parking brake Hyundai Matrix 2007 Workshop Manual

6 OWNER MAINTENANCE
10
G040B04FC-EAT
Diesel engine
Oil filter
G040B01FC
Oil filler cap
Centrepipe O-ring G040B02FC
Upper capO-ring
Oil filter element
Oil filterhousing
The engine oil and filter should be
changed at those intervals specified in the maintenance schedule in Section 5. If the car is being driven in severe conditions, more frequent oil and filter changes are required.
The procedure for changing the oil and
filter is as follows:
1. Park the car on level ground and set the parking brake. Start the engine and let it warm up until the needle on the coolant temperature gauge moves above the lowest mark. Turn the engine off and place the gear selector lever in "P" (automatic) or reverse gear (manual transaxle). 2. Open the bonnet and remove the
engine oil level dipstick.
3. Loosen the oil filter upper cap with a proper tool from the oil filter housing until an O-ring is seen. Then, drainthe oil completely.
CAUTION:
Slowly loosen the oil filter uppercap not to overflow the oil.
!
!
CAUTION:
Slowly pour the recommended oil into a funnel. Do not overfill to prevent engine to damage.!
WARNING:
Prolonged and repeated contact with used engine oils may result in seri- ous skin disorders including der- matitis and cancer. Avoid contact with skin as far as possible andalways wash thoroughly after any contact. Keep used oils out of reach of children. It is illegal to pollutedrains, water courses and soil. Use only authorized waste collection facilities including civic amenitysites and garages for the disposal of used oil and oil filters. If in doubt, contact the local authority for dis-posal instructions.
fcuk-6.p65 12/27/2006, 10:16 AM
10

6
OWNER MAINTENANCE
13
SG050C1-E
To Check the Coolant Level If the level is below the "L" mark, add coolant of the correct concentrationuntil the level is between the "L" and "F" marks. If the level falls below the "L" mark on a regular basis despitebeing topped up, consult a Hyundai authorised repairer.
G050C01FC G050C02FC
Petrol engine
Diesel engine
The engine coolant level may be observed through the side of the plas- tic coolant reservoir (expansion tank) when the engine is cold.
G050D01FC
SG050D2-E
To Change the Coolant
The coolant should be changed at
those intervals specified in the vehicle maintenance schedule in Section 5.
NOTE: Care should be taken to ensure that
coolant is not allowed to spill onto the paintwork since the finish maybecome damaged. If coolant spill- age occurs, the affected area should be rinsed thoroughly with water.
1. Park the vehicle on level ground
and ensure that the parking brake is firmly applied, and the engine al- lowed to cool. Do not attempt this operation whilst the engine is hot since burning or scalding may result. 2. Prepare a suitable receptacle to
collect the displaced coolant and position this under the radiator drain tap.
3. With the heater temperature control set to the "HOT" position, removethe radiator cap and open the radia- tor drain tap.
4. When the engine coolant has drained completely, close the drain tap en-suring that this is not over tight- ened.
5. Prepare a suitable quantity of new engine coolant (refer to section 9)and pour this into the radiator.
fcuk-6.p65 12/27/2006, 10:16 AM
13

6 OWNER MAINTENANCE
20
G100B03A-GAT
Checking the automatic transaxle fluid level
The automatic transaxle fluid level
should be checked regularly.
Keep the vehicle on the level ground
with the parking brake applied and check the fluid level according to thefollowing procedure. HFC5008
G110C01FC-EAT
Fluid Capacity
The total fluid capacity of the trans-mission unit is 6.1 litres (1.6 DOHC)/ 6.7 litres(1.8 DOHC).
! CAUTION:
The transaxle fluid level should be checked when the engine is at nor-mal operating temperature. This means that the engine, radia- tor, exhaust system etc., are very hot so you should exercise great care not to burn yourself during thisprocedure. 1. Place the selector lever in N (Neu-
tral) position and confirm the engineis running at normal idle speed.
2. After the transaxle is warmed up
sufficiently (fluid temperature70~80°C (158~176°F)), for example by 10 minutes usual driving, shift the selector lever through all posi-tions then place the selector lever in N (Neutral) or P (Park) position.
fcuk-6.p65 12/27/2006, 10:16 AM
20

