coolant HONDA S2000 2005 2.G User Guide

If the reserve tank is completely
empty, you should also check the
coolant level in the radiator.When the radiator and engine are
cool, relieve any pressure in the
cooling system by turning the
radiator cap counterclockwise,
without pressing down.
Remove the radiator cap by
pushing down and turning
counterclockwise.The coolant level should be up to
the base of the f iller neck. Add
coolant if it is low.
Pourthecoolantslowlyand
caref ully so you do not spill. Clean
up any spill immediately; it could
damage components in the engine
compartment.
Put the radiator cap on, and
tighten it fully.
Pour coolant into the reserve tank.
Fill it to half way between the MAX
and MIN marks. Put the cap back
on the reserve tank.
Do not add any rust inhibitors or
other additives to your vehicle’s
cooling system. They may not be
compatible with the coolant or
engine components.
2. 3.
4.
5.
1.
Engine Coolant
Maint enance
135
RADIATOR CAP
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

Open the hood.
If you need to change the high
beam headlight bulb on the lef t
side, remove the coolant reserve
tank f rom its holder by pulling it
straight up.
Remove the electrical connector
f rom the bulb by squeezing the
connector to unlock the tab, then
slide the connector of f the bulb.Remove the rubber weather seal
by pulling on the tab.
Unclip the end of the hold-down
wire f rom its slot. Pivot it out of
the way, and remove the bulb
socket.Insert the socket back into the
headlight assembly. Make sure
the bulb is installed correctly by
looking through the headlight lens.
The pins on the base of the bulb
should f it in the holes in the
headlight assembly. Pivot the hold-
down wire back in place, and clip
the end into the slot.
Install the rubber seal over the
back of the headlight assembly.
Push the electrical connector onto
the new bulb. Turn on the
headlights to test the new bulb.
(Lef t side)
Pull the bulb straight out of its
socket. Push the new bulb straight
into the socket until it bottoms. Reinstall the coolant reserve tank.
1.
2. 3.
4.
5.6.
7.
8.
9.
Lights
Maint enance
141

Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (seeon page ).
If the temperature gauge stays at
the red mark, turn of f the engine.
If you do not see steam or spray,
leave the engine running, and
watch the temperature gauge. If
the high heat is due to overloading,
the engine should start to cool
down almost immediately. If it
does, wait until the temperature
gauge comes down to the midpoint,
then continue driving. If you see steam and/or spray
coming f rom under the hood, turn
of f the engine. Wait until you see
no more signs of steam or spray,
then open the hood. Saf ely pull to the side of the road.
Put the transmission in Neutral,
and set the parking brake. Turn
of f the all accessories, and turn on
the hazard warning indicators. If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank. Add coolant
if the level is below the MIN mark
(seeon
page ).
2. 1.
3. 4.
5.
6.
179
134 Emergency
Towing
A dding Engine Coolant
If theEngineOverheats
168
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.

If there was no coolant in the
reserve tank, you may need to add
coolant to the radiator. Let the
engine cool down until the reading
reaches the middle of the
temperature gauge, or lower,
bef ore checking the radiator.Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. Af ter the
pressure releases, push down on
the cap, and turn it until it comes
off.Put the radiator cap back on
tightly. Run the engine, and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair (see
on page ).
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
Start the engine, and set the
temperature control dial to
maximum heat. Add coolant to the
radiator up to the base of the f iller
neck. If you do not have the
proper coolant mixture available,
you can add plain water.
Remember to have the cooling
system drained and ref illed with
the proper mixture as soon as you
can.
9. 8.
7. 10.
11.179
Emergency
Towing
If theEngineOverheats
T aking Care of t he Unexpect ed
169
Removing the radiator cap
while the engine is hot can
cause the coolant to spray out,
seriously scalding you.
Always let the engine and
radiator cool down before
removing the radiator cap.

Î
Î
´
µ
Î
Î
Specif ications
184
Dimensions
Engine WeightsCapacities
162.0 in (4,115 mm)
68.9 in (1,750 mm)
50.6 in (1,285 mm)
94.5 in (2,400 mm)
57.9 in (1,470 mm)
59.4 in (1,510 mm) 13.2 US gal (50)
132 cu-in (2,157 cm
)
11.1 : 1 1.72 US gal (6.5
)
2.01 US gal (7.6)
5.1 US qt (4.8
)
5.1 US qt (4.8)
5.9 US qt (5.6)
1.7 US qt (1.6)
1.7 US qt (1.6)
0.78 US qt (0.74
)
0.81 US qt (0.77)
2.6 US qt (2.5)
6.3 US qt (6.0)
3.43 x 3.57 in (87.0 x 90.7 mm)
Length
Width
Height
Wheelbase
Track
See the certification label attached
to the driver’s doorjamb.Water cooled 4-stroke DOHC
VTEC 4-cylinder gasoline engine
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Spark Plug Gap
0.04 in (1.1 mm)PK22PR-L11S PFR7G-11S
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
0.16 US gal (0.6
)
Excluding the oil remaining in the engine.
Gross vehicle weight rating
(GVWR)
Fuel tank
Engine coolant
Engine oil
Manual
transmission
fluid
Differential
fluid
Windshield
washer
reservoir
Front
Rear
1:
2:
NGK :
DENSO : Change
Total
Change
Total
Change
Total
Change
Total
U.S. Vehicles
Canadian
Vehicles
0mm
0.1 mm
1
2
Including filter
Without filter

