media HYUNDAI I20 2023 Workshop Manual
[x] Cancel search | Manufacturer: HYUNDAI, Model Year: 2023, Model line: I20, Model: HYUNDAI I20 2023Pages: 649, PDF Size: 12.35 MB
Page 573 of 649
9-14
Maintenance
„Smartstream G 1.0 T-GDi/ Smartstream G1.0 T-GDi (48V) MHEV
OBC3090011
„Smartstream G1.2
OBC3090013
„Petrol 1.4
OBC3090013R
7. If the oil level is below the L, add
enough oil to bring the level to F.
Use only the specified engine oil (Refer
to “Recommended Lubricants and
Capacities” section in chapter 2).
NOTICE
To prevent damage to your engine:
[ Do not spill engine oil when adding or
changing engine oil. Wipe off spilled
oil immediately.
[ The engine oil consumption may
increase whilst you break in a new
vehicle and it will be stabilized after
driving 6,000 km (4,000 miles).
[ The engine oil consumption can be
affected by driving habits, climate
conditions, traffic conditions,
oil quality, etc. Therefore, it is
recommended that you inspect the
engine oil level regularly and refill it if
necessary.
Page 580 of 649
9-21
09
WARNING
Do not allow brake/clutch fluid to come
in contact with your eyes. If brake/
clutch fluid comes in contact with
your eyes, flush your eyes with clean
water for at least 15 minutes and get
immediate medical attention.
NOTICE
[ ' R Q R W D O O R Z E U D N H F O X W F K I O X L G W R
contact the vehicle’s body paint, as
paint damage will result.
[ % U D N H F O X W F K I O X L G Z K L F K K D V E H H Q
exposed to open air for an extended
time should never be used as its
quality cannot be guaranteed. It
should be disposed of properly.
[ ' R QT W S X W L Q W K H Z U R Q J N L Q G R I I O X L G $
few drops of mineral-based oil, such
as engine oil, in your brake/clutch
system can damage system parts.
Page 588 of 649
9-29
09
WARNING
To prevent SERIOUS INJURY or DEATH
to you or bystanders, always follow
these precautions when working near
or handling the battery:
Always read and follow
instructions carefully when
handling a battery.
Wear eye protection designed
to protect the eyes from acid
splashes.
Keep all flames, sparks, or
smoking materials away from
the battery.
Hydrogen is always present in
battery cells, is highly
combustible, and may explode
if ignited.
% D W W H U L H V F R Q W D L Q V X O I X U L F D F L G
which is highly corrosive. Do
not allow acid to contact your
eyes, skin or clothing.
If acid gets into your eyes, flush your
eyes with clean water for at least 15
minutes and get immediate medical
attention. If acid gets on your skin,
thoroughly wash the area. If you
feel pain or a burning sensation, get
medical attention immediately.
[ When lifting a plastic-cased battery,
excessive pressure on the case may
cause battery acid to leak. Lift with a
battery carrier or with your hands on
opposite corners.
[ Do not attempt to jump start your
vehicle if your battery is frozen.
[ NEVER attempt to recharge the
battery when the vehicle’s battery
cables are connected to the battery.
[ The electrical ignition system works
with high voltage. NEVER touch these
components with the engine running
or when the Engine Start/Stop button
is in the ON position.
[ Do not allow the (+) and (-) jumper
cables to touch. It may cause sparks.
[ The battery may rupture or explode
when you jump start with a low or
frozen battery.
[ Leaked battery electrolyte due to
repeated driving on sharp curves
(e.g. on circuits) may cause safety
problem. Avoid repeated driving on
sharp curves.
NOTICE
If you connect unauthorised electronic
devices to the battery, the battery may
be discharged. Never use unauthorised
devices.
% $ 7 7 ( 5 <
Page 589 of 649
9-30
Maintenance
For best battery service
OBC3090024
[ Keep the battery securely mounted.
