air condition HYUNDAI IX35 2014 Workshop Manual

785
Maintenance
Operating precautions for catalyticconverters (if equipped)Your vehicle is equipped with a catalytic
converter emission control device.
Therefore, the following precautions
must be observed:
 Use only UNLEADED FUEL for petrol engine.
 Do not operate the vehicle when there are signs of engine malfunction, such
as misfire or a noticeable loss of per-
formance.
 Do not misuse or abuse the engine. Examples of misuse are coasting withthe ignition off and descending steep
grades in gear with the ignition off.
 Do not operate the engine at high idle speed for extended periods (5 minutesor more).
 Do not modify or tamper with any part of the engine or emission control sys-
tem. We recommend that the system
be inspected by an authorised
HYUNDAI dealer.
 Avoid driving with a extremely low fuel level. Running out of fuel cause the
engine to misfire, damaging the cat-
alytic converter.
Failure to observe these precautionscould result in damage to the catalytic
converter and to your vehicle.
Additionally, such actions could void your
warranties.Diesel Particulate Filter (if equipped)
The Diesel Particulate Filter (DPF) sys-
tem removes the soot emitted from the
vehicle.
Unlike a disposable air filter, the DPF
system automatically burns (oxidizes)
and removes the accumulated soot
according to the driving condition. In
other words, the active burning by engine
control system and high exhaust gas
temperature caused by normal/high driv-
ing condition burns and removes the
accumulated soot.
However, if the vehicle continues to be
driven at low speed for long time, the
accumulated soot may not be automati-
cally removed because of low exhaust
gas temperature. In this particular case,the amount of soot is out of detection
limit, the soot oxidation process by
engine control system may not happen
and the malfunction indicator light may
blink. When the malfunction indicator light
blinks, it may stop blinking by driving the
vehicle at more than 60km/h (37 mph) orat more than second gear with 1500 ~
2000 engine rpm for a certain time (for
about 25 minutes).
WARNING - Fire
 A hot exhaust system can ignite flammable items under your vehi-
cle. Do not park, idle, or drive the
vehicle over or near flammable
objects, such as dry grass, paper,
leaves, etc.
 The exhaust system and catalytic system are very hot whilst the
engine is running or immediately
after the engine is turned off.
Keep away from the exhaust sys-
tem and catalytic, you may get
burned.
Also, do not remove the heat sink
around the exhaust system, do
not seal the bottom of the vehicle
or do not coat the vehicle for cor-
rosion control. It may present a
fire risk under certain conditions.
EL(FL) Aust 7.QXP 7/26/2013 2:26 PM Page 85

Specifications & Consumer information
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
Air conditioning system . . . . . . . . . . . . . . . . . . . . . . 8-2
Bulb wattage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
Tyres and wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
Load and speed capacity tyres . . . . . . . . . . . . . . . . 8-4
Gross vehicle weight. . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Luggage volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Recommended lubricants and capacities . . . . . . . 8-6

Specifications & Consumer information
2
8
DIMENSIONS
Item mm (in)
Overall length 4410 (173.6)
Overall width 1820 (71.6)
Overall height 1655 (65.2)/1665 (65.6)* 1
Front tread 1585 (62.4)
Rear tread 1586 (62.4)
Wheelbase 2640 (103.9)
* 1
with roof rack
ENGINE Item Petrol 2.0
Diesel R2.0
Displacement cc (cu. in) 1,999 (121.99)
1,995 (121.74)
Bore x Stroke mm (in.)81X97
(3.19X3.81)
84X90
(3.30X3.54)
Firing order 1-3-4-2
1-3-4-2
No. of cylinders 4. In-line
4. In-line
ItemWeight of volume Classification
Refrigerant
550±25g R134a
Compressor lubricant
120±10cc PAG oil
AIR CONDITIONING SYSTEM
EL(FL) Aust 8.QXP 26.7.2013 17:46 Page 2