Î
................
DANGER, Explanation of . ii
...................................
Dashboard .3, 38
................
Daytime Running Lights . 48
Daytime Running Lights .......................................
Indicator .42
.................................
Dead Battery .166
............
Defects, Reporting Safety . 196
................
Def ogger, Rear Window . 50
................
Defrosting the Windows . 77
..........................
Dif f erential Fluid .138
....................................
Dimensions .184
...............
Dimming the Headlights . 48
Dipstick ..................................
Engine Oil .103
..........................
Directional Signals .48
........
Disc Brake Wear Indicators . 118
.....................
Disposal of Used Oil .134 ...................
Do Not Tow a Trailer . 119
Doors ..............
Locking and Unlocking . 54
.......................
Monitor Indicator .41
......................
Power Door Locks .54
..........
DOT Tire Quality Grading . 186
Downshif ting, Manual .............................
Transmission .115
...........
Driver and Passenger Safety . 5
...........................................
Driving .111
....................................
Economy .104
........................
Driving Guidelines .112
..............................
Economy, Fuel .104
..................................
Emergencies .157
.............
Battery, Jump Starting . 166
...........
Brake System Indicator . 172
................
Changing a Flat Tire . 159
.....
Charging System Indicator . 170
..................
Checking the Fuses . 174
...
Closing the Convertible Top . 173
.........
Hazard Warning Flashers . 49
............................
Jump Starting .166
.....
Low Oil Pressure Indicator . 170
.....................................
Child Saf ety .23
..............................
Booster Seats .32
...................................
Child Seats .28
.....
Important Saf ety Reminders . 26
..........................
Larger Children .31
.......................
Risk with Airbags .24
.............................
Small Children .27
.......................................
Child Seats .28
.......................
Cleaning Seat Belts .145
.................................................
Clock .45
...................................
Clutch Fluid .139
........................
CO in the Exhaust .189
............
Cold Weather, Starting in . 114
......................
Compact Spare Tire .158
...............
Consumer Inf ormation . 194
.............
Controls, Instruments and . 37
..............................
Convertible Top .61
...............
Convertible Top Cover . 63
..
Lowering the Convertible Top . 61
................................
Maintenance .65
.....
Raising the Convertible Top . 64
Coolant ........................................
Adding .134
....................................
Checking .104
.........................
Proper Solution .134
...................
Temperature Gauge . 45Crankcase Emission Control
........................................
System .189
................
Cruise Control Indicator . 41
..............
Cruise Control Operation . 95
......................................
Cup Holder .69
.............
Customer Service Of f ice . 194
Index
D
E
II

CONT INUED
.....................................
Fan, Interior .75
...........................................
Features .73
....................
Filling the Fuel Tank . 101
Filters .........................
Dust and Pollen .146
...............................................
Oil .132
.............
Flashers, Hazard Warning . 49
...................
Flat Tire, Changing a . 159
Fluids ..........................................
Brake .139
.........................................
Clutch .139
..............
Manual Transmission . 137
..................
Windshield Washer . 136
..........
FM Stereo Radio Reception . 81
..........................
Four-way Flashers .49
.................................................
Fuel .100
......................
Fill Door and Cap .101
...........................................
Gauge .45
.....................
Low Fuel Indicator .42
................
Octane Requirement . 100
...............................
Oxygenated .100 ........................
Tank, Ref ueling .101
...............................
Fuel Economy .104
..............
Fuel Station Procedures . 101
.....................
Fuses, Checking the .174
...
Malf unction Indicator Lamp . 171
..................
Overheated Engine . 167
.......................................
Towing .179
...........................
Emergency Brake .67
......................
Emergency Flashers .49
......................
Emergency Towing .179
............
Emergency Trunk Opener . 55
.......................
Emissions Controls .189
.............
Emissions Testing, State . 192
Engine ............
Adding Engine Coolant . 134
....
Coolant Temperature Gauge . 45
.........................
If It Won’t Start .164
Malf unction Indicator ................................
Lamp .41, 171
........
Oil Pressure Indicator . 40,170
..............
Oil, What Kind to Use . 131
...............................
Overheating .167
............................
Specif ications .184
............................
Speed Limiter .116
...............................
Start Button .114
.......................................
Starting .114
......................
Ethanol in Gasoline .100
...
Evaporative Emission Controls . 189
...............................
Exhaust Fumes .35 Expectant Mothers, Use of Seat
........................................
Belts by .14
...............
Gas Mileage, Improving . 104
..........................................
Gasohol .100
.........................................
Gasoline .100
...........................................
Gauge .45
.....................
Low Fuel Indicator .42
................
Octane Requirement . 100
........................
Tank, Ref ueling .101
.............................................
Gauges .44
...
Engine Coolant Temperature . 45
...............................................
Fuel .45
Gearshif t Lever Positions ..............
Manual Transmission . 116
Gross Vehicle Weight Rating .............................
(GVWR) .108, 184
Index
F
G
INDEX
III

