steering system INFINITI M35 2007 Factory User Guide

TROUBLE DIAGNOSIS FOR SELF-DIAGNOSTIC ITEMS
ACS-49
[ICC]
C
D
E
F
G
H
I
J
L
MA
B
ACS
Revision: 2007 April2007 M35/M45
4. CHECK ICC STEERING SWITCH SIGNAL CIRCUIT
1. Disconnect spiral cable connector and ECM connector.
2. Check continuity between spiral cable harness connector (A)
and ECM harness connector (B).
3. Check continuity between spiral cable harness connector (A)
and ground.
OK or NG
OK >> GO TO 5.
NG >> 1. Repair or replace harness between spiral cable and ECM.
2. Erase DTC and perform ICC system running test. Then perform self-diagnosis of ICC system
again.
5. CHECK COMBINATION SWITCH (SPIRAL CABLE)
Check continuity between spiral cable terminals.
OK or NG
OK >> 1. Perform “ENGINE” self-diagnosis. Refer to EC-123,
"CONSULT-II Function (ENGINE)" (for VQ35DE) or
EC-826, "
CONSULT-II Function (ENGINE)" (for
VK45DE).
2. After repairing or replacing applicable item, erase DTC and perform ICC system running test.
Then perform self-diagnosis of ICC system again.
NG >> 1. Replace spiral cable.
2. Erase DTC and perform ICC system running test. Then perform self-diagnosis of ICC system
again.
DTC 12 LASER BEAM OFFCNTRNKS004D6
1. ADJUST LASER BEAM AIMING
1. Adjust laser beam aiming. Refer to ACS-15, "
LASER BEAM AIMING ADJUSTMENT"
2. Erase DTC and perform ICC system running test. Then perform self-diagnosis of ICC system again.
3. Check if “LASER BEAM OFFCNTR [C1A12]” (DTC 12) is indicated in self-diagnosis item in the display.
Is it indicated?
YES >> 1. Replace ICC sensor integrated unit, and adjust laser beam aiming.
2. Erase DTC and perform ICC system running test. Then perform self-diagnosis of ICC system
again.
NO >> INSPECTION END
AB
Continuity
Connector Terminal Connector Terminal
M3931 F108 67
Ye s
34 M71 99
A
GroundContinuity
Connector Terminal
M3931
No
34
PKIB9339E
AB
Continuity
Terminal Terminal
31 18
Ye s
34 21
PKIB9340E

TROUBLE DIAGNOSIS FOR SYMPTOMS
ACS-63
[ICC]
C
D
E
F
G
H
I
J
L
MA
B
ACS
Revision: 2007 April2007 M35/M45
Symptom 1: MAIN Switch Does Not Turn ON*1 , MAIN Switch Does Not Turn
OFF
*2NKS004DK
NOTE:

*1: The MAIN switch indicator lamp in the combination meter does not illuminate.

*2: The MAIN switch indicator lamp in the combination meter remains powered.
1. CHECK MAIN SWITCH
With CONSULT-II
With “ICC” “DATA MONITOR”, check if “MAIN SW” and “CRUISE LAMP” operate normally.
OK or NG
OK >> GO TO 2.
NG >> GO TO 4.
2. CHECK UNIFIED METER AND A/C AMP.
With CONSULT-II
With “METER A/C AMP” “DATA MONITOR”, check if “CRUISE IND” operates normally.
OK or NG
OK >> 1. Perform “METER A/C AMP”self-diagnosis. Refer toDI-18, "CONSULT-II Function (METER A/C
AMP)" .
2. After repairing or replacing applicable item, erase DTC and perform ICC system running test.
Then perform self-diagnosis of ICC system again.
NG >> GO TO 3.
3. CHECK CONNECTOR ICC SENSOR INTEGRATED UNIT
1. Turn ignition switch OFF.
2. Disconnect ICC sensor integrated unit connector, and connect it securely again.
3. Check if the malfunction is improved.
Is it improved?
YES >> Poor connector connection
1. Check connector. (Check connector housing for disconnected, loose, bent, and collapsed ter-
minals. If any malfunction is detected, repair applicable part.)
2. Erase DTC and perform ICC system running test. Then perform self-diagnosis of ICC system
again.
NO >> GO TO 4.
4. PERFORM ICC SENSOR INTEGRATED UNIT SELF-DIAGNOSIS
With CONSULT-II
1. Perform self-diagnosis.
2. Check if “DTC 100 CAN COMM CIRCUIT” is indicated.
Is it indicated?
YES >> CAN communication inspection. Refer to ACS-61, "DTC 100 CAN COMM CIRCUIT" .
NO >> ICC steering switch inspection. Refer to ACS-48, "
DTC 6 OPERATION SW CIRC" .

