battery INFINITI M35 2007 Factory Workshop Manual
[x] Cancel search | Manufacturer: INFINITI, Model Year: 2007, Model line: M35, Model: INFINITI M35 2007Pages: 4647, PDF Size: 93.69 MB
Page 521 of 4647
ATC-70
TROUBLE DIAGNOSIS
Revision: 2007 April2007 M35/M45
Rear Control Switch CircuitNJS000GM
DIAGNOSIS PROCEDURE FOR REAR CONTROL SWITCH
SYMPTOM: Rear control switch does not operate.
1. CHECK A/C SYSTEM
Check multifunction switch, confirm A/C system operation.
OK or NG
OK >> GO TO 2.
NG >> Go to trouble diagnosis procedure for A/C system. Refer to AT C - 6 7 , "
Power Supply and Ground
Circuit for Auto Amp." .
2. CHECK REAR CONTROL SWITCH
Check rear control switch, except for A/C switch (audio) operation.
OK or NG
OK >> GO TO 5.
NG >> GO TO 3.
3. CHECK POWER SUPPLY FOR REAR CONTROL SWITCH
1. Turn ignition switch OFF.
2. Disconnect rear control switch connector.
3. Turn ignition switch ACC.
4. Check voltage between rear control switch harness connector
B554 terminal 1 and ground.
OK or NG
OK >> GO TO 4.
NG >> Check 10A fuse [No. 6 located in the fuse block (J/B)].
Refer to PG-114, "
FUSE BLOCK - JUNCTION BOX (J/
B)" .
If fuse is OK, check harness for open circuit. Repair or replace if necessary.
If fuse is NG, check harness for short circuit and replace fuse.
4. CHECK GROUND CIRCUIT FOR REAR CONTROL SWITCH
1. Turn ignition switch OFF.
2. Check continuity between rear control switch harness connector
B554 terminal 4 and ground.
OK or NG
OK >> GO TO 5.
NG >> Repair harness or connector.
5. CHECK REAR CONTROL SWITCH, AV CONTROL UNIT OR NAVI CONTROL UNIT
Check circuit between rear control switch and AV control unit or NAVI control unit. Refer to AV- 1 0 8 , "
TROU-
BLE DIAGNOSIS" (Without mobile entertainment system) or AV- 2 4 9 , "TROUBLE DIAGNOSIS" (With mobile
entertainment system).
OK or NG
OK >> Replace rear control switch.
NG >> Replace part or repair for result trouble diagnosis.1 – Ground : Battery voltage
RJIA3996E
4 – Ground : Continuity should exist.
RJIA3997E
Page 522 of 4647
TROUBLE DIAGNOSIS
ATC-71
C
D
E
F
G
H
I
K
L
MA
B
AT C
Revision: 2007 April2007 M35/M45
LAN System CircuitNJS000GN
SYMPTOM: Mode door motors, upper ventilator door motor, air mix door motors and intake door motor does
not operate normally.
DIAGNOSIS PROCEDURE FOR LAN CIRCUIT
1. CHECK POWER SUPPLY FOR UNIFIED METER AND A/C AMP.
1. Turn ignition switch ON.
2. Check voltage between unified meter and A/C amp. harness
connector M65 terminal 70 and ground.
OK or NG
OK >> GO TO 2.
NG >> Replace unified meter and A/C amp.
2. CHECK SIGNAL FOR UNIFIED METER AND A/C AMP.
Confirm A/C LAN signal between unified meter and A/C amp. har-
ness connector M65 terminal 69 and ground using an oscilloscope.
OK or NG
OK >> GO TO 3.
NG >> Replace unified meter and A/C amp.
RJIA4052E
70 – Ground : Battery voltage
RJIA4053E
Terminals
Vo l ta g e (+)
(−)
Unified meter and
A/C amp. connectorTerminal No.
M65 69 Ground
RJIA4054E
SJIA1453J
Page 523 of 4647
ATC-72
TROUBLE DIAGNOSIS
Revision: 2007 April2007 M35/M45
3. CHECK POWER SUPPLY FOR EACH DOOR MOTOR
Check voltage between each door motor harness connector terminal
1 and ground.