Specifications & Consumer information
10
8
AIR CONDITIONER COMPRESSOR LABEL
The tyres supplied on your new vehicle
are chosen to provide the best perform-
ance for normal driving.
The tyre label located on the driver's side
centre pillar gives the tyre pressures rec-
ommended for your vehicle. The engine number is stamped on the
engine block as shown in the drawing.A compressor label informs you the type
of compressor your vehicle is equipped
with such as model, supplier part num-
ber, production number, refrigerant (1)
and refrigerant oil (2).
TYRE SPECIFICATION AND PRESSURE LABEL
ENGINE NUMBER
OEL083010
OLM089004
■
Petrol engine
■Diesel engine
OEL083008ROHC081001
EL(FL) Aust 8.QXP 26.7.2013 17:47 Page 10

Index
2
I
Active ECO ......................................................................5-50
Air bag warning label ......................................................3-59
Air bag warning light ......................................................3-42
Air bags ............................................................................3-39
Air bag warning label ................................................3-59
Air bag warning light ................................................3-42
Curtain air bag ............................................................3-49
Driver's and passenger's front air bag ........................3-45
Operation ....................................................................3-40
Side impact air bag ....................................................3-48
SRS components and functions..................................3-43
Air cleaner ........................................................................7-30
Air conditioner compressor label ....................................8-10Air conditioning system Automatic climate control system ............................4-113
Manual climate control system ................................4-104
Alarm system ..................................................................4-13
Antenna ..........................................................................4-134
Anti-lock brake system (ABS) ........................................5-34
Appearance care ..............................................................7-77 Exterior care ..............................................................7-77
Interior care ................................................................7-82
Armrest (rear seat) ..........................................................3-13
Ashtray ..........................................................................4-126
Audio remote control ....................................................4-135 Audio system ................................................................4-134
Antenna ....................................................................4-134
Audio remote control ..............................................4-135
Auto light position ..........................................................4-90
Automatic climate control system ................................4-113 Air conditioning........................................................4-119
Automatic heating and air conditioning ..................4-114
Manual heating and air conditioning........................4-115
Automatic transaxle ........................................................5-18 Sports mode ................................................................5-21
Shift lock system ........................................................5-21
Aux, USB and iPod ®
......................................................4-129
A
EL(FL) Aust Index.qxp 7/26/2013 2:14 PM Page 2

I7
Index
Label
Air bag warning label ................................................3-59
Air conditioner compressor label ..............................8-10
Tyre sidewall labeling ................................................7-46
Tyre specification and pressure label ........................8-10
Vehicle certification label ............................................8-9
Lap/shoulder belt ............................................................3-19
LCD display ....................................................................4-53 Information Mode ......................................................4-54
LCD modes ................................................................4-53
User Settings Mode ....................................................4-55
Warning Messages......................................................4-57
LCD Display Control ......................................................4-47
LCD modes ......................................................................4-53
Light bulbs ......................................................................7-63
Lighting ............................................................................4-88 Auto light position......................................................4-90
Battery saver function ................................................4-88
Daytime running light ................................................4-93
Front fog light ............................................................4-92
Headlight (Headlamp) escort function ......................4-88
Headlight levelling device..........................................4-93
Headlight position ......................................................4-89
High-beam operation ..................................................4-90
Parking light position ................................................4-89
Rear fog light..............................................................4-92 Turn signals ................................................................4-91
Lubricants and capacities ..................................................8-6
Luggage net (holder) ......................................................4-130
Luggage room lamp ......................................................4-100
Luggage volume ................................................................8-5 Maintenance Explanation of scheduled maintenance items ............7-19
Maintenance services ..................................................7-5
Owner maintenance ......................................................7-7
Scheduled maintenance service....................................7-9
Tyre maintenance ......................................................7-46
Maintenance schedule ......................................................7-10
Maintenance services ........................................................7-5
Manual climate control system ......................................4-104 Air conditioning........................................................4-110
Climate control air filter ..........................................4-111
Heating and air conditioning ....................................4-105
Manual transaxle ..............................................................5-15
Map lamp ........................................................................4-99
Mirrors ............................................................................4-39 Day/night rearview mirror..........................................4-39
Electric chromic mirror (ECM) with compass ..........4-40
Electric chromic mirror (ECM)..................................4-39
Inside rearview mirror ................................................4-39
Outside rearview mirror ............................................4-43
M
L
EL(FL) Aust Index.qxp 7/26/2013 2:14 PM Page 7