TROUBLE DIAGNOSIS FOR SYMPTOMS
ACS-65
[ICC]
C
D
E
F
G
H
I
J
L
MA
B
ACS
Revision: 2007 April2007 M35/M45
Symptom 3: ICC System Cannot Be Operated by CANCEL Switch, RESUME/
ACCELERATE Switch or DISTANCE Switch
NKS004DM
RESUME does not function in the following cases.

When MAIN switch is turned off once.

When the vehicle speed is less than 25 MPH (40 km/h).
1. CHECK SWITCHES
With CONSULT-II
With “ICC” “DATA MONITOR”, check if switches operate normally.

“RESUME/ACC SW”

“CANCEL SW”

“DISTANCE SW”
OK or NG
OK >> 1. Replace ICC sensor integrated unit, and adjust laser beam aiming.
2. Erase DTC and perform ICC system running test. Then perform self-diagnosis of ICC system
again.
NG >> GO TO 2.
2. PERFORM ICC SENSOR INTEGRATED UNIT SELF-DIAGNOSIS
With CONSULT-II
1. Perform self-diagnosis.
2. Check if “DTC 100 CAN COMM CIRCUIT” is indicated.
Is it indicated?
YES >> CAN communication inspection. Refer to ACS-61, "DTC 100 CAN COMM CIRCUIT" .
NO >> ICC steering switch inspection. Refer to ACS-48, "
DTC 6 OPERATION SW CIRC" .
Symptom 4: ICC System Is Not Cancelled When the A/T Selector Lever Is In
Other Than “D” and “M”
NKS004DN
1. CHECK D RANGE SWITCH
With CONSULT-II
With “ICC” “DATA MONITOR”, check if “D RANGE SW” and “NP RANGE SW” operate normally.
OK or NG
OK >> 1. Replace ICC sensor integrated unit, and adjust laser beam aiming.
2. Erase DTC and perform ICC system running test. Then perform self-diagnosis of ICC system
again.
NG >> GO TO 2.
2. PERFORM ICC SENSOR INTEGRATED UNIT SELF-DIAGNOSIS
With CONSULT-II
1. Perform self-diagnosis.
2. Check if “DTC 100 CAN COMM CIRCUIT” is indicated.
Is it indicated?
YES >> CAN communication inspection. Refer to ACS-61, "DTC 100 CAN COMM CIRCUIT" .
NO >> GO TO 3.

