf ormation
display. The oil and f ilter collect
contaminants that can damage your
engine if they are not removed
regularly.
Changing the oil and f ilter requires
special tools and access f rom
underneath the vehicle. The vehicle
should be raised on a service station-
type hydraulic lif t f or this service.
Unless you have the knowledge and
proper equipment, you should have
this maintenance done by a skilled
mechanic.
1.
2.
Synthetic Oil
Engine Oil A dditives
Changing the Engine Oil and
Filter
A dding Engine Oil, Changing the Engine Oil and Filter
246
DRAIN BOLT
WASHER
\f—\f—\fy
y
(+\fy\f
y
2008 Pilot
Page 255 of 329
Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely. Tightening
torque:
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
VTM-4 Dif f erential Fluid until it
starts to run out of the hole. The rear dif f erential should be
drained and ref illed with new f luid
according to the maintenance
messages shown on the inf ormation
display. Have your dealer replace the
rear dif f erential f luid.
The transf er assembly should be
drained and ref illed with new f luid
when this service is indicated by a
maintenance message on the
inf ormation display.
Always use Hypoid gear oil GL4 or
GL5 with a viscosity of SAE 90 or
80W-90, and have your dealer
replace the transfer assembly fluid.
Insert the dipstick all the way back
into the transmission securely as
shown in the illustration.
6.
4WD models only
Dif f erential Oil
Transf er Assembly Fluid
Automatic Transmission Fluid, Dif f erential Oil, Transf er Assembly Fluid
Maint enance
251
FILLER BOLTCORRECT LEVEL
33 lbf·ft (45 N·m , 4.6 kgf·m)
Use only Honda Genuine ATF-Z1
(Automatic Transmission Fluid). Do
not mix with other transmission f luids.
Using transmission f luid other than
Honda Genuine ATF-Z1 may cause
deterioration in transmission operation
and durability, and could result in
damage to the transmission.
Damage resulting f rom the use of
transmission f luid other than Honda
Genuine ATF-Z1 is not covered by the
Honda new vehicle warranty.
\f—\f—\fy
y
(+\fy\fy
2008 Pilot
Page 298 of 329
ÎÎ Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
Î
µ
ÎÎ
Specif ications
294
Dimensions
Weights
Battery
Capacities
Seating Capacities 1.93 US gal (7.3
)
2.43 US gal (9.2)
4.5 US qt (4.3
)
4.2 US qt (4.0
)
5.3 US qt (5.0
)
20.34 US gal (77.0
)
188.0 in (4,775 mm)
76.5 in (1,943 mm)
Length
Width
Height
Wheelbase
Track 66.3 in (1,685 mm) 106.3 in (2,700 mm)
70.5 in (1,790 mm)
Gross vehicle weight rating
Gross combined weight
rating (GCWR) See the tire information label atta-
ched to the driver’s doorjamb.
9,700 lbs (4,400 kg)
77.5 in (1,968 mm)
71.7 in (1,821 mm)
70.1 in (1,780 mm)
71.3 in (1,811 mm)
66.5 in (1,690 mm)
66.5 in (1,690 mm)
66.7 in (1,694 mm)
12 V 20 AH/5 HR
Capacity Excluding the oil remaining in the engine
0.193 US gal (0.73
)
Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 2.79 US qt (2.64
)
4.8 US qt (4.5
)
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Rear
differential
fluid (4WD)
Windshield
washer
reservoir
8.3 US qt (7.9
)
3.5 US qt (3.3
)
8.9 US qt (8.4
)
4.0 US qt (3.8
)
Equipped with transmission fluid cooler and power steering
fluid cooler.
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation.
Total
Front
Rear 8
2
3
3 Approx.
1:
2:
1:
2: Front
Rear
4WD
2WD
Front
Rear
4WD
2WD Change
Total
Change
Including
filter
Without
filter
Total
Change
Total
Change 4WD
2WD
4WD
2WD
Second row
Third row
1 : LX and LX-VP models 2 : EX, EX-L, and EX-SE models
2
1 1
2
1
2
1
2
1
2
\f—\f—\fy
y
(+\fy\fy
2008 Pilot
Page 317 of 329
CONT INUED
...
Accessories and Modif ications .196
ACCESSORY (Ignition Key
.......................................
Position) .81
............
Accessory Power Sockets .101
...........................
AC Power Outlet .102
....................
Additives, Engine Oil .245
...............
AdvancedAirbagSystem .30
.............................
Airbag (SRS) .11,25
..........
Airbag System Components .25
..............
Air Conditioning System .106
.....................
Rear A/C Control .113
.......................