I9
Index
Scheduled maintenance service ........................................7-9
Seat belt warning ............................................................3-18
Seat belts ..........................................................................3-17
Height adjustment ......................................................3-20
Lap/shoulder belt ........................................................3-19
Precautions ................................................................3-27
Pre-tensioner seat belt ................................................3-24
Seat belt warning ........................................................3-18
Stowing the rear seat belt ..........................................3-23
Seat warmer (rear seat) ....................................................3-13
Seat warmer(front) ..........................................................3-10
Seatback pocket................................................................3-11
Seats ..................................................................................3-2 Armrest (rear seat)......................................................3-13
Folding the rear seat ..................................................3-14
Front seat adjustment - manual ....................................3-5
Front seat adjustment - power ......................................3-6
Headrest(front) ............................................................3-8
Headrest(rear) ............................................................3-12
Rear seat ....................................................................3-12
Seat warmer (rear seat) ..............................................3-13
Seat warmer(front) ....................................................3-10
Seatback pocket ..........................................................3-11
Shift lock system ..............................................................5-21
Side impact air bag ..........................................................3-48
Smart key ........................................................................4-10 Smooth cornering ............................................................5-54
Snow tyres........................................................................5-57
Changing tyres..............................................................6-9
Compact spare tyre replacement ................................7-45
Removing and storing the spare tyre ..........................6-9
Spare tyre ..........................................................................6-9
Special driving conditions ..............................................5-53 Driving at night ..........................................................5-54
Driving in flooded areas ............................................5-55
Driving in the rain ......................................................5-55
Hazardous driving conditions ....................................5-53
Highway driving ........................................................5-56
Rocking the vehicle ....................................................5-53
Smooth cornering ......................................................5-54
Speedometer ....................................................................4-48
Sports mode ....................................................................5-21
SRS components and functions ......................................3-43
Starting difficulties, see engine will not start ....................6-4
Steering wheel ..................................................................4-34 Electric power steering ..............................................4-34
Flex steering wheel ....................................................4-37
Heated steering wheel ................................................4-35
Horn ............................................................................4-36
Storage compartment ....................................................4-123 Centre console storage ............................................4-123
Cool box ..................................................................4-124
Glove box ................................................................4-123
Sunglass holder ........................................................4-124
S
EL(FL) Aust Index.qxp 7/26/2013 2:14 PM Page 9

347
Safety features of your vehicle
SRS components and functions
The SRS consists of the following com- ponents:
1. Driver's front air bag module*
2. Front impact sensors*
3. Passenger's front air bag module*
4. Retractor pre-tensioner assemblies*
5. Side impact sensors*
6. Curtain air bag modules*
7. Side air bag modules*
8. SRS control module (SRSCM)
9. Air bag warning light
10. Anchor pre-tensioner assembly* (driver side)
11. Passenger’s front air bag ON/OFF switch*
12. Passenger’s front air bag ON/OFF indicator*
*: if equipped The SRSCM continually monitors all ele-
ments while the ignition switch is ON to
determine if a frontal, near-frontal impact
or side impact is severe enough to
require air bag deployment or pre-ten-
sioner seat belt deployment.
The SRS air bag warning light on the
instrument panel will illuminate for about
6 seconds after the ignition switch is
turned to the ON position, after which the
air bag warning light should go out.
The front air bag modules are located
both in the center of the steering wheel
and in the front passenger's panel above
the glove box. When the SRSCM detects
a sufficiently severe impact to the front of
the vehicle, it will automatically deploy
the front air bags.
WARNING
If any of the following conditions
occurs, this indicates a malfunction
of the SRS. We recommend that the
system be inspected by an author-
ized HYUNDAI dealer.
 The light does not turn on briefly when you turn the ignition ON.
 The light stays on after illuminat- ing for approximately 6 seconds.
 The light comes on while the vehicle is in motion.
 The light blinks when the ignition switch is in ON position.
B240B01L
Driver’s front air bag (1)
EL(FL) Eng 3.QXP 7/11/2013 10:57 AM Page 47

