oil pressure Hyundai H-1 (Grand Starex) 2003 Owner's Manual

INSTRUMENTS & CONTROLS
INSTRUMENTS & CONTROLS INSTRUMENTS & CONTROLS
INSTRUMENTS & CONTROLS
INSTRUMENTS & CONTROLS
2-8 C130A04P-GAT
INDICATION AND WARNING LAMPS
INDICATION AND WARNING LAMPS INDICATION AND WARNING LAMPS
INDICATION AND WARNING LAMPS
INDICATION AND WARNING LAMPS
1. A/T Oil temperature warning light (If installed)
2. 4WD high indicator light
3. Fuel filter warning light (Diesel only)
4. 4WD low indicator light
5. POWER mode indicator light (A/T only)
6. Charge warning light
7. Brake warning and parking brake indicator
light
8. SRS (Airbag) warning light (If installed) 9. Diesel preheat indicator light
10. Overdrive off indicator light (A/T only)
11. Door-ajar warning light
12. Automatic transmission position indicator
light (A/T only)
13. High-beam indicator light
14. Turn-signal indicator light
15. HOLD mode indicator light (A/T only) 16. Oil pressure warning light
17. Low fuel warning light
18. Immobilizer warning indicator light/
Seat belt reminder light (If installed)
19. ABS Service reminder indicator light (SRI) (If installed)
20. Malfunction indicator light (MIL) (If installed)
2
C130A01P-3
14
13 678 1 618 19 20
17
12
111091 345
15

2-9
INSTRUMENTS & CONTROLS
INSTRUMENTS & CONTROLS INSTRUMENTS & CONTROLS
INSTRUMENTS & CONTROLS
INSTRUMENTS & CONTROLS
C130B01P-GAT DOOR-AJAR WARNING
DOOR-AJAR WARNING DOOR-AJAR WARNING
DOOR-AJAR WARNING
DOOR-AJAR WARNING
LAMP-RED
LAMP-RED LAMP-RED
LAMP-RED
LAMP-RED
This lamp illuminates and the warning chime
will sound at the same time when a door is opened or incompletely closed.
C130F01P-GAT TURN-SIGNAL INDICATION
TURN-SIGNAL INDICATION TURN-SIGNAL INDICATION
TURN-SIGNAL INDICATION
TURN-SIGNAL INDICATION
LAMPS-GREEN
LAMPS-GREEN LAMPS-GREEN
LAMPS-GREEN
LAMPS-GREEN
These indication lamps blink on and off when a
turn-signal lamp is blinking. If the blinking is too short, the cause may be a faulty turn-signallamp connection or a blown lamp bulb.
C130G01P-GAT HIGH-BEAM INDICATION
HIGH-BEAM INDICATION HIGH-BEAM INDICATION
HIGH-BEAM INDICATION
HIGH-BEAM INDICATION
LAMP-BLUE
LAMP-BLUE LAMP-BLUE
LAMP-BLUE
LAMP-BLUE
This indication lamp illuminates when the high
beams are on.
C130H01P-GAT FUEL FILTER WARNING
FUEL FILTER WARNING FUEL FILTER WARNING
FUEL FILTER WARNING
FUEL FILTER WARNING
LAMP-RED
LAMP-RED LAMP-RED
LAMP-RED
LAMP-RED
This lamp illuminates when the ignition switch
is set to the "ON" position and goes off after the engine has started. If it lights up while theengine is running, it indicates that water hasaccumulated inside the fuel filter. If this hap-pens, remove the water from the fuel filter.
(Refer to "In case of emergency")
C130I01P-GAT OVERDRIVE/OFF
OVERDRIVE/OFF OVERDRIVE/OFF
OVERDRIVE/OFF
OVERDRIVE/OFF
INDICATOR (If installed)
INDICATOR (If installed) INDICATOR (If installed)
INDICATOR (If installed)
INDICATOR (If installed)
When the overdrive switch is turned on and 4th
gear is engaged, the overdrive off indicator will go out. This amber indicator will be illuminatedwhen the overdrive switch is turned off.
