fuses Hyundai H-1 (Grand Starex) 2003 Owner's Manual

IN CASE OF EMERGENCY
IN CASE OF EMERGENCY IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
4-15
E120A01P-GATFUSES
FUSES FUSES
FUSES
FUSES
HSR4021
To prevent damage to the electrical system due to short-circuiting or overloading, each individ-ual current circuit is provided with a fuse. The fuse housing is located under the dash- board on the driver's side. E120B01P-GAT Fuse load capacity
Fuse load capacity Fuse load capacity
Fuse load capacity
Fuse load capacity
The fuse housing cover lists the names of the electrical systems and the fuse capacities. E120C01P-GAT
Spare fuse
Spare fuse Spare fuse
Spare fuse
Spare fuse
Spare fuses are contained in the fuse housing. Always use a fuse of the same capacity forreplacement.
GS40360A
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
(1)(1)
(1)(1)
(1) Do not allow the jumper cable clips to
Do not allow the jumper cable clips to Do not allow the jumper cable clips to
Do not allow the jumper cable clips to
Do not allow the jumper cable clips to
touch one another.
touch one another. touch one another.
touch one another.
touch one another.
(2)(2)
(2)(2)
(2) Do not connect the jumper cable to the
Do not connect the jumper cable to the Do not connect the jumper cable to the
Do not connect the jumper cable to the
Do not connect the jumper cable to the
negative terminal of the flat battery.
negative terminal of the flat battery. negative terminal of the flat battery.
negative terminal of the flat battery.
negative terminal of the flat battery.
The battery generates explosive gas, and
The battery generates explosive gas, and The battery generates explosive gas, and
The battery generates explosive gas, and
The battery generates explosive gas, and
a spark caused when the jumper cable is
a spark caused when the jumper cable is a spark caused when the jumper cable is
a spark caused when the jumper cable is
a spark caused when the jumper cable is
disconnected from the negative terminal
disconnected from the negative terminal disconnected from the negative terminal
disconnected from the negative terminal
disconnected from the negative terminal
could ignite this gas and cause an explo-
could ignite this gas and cause an explo- could ignite this gas and cause an explo-
could ignite this gas and cause an explo-
could ignite this gas and cause an explo-
sion.
sion. sion.
sion.
sion.
(3)(3)
(3)(3)
(3)
Be careful that the jumper cable becomes
Be careful that the jumper cable becomes Be careful that the jumper cable becomes
Be careful that the jumper cable becomes
Be careful that the jumper cable becomes
not caught in the cooling fan, etc.
not caught in the cooling fan, etc. not caught in the cooling fan, etc.
not caught in the cooling fan, etc.
not caught in the cooling fan, etc.
8. Start engine as described in "Starting the engine".
9. After the engine is started, disconnect the cables in the reverse order. E120D01P-GAT
Changing a fuse
Changing a fuse Changing a fuse
Changing a fuse
Changing a fuseGS40380A
Good
Blown
1. Before replacing a fuse, be sure to turn off the electrical item concerned.
2. Remove the fuse housing cover.
3. Referring to the fuse load capacity table, check the fuse pertaining to the problem.
4. If the fuse is blown, pull it straight out. If it is not blown, something else must be causing the problem; contact an authorizedHYUNDAI dealer to have the problemchecked.
5. Insert a new fuse of the same capacity securely into the clip.
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
(1)(1)
(1)(1)
(1) If the newly inserted fuse blows again
If the newly inserted fuse blows again If the newly inserted fuse blows again
If the newly inserted fuse blows again
If the newly inserted fuse blows again
after a short time, the cause should be
after a short time, the cause should be after a short time, the cause should be
after a short time, the cause should be
after a short time, the cause should be
diagnosed and corrected by an autho-
diagnosed and corrected by an autho- diagnosed and corrected by an autho-
diagnosed and corrected by an autho-
diagnosed and corrected by an autho-
rized HYUNDAI dealer.
rized HYUNDAI dealer. rized HYUNDAI dealer.
rized HYUNDAI dealer.
rized HYUNDAI dealer.