OK or NG
OK >> GO TO 4.
NG >> Repair harness or connector.
4. CHECK SIGNAL FOR EACH DOOR MOTOR
Confirm A/C LAN signal between each door motor harness connec-
tor terminal 3 and ground using an oscilloscope.
OK or NG
OK >> GO TO 5.
NG >> Repair harness or connector.
5. CHECK MOTOR GROUND CIRCUIT
1. Turn ignition switch OFF.
2. Disconnect each door motor connector.
3. Check continuity between each door motor harness connector
terminal 2 and ground.
OK or NG
OK >> GO TO 6.
NG >> Repair harness or connector.1 – Ground : Battery voltage
RJIA1988E
Door motorTerminals
Vo l ta g e (+)
(−)
Con-
nectorTerminal
No.
Mode (Driver
side)M252 3
Ground Mode (Pas-
senger side)M255 3
Upper venti-
latorM254 3
Air mix
(Driver side)M253 3
Air mix (Pas-
senger side)M256 3
Intake M257 3
RJIA1989E
SJIA1453J
2 – Ground : Continuity should exist.
RJIA1990E
Page 542 of 4647
TROUBLE DIAGNOSIS
ATC-91
C
D
E
F
G
H
I
K
L
MA
B
AT C
Revision: 2007 April2007 M35/M45
1. CHECK POWER SUPPLY FOR BLOWER MOTOR
1. Disconnect blower motor connector.
2. Turn ignition switch ON.
3. Check voltage between blower motor harness connector M91
terminal 1 and ground.
OK or NG
OK >> GO TO 2.
NG >> Check power supply circuit and 15A fuses [Nos. 10 and
11, located in the fuse block (J/B)]. Refer to PG-114,
"FUSE BLOCK - JUNCTION BOX (J/B)" .
If fuses are OK, check harness for open circuit. Repair or replace if necessary.
If fuses are NG, check harness for short circuit and replace fuse.
2. CHECK BLOWER MOTOR GROUND CIRCUIT
1. Turn ignition switch OFF.
2. Check continuity between blower motor harness connector M91
terminal 3 and ground.
OK or NG
OK >> GO TO 3.
NG >> Repair harness or connector.
3. CHECK CIRCUIT CONTINUITY BETWEEN BLOWER MOTOR AND UNIFIED METER AND A/C AMP.
1. Disconnect unified meter and A/C amp. connector.
2. Check continuity between blower motor harness connector M91
terminal 2 and unified meter and A/C amp. harness connector
M64 terminal 38.
OK or NG
OK >> GO TO 4.
NG >> Repair harness or connector.1 – Ground : Battery voltage
RJIA1997E
3 – Ground : Continuity should exist.
RJIA4072E
2 – 38 : Continuity should exist.
RJIA4073E
Page 546 of 4647
TROUBLE DIAGNOSIS
ATC-95
C
D
E
F
G
H
I
K
L
MA
B
AT C
Revision: 2007 April2007 M35/M45
1. CHECK AMBIENT SENSOR AND INTAKE SENSOR CIRCUIT
Check ambient sensor and intake sensor. Refer to AT C - 5 7 , "
FUNCTION CONFIRMATION PROCEDURE" ,
see No. 9 and 11.
OK or NG
OK >> GO TO 2.
NG >>
Malfunctioning ambient sensor: Refer to AT C - 11 2 , "Ambient Sensor Circuit" .
Malfunctioning intake sensor: Refer to ATC-121, "Intake Sensor Circuit" .
2. PERFORM AUTO ACTIVE TEST
Refer to PG-23, "
Auto Active Test" .
Does the magnet clutch operate?
YES >>WITH CONSULT-II: GO TO 5.
WITHOUT CONSULT-II: GO TO 6.
NO >> Check 10A fuse (No. 79, located in IPDM E/R). Refer to PG-28, "
IPDM E/R Terminal Arrange-
ment" , and GO TO 3.