C130J01P-GAT BRAKE WARNING AND
BRAKE WARNING AND BRAKE WARNING AND
BRAKE WARNING AND
BRAKE WARNING AND
PARKING BRAKE INDICATION
PARKING BRAKE INDICATION PARKING BRAKE INDICATION
PARKING BRAKE INDICATION
PARKING BRAKE INDICATION
LAMP-RED
LAMP-RED LAMP-RED
LAMP-RED
LAMP-RED
With the ignition switch at the "ON" position,
the brake warning lamp illuminates under the following conditions:
1. When the brake fluid level in the reservoir falls to a low level.
2. If a malfunction develops in the brake servo system.
If the lamp illuminates, stop the vehicle immedi-
ately and call the nearest authorized HYUNDAI dealer.
C130C01P-GAT
OIL PRESSURE WARNING
OIL PRESSURE WARNING OIL PRESSURE WARNING
OIL PRESSURE WARNING
OIL PRESSURE WARNING
LAMP-RED
LAMP-RED LAMP-RED
LAMP-RED
LAMP-RED
This lamp illuminates when the ignition switch
is set to the "ON" position and goes off after theengine has started. If it lights up while theengine is running, the engine must be stoppedat once. Contact the nearest authorizedHYUNDAI dealer.
C130D01P-GAT LOW FUEL WARNING
LOW FUEL WARNING LOW FUEL WARNING
LOW FUEL WARNING
LOW FUEL WARNING
LAMP-AMBER
LAMP-AMBER LAMP-AMBER
LAMP-AMBER
LAMP-AMBER
This lamp illuminates when the fuel level in the
fuel tank falls to a low level. If it illuminates, the fuel should be added soon.
C130E01P-GAT CHARGE WARNING
CHARGE WARNING CHARGE WARNING
CHARGE WARNING
CHARGE WARNING
LAMP-RED
LAMP-RED LAMP-RED
LAMP-RED
LAMP-RED
This lamp illuminates when the ignition switch
is set to the "ON" position and goes off after the engine has started. If it lights up while theengine is running, there is a problem in thecharging system. Check to see if the V-belt isbroken, and then contact the nearest autho-rized HYUNDAI dealer.
C130L01P-GAT
DIESEL PREHEAT
DIESEL PREHEAT DIESEL PREHEAT
DIESEL PREHEAT
DIESEL PREHEAT
INDICATION LIGHT-AMBER
INDICATION LIGHT-AMBER INDICATION LIGHT-AMBER
INDICATION LIGHT-AMBER
INDICATION LIGHT-AMBER
The indication light illuminates amber when the
ignition switch is placed at the "ON" position. The engine can be started after the preheatindication light goes off. The illuminating timevaries with the water temperature.
Water temperature
(°C)
Below -30 -20
0
20 40 Illuminating time
(sec)
151032 1

IN CASE OF EMERGENCY
IN CASE OF EMERGENCY IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
IN CASE OF EMERGENCY
4-3
GS40090A
Notch of handle
Pressure piston
Then fit the handle into the pressure piston, and
align the groove of the handle with the notch of the holder.
Move the jack handle up and down to raise the
piston.
Using a jack handle, turn the relief valve coun-
terclockwise slowly to lower the piston.
Press the piston down all the way, and turn the
relief valve clockwise as far as possible.
GS40100A
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
(1)(1)
(1)(1)
(1)
Use only the jack included with the ve-
Use only the jack included with the ve- Use only the jack included with the ve-
Use only the jack included with the ve-
Use only the jack included with the ve-
hicle and use it only for changing a wheel.
hicle and use it only for changing a wheel. hicle and use it only for changing a wheel.
hicle and use it only for changing a wheel.
hicle and use it only for changing a wheel.
