engine HYUNDAI I10 2019 Repair Manual
[x] Cancel search | Manufacturer: HYUNDAI, Model Year: 2019, Model line: I10, Model: HYUNDAI I10 2019Pages: 486, PDF Size: 6.04 MB
Page 291 of 486
6-35
06
Parking brake warning light
& K H F N W K H 3 D U N L Q J % U D N H
Warning Light by placing
the ignition switch to the
ON position (do not start
the engine).
This light will be illuminated when the
parking brake is applied with the igni-
tion switch in the START or ON posi-
tion.
% H I R U H G U L Y L Q J E H V X U H W K H S D U N L Q J
E U D N H L V U H O H D V H G D Q G W K H % U D N H
Warning Light is OFF.
, I W K H 3 D U N L Q J % U D N H : D U Q L Q J / L J K W
remains on after the parking brake is
released whilst the engine is running,
there may be a malfunction in the
brake system. Immediate attention is
necessary.
If at all possible, cease driving the
vehicle immediately. If that is not pos-
sible, use extreme caution whilst
operating the vehicle and only con-
tinue to drive the vehicle until you can
reach a safe location.
Anti-lock Brake System (ABS)
WARNING
$ Q $ Q W L / R F N % U D N L Q J 6 \ V W H P
(ABS) or an Electronic Stability
Control (ESC) system will not pre-
vent accidents due to improper or
dangerous driving manoeuvres.
Even though vehicle control is
improved during emergency brak-
ing, always maintain a safe dis-
tance between you and objects
ahead of you. Vehicle speeds
should always be reduced during
extreme road conditions. The brak-
ing distance for vehicles equipped
with ABS or ESC may be longer
than for those without these sys-
tems in the following road condi-
tions.
Drive your vehicle at reduced
speeds during the following condi-
tions:
Page 292 of 486
6-36
Whilst driving
Using ABS
To obtain the maximum benefit from
\ R X U $ % 6 L Q D Q H P H U J H Q F \ V L W X D W L R Q
do not attempt to modulate your
brake pressure and do not try to
pump your brakes. Depress your
brake pedal as hard as possible.
When you apply your brakes under
conditions which may lock the wheels,
you may hear sounds from the
brakes, or feel a corresponding sen-
sation in the brake pedal. This is nor-
P D O D Q G L W P H D Q V \ R X U $ % 6 L V D F W L Y H
$ % 6 G R H V Q R W U H G X F H W K H W L P H R U G L V-
tance it takes to stop the vehicle.
Always maintain a safe distance from
the vehicle in front of you.
$ % 6 Z L O O Q R W S U H Y H Q W D V N L G W K D W U H V X O W V
from sudden changes in direction,
such as trying to take a corner too
fast or making a sudden lane change.
Always drive at a safe speed for the
road and weather conditions.
$ % 6 F D Q Q R W S U H Y H Q W D O R V V R I V W D E L O L-
ty. Always steer moderately when
braking hard. Severe or sharp steer-
ing wheel movement can still cause
your vehicle to veer into oncoming
traffic or off the road.
On loose or uneven road surfaces,
operation of the anti-lock brake sys-
tem may result in a longer stopping
distance than for vehicles equipped
with a conventional brake system.
7 K H $ % 6 Z D U Q L Q J O L J K W
) will stay
on for several seconds after the igni-
tion switch is in the ON position.
' X U L Q J W K D W W L P H W K H $ % 6 Z L O O J R
through self-diagnosis and the light
will go off if everything is normal. If
the light stays on, you may have a
S U R E O H P Z L W K \ R X U $ % 6 : H U H F R P-
mend that you contact a HYUNDAI
authorised repairer as soon as pos-
sible.
WARNING
If the ABS warning light () is on
and stays on, you may have a
problem with the ABS. Your power
brakes will work normally. To
reduce the risk of serious injury or
death, we recommend that you
contact a HYUNDAI authorised
repairer as soon as possible.
NOTICE
When you drive on a road having
poor traction, such as an icy road,
and apply your brakes continuous-
ly, the ABS will be active continu-
ously and the ABS warning light
(
) may illuminate. Pull your
vehicle over to a safe place and
turn the engine off.
Restart the engine. If the ABS
warning light is off, then your ABS
system is normal.
Otherwise, you may have a prob-
lem with your ABS system. We rec-
ommend that you contact a
HYUNDAI authorised repairer as
soon as possible.
i Information
When you jump start your vehicle
because of a drained battery, the ABS
warning light (
) may turn on at the
same time. 7his happens because of the
low battery voltage. It does not mean
your ABS is malfunctioning. +ave the
battery recharged before driving the
vehicle.