[ Keep the battery top clean and dry.
[ Keep the terminals and connections
clean, tight, and coated with
petroleum jelly or terminal grease.
[ Rinse any spilled electrolyte from the
battery immediately with a solution of
water and baking soda.
[ If the vehicle is not going to be used
for an extended time, disconnect the
battery cables.
i Information
- For batteries marked with
UPPER and LOWER
OHYK077011
, I \ R X U Y H K L F O H L V H T X L S S H G Z L W K D E D W W H U \
P D U N H G Z L W K / 2 : ( 5 0 , 1 D Q G 8 3 3 ( 5
0 $ ; R Q W K H V L G H \ R X V K R X O G F K H F N W K H
H O H F W U R O \ W H O H Y H O
7 K H H O H F W U R O \ W H O H Y H O V K R X O G E H E H W Z H H Q
/ 2 : ( 5 0 , 1 D Q G 8 3 3 ( 5 0 $ ;
: K H Q W K H H O H F W U R O \ W H O H Y H O L V O R Z D G G
G L V W L O O H G R U G H P L Q H U D O L ] H G Z D W H U 1 H Y H U
D G G V X O I X U L F D F L G V R U R W K H U H O H F W U R O \ W H
% H F D U H I X O Q R W W R V S L O O G L V W L O O H G R U
G H P L Q H U D O L ] H G Z D W H U R Y H U W K H E D W W H U \
V X U I D F H R U R W K H U D G M D F H Q W F R P S R Q H Q W V
$ O V R G R Q R W R Y H U I L O O W K H E D W W H U \ F H O O V
, I Q R W L W P D \ F R U U R G H W K H E D W W H U \ R U R W K H U
F R P S R Q H Q W V ) L Q D O O \ V H F X U H O \ F O R V H W K H
F H O O F D S + R Z H Y H U Z H U H F R P P H Q G \ R X W R
F R Q W D F W D + < 8 1 ' $ , D X W K R U L V H G U H S D L U H U
I R U E H W W H U E D W W H U \ V H U Y L F H
Page 620 of 649
9-61
09
OLMB073042L
WARNING
[ Handle halogen bulbs with care.
Halogen bulbs contain pressurized
gas that will produce flying pieces
of glass that could cause injuries if
broken.
[ Wear eye protection when changing
a bulb. Allow the bulb to cool down
before handling it.
[ Always handle them carefully, and
avoid scratches and abrasions. If
the bulbs are lit, avoid contact with
liquids.
[ Never touch the glass with bare
hands. Residual oil may cause the bulb
to overheat and burst when lit.
[ A bulb should be operated only when
installed in a headlight.
[ If a bulb becomes damaged or
cracked, replace it immediately and
carefully dispose of it.
i Information
: H U H F R P P H Q G W K D W W K H K H D G O L J K W D L P L Q J
E H D G M X V W H G D I W H U D Q D F F L G H Q W R U D I W H U W K H
K H D G O L J K W D V V H P E O \ L V U H L Q V W D O O H G
❈ 7 U D I I L F & K D Q J H ) R U ( X U R S H
The low beam light distribution is
asymmetric. If you go abroad to a
country with opposite traffic direction,
this asymmetric part will dazzle
oncoming car driver. To prevent dazzle,
ECE regulation demands several
technical solutions (ex. automatic
change system, adhesive sheet, down
aiming). This headlamps are designed
not to dazzle opposite drivers.
So, you need not change your
headlamps in a country with the
opposite traffic direction.
Page 639 of 649
9-80
Maintenance
NOTICE
If you park your vehicle near a stainless
steel sign or glass facade building, the
vehicle’s exterior plastic parts such
as a bumper, spoiler, garnish, lamp
or outside rearview mirror might be
damaged due to sunlight reflected
from the sign or building. To prevent
damage of the exterior plastic parts,
you should avoid parking in areas
where light may be reflected or use a
car cover. (The exterior plastic parts
applied to your vehicle may vary.)