(2)(2)
(2)(2)
(2)
Position the jack on a hard level surface.
Position the jack on a hard level surface. Position the jack on a hard level surface.
Position the jack on a hard level surface.
Position the jack on a hard level surface.
(3)(3)
(3)(3)
(3)
If the relief valve is loosened by turning
If the relief valve is loosened by turning If the relief valve is loosened by turning
If the relief valve is loosened by turning
If the relief valve is loosened by turning
it 2 or more times in the counterclock-
it 2 or more times in the counterclock- it 2 or more times in the counterclock-
it 2 or more times in the counterclock-
it 2 or more times in the counterclock-
wise direction, the jack’s oil will leak and
wise direction, the jack’s oil will leak and wise direction, the jack’s oil will leak and
wise direction, the jack’s oil will leak and
wise direction, the jack’s oil will leak and
the jack cannot be used.
the jack cannot be used. the jack cannot be used.
the jack cannot be used.
the jack cannot be used.
(4)(4)
(4)(4)
(4)
This jack is hydraulic, and the ram is a
This jack is hydraulic, and the ram is a This jack is hydraulic, and the ram is a
This jack is hydraulic, and the ram is a
This jack is hydraulic, and the ram is a
two-stage type. When both rams are
two-stage type. When both rams are two-stage type. When both rams are
two-stage type. When both rams are
two-stage type. When both rams are
raised and the stop mark(Green paint)
raised and the stop mark(Green paint) raised and the stop mark(Green paint)
raised and the stop mark(Green paint)
raised and the stop mark(Green paint)
of the upper ram becomes visible, stop
of the upper ram becomes visible, stop of the upper ram becomes visible, stop
of the upper ram becomes visible, stop
of the upper ram becomes visible, stop
jacking immediately.
jacking immediately. jacking immediately.
jacking immediately.
jacking immediately.
Further extension of the ram may dam-
Further extension of the ram may dam- Further extension of the ram may dam-
Further extension of the ram may dam-
Further extension of the ram may dam-
age the jack.
age the jack. age the jack.
age the jack.
age the jack.
(5)(5)
(5)(5)
(5) When the jack is used, be sure that there
When the jack is used, be sure that there When the jack is used, be sure that there
When the jack is used, be sure that there
When the jack is used, be sure that there
is no one in or under the vehicle.
is no one in or under the vehicle. is no one in or under the vehicle.
is no one in or under the vehicle.
is no one in or under the vehicle. (6)(6)
(6)(6)
(6) When jacking up the vehicle, do so only
When jacking up the vehicle, do so only When jacking up the vehicle, do so only
When jacking up the vehicle, do so only
When jacking up the vehicle, do so only
until the tires are slightly lifted from the
until the tires are slightly lifted from the until the tires are slightly lifted from the
until the tires are slightly lifted from the
until the tires are slightly lifted from the
ground. It is dangerous to jack up the
ground. It is dangerous to jack up the ground. It is dangerous to jack up the
ground. It is dangerous to jack up the
ground. It is dangerous to jack up the
vehicle more than that much.
vehicle more than that much. vehicle more than that much.
vehicle more than that much.
vehicle more than that much.
(7)(7)
(7)(7)
(7) It is very dangerous if the jack somehow
It is very dangerous if the jack somehow It is very dangerous if the jack somehow
It is very dangerous if the jack somehow
It is very dangerous if the jack somehow
slips, so never leave the vehicle in the
slips, so never leave the vehicle in the slips, so never leave the vehicle in the
slips, so never leave the vehicle in the
slips, so never leave the vehicle in the
jacked-up position, and never shake the
jacked-up position, and never shake the jacked-up position, and never shake the
jacked-up position, and never shake the
jacked-up position, and never shake the
vehicle while it is raised.
vehicle while it is raised. vehicle while it is raised.
vehicle while it is raised.
vehicle while it is raised.