Air Pressure, Tires .264
......................................
Antif reeze .248
...............
Anti-lock Brakes (ABS) .216
...............................
Indicator .63,217
...................................
Operation .216
..............
Anti-thef t, Audio System .141
.
Anti-thef t Steering Column Lock .81
................................
Audio System .115
...
Automatic Seat Belt Tensioners .23
...
Automatic Lighting Off Feature .76
.............
Automatic Speed Control .177
..............
Automatic Transmission .206
..........................
Capacity, Fluid .294 ...............
Checking Fluid Level .250
.......................................
Shif ting .206
.
Shif t Lever Position Indicator .206
................
Shif t Lever Positions .207
....................
Shif t Lock Release .209
Battery Charging System ...........................
Indicator .62,282
............................
Jump Starting .278
..............................
Maintenance .269
............................
Specif ications .294
..............................
Bef ore Driving .187
..................................
Belts, Seat .10,21
...........................
Beverage Holders .99
..................................
Booster Seats .54
Brakes
...........
Anti-lock System (ABS) .216
.............
Break-in, New Linings .188
....................
Bulb Replacement .258
...........................................
Fluid .252
.........................................
Parking .97
.................
System Indicator .63,284
........................
Wear Indicators .215 .............................
Braking System .215
.................
Break-in, New Vehicle .188
..
Brightness Control, Instruments .76
........................
Brights, Headlights .75
Bulb Replacement
..........................
Back-up Lights .258
.....................
Brake Lights .258,259
................
Front Parking Lights .255
........
Front Side Marker Lights .255
.................................
Headlights .254
........
High-mount Brake Lights .259
.................................
Rear Bulbs .258
............................
Specif ications .295
.............
Turn Signal Light .255,258
..............................
Bulbs, Halogen .254
............................
Capacities Chart .294
.............
Carbon Monoxide Hazard .57
.............................
Carrying Cargo .198
.............
CAUTION, Explanation of .iii
..........................
CD Changer .131,134
.......................................
CD Player .130
Index
A
B
C
INDEX
I
— — y
y
(+ y
y
2008 Pilot
Page 318 of 329
........................
Certif ication Label .292
............................................
Chains .268
....................
Changing a Flat Tire .273
Change Oil
........................................
How to .246
......................................
When to .237
...
Charging System Indicator .62,282
............
Checklist, Bef ore Driving .204
..................
Childproof Door Locks .83
Child Seats
.........................................
LATCH .47
..........
Tether Anchorage Points .51
...............
Climate Control System .112
.........................
Clock, Setting the .142
.....................
Code, Audio System .141
........................
CO in the Exhaust .302
............
Cold Weather, Starting in .205
......................
Compact Spare Tire .272
...................
Console Compartment .99
.................
Consumer Inf ormation .308
.............
Controls, Instruments and .59
Coolant
........................................
Adding .248
....................................
Checking .192
.........................
Proper Solution .248
...................
Temperature Gauge .71 ...................
Conversation Mirror .100
Crankcase Emissions Control
........................................
System .302
............
Cruise Control Operation .177
....
Customer Service Inf ormation .308
..............................
Economy, Fuel .193
............
Emergencies on the Road .271
.............
Battery, Jump Starting .278
...........
Brake System Indicator .284
................
Changing a Flat Tire .273
.....
Charging System Indicator .282
..................
Checking the Fuses .285
.....
Low Oil Pressure Indicator .282
...
Malf unction Indicator Lamp .283
..................
Overheated Engine .280
...........................
Emergency Brake .97
......................
Emergency Flashers .77
......................
Emergency Towing .285
.......................
Emissions Controls .302
........................
Emissions Testing .305
...............
DANGER, Explanation of .iii
...................................
Dashboard .4,60
................
Daytime Running Lights .76
Daytime Running Lights
.......................................
Indicator .67
.................................
Dead Battery .278
............
Def ects, Reporting Saf ety .310
................
Def ogger, Rear Window .77
......
Def rosting the Windows .108,110
....................................
Dimensions .294
...............
Dimming the Headlights .75
Dipstick
..........
Automatic Transmission .250
..................................
Engine Oil .191
....................
Directional Signals .66,75
........
Disc Brake Wear Indicators .215
.....................
Disposal of Used Oil .247 Doors
..............
Locking and Unlocking .82
..........
DOT Tire Quality Grading .296
...........
Driver and Passenger Safety .7
...........................................
Driving .203
....................................
Economy .193
...................................
DVD Player .144
........
DVD Player Error Message .173
Index
D
E
II
— — y
y
(+ y
y
2008 Pilot