ATC-1
AUTOMATIC AIR CONDITIONER
J AIR CONDITIONER
CONTENTS
C
D
E
F
G
H
I
K
L
M
SECTION AT C
A
B
AT C
Revision: 2007 April2007 M35/M45
AUTOMATIC AIR CONDITIONER
PRECAUTIONS .......................................................... 5
Precautions for Supplemental Restraint System
(SRS) “AIR BAG” and “SEAT BELT PRE-TEN-
SIONER” .................................................................. 5
Precautions Necessary for Steering Wheel Rotation
After Battery Disconnect .......................................... 5
OPERATION PROCEDURE ................................. 5
Precautions for Procedures without Cowl Top Cover ..... 6
Precautions for Working with HFC-134a (R-134a) ..... 6
CONTAMINATED REFRIGERANT ....................... 7
General Refrigerant Precautions .............................. 7
Precautions for Refrigerant Connection ................... 7
ABOUT ONE-TOUCH JOINT ................................ 7
FEATURES OF NEW TYPE REFRIGERANT
CONNECTION .................................................... 10
O-RING AND REFRIGERANT CONNECTION ... 10
Precautions for Servicing Compressor ................... 12
Precautions for Service Equipment ........................ 13
RECOVERY/RECYCLING EQUIPMENT ............ 13
ELECTRICAL LEAK DETECTOR ....................... 13
VACUUM PUMP ................................................. 13
MANIFOLD GAUGE SET .................................... 13
SERVICE HOSES ............................................... 14
SERVICE COUPLERS ........................................ 14
REFRIGERANT WEIGHT SCALE ...................... 14
CHARGING CYLINDER ...................................... 14
Precautions for Leak Detection Dye ....................... 15
IDENTIFICATION ................................................ 15
IDENTIFICATION LABEL FOR VEHICLE ........... 15
PREPARATION ......................................................... 16
Special Service Tools ............................................. 16
HFC-134a (R-134a) Service Tools and Equipment ... 17
Commercial Service Tools ...................................... 19
REFRIGERATION SYSTEM ..................................... 20
Refrigerant Cycle ................................................... 20
REFRIGERANT FLOW ....................................... 20
FREEZE PROTECTION ..................................... 20
Refrigerant System Protection ............................... 20
REFRIGERANT PRESSURE SENSOR ............. 20
PRESSURE RELIEF VALVE ............................... 20Variable Displacement Compressor ....................... 21
GENERAL INFORMATION ................................. 21
DESCRIPTION .................................................... 22
Component Layout ................................................. 25
LUBRICANT .............................................................. 26
Maintenance of Lubricant Quantity in Compressor ... 26
LUBRICANT ........................................................ 26
LUBRICANT RETURN OPERATION .................. 26
LUBRICANT ADJUSTING PROCEDURE FOR
COMPONENTS REPLACEMENT EXCEPT
COMPRESSOR .................................................. 27
LUBRICANT ADJUSTING PROCEDURE FOR
COMPRESSOR REPLACEMENT ....................... 27
AIR CONDITIONER CONTROL ............................... 29
Description of Air Conditioner LAN Control System ... 29
System Construction .............................................. 29
OPERATION ........................................................ 30
TRANSMISSION DATA AND TRANSMISSION
ORDER ............................................................... 30
AIR MIX DOOR CONTROL (AUTOMATIC TEM-
PERATURE CONTROL) ..................................... 31
FAN SPEED CONTROL ...................................... 31
INTAKE DOOR CONTROL ................................. 31
MODE DOOR CONTROL ................................... 31
UPPER VENTILATOR DOOR CONTROL .......... 31
MAGNET CLUTCH CONTROL ........................... 32
SELF-DIAGNOSIS SYSTEM .............................. 32
Description of Control System ................................ 33
Control Operation ................................................... 33
DISPLAY SCREEN .............................................. 33
MULTIFUNCTION SWITCH ................................ 34
DISPLAY SCREEN .............................................. 34
MODE SWITCH (DRIVER SIDE) ........................ 34
MODE SWITCH (PASSENGER SIDE) ................ 34
TEMPERATURE CONTROL SWITCH (POTEN-
TIO TEMPERATURE CONTROL) (DRIVER
SIDE) ................................................................... 34
TEMPERATURE CONTROL SWITCH (POTEN-
TIO TEMPERATURE CONTROL) (PASSEN-
GER SIDE) .......................................................... 34

PRECAUTIONS
ATC-5
C
D
E
F
G
H
I
K
L
MA
B
AT C
Revision: 2007 April2007 M35/M45
PRECAUTIONSPFP:00001
Precautions for Supplemental Restraint System (SRS) “AIR BAG” and “SEAT
BELT PRE-TENSIONER”
NJS000FN
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. This system includes seat belt switch inputs and dual stage front air bag modules. The SRS
system uses the seat belt switches to determine the front air bag deployment, and may only deploy one front
air bag, depending on the severity of a collision and whether the front occupants are belted or unbelted.
Information necessary to service the system safely is included in the SRS and SB section of this Service Man-
ual.
WARNING:

To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death
in the event of a collision which would result in air bag inflation, all maintenance must be per-
formed by an authorized NISSAN/INFINITI dealer.

Improper maintenance, including incorrect removal and installation of the SRS, can lead to per-
sonal injury caused by unintentional activation of the system. For removal of Spiral Cable and Air
Bag Module, see the SRS section.

Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or
harness connectors.
Precautions Necessary for Steering Wheel Rotation After Battery DisconnectNJS000FO
NOTE:

This Procedure is applied only to models with Intelligent Key system and NVIS/IVIS (NISSAN/INFINITI
VEHICLE IMMOBILIZER SYSTEM - NATS).