E040B01P-GAT To jack up vehicle on 4-wheel drive
To jack up vehicle on 4-wheel drive To jack up vehicle on 4-wheel drive
To jack up vehicle on 4-wheel drive
To jack up vehicle on 4-wheel drive
GS40110A
Do not crank the engine while jacking up the
vehicle.
The tire on the ground may turn and the vehicle
may roll off the jack.

APPEARANCE CARE
APPEARANCE CARE APPEARANCE CARE
APPEARANCE CARE
APPEARANCE CARE
5-2 Have the underbody checked regularly (au-
tumn and spring) and have additional protec- tion treatment carried out as required. As not allof the commercially available materials aresuitable for use on your vehicle, it is recom-mended that you have this work done at anauthorized HYUNDAI dealer.
When washing the vehicle, especially in winter,
spray the underbody with water to remove dirtand dust which might contain salts, road chemi-cals, etc. Clean the carpeting with a vacuum cleaner andremove any stains with carpet cleaner.Oil and grease can be removed by lightlydabbing with a clean colorfast cloth and ben-zene or spot remover.
F010O01P-GAT
Load weight and driving speed
Load weight and driving speed Load weight and driving speed
Load weight and driving speed
Load weight and driving speed
Remove any luggage, etc., which is not neces-sary from the vehicle. The load weight placedon the roof or towed in a trailer also should notbe excessive. Correctly adjusting the air pressure of the tires before driving under maximum load weight con-ditions and before driving long distances isespecially important. F010P01P-GAT
Tire replacement
Tire replacement Tire replacement
Tire replacement
Tire replacement
Tires which do not meet the size specifications must not be used. Replacement of the tiresmust be made as a set of the two front tires, thetwo rear tires, or all four tires. A mixture of bias-ply tires and radial tires must not be used. Consult an authorized HYUNDAIdealer regarding tire replacement. F010Q01P-GAT
Kerb parking
Kerb parking Kerb parking
Kerb parking
Kerb parking
If the tires strike a kerb or concrete parking barrier, they could be damaged, and this dam-age could become a source of extreme dangerwhen the vehicle is subsequently driven at highspeed. If the vehicle is to be driven or onto akerb or any other such barrier, it should bedriven slowly and at an appropriate angle to thekerb or barrier.
F010J01P-GAT
Engine compartment
Engine compartment Engine compartment
Engine compartment
Engine compartment
Clean the engine compartment at the beginning
and end of winter. Pay particualr attention toflanges, crevices, and peripheral parts wheredust containing road chemicals and other cor-rosive materials might collect.
If salt and other chemicals are used on the
roads in your area, clean the engine compart-ment at least every three months.
F010K01P-GATUpholstery and Interior
Upholstery and Interior Upholstery and Interior
Upholstery and Interior
Upholstery and Interior
To maintain the value of your new vehicle,
handle the upholstery carefully and keep theinterior clean.
Use a vacuum cleaner and brush to clean the
seats. If stained, vinyl and synthetic leathershould be cleaned with an appropriate cleaner,and cloth fabrics can be cleaned with eitherupholstery cleaner or a 3% solution of neutraldetergent in lukewarm water. F010L01P-GAT
Damaged paint
Damaged paint Damaged paint
Damaged paint
Damaged paint
Small cracks and scratches in the paint coatshould be touched up as soon as possible withHYUNDAI paint pencil or spray paint to preventcorrosion. Check body areas facing the road orthe tires especially carefully for damage to thepaint coat caused by flying stones, etc. Thepaint code number for your vehicle can befound on the vehicle information code plate.
F010M01P-GATTarTar
TarTar
Tar
If tar becomes adhered to the vehicle, usespecial tar remover to remove it as soon aspossible. If the tar leaves a stain, polish theaffected area. F010N01P-GAT
Plastic and rubber parts
Plastic and rubber parts Plastic and rubber parts
Plastic and rubber parts
Plastic and rubber parts
Use a soft cloth and wash with water. If neces- sary, a cleaning agent specially designed forplastics can be used. If engine oil, brake fluid,battery fluid, etc., comes in contact with theseparts, wash promptly with water and then usealcohol to remove the stain completely.