Page 293 of 486
6-37
06
Electronic Stability Control
(ESC)
2 $ & 5
2 $ & 5
„ 7 \ S H %
The Electronic Stability Control (ESC)
system helps to stabilize the vehicle
during cornering manoeuvres.
ESC checks where you are steering
and where the vehicle is actually
going.
ESC applies braking pressure to any
one of the vehicle’s brakes and inter-
venes in the engine management
system to assist the driver with keep-
ing the vehicle on the intended path.
It is not a substitute for safe driving
S U D F W L F H V $ O Z D \ V D G M X V W \ R X U V S H H G
and driving to the road conditions.
WARNING
Never drive too fast for the road
conditions or too quickly when
cornering. The ESC system will
not prevent accidents.
Excessive speed in turns, abrupt
manoeuvres, and hydroplaning on
wet surfaces can result in severe
accidents.
Page 295 of 486
6-39
06
‡ 6 W D W H
2 $ & 7 8
3 U H V V D Q G K R O G W K H ( 6 & 2 ) ) E X W W R Q
continuously for more than 3 sec-
onds. The ESC OFF indicator light
and/or message “Traction control and
ESC disabled” illuminates and a
warning chime sounds. In this state,
both the traction control function of
ESC (engine management) and the
brake control function of ESC (brak-
ing management) are disabled.
If the ignition switch is placed in the
LOCK/OFF position when ESC is off,
ESC remains off. Upon restarting the
vehicle, the ESC will automatically
turn on again.
Indicator lights
„ ESC indicator light (blinks)
„ ESC OFF indicator light (comes on)
2 7 '
2 7 '
When the ignition switch is in the ON
position, the ESC indicator light illu-
minates, then goes off if the ESC sys-
tem is operating normally.
The ESC indicator light blinks when-
ever the ESC is operating.
If the ESC indicator light stays on,
your vehicle may have a malfunction
with the ESC system. When this
warning light illuminates we recom-
mend that the vehicle be checked by
a HYUNDAI authorised repairer as
soon as possible.
The ESC OFF indicator light comes
on when the ESC is turned off with
the button.
WARNING
When the ESC is blinking, this
indicates the ESC is active:
Drive slowly and NEVER attempt
to accelerate. NEVER turn the ESC
off whilst the ESC indicator light is
blinking or you may lose control of
the vehicle resulting in an acci-
dent.
Page 300 of 486
6-44
Whilst driving
The ISG system is to reduce the fuel
consumption by automatically shut-
ting down the engine, when the vehi-
cle is at a standstill (i.e. red stop light,
V W R S V L J Q D Q G W U D I I L F M D P
The engine is automatically started
upon satisfying the starting condi-
tions.
The ISG system is always active,
when the engine is running.
i Information
When the engine is automatically
started by the IS * system, some warn-
ing lights (i.e. ABS, ESC, ESC 2FF,
EPS, and parking brake warning light)
may illuminate for a few seconds due
to the low battery voltage. +owever, it
does not indicate a malfunction with
the IS * system.
To activate the ISG system
Prerequisite for activation
The ISG system operates in the fol-
lowing situations.
‡ 7 K H G U L Y H U‹ V V H D W E H O W L V I D V W H Q H G
Page 301 of 486
6-45
06
Auto stop
7o stop the engine in idle stop mode
Manual transmission vehicle
' H F U H D V H W K H Y H K L F O H V S H H G W R
P S K N P K
2. Set the gear in N (Neutral).
3. Release the clutch pedal.
The auto stop indicator (
) illumi-
nates in green on the instrument clus-
ter, when the engine stops.
i Information
7he driving speed must reach at least 5
km/h (3 mph) after an idle stop to stop
the engine in idle stop mode again.
Automated Manual Transmission
vehicle
' H F U H D V H W K H Y H K L F O H V S H H G W R
km/h.
2. Depress the brake pedal with the
shift lever in D (Drive) or N (Neutral).
The auto stop indicator () illumi-
nates in green on the instrument clus-
ter, when the engine stops.
i Information
7he driving speed must reach at least 3
mph (5 km/h) after an idle stop to stop
the engine in idle stop mode again.In auto stop mode, when the driver
opens the bonnet, the ISG system
will be deactivated.