Remove and install all control units after disconnecting both battery cables with the ignition knob in the
″LOCK″ position.

Always use CONSULT-II to perform self-diagnosis as a part of each function inspection after finishing
work. If DTC is detected, perform trouble diagnosis according to self-diagnostic results.
For models equipped with the Intelligent Key system and NVIS/IVIS, an electrically controlled steering lock
mechanism is adopted on the key cylinder.
For this reason, if the battery is disconnected or if the battery is discharged, the steering wheel will lock and
steering wheel rotation will become impossible.
If steering wheel rotation is required when battery power is interrupted, follow the procedure below before
starting the repair operation.
OPERATION PROCEDURE
1. Connect both battery cables.
NOTE:
Supply power using jumper cables if battery is discharged.
2. Use the Intelligent Key or mechanical key to turn the ignition switch to the ″ACC″ position. At this time, the
steering lock will be released.
3. Disconnect both battery cables. The steering lock will remain released and the steering wheel can be
rotated.
4. Perform the necessary repair operation.
5. When the repair work is completed, return the ignition switch to the ″LOCK″ position before connecting
the battery cables. (At this time, the steering lock mechanism will engage.)
6. Perform a self-diagnosis check of all control units using CONSULT-II.

ATC-134
HEATER & COOLING UNIT ASSEMBLY
Revision: 2007 April2007 M35/M45
HEATER & COOLING UNIT ASSEMBLYPFP:27110
Removal and InstallationNJS000HF
REMOVAL
1. Use a refrigerant collecting equipment (for HFC-134a) to discharge the refrigerant.
2. Drain coolant from cooling system. Refer to CO-11, "
Changing Engine Coolant" (VQ35DE) or CO-40,
"Changing Engine Coolant" (VK45DE).
3. Remove cowl top cover. Refer to EI-18, "
COWL TOP" .
4. Disconnect low-pressure flexible hose and high-pressure pipe 1
from evaporator.
a. Set a disconnector [high-pressure side (SST: 9253089908), low-
pressure side (SST: 9253089916)] on A/C piping.
b. Slide a disconnector toward vehicle front until it clicks.
c. Slide A/C piping toward vehicle front and disconnect it.
CAUTION:
Cap or wrap the joint of low-pressure flexible hose, low-
pressure pipe 1 and high-pressure pipe 1, 2 with suitable
material such as vinyl tape to avoid the entry of air.
5. Remove electric throttle control actuator. Refer to EM-21,
"INTAKE MANIFOLD COLLECTOR" (VQ35DE) or EM-179, "INTAKE MANIFOLD" (VK45DE).
6. Disconnect two heater hoses from heater core.
7. Remove instrument panel & pad. Refer to IP-10, "
INSTRUMENT PANEL ASSEMBLY" .
8. Remove blower unit. Refer to ATC-129, "
BLOWER UNIT" .
9. Remove clips of vehicle harness from steering member.
10. Remove mounting nuts and bolts, and then remove instrument stays.
RJIA4117E
RJIA4118E
RJIA4119E