5-3
APPEARANCE CARE
APPEARANCE CARE APPEARANCE CARE
APPEARANCE CARE
APPEARANCE CARE
F010R01P-GAT Tire care
Tire care Tire care
Tire care
Tire care
For driving safely, and in order to obtain the
maximum useful life of the tires, the following points should be observed. For informationconcerning inspection, air pressure, and rota-tion of the tires, refer to the part which dealswith wheels in the section of this manual en-titled "Consumer Information".
F010S01P-GATTire air pressure
Tire air pressure Tire air pressure
Tire air pressure
Tire air pressure
The air pressure of the tires must always be
maintained in accordance with the specifica-tions, and should be measured when the tiresare cool.
If any changes in driving conditions(speed and/
or load weight) occur, the air pressure of thetires must meet the specifications which applyto the new driving conditions. If the vehicle isgoing to be driven under varying load weight,etc., the air pressure must be adjusted in orderto meet the highest specifications of the condi-tions under which the vehicle is driven (highspeeds and maximum load weight).
F010T01P-GATTire storage
Tire storage Tire storage
Tire storage
Tire storage
Storage of the tires should be in a dark, well-
ventilated place.
Tires not mounted on rims should be stored
vertically. Be sure that the tires are not incontact with fuel, oil grease, etc.

6-3
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
DESCRIPTION
GENERAL MAINTENANCE ENGINE COOLANT *1 MANUAL TRANSMISSION OILAUTOMATIC TRANSMISSION OILTRANSFER CASE OIL *2REAR AXLE OILCLUTCH / BRAKE PEDAL FREE PLAY CLUTCH / BRAKE OIL RESERVOIR BRAKE HYDRAULIC FLUIDFRONT BRAKE PADSFRONT BRAKE CALIPERS / CYLINDERS / DISCREAR BRAKE DRUMS / LININGS / CYLINDERSHANDBRAKETIRE CONDITION / PRESSURE EXHAUST SYSTEM / MOUNTING STEERING JOINT / RACK / BOX OIL LEAKSSUSPENSION JOINT / SEALSFRONT WHEEL BEARINGENGINE COOLANT HOSESBRAKE PIPE CORROSION SEATBELTS / MOUNTINGS HEAD LAMPSAIR FILTER (For Evaporator and Blower unit) *3
NO.
123456 7 89
10111213 14 1516171819 20 2122
G030A04P-GAT R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY
70 56
I I I I I I III I I 80 64
I I
R II I IIII I I IIII I90 72
I I I III I I I I I II
20 16
I I I II I IIIII I IIII I 30 24
I I I III I III I II 40 32
I I
R II I III I I IIIII I 50 40
I I I I I I III I I 60 48
I I I IIIII I I I I IIIIIII
See below
KILOMETERS X 1000 MONTHS
54
R 10
8
I I I I I I III I I
See below
*1. For every 24 months or 40,000 km, whichever occurs first : "R"
*2. For every 24 months or 48,000 km, whichever occurs first : "R"
*3. For every 12 months or 20,000 km, whichever occurs first : "R" See below

6-7
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
PREVENTIVE MAINTENANCE
DESCRIPTION
GENERAL MAINTENANCE ENGINE COOLANT *1 MANUAL TRANSMISSION OIL AUTOMATIC TRANSMISSION OIL TRANSFER CASE OIL *2 REAR AXLE OIL CLUTCH/BRAKE PEDAL FREEPLAY CLUTCH/BRAKE OIL RESERVOIR BRAKE HYDRAULIC FLUID FRONT BRAKE PAD FRONT BRAKE CALIPERS/CYLINDERS/DISC REAR BRAKE DRUMS/LININGS/CYLINDERS HAND BRAKE TIRE CONDITION/PRESSURE EXHAUST SYSTEM/MOUNTING STEERING JOINT/RACK/BOX/OIL LEAKS SUSPENSION JOINT/SEALS FRONT WHEEL BEARING ENGINE COOLANT HOSES BRAKE PIPE CORROSION
AIR FILTER (F o r Evapoerator and Blower unit) *3
NO.