9 VEHICLE SPECIFICATIONS
2
J010A01FC-EAT MEASUREMENT
158.4 (4,025)68.5 (1,740) 64.3 (1,635)
*66.3 (1,685)
102.3 (2,600) 58.5 (1,485)58.5 (1,485)
Overall lengthOverall width Overall height (unladen) Wheel base Wheel tread
Front
Rear
Type Wheel free playRack stroke Oil pump type Rack and pinion0 ~ 1.18 in. (0 ~ 30 mm) 5.7±0.04 in. (146±1mm)Vane type
SJ030A1-F FUEL SYSTEM
J020A01FC-EATPOWER STEERING J030A01FC-DATTIRE
185/65 R14 195/55 R15205/55 R15 (1.8 DOHC only)
StandardOption
J050A01FC-GAT BRAKE Dual hydraulic with brake booster Ventilated discDrum Cable
Type Front brake typeRear brake type Parking brake
Item Battery Generator
J040A02FC-EAT ELECTRICAL
Petrol
MF45AH
90A (13.5V)
in. (mm)
Fuel tank capacityLitre
55 US.gal
14.5 Imp.gal
12
Diesel
CMF 68 AH 120A (12V)
* If installed roof rack J030B01FC-EAT SPARE TYRE
Space-saver Full size
StandardOption
fcuk-9.p65
12/27/2006, 10:17 AM
2

10INDEX
4
M MAINTENANCE AND SERVICING REQUIREMENTS .... 5-2
MAINTENANCE UNDER SEVERE USAGE CONDITIONS ............................................................................. 5-6
MANUAL TRANSAXLE ............................................... 2-8
MANUAL TRANSAXLE LUBRICANT .........................6-18
MAP LIGHT ............................................................... 1-65
MULTI BOX ............................................................... 1-66
MULTI FUNCTION SWITCH ......................................1-54
O
OVERDRIVE SWITCH .............................................. 2-12
P PARKING BRAKE ..................................................... 1-62
POWER OUTLET ...................................................... 1-60
POWER STEERING FLUI D LEVEL .......................... 6-31
POWER STEERING HOSES .................................... 6-32
POWER WINDOW ..................................................... 1-11
PROTECTING YOUR HYUNDAI FROM CORROSION .... 4-2
RREAR FOG AUDIBLE WARNING SOUND ................ 1-49
REAR FOG LIGHT SWITCH ..................................... 1-58
REAR SEAT ARM REST .......................................... 1-63
REAR SEAT WARNING ............................................ 1-19
RECOMMENDED SHIFT POINTS .............................. 2-9REMOTE FUEL FILLER LID
RELEASE .................. 1-71
REMOVAL OF WATER FROM THE FUEL FILTER . 6-33
REPLACING LIGHT BULBS ...................................... 6-35
ROOF RACK ............................................................. 1-74
RUNNING IN ............................................................... 1-3
SSCHEDULED MAINTENANCE .................................... 5-3
SEAT ADJUSTMENT ................................................ 1-12
SEAT BELT PRECAUTIONS ....................................1-19
SEAT BELTS ............................................................ 1-19
SEAT CUSHION HEIGHT ADJUSTMENT ................1-14
SEAT WARMER ........................................................ 1-18
SERVICE HISTORY .................................................... 5-2
SIDE VENTILATOR .................................................. 1-76
SMOOTH CORNERING ............................................. 2-19
SNOW TYRES ............................................................ 8-3
SPARE WHEEL .......................................................... 3-6
SPECTACLE CASE .................................................. 1-66
SUPPLEMENTAL RESTRAINT (AIRBAG) SYSTEM ... 1-33
STARTING THE ENGINE ........................................... 2-3
STEERING WHEEL FREEPLAY ...............................6-26
STEERING WHEEL TILT LEVER ............................. 1-75
STEREO SOUND SYSTEM ...................................... 1-92
SUN-VISOR ............................................................... 1-69
SUNROOF ................................................................. 1-63
fcuk-10.p65 12/27/2006, 10:14 AM
4