3. CHECK CIRCUIT CONTINUITY BETWEEN IPDM E/R AND COMPRESSOR
1. Turn ignition switch OFF.
2. Disconnect IPDM E/R connector and compressor connector.
3. Check continuity between IPDM E/R harness connector E8 ter-
minal 34 and compressor harness connector F24 terminal 1.
OK or NG
OK >> GO TO 4.
NG >> Repair harness or connector.
4. CHECK MAGNET CLUTCH CIRCUIT
Check for operation sound when applying battery voltage direct cur-
rent to terminal.
OK or NG
OK >> 1. Replace IPDM E/R.
2. Go to self-diagnosis procedure AT C - 5 7 , "
FUNCTION
CONFIRMATION PROCEDURE" and perform self-
diagnosis STEP-4. Confirm that magnet clutch opera-
tion normal.
NG >> 1. Replace compressor.
2. Go to self-diagnosis procedure AT C - 5 7 , "
FUNCTION
CONFIRMATION PROCEDURE" and perform self-
diagnosis STEP-4. Confirm that magnet clutch operation normal.
34 – 1 : Continuity should exist.
RJIA4079E
RJIA2005E
Page 557 of 4647
ATC-106
TROUBLE DIAGNOSIS
Revision: 2007 April2007 M35/M45
Low-pressure Side Sometimes Becomes Negative
Low-pressure Side Becomes Negative
DIAGNOSIS PROCEDURE FOR INSUFFICIENT COOLING
SYMPTOM: Insufficient cooling
1. CHECK POWER SUPPLY FOR ECV (ELECTRONIC CONTROL VALVE)
1. Disconnect compressor (ECV) connector.
2. Turn ignition switch ON.
3. Check voltage between compressor (ECV) harness connector
F34 terminal 2 and ground.
OK or NG
OK >> GO TO 2.
NG >> Check power supply circuit and 10A fuse [No. 12,
located in the fuse block (J/B)]. Refer to PG-114, "
FUSE
BLOCK - JUNCTION BOX (J/B)" .
If fuse is OK, check harness for open circuit. Repair or replace if necessary.
If fuse is NG, check harness for short circuit and replace fuse.
Gauge indication Refrigerant cycle Probable cause Corrective action
Low-pressure side sometimes
becomes negative.
Air conditioning system
does not function and does
not cyclically cool the com-
partment air.
The system constantly func-
tions for a certain period of
time after compressor is
stopped and restarted.Refrigerant does not dis-
charge cyclically.
↓
Moisture is frozen at expan-
sion valve outlet and inlet.
↓
Water is mixed with refriger-
ant.
Drain water from refrigerant
or replace refrigerant.
Replace liquid tank.
AC354A
Gauge indication Refrigerant cycle Probable cause Corrective action
Low-pressure side becomes nega-
tive.
Liquid tank or front/rear side of
expansion valve’s pipe is
frosted or wet with dew.High-pressure side is closed
and refrigerant does not flow.
↓
Expansion valve or liquid tank
is frosted.Leave the system at rest until
no frost is present. Start it
again to check whether or not
the malfunction is caused by
water or foreign particles.
If water is the cause, initially
cooling is okay. Then the
water freezes causing a
blockage. Drain water from
refrigerant or replace refrig-
erant.
If due to foreign particles,
remove expansion valve
and remove the particles
with dry and compressed air
(not shop air).
If either of the above meth-
ods cannot correct the mal-
function, replace expansion
valve.
Replace liquid tank.
Check lubricant for contami-
nation.
AC362A
2 – ground : Battery voltage
RJIA4213E
Page 591 of 4647
ATC-140
AIR MIX DOOR MOTOR
Revision: 2007 April2007 M35/M45
AIR MIX DOOR MOTOR PFP:27732
Removal and InstallationNJS000HI
REMOVAL
Driver Side
1. Set the temperature control switch (driver side) at 18°C (60°F), and then disconnect the battery cable from
the negative terminal.
2. Remove heater & cooling unit assembly. Refer to ATC-134, "
HEATER & COOLING UNIT ASSEMBLY" .
3. Remove mounting screws, and then remove air mix door motor.
4. Disconnect air mix door motor connector.
Passenger Side
1. Set the temperature control switch (passenger side) at 18°C (60°F), and then disconnect the battery cable
from the negative terminal.