12 3 4 5 6 7 8 9
1011 12 13 14 15 16 17 18 19 20KILOMETERS X 1000 MONTH90 72
I
R R I I I I I I I I I I I I I I
G060A04P-GAT R : REPLACE I : INSPECT AND, AFTER INSPECTION, CLEAN, ADJUST, REPAIR OR REPLACE IF NECESSARY15 12
II I I I I I I I 30 24
II I I I I I I I I I I I I I I I 4536
II
R II I I I I 60 48
II I I I I I I I I I I I I I I I 7560
II I I I I I I I7.5 6
R
See below See below
*1. For every 24 months or 45,000 km, whichever occurs first : "R" *2. For every 24 months or 48,000 km, whichever occurs first : "R"*3. For every 12 months or 20,000 km, whichever occurs first : "R"
See below

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-6 I040A01P-GAT
Vehicle Interior
Vehicle Interior Vehicle Interior
Vehicle Interior
Vehicle Interior
The following should be checked each time when the vehicle is driven:
o Light operation
o Windshield wiper operation
o Horn operation
o Defroster, heater operation (and air condi- tioning, if equipped)
o Steering operation and condition
o Mirror condition and operation
o Turn signal operation
o Accelerator pedal operation
o Brake operation, including parking brake
o Manual transmission operation, including clutch operation
o Automatic transmission operation, including "Park" mechanism operation
o Seat control condition and operation
o Seat belt condition and operation
o Sunvisor operation
If you notice anything that does not operate correctly or appear to be functioning correctly,inspect it carefully and seek assistance fromyour Hyundai dealer if service is needed. Adequate care of your vehicle at regular inter- vals serves to preserve the value and appear-ance as long as possible. Some maintenance items can be carried out bythe owner (Consumer Information), while othershould be done only by an authorized dealer(Periodic Inspection and Maintenance). Thissection describes only those items which canbe carried out by the owner. In the event amalfunction or other problem is discovered,have it corrected by an authorized HYUNDAIdealer. This section contains information oninspection maintenance procedures that youcan do yourself, if you so desire. Follow theinstructions and cautions for each of the vari-ous procedures. When checking or servicing the inside of the engine compartment, be sure the engine isstopped and has had a chance to cool down. Ifit is necessary to do work in the engine com-partment with the engine running, be especiallycareful that your clothing, hair, etc., becomesnot caught by the fan, V-belts, or other movingparts. I050A01P-GAT
Inspection items
Inspection items Inspection items
Inspection items
Inspection items
( 1 ) Engine oil
( 2 ) Engine coolant
(3) Battery
( 4 ) Brake fluid
( 5 ) Clutch fluid (hydraulic clutch only)
( 6 ) Washer fluid
( 7 ) Wheel condition (including spare wheel)
(8) Tire inflation pressure (including spare
wheel)
I020A02P-GAT
GENERAL CHECKS
GENERAL CHECKS GENERAL CHECKS
GENERAL CHECKS
GENERAL CHECKS
Engine Compartment
Engine Compartment Engine Compartment
Engine Compartment
Engine Compartment The following should be checked regularly:
o Engine oil level and condition
o Transmission fluid level and condition
o Brake fluid level
o Clutch fluid level
o Engine coolant level
o Windshield washer fluid level
o Accessory drive belt condition
o Coolant hose condition
o Fluid leaks (on or below components)
o Power steering fluid level and condition
o Tire pressure and condition (including spare)
o Battery condition I030A02P-GAT
Vehicle Exterior
Vehicle Exterior Vehicle Exterior
Vehicle Exterior
Vehicle Exterior The following should be checked monthly:
o Overall appearance and condition
o Wheel condition and wheel nut tightness
o Air cleaner filter condition
o Exhaust system condition
o Light condition and operation
o Windshield glass condition
o Wiper blade condition
o Paint condition and corrosion
o Fluid leaks
o Door and hood lock condition

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-8 G350A01A-GAT
ENGINE OIL CONSUMPTION
ENGINE OIL CONSUMPTION ENGINE OIL CONSUMPTION
ENGINE OIL CONSUMPTION
ENGINE OIL CONSUMPTION
Function of Engine Oil
Function of Engine Oil Function of Engine Oil
Function of Engine Oil
Function of Engine Oil
Engine oil has the primary function of lubricat-
ing and cooling the inside of the engine.