CONT INUED
Lights....................
Bulb Replacement .140
.......................................
Indicator .40
..................................
Turn Signal .48
....................................
Load Limits .108
......
LOCK (Ignition Key Position) . 53
Locks .......
Anti-thef t Steering Column . 53
............................
Fuel Fill Door .101
.................................
Power Door .54
...........................................
Trunk .54
........................
Low Coolant Level .104
.........................
Low Fuel Indicator .42
...
Low Oil Pressure Indicator . 40,170
...
Lubricant Specif ications Chart . 184
...........
Luggage, Storing (Cargo) . 107..................
New Vehicle Break-in . 100
.....................
Normal Shif t Speeds .116
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 182
..................................
Maintenance .121
Owner’s Maintenance ...................................
Checks .124
........................................
Record .127
......................
Required Indicator .43
..........................................
Saf ety .122
....................................
Schedule .123 .
Malf unction Indicator Lamp . 41,171
...................
Manual Transmission . 115
........
Manual Transmission Fluid . 137
...............................
Meters, Gauges .44
...................
Methanol in Gasoline . 100
..........................
Mirrors, Adjusting .66
...............
Modif ying Your Vehicle . 106
..............
Panel Brightness Control . 49
...........................................
Parking .117
.................................
Parking Brake .67
Parking Brake and Brake System .....................................
Indicator .172
.................................
Parking Lights .48
.............................
PGM-FI System .190
...................................
Pollen Filter .146
..........................
Power Door Locks .54
..................
Power Socket Location . 68
..............................
Power Windows .59
...
Octane Requirement, Gasoline . 100
.........................................
Odometer .44
...............................
Odometer, Trip .44
Oil ........................
Change, How to .132
......................
Change, When to .125
......................
Checking Engine .103
..............
Pressure Indicator . 40,170 Selecting Proper Viscosity
......................................
Chart .132
...........
ON (Ignition Key Position) . 53
Onboard Ref ueling Vapor ....................................
Recovery .189
.........................
Opening the Trunk .54
..............................
Outside Mirrors .66
....................
Overheating, Engine .167
....
Owner’s Maintenance Checks . 124
.........................
Oxygenated Fuels .100
Index
M N
O
P
INDEX
V

ÎÎ Î
.........
Pregnancy, Using Seat Belts . 14
........................
Preparing to Drive .113
.........
Protecting Adults and Teens . 10
...
Additional Safety Precautions . 15
.....
Advice f or Pregnant Women . 14
........................
Protecting Children .23
.....................
General Guidelines .23
.......
Protecting Larger Children . 31
.........
Protecting Small Children . 27
...................
Radiator Overheating . 167
...............
Radio/CD Sound System . 78
...................
Radio Thef t Protection . 94
...................
Readiness Codes . 171,192
..
Rear Lights, Bulb Replacement . 144
............................
Rear View Mirror .66
.................
Rear Window Def ogger . 50
................
Reclining the Seat-backs . 58
.......
Recommended Shif t Speeds . 116
Recovery Vehicle, Emergency .......................................
Towing .179
........................................
Ref ueling .101
.................
Reminder Indicators . 39,40
.......................
Remote Transmitter .56 Replacement Inf ormation
..............
Dust and Pollen Filter . 146
................
Engine Oil and Filter . 132
..........................................
Fuses .174
................................
Light Bulbs .140
....................................
Schedule .123
...........................................
Tires .152
.............................
Wiper Blades .147
Replacing Seat Belts Af ter a ............................................
Crash .17
..........
Reporting Saf ety Def ects . 196
Reserve Tank, Engine ...............................
Coolant .104, 134
...............................
Restraint, Child .23
...........................
Reverse Lockout .116
................................
Rotation, Tire .151
..................................
Saf ety Belts .8, 16
.........
Safety Defects, Reporting . 196
.................................
Saf ety Features .7
...........................................
Airbags .9
.......................................
Seat Belts .8
.............
Saf ety Labels, Location of . 36
...............................
Saf ety Messages .ii ..................................
Satellite Radio .83
.....................................
Seat Belts .8, 16
...............
Additional Information . 16
.....
Advice f or Pregnant Women . 14
Automatic Seat Belt ...............................
Tensioners .17
.....................................
Cleaning .145
......................
Lap/Shoulder Belt .16
................................
Maintenance .17
Reminder Indicator and ................................
Beeper .16, 40
...................
System Components . 16
...............
Use During Pregnancy . 14
........................
Seats, Adjusting the .58
...............................
Serial Number .182
...........................
Service Intervals .125
...........................
Service Manual .197
.........
Service Station Procedures . 101
............................
Setting the Clock .45
Shif ting .............
Manual Transmission . 115
Side Turn Signal, Bulb .............................
Replacement .143
...............................
Signaling Turns .48
.....................................
Snow Tires .153
..................................
Sound System .78
Index
S
R
VI