2. Remove blower unit. Refer to ATC-129, "
BLOWER UNIT" .
3. Remove mounting screws, and then remove air mix door motor.
4. Disconnect air mix door motor connector.
INSTALLATION
Installation is basically the reverse order of removal.
RJIA4126E
RJIA4125E
Page 612 of 4647
REFRIGERANT LINES
ATC-161
C
D
E
F
G
H
I
K
L
MA
B
AT C
Revision: 2007 April2007 M35/M45
Removal and Installation of Low-pressure Pipe 1 and High-pressure Pipe 2NJS000HS
REMOVAL
1. Set the temperature control switch (passenger side) at 18°C (60°F), and then disconnect the battery cable
from the negative terminal.
2. Use a refrigerant collecting equipment (for HFC-134a) to discharge the refrigerant.
3. Remove cowl top cover. Refer to EI-18, "
COWL TOP" .
4. Remove mounting bolt from low-pressure flexible hose bracket.
5. Remove high-pressure pipe 1 from vehicle clip.
6. Disconnect one-touch joints.
a. Set a disconnector [high-pressure side (SST: 9253089908), low-
pressure side (SST: 9253089916)] on A/C piping.
b. Slide a disconnector toward vehicle front until it clicks.
c. Slide A/C piping toward vehicle front and disconnect it.
CAUTION:
Cap or wrap the joint of low-pressure flexible hose, low-
pressure pipe 1 and high-pressure pipe 1, 2 with suitable
material such as vinyl tape to avoid the entry of air.
7. Remove instrument passenger lower panel and glove box. Refer
to IP-10, "
INSTRUMENT PANEL ASSEMBLY" .
8. Remove foot grille (right). Refer to ATC-148, "
Removal of Foot Grilles" .
9. Remove air mix door motor (passenger side). Refer to ATC-140, "
AIR MIX DOOR MOTOR" .
10. Remove mode door motor (passenger side). Refer to ATC-139, "
MODE DOOR MOTOR" .
11. Remove main link (right) and max. cool door link (right). Refer to ATC-134, "
HEATER & COOLING UNIT
ASSEMBLY" .
12. Remove mounting screws, and then remove evaporator cover.
RJIA4169E
RJIA4117E
RJIA4170E
Page 627 of 4647
AV-2Revision: 2007 April2007 M35/M45 Rear View Monitor Guiding Line Adjustment ........101
CONSULT-II Functions (Multi AV) .........................102
OPERATION PROCEDURE ..............................102
SELF-DIAG RESULTS ......................................103
DATA MONITOR ................................................105
AV COMM MONITOR ........................................106
ECU PART NUMBER ........................................107
TROUBLE DIAGNOSIS ..........................................108
Multifunction Switch Cannot Be Operated ............108
RGB Image Is Not Displayed ................................108
RGB Screen Is Rolling ..........................................109
Rear View Monitor Image Is Not Displayed ..........109
DVD IMAGE IS DISPLAYED .............................109
DVD IMAGE IS NOT DISPLAYED .....................112
IT CANNOT BE SWITCHED TO REAR VIEW
MONITOR IMAGE .............................................112
DVD Image Is Not Displayed ................................113
Warning Message of Whether Rear View Image Is
Rolling or Not Displayed .......................................115
DVD Operation Screen Is Not Displayed ..............115
It Cannot Be Switched to DVD Mode ...................115
Sound Is Not Output (Voice Guidance and TEL
Voice Are Normal) ................................................116
DVD AND AUDIO SOUND ARE NOT OUTPUT .116
DVD SOUND IS NOT OUTPUT ........................116
Voice Activated Control System Is Not Activated . 116
THE SCREEN IS SWITCHED BY PRESSING
THE STEERING SWITCH .................................116
THE SCREEN IS NOT SWITCHED BY PRESS-
ING THE STEERING SWITCH .........................117
Steering Switch Cannot Be Operated ...................118
NONE OF THE OPERATIONS WORK. .............118
“ENTER”, “MENU UP-DOWN”, AND “SOURCE”
SWITCHES ARE NOT OPERATED ..................118
“PTT/TEL”, “BACK”, AND “VOLUME CONTROL”
SWITCHES ARE NOT OPERATED ..................119
The Hands-Free Phone Cannot Be Used .............119
THE VOICE CANNOT BE HEARD ....................119
THE VOICE CANNOT BE TRANSMITTED .......120
Voice Guidance Is Not Heard (Base System) .......120
Voice Guidance Is Not Heard (BOSE System) .....121
Example of Symptoms Judged Not Malfunction ...122
BASIC OPERATION ..........................................122
VEHICLE ICON .................................................122
MAP DVD-ROM .................................................123
ROUTE CALCULATION AND VISUAL GUID-
ANCE .................................................................123
VOICE GUIDANCE ...........................................124
VOICE RECOGNITION .....................................124
REAR VIEW MONITOR ....................................124
REMOVAL AND INSTALLATION ...........................126
Removal and Installation/Precautions for Replace-
ment ......................................................................126
REMOVAL OF BATTERY ..................................126
Audio Unit .............................................................126
REMOVAL .........................................................126
INSTALLATION ..................................................126
Front Door Speaker ..............................................126
REMOVAL .........................................................126INSTALLATION ..................................................126
Rear Door Speaker ...............................................127
REMOVAL ..........................................................127
INSTALLATION ..................................................127
Tweeter .................................................................127
REMOVAL ..........................................................127