Engine oil consumption
Engine oil consumption Engine oil consumption
Engine oil consumption
Engine oil consumption
It is normal that an engine should consumesome engine oil while normal driving. The cause
of oil consumption in a normal engine are asfollows;
o Engine oil is used to lubricate pistons, piston
rings and cylinders. A thin film of oil is left on the cylinder wall when a piston moves downwards in the
cylinder. High negative pressure generatedduring engine operation sucks some of the
oil into the combustion chamber.This oil with some oil of the cylinder wall isburned by the high temperature combustion
gases during the combustion process.
o The engine oil consumption is strongly ef- fected by the viscosity and quality of oil,
engine rpm and driving condition etc. Theengine oil is more consumed under severe
driving conditions such as high speeds andfrequent acceleration and deceleration than
normal driving condition.
NOTE:
NOTE: NOTE:
NOTE:
NOTE:
For diesel-powered vehicle SAE 0W-30 oil
For diesel-powered vehicle SAE 0W-30 oil For diesel-powered vehicle SAE 0W-30 oil
For diesel-powered vehicle SAE 0W-30 oil
For diesel-powered vehicle SAE 0W-30 oil should be used only in areas where ex-
should be used only in areas where ex- should be used only in areas where ex-
should be used only in areas where ex-
should be used only in areas where ex-
tremely cold temperatures of 10°C (50°F) or
tremely cold temperatures of 10°C (50°F) or tremely cold temperatures of 10°C (50°F) or
tremely cold temperatures of 10°C (50°F) or
tremely cold temperatures of 10°C (50°F) or
below are experienced.
below are experienced. below are experienced.
below are experienced.
below are experienced.
For diesel-powered vehicle, if the atmo-
For diesel-powered vehicle, if the atmo- For diesel-powered vehicle, if the atmo-
For diesel-powered vehicle, if the atmo-
For diesel-powered vehicle, if the atmo-spheric temperatures are 0°C (32°F) or be-
spheric temperatures are 0°C (32°F) or be- spheric temperatures are 0°C (32°F) or be-
spheric temperatures are 0°C (32°F) or be-
spheric temperatures are 0°C (32°F) or be-
low, SAE 30 oil must not be used. This oil
low, SAE 30 oil must not be used. This oil low, SAE 30 oil must not be used. This oil
low, SAE 30 oil must not be used. This oil
low, SAE 30 oil must not be used. This oil
should be used only in areas where the
should be used only in areas where the should be used only in areas where the
should be used only in areas where the
should be used only in areas where the
atmospheric temperatures are 0°C(32°F) or
atmospheric temperatures are 0°C(32°F) or atmospheric temperatures are 0°C(32°F) or
atmospheric temperatures are 0°C(32°F) or
atmospheric temperatures are 0°C(32°F) or
above.
above. above.
above.
above.