349
Safety features of your vehicle
Driver's and passenger's front air
bag (if equipped)
Your vehicle is equipped with a
Supplemental Restraint (Air Bag) System
and lap/shoulder belts at both the driver
and passenger seating positions.
WARNING
 If an air bag deploys, there may be a loud noise followed by a fine
dust released in the vehicle.These conditions are normal and
are not hazardous - the air bags
are packed in this fine powder.
The dust generated during air
bag deployment may cause skin
or eye irritation as well as aggra-
vate asthma for some persons.
Always wash all exposed skin
areas thoroughly with lukewarmwater and a mild soap after an
accident in which the air bags
were deployed.
(Continued)(Continued)
 The SRS can function only whenthe ignition key is in the "ON"
position. If the SRS air bag warn-
ing light does not illuminate, or
continuously remains on after
illuminating for about 6 seconds
when the ignition key is turned to
the ON position, or after the
engine is started, comes on while
driving, the SRS is not working
properly. If this occurs, we recom-mend that the system be inspect-
ed by an authorized HYUNDAI
dealer.
 Before you replace a fuse or dis- connect a battery terminal, turn
the ignition switch to the LOCK
position and remove the ignition
key. Never remove or replace the
air bag related fuse(s) when the
ignition switch is in the ON posi-
tion. Failure to heed this warning
will cause the SRS air bag warn-
ing light to illuminate.
OEL039037
OEL039038
Driver’s front air bag
Passenger’s front air bag
EL(FL) Eng 3.QXP 7/11/2013 10:57 AM Page 49

355
Safety features of your vehicle
 The side air bags are designed todeploy only during certain side-impact
collisions, depending on the crash
severity, angle, speed and point ofimpact.
 The side air bags do not only deploy on the side of the impact but also on the
opposite side.(Continued)
 Use of seat covers could reduceor prevent the effectiveness of the system.
 Do not install any accessories on the side or near the side air bag.
 Do not place any objects over the air bag or between the air bag
and yourself.
 Do not place any objects (an umbrella, bag, etc.) between the
front door and the front seat.
Such objects may become dan-
gerous projectiles and cause
injury if the supplemental side air
bag inflates.
 To prevent unexpected deploy- ment of the side air bag that may
result in personal injury, avoidimpact to the side impact sensor
when the ignition key is on.
 If seat or seat cover is damaged, we recommend that the system
be serviced by an authorized
HYUNDAI dealer. Inform that your
vehicle is equipped with side air
bags.WARNING
 The side air bag is supplemental to the driver's and the passen-
ger's seat belt systems and is not
a substitute for them. Therefore
your seat belts must be worn at
all times while the vehicle is in
motion. The air bags deploy only
in certain side impact conditions
severe enough to cause signifi-
cant injury to the vehicle occu-pants.
 For best protection from the side air bag system and to avoid being
injured by the deploying side air
bag, both front seat occupantsshould sit in an upright position
with the seat belt properly fas-
tened. The driver's hands shouldbe placed on the steering wheelat the 9:00 and 3:00 positions.
The passenger's arms and handsshould be placed on their laps.
 Do not use any accessory seat covers.
(Continued)
WARNING
Do not allow the passengers to lean
their heads or bodies onto doors,
put their arms on the doors, stretch
their arms out of the window, or
place objects between the doors
and passengers when they areseated on seats equipped with side
and/or curtain air bags.
EL(FL) Eng 3.QXP 7/11/2013 10:57 AM Page 55