INSTALLATION ..................................................127
Center Speaker .....................................................127
REMOVAL ..........................................................127
INSTALLATION ..................................................127
Seat Speaker ........................................................128
REMOVAL ..........................................................128
INSTALLATION ..................................................128
Rear Surround Speaker ........................................128
REMOVAL ..........................................................128
INSTALLATION ..................................................128
Woofer ..................................................................128
REMOVAL ..........................................................128
INSTALLATION ..................................................129
BOSE Amp ............................................................129
REMOVAL ..........................................................129
INSTALLATION ..................................................129
AudioPilot® Microphone .......................................129
REMOVAL ..........................................................129
INSTALLATION ..................................................129
Satellite Radio Tuner .............................................129
REMOVAL ..........................................................129
INSTALLATION ..................................................130
Antenna Amp ........................................................130
REMOVAL ..........................................................130
INSTALLATION ..................................................130
Satellite Radio Antenna ........................................130
REMOVAL ..........................................................130
INSTALLATION ..................................................131
AV (NAVI) Control Unit ..........................................131
REMOVAL ..........................................................131
INSTALLATION ..................................................131
Front Display Unit (Base System) .........................132
REMOVAL ..........................................................132
INSTALLATION ..................................................132
Front Display Unit (BOSE System) .......................132
REMOVAL ..........................................................132
INSTALLATION ..................................................133
Multifunction Switch ..............................................133
REMOVAL ..........................................................133
INSTALLATION ..................................................133
Preset Switch ........................................................133
REMOVAL ..........................................................133
INSTALLATION ..................................................133
Steering Switch .....................................................134
REMOVAL ..........................................................134
INSTALLATION ..................................................134
DVD Player ...........................................................134
REMOVAL ..........................................................134
INSTALLATION ..................................................135
Auxiliary Input Jacks .............................................136
REMOVAL ..........................................................136
INSTALLATION ..................................................136
Microphone ...........................................................136
Page 629 of 4647
AV-4Revision: 2007 April2007 M35/M45 Warning Message of Whether Rear View Image Is
Rolling or Not Displayed .......................................263
DVD Operation Screen Is Not Displayed ..............265
ONLY FRONT DISPLAY ....................................265
ONLY REAR DISPLAY ......................................265
It Cannot Be Switched to DVD Mode ...................266
Sound Is Not Output (Voice Guidance and TEL
Voice Are Normal) ................................................266
DVD AND AUDIO SOUND ARE NOT OUTPUT .266
DVD SOUND IS NOT OUTPUT ........................266
HEADPHONE SOUND IS NOT OUTPUT (BOTH
SIDES) ...............................................................267
Voice Activated Control System Is Not Activated . 268
THE SCREEN IS SWITCHED BY PRESSING
THE STEERING SWITCH .................................268
THE SCREEN IS NOT SWITCHED BY PRESS-
ING THE STEERING SWITCH .........................269
Steering Switch Cannot Be Operated ...................269
NONE OF THE OPERATIONS WORK. .............269
“ENTER”, “MENU UP-DOWN”, AND “SOURCE”
SWITCHES ARE NOT OPERATED ..................269
“PTT/TEL”, “BACK”, AND “VOLUME CONTROL”
SWITCHES ARE NOT OPERATED ..................270
The Hands-Free Phone Cannot Be Used .............271
THE VOICE CANNOT BE HEARD ....................271
THE VOICE CANNOT BE TRANSMITTED .......271
Voice Guidance Is Not Heard ...............................272
Example of Symptoms Judged Not Malfunction ...273
BASIC OPERATION ..........................................273
VEHICLE ICON .................................................273
MAP DVD-ROM .................................................274
ROUTE CALCULATION AND VISUAL GUID-
ANCE .................................................................274
VOICE GUIDANCE ...........................................275
VOICE RECOGNITION .....................................275
REAR VIEW MONITOR ....................................275