GS80050A
Gasoline Engine
Diesel Engine ( Except 2.5 CRDi)
GT80051A-1
Diesel Engine (
2.5 CRDi only)
G030B02HP

8-9
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
G210A01A-AATCHECKING THE BATTERY
CHECKING THE BATTERY CHECKING THE BATTERY
CHECKING THE BATTERY
CHECKING THE BATTERY
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
When working with batteries, carefully ob-
When working with batteries, carefully ob- When working with batteries, carefully ob-
When working with batteries, carefully ob-
When working with batteries, carefully ob-
serve the following precautions to avoid
serve the following precautions to avoid serve the following precautions to avoid
serve the following precautions to avoid
serve the following precautions to avoid
serious injuries.
serious injuries. serious injuries.
serious injuries.
serious injuries. The fluid in the battery contains a strong solu- tion of sulfuric acid, which is poisonous andhighly corrosive. Be careful not to spill it onyourself or the car. If you do spill battery fluid onyourself, immediately do the following:
o If battery fluid is on your skin, flush the affected areas with water for at least 15minutes and then seek medical assistance.
o If battery fluid is in your eyes, rinse out your eyes with water and get medical assistanceas soon as possible. While you are beingdriven to get medical assistance, continueto rinse your eyes by using a sponge or softcloth saturated with water.
o If you swallow battery fluid, drink a large quantity of water or milk followed by milk ofmagnesia, eat a raw egg or drink vegetableoil. Get medical assistance as soon aspossible.
While batteries are being charged (either by abattery charger or by the vehicle’s alternator),they produce explosive gases. Always observethese warnings to prevent injuries from occur-ring:
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia- Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia- tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant
system is under pressure and any hot cool-
system is under pressure and any hot cool- system is under pressure and any hot cool-
system is under pressure and any hot cool-
system is under pressure and any hot cool-
ant escaping could cause severe burns.
ant escaping could cause severe burns. ant escaping could cause severe burns.
ant escaping could cause severe burns.
ant escaping could cause severe burns.
I080B01P-GATAnti-freeze
Anti-freeze Anti-freeze
Anti-freeze
Anti-freeze
The engine coolant contains an ethylene glycol
anti-corrosion agent. The cylinder head and coolant pump housing are cast aluminium alloy,and periodic changing of the engine coolant isnecessary to prevent corrosion of these parts. Because of the necessity of this anti-corrosion
agent, the coolant must not be replaced withplain water even in summer.
The required concentration of anti-freeze differs
depending on the expected ambient tempera-ture.
Ambient tempera-ture (minimum) °C (°F) Anti-freeze concentration %
-10
(15)
30 -20
(-5)
40 -30
(-20)
50 -45
(-49)
60
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen- performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen-
tration within the range of 30 to 60%.
tration within the range of 30 to 60%. tration within the range of 30 to 60%.
tration within the range of 30 to 60%.
tration within the range of 30 to 60%.
Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result in Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result ina reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool- a reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool-
ing performance thus adversely affecting
ing performance thus adversely affecting ing performance thus adversely affecting
ing performance thus adversely affecting
ing performance thus adversely affecting
the engine.
the engine. the engine.
the engine.
the engine.
I080A01P-GAT
ENGINE COOLANT
ENGINE COOLANT ENGINE COOLANT
ENGINE COOLANT
ENGINE COOLANT
I080A01P-GAG
FULL
LOW
A translucent coolant reservoir tank is in the
engine compartment. The coolant level in this tank should be kept
between the "LOW" and "FULL" marks when measured while the engine is warm and idling.
The cooling system is a closed system and
normally the loss of coolant should be veryslight. A noticeable drop in the coolant levelcould indicate leakage.
If this occurs, have the system checked at an
authorized HYUNDAI dealer as soon as pos-sible.
If the level should drop below the "LOW" level
on the reservoir tank, add coolant.
Also, if the reservoir tank is completely empty,
remove the radiator cap and add coolant untilthe level reaches the filler neck.