AV-2Revision: 2007 April2007 M35/M45 Rear View Monitor Guiding Line Adjustment ........101
CONSULT-II Functions (Multi AV) .........................102
OPERATION PROCEDURE ..............................102
SELF-DIAG RESULTS ......................................103
DATA MONITOR ................................................105
AV COMM MONITOR ........................................106
ECU PART NUMBER ........................................107
TROUBLE DIAGNOSIS ..........................................108
Multifunction Switch Cannot Be Operated ............108
RGB Image Is Not Displayed ................................108
RGB Screen Is Rolling ..........................................109
Rear View Monitor Image Is Not Displayed ..........109
DVD IMAGE IS DISPLAYED .............................109
DVD IMAGE IS NOT DISPLAYED .....................112
IT CANNOT BE SWITCHED TO REAR VIEW
MONITOR IMAGE .............................................112
DVD Image Is Not Displayed ................................113
Warning Message of Whether Rear View Image Is
Rolling or Not Displayed .......................................115
DVD Operation Screen Is Not Displayed ..............115
It Cannot Be Switched to DVD Mode ...................115
Sound Is Not Output (Voice Guidance and TEL
Voice Are Normal) ................................................116
DVD AND AUDIO SOUND ARE NOT OUTPUT .116
DVD SOUND IS NOT OUTPUT ........................116
Voice Activated Control System Is Not Activated . 116
THE SCREEN IS SWITCHED BY PRESSING
THE STEERING SWITCH .................................116
THE SCREEN IS NOT SWITCHED BY PRESS-
ING THE STEERING SWITCH .........................117
Steering Switch Cannot Be Operated ...................118
NONE OF THE OPERATIONS WORK. .............118
“ENTER”, “MENU UP-DOWN”, AND “SOURCE”
SWITCHES ARE NOT OPERATED ..................118
“PTT/TEL”, “BACK”, AND “VOLUME CONTROL”
SWITCHES ARE NOT OPERATED ..................119
The Hands-Free Phone Cannot Be Used .............119
THE VOICE CANNOT BE HEARD ....................119
THE VOICE CANNOT BE TRANSMITTED .......120
Voice Guidance Is Not Heard (Base System) .......120
Voice Guidance Is Not Heard (BOSE System) .....121
Example of Symptoms Judged Not Malfunction ...122
BASIC OPERATION ..........................................122
VEHICLE ICON .................................................122
MAP DVD-ROM .................................................123
ROUTE CALCULATION AND VISUAL GUID-
ANCE .................................................................123
VOICE GUIDANCE ...........................................124
VOICE RECOGNITION .....................................124
REAR VIEW MONITOR ....................................124
REMOVAL AND INSTALLATION ...........................126
Removal and Installation/Precautions for Replace-
ment ......................................................................126
REMOVAL OF BATTERY ..................................126
Audio Unit .............................................................126
REMOVAL .........................................................126
INSTALLATION ..................................................126
Front Door Speaker ..............................................126
REMOVAL .........................................................126INSTALLATION ..................................................126
Rear Door Speaker ...............................................127
REMOVAL ..........................................................127
INSTALLATION ..................................................127
Tweeter .................................................................127
REMOVAL ..........................................................127
INSTALLATION ..................................................127
Center Speaker .....................................................127
REMOVAL ..........................................................127
INSTALLATION ..................................................127
Seat Speaker ........................................................128
REMOVAL ..........................................................128
INSTALLATION ..................................................128
Rear Surround Speaker ........................................128
REMOVAL ..........................................................128
INSTALLATION ..................................................128
Woofer ..................................................................128
REMOVAL ..........................................................128
INSTALLATION ..................................................129
BOSE Amp ............................................................129
REMOVAL ..........................................................129
INSTALLATION ..................................................129
AudioPilot® Microphone .......................................129
REMOVAL ..........................................................129
INSTALLATION ..................................................129
Satellite Radio Tuner .............................................129
REMOVAL ..........................................................129
INSTALLATION ..................................................130
Antenna Amp ........................................................130
REMOVAL ..........................................................130
INSTALLATION ..................................................130
Satellite Radio Antenna ........................................130
REMOVAL ..........................................................130
INSTALLATION ..................................................131
AV (NAVI) Control Unit ..........................................131
REMOVAL ..........................................................131
INSTALLATION ..................................................131
Front Display Unit (Base System) .........................132
REMOVAL ..........................................................132
INSTALLATION ..................................................132
Front Display Unit (BOSE System) .......................132
REMOVAL ..........................................................132
INSTALLATION ..................................................133
Multifunction Switch ..............................................133
REMOVAL ..........................................................133
INSTALLATION ..................................................133
Preset Switch ........................................................133
REMOVAL ..........................................................133
INSTALLATION ..................................................133
Steering Switch .....................................................134
REMOVAL ..........................................................134
INSTALLATION ..................................................134
DVD Player ...........................................................134
REMOVAL ..........................................................134
INSTALLATION ..................................................135
Auxiliary Input Jacks .............................................136
REMOVAL ..........................................................136
INSTALLATION ..................................................136
Microphone ...........................................................136