REMOTE CONTROLLER ..................................276
REMOVAL AND INSTALLATION ...........................277
Removal and Installation/Precautions for Replace-
ment ......................................................................277
REMOVAL OF BATTERY ..................................277
Audio Unit .............................................................277
REMOVAL .........................................................277
INSTALLATION ..................................................277
Front Door Speaker ..............................................277
REMOVAL .........................................................277
INSTALLATION ..................................................277
Rear Door Speaker ...............................................278
REMOVAL .........................................................278
INSTALLATION ..................................................278
Tweeter .................................................................278
REMOVAL .........................................................278
INSTALLATION ..................................................278
Center Speaker ....................................................278
REMOVAL .........................................................278
INSTALLATION ..................................................278
Seat Speaker ........................................................279
REMOVAL .........................................................279
INSTALLATION ..................................................279Rear Surround Speaker ........................................279
REMOVAL ..........................................................279
INSTALLATION ..................................................279
Woofer ..................................................................279
REMOVAL ..........................................................279
INSTALLATION ..................................................280
BOSE Amp ............................................................280
REMOVAL ..........................................................280
INSTALLATION ..................................................280
AudioPilot® Microphone .......................................280
REMOVAL ..........................................................280
INSTALLATION ..................................................280
Satellite Radio Tuner .............................................280
REMOVAL ..........................................................280
INSTALLATION ..................................................281
Antenna Amp ........................................................281
REMOVAL ..........................................................281
INSTALLATION ..................................................281
Satellite Radio Antenna ........................................281
REMOVAL ..........................................................281
INSTALLATION ..................................................282
AV (NAVI) Control Unit ..........................................282
REMOVAL ..........................................................282
INSTALLATION ..................................................282
Front Display Unit .................................................283
REMOVAL ..........................................................283
INSTALLATION ..................................................283
Rear Display Unit ..................................................283
REMOVAL ..........................................................283
INSTALLATION ..................................................284
Multifunction Switch ..............................................284
REMOVAL ..........................................................284
INSTALLATION ..................................................284
Preset Switch ........................................................284
REMOVAL ..........................................................284
INSTALLATION ..................................................284
Steering Switch .....................................................285
REMOVAL ..........................................................285
INSTALLATION ..................................................285
Rear Control Switch ..............................................286
REMOVAL ..........................................................286
INSTALLATION ..................................................286
Video Distributor ...................................................286
REMOVAL ..........................................................286
INSTALLATION ..................................................287
DVD Player ...........................................................287
REMOVAL ..........................................................287
INSTALLATION ..................................................287
Auxiliary Input Jacks .............................................288
REMOVAL ..........................................................288
INSTALLATION ..................................................288
Headphone Amp ...................................................288
REMOVAL ..........................................................288
INSTALLATION ..................................................288
Microphone ...........................................................288
REMOVAL ..........................................................288
INSTALLATION ..................................................289
GPS Antenna ........................................................289
REMOVAL ..........................................................289