Exterior care
Exterior general caution
It is very important to follow the label
directions when using any chemical
cleaner or polish. Read all warning and
caution statements that appear on the
label.
Finish maintenance
: D V K L Q J
To help protect your vehicle’s finish
from rust and deterioration, wash it
thoroughly and frequently at least once
a month with lukewarm or cold water.
If you use your vehicle for off-road driving,
you should wash it after each off-road trip.
Pay special attention to the removal of any
accumulation of salt, dirt, mud, and other
foreign materials. Make sure the drain
holes in the lower edges of the doors and
rocker panels are kept clear and clean.
Insects, tar, tree sap, bird droppings,
industrial pollution and similar deposits
can damage your vehicle’s finish if not
removed immediately.
Even prompt washing with plain water
may not completely remove all these
deposits.
A mild soap, safe for use on painted
surfaces, may be used.
After washing, rinse the vehicle
thoroughly with lukewarm or cold water.
Do not allow soap to dry on the finish.
NOTICE
[ ' R Q R W X V H V W U R Q J V R D S F K H P L F D O
detergents or hot water, and do not
wash the vehicle in direct sunlight
or when the body of the vehicle is
warm.
[ % H F D U H I X O Z K H Q Z D V K L Q J W K H V L G H
windows of your vehicle.
Especially, with high-pressure water,
water may leak through the windows
and wet the interior.
[ 7 R S U H Y H Q W G D P D J H W R W K H S O D V W L F
parts and lamps, do not clean
with chemical solvents or strong
detergents.
WARNING
Wet brakes
After washing the vehicle, test the
brakes whilst driving slowly to see if
they have been affected by water. If
braking performance is impaired, dry
the brakes by applying them lightly
whilst maintaining a slow forward
speed.
+ L J K S U H V V X U H Z D V K L Q J
[ : K H Q X V L Q J K L J K S U H V V X U H Z D V K H U V
make sure to maintain sufficient
distance from the vehicle.
Insufficient clearance or excessive
pressure can lead to component
damage or water penetration.
[ ' R Q R W V S U D \ W K H F D P H U D V H Q V R U V R U
its surrounding area directly with a
high pressure washer. Shock applied
from high pressure water may cause
the device to not operate normally.
[ ' R Q R W E U L Q J W K H Q R ] ] O H W L S F O R V H W R
boots (rubber or plastic covers) or
connectors as they may be damaged
if they come into contact with high
pressure water.
APPEARANCE CARE
Page 640 of 649
9-81
09
OBC3090054
NOTICE
[ : D W H U Z D V K L Q J L Q W K H H Q J L Q H
compartment including high pressure
water washing may cause the failure
of electrical circuits located in the
engine compartment.
[ 1 H Y H U D O O R Z Z D W H U R U R W K H U O L T X L G V
to come in contact with electrical/
electronic components inside the
vehicle as this may damage them.
NOTICE
Matte paint finish vehicle
(if equipped)
Automatic car wash which uses
rotating brushes should not be used
as this can damage the surface of your
vehicle. A steam cleaner which washes
the vehicle surface at high temperature
may result the oil to adhere and leave
stains that is difficult to remove.
Use a soft cloth (e.g. microfiber towel
or sponge) when washing your vehicle
and dry with a microfiber towel. When
you handwash your vehicle, you should
not use a cleaner that finishes with
wax. If the vehicle surface is too dirty
(sand, dirt, dust, contaminant, etc.),
clean the surface with water before
washing the car.
: D [ L Q J
Wax the vehicle when water will no
longer bead on the paint.
Always wash and dry the vehicle
before waxing. Use a good quality
liquid or paste wax, and follow the
manufacturer’s instructions. Wax all
metal trim to protect it and to maintain
its luster. Removing oil, tar, and similar
materials with a spot remover will
usually strip the wax from the finish. Be
sure to re-wax these areas even if the
rest of the vehicle does not yet need
waxing.