AV-3
C
D
E
F
G
H
I
J
L
MA
B
AV
Revision: 2007 April2007 M35/M45 REMOVAL ......................................................... 136
INSTALLATION ................................................. 136
GPS Antenna ....................................................... 136
REMOVAL ......................................................... 136
INSTALLATION ................................................. 137
Camera Control Unit ............................................ 138
REMOVAL ......................................................... 138
INSTALLATION ................................................. 138
Rear View Camera ............................................... 138
REMOVAL ......................................................... 138
INSTALLATION ................................................. 138
Steering Angle Sensor ......................................... 138
REMOVAL ......................................................... 138
INSTALLATION ................................................. 139
WITH MOBILE ENTERTAINMENT SYSTEM
PRECAUTION ........................................................ 140
Precautions for Supplemental Restraint System
(SRS) “AIR BAG” and “SEAT BELT PRE-TEN-
SIONER” .............................................................. 140
Precautions for Trouble Diagnosis ....................... 140
AV COMMUNICATION SYSTEM ...................... 140
Precautions for Harness Repair ........................... 140
AV COMMUNICATION SYSTEM ...................... 140
PREPARATION ....................................................... 141
Commercial Service Tools .................................... 141
SYSTEM DESCRIPTION ........................................ 142
System Functions ................................................. 142
AUDIO ............................................................... 142
VEHICLE INFORMATION SYSTEM ................. 142
NAVIGATION SYSTEM ..................................... 142
MOBILE ENTERTAINMENT SYSTEM .............. 144
HANDS-FREE PHONE ..................................... 144
REAR VIEW MONITOR .................................... 144
Component Description ........................................ 145
AUDIO UNIT ..................................................... 145
BOSE AMP ....................................................... 145
SATELLITE TUNER .......................................... 146
AV CONTROL UNIT (WITHOUT NAVI) ............ 146
NAVI CONTROL UNIT (WITH NAVI) ................ 146
FRONT DISPLAY UNIT .................................... 146
REAR DISPLAY UNIT ....................................... 147
VIDEO DISTRIBUTOR ...................................... 147
DVD PLAYER .................................................... 147
CAMERA CONTROL UNIT ............................... 147
CAN Communication System Description ............ 148
CAN Communication Unit .................................... 148
Schematic — BOSE Audio 2ch System — .......... 149
Wiring Diagram — AV — / BOSE Audio 2ch System . 152
Schematic — BOSE Surround Audio 5.1ch System
— .......................................................................... 171
Wiring Diagram — AV — / BOSE Surround Audio
5.1ch System ....................................................... 174
Component Parts Location ................................... 198
Location of Antenna ............................................. 199
TERMINALS AND REFERENCE VALUE FOR CON-
TROL UNIT ............................................................. 200
Audio Unit ............................................................. 200BOSE Amp ...........................................................202
Satellite Radio Tuner ............................................206
AV (NAVI) Control Unit .........................................207
Video Distributor ...................................................210
Front Display Unit .................................................215
Rear Display Unit ..................................................217
DVD Player ...........................................................219
Headphone Amp ...................................................222
Camera Control Unit .............................................223
DIAGNOSIS SYSTEM .............................................226
Multifunction Switch Self-Diagnosis Function .......226
SELF-DIAGNOSIS MODE ................................226
FINISHING SELF-DIAGNOSIS MODE .............226
Multi AV System Diagnosis Functions ..................226
On Board Diagnosis .............................................226
DESCRIPTION ..................................................226
STARTING PROCEDURE .................................227
Self Diagnosis .......................................................228
DIAGNOSIS RESULTS .....................................229
Confirmation/Adjustment Mode ............................231
DISPLAY DIAGNOSIS .......................................231
VEHICLE SIGNALS ..........................................232
SPEAKER TEST ...............................................232
CLIMATE CONTROL .........................................232
NAVIGATION .....................................................233
ERROR HISTORY .............................................233
VEHICLE CAN DIAGNOSIS .............................237
AV COMM DIAGNOSIS .....................................237
HANDSFREE PHONE ......................................238
REAR DISPLAY .................................................238
CAMERA CONT. ...............................................239
BLUETOOTH .....................................................240
DELETE UNIT CONNECTION LOG .................240
Rear View Monitor Guiding Line Adjustment ........241
CONSULT-II Functions (Multi AV) ........................242
OPERATION PROCEDURE ..............................242
SELF-DIAG RESULTS ......................................243
DATA MONITOR ...............................................246
AV COMM MONITOR ........................................247
ECU PART NUMBER ........................................248
TROUBLE DIAGNOSIS ..........................................249
Multifunction Switch Cannot Be Operated ............249
RGB Image Is Not Displayed ................................249
RGB IMAGE IS NOT DISPLAYED ON FRONT
AND REAR DISPLAYS ......................................249
ONLY FRONT DISPLAY ....................................249
ONLY REAR DISPLAY ......................................250
RGB Screen Is Rolling. .........................................251
ONLY FRONT DISPLAY ....................................251
ONLY REAR DISPLAY ......................................253
Rear View Monitor Image Is Not Displayed ..........255
DVD IMAGE IS DISPLAYED .............................255
DVD IMAGE IS NOT DISPLAYED ....................257
IT CANNOT BE SWITCHED TO REAR VIEW
MONITOR IMAGE .............................................258
DVD Image Is Not Displayed ................................259
ONLY FRONT DISPLAY ....................................259
ONLY REAR DISPLAY ......................................261
BOTH FRONT DISPLAY AND REAR DISPLAY .262