: K H Q W K H V \ V W H P L V G H D F W L Y D W H G
2 $ & 7 8
The ISG OFF button indicator illumi-
nates.
2 $ & 7 8
The message, ‘‘Auto Stop is Off.
3 U H V V F O X W F K S H G D O D Q G V W D U W H Q J L Q H
manually’’, appears on the LCD dis-
play with a beep sound.
Page 302 of 486
![HYUNDAI I10 2019 Repair Manual 6-46
Whilst driving
At this time, restart the vehicle manu-
D O O \ E \
Manual transmission vehicle
Depressing the clutch and brake
pedal with the gear in neutral.
Automated Manual Transmission](/img/35/56226/w960_56226-301.png "HYUNDAI I10 2019 Repair Manual 6-46
Whilst driving
At this time, restart the vehicle manu-
D O O \ E \
Manual transmission vehicle
Depressing the clutch and brake
pedal with the gear in neutral.
Automated Manual Transmission")
6-46
Whilst driving
At this time, restart the vehicle manu-
D O O \ E \
Manual transmission vehicle
Depressing the clutch and brake
pedal with the gear in neutral.
Automated Manual Transmission
vehicle
Depressing the brake pedal with the
shift lever in N (Neutral).
Auto start
7o restart the engine in the auto stop
mode
Manual transmission vehicle
Page 304 of 486
6-48
Whilst driving
The battery sensor
deactivation
2 $ & 7 8
> $ @ % D W W H U \ V H Q V R U
The battery sensor is deactivated,
when the battery is disconnected
from the negative pole for mainte-
nance purpose.
In this case, the ISG system is limit-
edly operated due to the battery sen-
sor deactivation. Thus, the driver
needs to take the following proce-
dures to reactivate the battery sensor
after disconnecting the battery.
Prerequisites to reactivate the
battery sensor
Keep the engine in the OFF status for
K R X U V D Q G D W W H P S W W R U H V W D U W W K H
H Q J L Q H W R W L P H V I R U W K H E D W W H U \
sensor reactivation.
3 D \ H [ W U H P H F D X W L R Q Q R W W R F R Q Q H F W
any accessories (i.e. navigation and
black box) to the vehicle with the
engine in the OFF status. If not, the
battery sensor may not be reactivat-
ed.
i Information
7he IS * system may not operate in the
following situations.
- 7here is a malfunction with the IS *
system.
- 7he battery is weak.
- 7he brake vacuum pressure is low.
In those cases, we recommend that you
have the IS * system checked by a
+ < 8 1 'AI authorised repairer.
NOTICE
Page 308 of 486
6-52
Whilst driving
Emergency braking
(Second warning)
2 $ & 7 8
This warning message appears on
the LCD display with a warning
chime. Additionally, some vehicle
system intervention occurs by the
engine management system to help
decelerate the vehicle.
7 K H E U D N H F R Q W U R O L V P D [ L P L V H G M X V W
before a collision, reducing impact
when it strikes a forward vehicle.
- It will operate if the vehicle speed is
J U H D W H U W K D Q P S K N P K D Q G
O H V V W K D Q R U H T X D O W R P S K
km/h) on a forward vehicle.
(Depending on the condition of the
vehicle ahead and the environment
surrounding it, the possible maxi-
mum operating speed may be
reduced.)
- For pedestrians, the vehicle speed
is greater than or equal to 6 mph
N P K D Q G O H V V W K D Q P S K
km/h). (Depending on the condition
of pedestrians and the surrounding
environment the possible maximum
operating speed may be reduced.)
- If you select ‘Warning only’, FCA
system activates and produces
only warning alarms in accordance
with the collision risk levels. You
should control the brake directly
because FCA system do not control
the brake.
The others
Page 310 of 486
6-54
Whilst driving
Warning message and warning
light
2 $ & 7 8
Critical forward safety functions are
limited. Camera obscured
When the camera is blocked with dirt,
snow, or debris, FCA system may not
detect other vehicles.
If this occurs, a warning message will
appear on the LCD display.
The system will operate normally
when such dirt, snow or debris is
removed.
FCA may not properly operate in an
area (e.g. open terrain) where any
R E M H F W V R U Y H K L F O H V D U H Q R W G H W H F W H G
after turning on the engine.
Also, even though a warning mes-
sage does not appear on the LCD
display, FCA may not properly oper-
ate.
WARNING
FCA system may not activate
according to road conditions,
inclement weather, driving condi-
tions or traffic conditions.
System malfunction
2 $ & 7 8
Check forward safety systems