NOTICE
[ : L S L Q J G X V W R U G L U W R I I W K H E R G \ Z L W K
a dry cloth will scratch the finish.
[ ' R Q R W X V H V W H H O Z R R O D E U D V L Y H
cleaners, or strong detergents
containing highly alkaline or caustic
agents on chrome-plated or anodized
aluminium parts. This may result in
damage to the protective coating
and cause discolouration or paint
deterioration.
NOTICE
Matte paint finish vehicle
(if equipped)
Do not use any polish protector such as
a detergent, an abrasive and a polish.
In case wax is applied, remove the wax
immediately using a silicon remover
and if any tar or tar contaminant is on
the surface, use a tar remover to clean.
However, be careful not to apply too
much pressure on the painted area.
Page 644 of 649
9-85
09
Keep your garage dry
Don’t park your vehicle in a damp,
poorly ventilated garage. This creates
a favorable environment for corrosion.
This is particularly true if you wash your
vehicle in the garage or drive it into the
garage when it is still wet or covered
with snow, ice or mud. Even a heated
garage can contribute to corrosion
unless it is well ventilated so moisture is
dispersed.
Keep paint and trim in good condition
Scratches or chips in the finish should
be covered with “touch-up” paint as
soon as possible to reduce the possibility
of corrosion. If bare metal is showing
through, the attention of a qualified
body and paint shop is recommended.
Bird droppings : Bird droppings are
highly corrosive and may damage
painted surfaces in just a few hours.
Always remove bird droppings as soon
as possible.
Don’t neglect the interior
Moisture can collect under the floor
mats and carpeting to cause corrosion.
Check under the mats periodically to be
sure the carpeting is dry. Use particular
care if you carry fertilizers, cleaning
materials or chemicals in the vehicle.
These should be carried only in proper
containers and any spills or leaks should
be cleaned up, flushed with clean water
and thoroughly dried.
Interior care
Interior general precautions
Prevent chemicals such as perfume,
cosmetic oil, sun cream, hand cleaner
and air freshener from contacting the
interior parts because they may cause
damage or discolouration. If they do
contact the interior parts, wipe them off
immediately.
See the instructions that follow for the
proper way to clean vinyl.
NOTICE
Never allow water or other liquids
to come in contact with electrical/
electronic components inside the
vehicle as this may damage them.
NOTICE
When cleaning leather products
(steering wheel, seats etc.), use neutral
detergents or low alcohol content
solutions. If you use high alcohol
content solutions or acid/alkaline
detergents, the colour of the leather
may fade or the surface may get
stripped off.
Page 645 of 649
9-86
Maintenance
Cleaning the upholstery and interior
trim
9 L Q \ O L I H T X L S S H G
Remove dust and loose dirt from vinyl
with a whisk broom or vacuum cleaner.
Clean vinyl surfaces with a vinyl cleaner.
) D E U L F L I H T X L S S H G
Remove dust and loose dirt from
fabric with a whisk broom or vacuum
cleaner. Clean with a mild soap solution
recommended for upholstery or carpets.
Remove fresh spots immediately with
a fabric spot cleaner. If fresh spots do
not receive immediate attention, the
fabric can be stained and its colour
can be affected. Also, its fire-resistant
properties can be reduced if the material
is not properly maintained.
NOTICE
Using anything but recommended
cleaners and procedures may affect the
fabric’s appearance and fire-resistant
properties.
/ H D W K H U L I H T X L S S H G
[ ) H D W X U H V R I 6 H D W / H D W K H U
- Leather is made from the outer skin
of an animal, which goes through a
special process to be available for
use. Since it is a natural product,
each part differs in thickness or
density.
Wrinkles may appear as a natural
result of stretching and shrinking
depending on the temperature and
humidity.
- The seat is made of stretchable
fabric to improve comfort.