AV-4Revision: 2007 April2007 M35/M45 Warning Message of Whether Rear View Image Is
Rolling or Not Displayed .......................................263
DVD Operation Screen Is Not Displayed ..............265
ONLY FRONT DISPLAY ....................................265
ONLY REAR DISPLAY ......................................265
It Cannot Be Switched to DVD Mode ...................266
Sound Is Not Output (Voice Guidance and TEL
Voice Are Normal) ................................................266
DVD AND AUDIO SOUND ARE NOT OUTPUT .266
DVD SOUND IS NOT OUTPUT ........................266
HEADPHONE SOUND IS NOT OUTPUT (BOTH
SIDES) ...............................................................267
Voice Activated Control System Is Not Activated . 268
THE SCREEN IS SWITCHED BY PRESSING
THE STEERING SWITCH .................................268
THE SCREEN IS NOT SWITCHED BY PRESS-
ING THE STEERING SWITCH .........................269
Steering Switch Cannot Be Operated ...................269
NONE OF THE OPERATIONS WORK. .............269
“ENTER”, “MENU UP-DOWN”, AND “SOURCE”
SWITCHES ARE NOT OPERATED ..................269
“PTT/TEL”, “BACK”, AND “VOLUME CONTROL”
SWITCHES ARE NOT OPERATED ..................270
The Hands-Free Phone Cannot Be Used .............271
THE VOICE CANNOT BE HEARD ....................271
THE VOICE CANNOT BE TRANSMITTED .......271
Voice Guidance Is Not Heard ...............................272
Example of Symptoms Judged Not Malfunction ...273
BASIC OPERATION ..........................................273
VEHICLE ICON .................................................273
MAP DVD-ROM .................................................274
ROUTE CALCULATION AND VISUAL GUID-
ANCE .................................................................274
VOICE GUIDANCE ...........................................275
VOICE RECOGNITION .....................................275
REAR VIEW MONITOR ....................................275
REMOTE CONTROLLER ..................................276
REMOVAL AND INSTALLATION ...........................277
Removal and Installation/Precautions for Replace-
ment ......................................................................277
REMOVAL OF BATTERY ..................................277
Audio Unit .............................................................277
REMOVAL .........................................................277
INSTALLATION ..................................................277
Front Door Speaker ..............................................277
REMOVAL .........................................................277
INSTALLATION ..................................................277
Rear Door Speaker ...............................................278
REMOVAL .........................................................278
INSTALLATION ..................................................278
Tweeter .................................................................278
REMOVAL .........................................................278
INSTALLATION ..................................................278
Center Speaker ....................................................278
REMOVAL .........................................................278
INSTALLATION ..................................................278
Seat Speaker ........................................................279
REMOVAL .........................................................279
INSTALLATION ..................................................279Rear Surround Speaker ........................................279
REMOVAL ..........................................................279
INSTALLATION ..................................................279
Woofer ..................................................................279
REMOVAL ..........................................................279
INSTALLATION ..................................................280
BOSE Amp ............................................................280
REMOVAL ..........................................................280
INSTALLATION ..................................................280
AudioPilot® Microphone .......................................280
REMOVAL ..........................................................280
INSTALLATION ..................................................280
Satellite Radio Tuner .............................................280
REMOVAL ..........................................................280
INSTALLATION ..................................................281
Antenna Amp ........................................................281
REMOVAL ..........................................................281
INSTALLATION ..................................................281
Satellite Radio Antenna ........................................281
REMOVAL ..........................................................281
INSTALLATION ..................................................282
AV (NAVI) Control Unit ..........................................282
REMOVAL ..........................................................282
INSTALLATION ..................................................282
Front Display Unit .................................................283
REMOVAL ..........................................................283
INSTALLATION ..................................................283
Rear Display Unit ..................................................283
REMOVAL ..........................................................283
INSTALLATION ..................................................284
Multifunction Switch ..............................................284
REMOVAL ..........................................................284
INSTALLATION ..................................................284
Preset Switch ........................................................284
REMOVAL ..........................................................284
INSTALLATION ..................................................284
Steering Switch .....................................................285
REMOVAL ..........................................................285
INSTALLATION ..................................................285
Rear Control Switch ..............................................286
REMOVAL ..........................................................286
INSTALLATION ..................................................286
Video Distributor ...................................................286
REMOVAL ..........................................................286
INSTALLATION ..................................................287
DVD Player ...........................................................287
REMOVAL ..........................................................287
INSTALLATION ..................................................287
Auxiliary Input Jacks .............................................288
REMOVAL ..........................................................288
INSTALLATION ..................................................288
Headphone Amp ...................................................288
REMOVAL ..........................................................288
INSTALLATION ..................................................288
Microphone ...........................................................288
REMOVAL ..........................................................288
INSTALLATION ..................................................289
GPS Antenna ........................................................289
REMOVAL ..........................................................289