8-13
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
I200A01P-GAG


30 mm (1.2 in.)
I200A01P-GAT
STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY
STEERING WHEEL FREE PLAY
Check by moving the steering wheel left and
right. The free play at the circumference should not
exceed the standard value.
Free play 30 mm (1.2 in.) If the steering wheel free play exceeds the
standard value, have the steering wheel ad- justed at an authorized HYUNDAI dealer.
I170A01P-GAT
FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND
FUEL, ENGINE COOLANT, OIL, AND
EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE
EXHAUST GAS LEAKAGE
Look under the body of your vehicle to check
for fuel, engine coolant, oil, and exhaust gasleaks. If leaks are evident, take your vehicle to an
authorized HYUNDAI dealer for inspection.
I160A02P-GAT
TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE
TIRE INFLATION PRESSURE
Check the tire inflation pressure of all the tires
while they are cold; if insufficient or excessive,adjust to the specified value.
After the tire inflation pressure has been ad-
justed, check the tires for damage and airleaks.
Be sure to put rubber caps on the valves.
kg/cm² (PSI)
Mini- Bus Tire size
195R 14C-6PR 205/70R 15 215/80R 15
205/70R 15C-6PR Rear
2.8(40)2.8(40)2.2(32) 2.8(40) Front
2.8(40) 2.8(40)2.2(32)2.8(40)
Up to 3 persons Up to
MAX. load
Rear
3.5(50)2.8(40)2.2(32)3.5(50)
Front
2.8(40) 2.8(40) 2.2(32)2.8(40)
Veh- icle
kg/cm² (PSI)
Vehicle
VAN
TRUCK Tire size
195R 14C-8PR 195R 14C-6PR195R 13C-8PR Rear
4.5(65) -
3.5(50)
Front
2.8(40)2.8(40)
-
I180A01P-GATEXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP- EXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP-
EXTERIOR AND INTERIOR LAMP OP-
ERATION
ERATION ERATION
ERATION
ERATION
Operate the light switch and combination switch
to confirm that all lamps are functioning prop- erly.
If the lamps do not go on, the probable cause
is a blown fuse or defective lamp bulb. Checkthe fuses first. If there is no blown fuse, checkthe lamp bulbs.
For information regarding the inspection and
replacement of the fuses and the lamp bulbs,refer to the section entitled "In case of emer-gency" If the fuses and bulbs are all OK, take the
vehicle to an authorized HYUNDAI dealer forinspection.
I190A01P-GATMETER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/ METER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/
METER, GAUGE, AND INDICATION/
WARNING LAMP OPERATION
WARNING LAMP OPERATION WARNING LAMP OPERATION
WARNING LAMP OPERATION
WARNING LAMP OPERATION
Run the engine to check the operation of all
meters, gauge, and indication/ warning lamps.If there is anything wrong, take the vehicle toan authorized HYUNDAI dealer for inspection.

INDEX
INDEX INDEX
INDEX
INDEX
10-2 EMISSION CONTROL SYSTEM
........................................................... 7-1
ENGINE ........................................................................................................ 9-2
ENGINE COOLANT .................................................................................. 8-9
ENGINE NUMBER .................................................................................... 1-2
ENGINE OIL .................................................................................... 8 - 7 ~ 8 - 8
ENGINE OVERHEATING ........................................................ 4-11 ~ 4-12
ENGINE RPM ADJUSTMENT KNOB ...............................................2-15
ENGINE WARNING LIGHT ................................................................. 2-10
EXTERIOR AND INTERIOR LAMP OPERATION .........................8-13
F FOUR-WHEEL DRIVE (4WD) ..................................................3-9 ~ 3-10
FOURTH SEAT ....................................................................................... 1-21
FRONT DOOR EDGE WARNING LIGHT .......................................2-15
FRONT DOOR WINDOW GLASS .....................................................1-17
FRONT FOG LAMP SWITCH ........................................................... 2-16
FRONT INTERIOR LIGHT ................................................................... 2-17
FRONT ROOM LAMP ........................................................................... 2-18
FRONT SEATS ....................................................................................... 1-18
FUEL FILTER WARNING LAMP-RED ................................................. 2-9
FUEL GAUGE ............................................................................................. 2-5
FUEL TANK CAPACITY .......................................................................... 9-1
FUEL, ENGINE COOLANT, OIL, AND EXHAUST GAS LEAKAGE .................................................................................... 8-13
FUSES ....................................................................................................... 4-15
G GASOLINE ENGINE ROOM .................................................................. 8-5
GOOD BRAKING PRACTICE ............................................................. 3-11H
HAZARD WARNING LIGHT SWITCH ..............................................2-16
HEADLAMP LEVELING DEVICE SYSTEM ....................................2-14
HEADREST .............................................................................................. 1-22
HEATING AND COOLING ...................................................... 2-24 ~ 2-25
HEATING CONTROLS .......................................................................... 2-25
HEIGHT ADJUSTABLE FRONT SEAT SHOULDER BELT .......1-23
HIGH-BEAM INDICATION LAMP-BLUE .............................................. 2-9
HIGH-BEAM SWITCH ........................................................................... 2-11
HINGED WINDOW .................................................................... 1-16 ~ 1-17
HINGES AND LATCHES LUBRICATION ........................................8-15
"HOLD" MODE SWITCH ......................................................................... 3-7
HOOD RELEASE .................................................................................... 1-12
HORN SWITCH ....................................................................................... 2-17
I IF A TIRE IS FLATENED ............................................................ 4 - 6 ~ 4 - 8
IF THE ENGINE OVERHEATS .............................................4-11 ~ 4-12
IGNITION SWITCH ................................................................................... 3-1
ILLUMINATED IGNITION SWITCH ...................................................... 1-8
IMMOBILIZER SYSTEM .............................................................. 1 - 5 ~ 1 - 8
INCLINOMETER ......................................................................................... 2-6
INDEX ........................................................................................................ 10-1
INDICATION AND WARNING LAMPS ..................................2-9 ~ 2-10
INSIDE REAR-VIEW MIRROR ........................................................... 2-21
INSTALLATION OF ACCESSORIES ................................................... 1-3
INSTRUMENTS .......................................................................................... 2-3
INSTRUMENTS PANEL LIGHT CONTROL (=RHEOSTAT) ......2-14