- The parts contacting the body are
curved and the side supporting
area is high which provides driving
comfort and stability.
- Wrinkles may appear naturally
from usage. It is not a fault of the
products.
CAUTION
[ : U L Q N O H V R U D E U D V L R Q V Z K L F K D S S H D U
naturally from usage are not covered
by warranty.
[ % H O W V Z L W K P H W D O O L F D F F H V V R U L H V
zippers or keys inside the back
pocket may damage the seat fabric.
[ 0 D N H V X U H Q R W W R Z H W W K H V H D W , W P D \
change the nature of natural leather.
[ - H D Q V R U F O R W K H V Z K L F K F R X O G E O H D F K
may contaminate the surface of the
seat covering fabric.
Page 648 of 649
9-89
09
3. Exhaust emission control
system
The Exhaust Emission Control System is
a highly effective system which controls
exhaust emissions whilst maintaining
good vehicle performance.
Engine exhaust gas precautions
(carbon monoxide)
[ & D U E R Q P R Q R [ L G H F D Q E H S U H V H Q W Z L W K
other exhaust fumes. Therefore, if
you smell exhaust fumes of any kind
inside your vehicle, have it inspected
and repaired immediately. If you ever
suspect exhaust fumes are coming
into your vehicle, drive it only with
all the windows fully open. Have
your vehicle checked and repaired
immediately.
WARNING
Engine exhaust gases contain carbon
monoxide (CO). Though colourless and
odourless, it is dangerous and could be
lethal if inhaled. Follow the instructions
following to avoid CO poisoning.
[ ' R Q R W R S H U D W H W K H H Q J L Q H L Q F R Q I L Q H G
or closed areas (such as garages) any
more than what is necessary to move
the vehicle in or out of the area.
[ : K H Q W K H Y H K L F O H L V V W R S S H G L Q D Q
open area for more than a short time
with the engine running, adjust the
ventilation system (as needed) to draw
outside air into the vehicle.
[ 1 H Y H U V L W L Q D S D U N H G R U V W R S S H G
vehicle for any extended time with the
engine running.
[ : K H Q W K H H Q J L Q H V W D O O V R U I D L O V W R
start, excessive attempts to restart
the engine may cause damage to the
emission control system.
Operating precautions for catalytic
converters (if equipped)
WARNING
[ $ K R W H [ K D X V W V \ V W H P F D Q L J Q L W H
flammable items under your vehicle.
Do not park, idle, or drive the vehicle
over or near flammable objects, such
as dry grass, paper, leaves, etc.
[ 7 K H H [ K D X V W V \ V W H P D Q G F D W D O \ W L F
system are very hot whilst the engine
is running or immediately after the
engine is turned off. Keep away from
the exhaust system and catalytic
converter as you may get burned.
Also, do not remove the heat sink
around the exhaust system, do not
seal the bottom of the vehicle and
do not coat the vehicle for corrosion
control. It may present a fire risk
under certain conditions.
Your vehicle is equipped with a catalytic
converter emission control device.
Therefore, the following precautions
must be observed:
[ 8 V H R Q O \ 8 1 / ( $ ' ( ' ) 8 ( / I R U S H W U R O
engines.
[ ' R Q R W R S H U D W H W K H Y H K L F O H Z K H Q
there are signs of engine malfunction,
such as misfire or a noticeable loss of
performance.
[ ' R Q R W P L V X V H R U D E X V H W K H H Q J L Q H
Examples of misuse are coasting with
the engine off and descending steep
grades in gear with the engine off.
[ ' R Q R W R S H U D W H W K H H Q J L Q H D W K L J K L G O H
speed for extended periods (5 minutes
or more).
[ ' R Q R W P R G L I \ R U W D P S H U Z L W K D Q \
part of the engine or emission control
system. We recommend that all
inspections and adjustments are
made by a HYUNDAI authorised
repairer.