AV-8
[WITHOUT MOBILE ENTERTAINMENT SYSTEM]
SYSTEM DESCRIPTION
Revision: 2007 April2007 M35/M45
SYSTEM DESCRIPTIONPFP:00000
System FunctionsNKS00489
Here is an example of functions. For details, refer to the owner's manual or navigation system owner's manual.
AUDIO
Speed Sensitive Volume (for BASE System)

Volume level of this system gone up and down automatically in proportion to the vehicle speed. And the
control level can be selected by the customer.

The audio unit inputs the vehicle signal that is sent from unified meter and A/C amp via CAN communica-
tion through AV (NAVI) control unit.
Precision Phased Audio (for BASE System)

It plays back the sound using the woofer (ultra-low bass and clear midrange sound) and reproduces the
sound with presence.

When the conventional BASS/TREBLE adjustment is a maximum, the sounds might be unclear because
the volume of midrange sound also rises together with the bass and treble. The precision phased audio
can emphasize ultra-low bass and ultra-high treble without changing the midrange sound by digital pro-
cessing using DSP.
NOTE:
When the radio is played, the noise may increase more than the presence due to the characteristics of
broadcasting waves. Therefore, the amplification rate while playing the radio is controlled lower than the
rate while playing CD.
AudioPilot® (for BOSE System)
AudioPilot® is the sound improving system that picks up any noises and the sound of music coming into the
vehicle by a microphone under the steering, and that the BOSE amp revises the frequency feature of music at
real time in response to the frequency feature of the noise while driving and listening to music.

If low frequency area noise from vehicle is loud, it adjusts low frequency element of music to be bigger
than vehicle noise.

If high frequency area noise from vehicle is loud, it adjusts all frequency element of music to be bigger
than vehicle noise.
Centerpoint® (for BOSE Surround 5.1ch System)
CD and 2.0ch DVD stereo sound played at audio unit and DVD player are subjected to signal processing in
BOSE amp. It can play the surround sound with presence.
VEHICLE INFORMATION SYSTEM

The status of audio, climate control system, fuel consumption, and navigation system (if equipped) are
displayed.

AV (NAVI) control unit receives the data signal from ECM, unified meter and A/C amp and low tire pres-
sure warning control unit via CAN communication. It calculates the values of fuel economy, tire pressure,
and trip computer from the received information and displays them.
NAVIGATION SYSTEM
Location Detection Principle
The navigation system periodically calculates the vehicle's current
position according to the following three signals:

Travel distance of the vehicle as determined by the vehicle
speed sensor

Turning angle of the vehicle as determined by the gyroscope
(angular velocity sensor)

Direction of vehicle travel as determined by the GPS antenna
(GPS information)
The current position of the vehicle is then identified by comparing the
calculated vehicle position with map data read from the map DVD-
ROM, which is stored in the DVD-ROM drive (map-matching), and
SKIB1058E