window ISUZU TROOPER 1998 Service Service Manual
[x] Cancel search | Manufacturer: ISUZU, Model Year: 1998, Model line: TROOPER, Model: ISUZU TROOPER 1998Pages: 3573, PDF Size: 60.36 MB
Page 2861 of 3573
8DÐ268 WIRING SYSTEM
Window On The Front PassengerÕs Side Does Not Operate
STEP ACTION VALUE(S) YES NO
Is BÐ1 grounded securely?
Disconnect the front power window & door lock switchÐLH
connector DÐ14.
Is there continuity between harness side connector DÐ14
terminal 7 and the ground BÐ1?
Repair an open circuit between connector DÐ14 terminal 7
and the ground BÐ1.
Is the action complete?
Turn the starter switch on.
Is the battery voltage applied between harness side
connector DÐ14 terminal 5 and the ground?
Repair an open circuit between connector BÐ37 terminal 4
and connector DÐ14 terminal 5.
Is the action complete?
Connect the battery positive terminal with harness side
connector DÐ14 terminal 10 or 1, and connect the battery
negative terminal with harness side connector DÐ14 terminal
1 or 10.
Does the motor operate?
1. Disconnect the front power window motorÐLH connector
DÐ11.
2. Connect the battery positive terminal with the motor side
connector DÐ11 terminal 1 or 2, and connect the battery
negative terminal with the motor side connector DÐ11
terminal 2 or 1.
Does the motor operate?
Repair an open circuit between the front power window &
door lock switchÐLH and the front power window motorÐLH.
Is the action complete?Ð
Ð
Ð
Approx. 12V
Ð
Ð
Ð
ÐGo to
step 2
Go to
step 4
Go to
step 2
Go to
step 6
Go to
step 4
Replace
the front
power
window &
door lock
switchÐLH
Go to
step 8
Verify
repairGround it
securely
Go to
step 3
Ð
Go to
step 5
Ð
Go to
step 7
Replace
the motor
Ð 1
2
3
4
5
6
7
8
Page 2862 of 3573
WIRING SYSTEM 8DÐ269
Rear Window On The Left (or Right) Side Does Not Operate
STEP ACTION VALUE(S) YES NO
1. Disconnect the rear power window switchÐLH connector
DÐ22 or the rear power window & door lock switchÐRH
connector DÐ27.
2. Turn the starter switch on.
Is the battery voltage applied between harness side
connector DÐ22 terminal 4 and the ground, or harness side
connector DÐ27 terminal 4 and the ground?
Repair an open circuit between connector BÐ37 terminal 4
and connector DÐ22 terminal 4 or connector DÐ27 terminal 4.
Is the action complete?
Is there continuity between harness side connector DÐ22
terminal 3 and the ground, or harness side connector
DÐ27 terminal 3 and the ground?
Repair an open circuit between connector DÐ22 terminal 3 or
connector DÐ27 terminal 3 and the ground.
Is the action complete?
Connect the battery positive terminal with harness side
connector DÐ22 terminals 5 or harness side connector DÐ27
terminal 5, and connect the battery negative terminal with
harness side connector DÐ22 terminal 6 or harness side
connector DÐ27 terminal 6.
Does the motor operate?
1. Disconnect the rear power window motor connector DÐ20
or DÐ25.
2. Connect the battery positive terminal with motor side
connector DÐ20 or DÐ25 terminal 1 or 2, and connect the
battery negative terminal with the motor side connector
DÐ20 or DÐ25 terminal 2 or 1.
Does the motor operate?
Repair an open circuit between the rear power window
switch and the rear power window motor.
Is the action complete?Approx. 12V
Ð
Ð
Ð
Ð
Ð
ÐGo to
step 3
Go to
step 1
Go to
step 5
Go to
step 3
Replace
the rear
power
window
switchÐLH
or ÐRH
Go to
step 7
Verify
repairGo to
step 2
Ð
Go to
step 4
Ð
Go to
step 6
Replace
the motor
Ð 1
2
3
4
5
6
7
Page 2863 of 3573
8DÐ270 WIRING SYSTEM
Window on the Front PassengerÕs Side Does Not Operate by the Front Power Window &
Door Lock Switch Ð RH
STEP ACTION VALUE(S) YES NO
Disconnect the front power window & door lock switchÐRH
connector DÐ30 and the front power window & door lock
switchÐRH connector DÐ14.
Is there continuity between harness side connector DÐ30
terminal 5 and harness side connector DÐ14 terminal 2?
Repair an open circuit between connector DÐ30 terminal 5
and connector DÐ14 terminal 2.
Is the action complete?Ð
ÐReplace
the front
power
window &
door lock
switchÐRH
Verify
repairGo to
step 2
Ð 1
2
Page 2864 of 3573
WIRING SYSTEM 8DÐ271
Lock SW Does Not Function
STEP ACTION VALUE(S) YES NO
Repair or replace the front power window & door lock
switchÐRH.
Is the action complete?Ð Verify
repairÐ 1
Page 2994 of 3573
WIRING SYSTEM 8DÐ401
System Check Procedure
STEP OPERATION ITEM TO BE CHECKEDITEM OF
REMARKS
MALFUNCTION
Be sure to lock door
with locking knob.
Activate alarm
device.
All doors are
unlocked.
With key set at unlock
position, check to see
if alarm stops.
All doors are
locked.
Activate alarm
device.
Activate alarm
device.
Only left rear door
is unlocked. Check to see if engine hood,
tailgate and doors are closed and
locked.
Check to see if indicator light
remains lit off.
Check to see if indicator light
flashes.
Check to see if dome light and
courtesy light illuminate.
Check to see if indicator light
changes from flashing to steadily
on.
Check to see if indicator light
turns off in about 10 seconds.
Check to see if alarm operates
(with headlight flashing, and horn
blaring intermittently.)
Check to see if alarm stops.
Check to see if indicator light
turns on.
Check to see if indicator light
goes off after about 10 seconds.
Check to see if alarm does not
operate.
Check to see if indicator light
turns on.
Check to see if indicator light
goes off after about 10 seconds.
Check to see if alarm starts. Turn starter key to ÒONÓ position.
Open windows fully.
Pull out starter key after turning it
back to ÒOFFÓ position.
Unlock left front door with locking
knob.
Open left front door. (And get out
of the vehicle.)
Close left front door.
Lock left front door.
Wait about 10 seconds
Unlock left front door with locking
knob.
Insert key into key cylinder of left
front door and turn it in unlock
direction.
Lock left front door.
Wait for about 10 seconds.
Unlock left front door with key.
Lock left front door with key.
Wait for about 10 seconds.
Unlock left rear door with locking
knob.K
A
B
C
D
E
B
C
F
B
C
D 1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
Page 3077 of 3573
8D – 484 WIRING SYSTEM
Sun Roof
General Description
The circuit consists of sun roof switch, sun roof
control unit, safety stop switch, limit switch and sun
roof motor.
When sun roof switch is turned on, battery voltage is
applied to sun roof control unit through circuit breaker
and power window relay.
Accordingly, when sun roof switch is set to “Open” or
“Close” position, open or close relay incorporated
into the control unit is activated to change rotational
direction of sun roof motor to open or close sun roof.
Also, operational process (full close → limit stop →
full open → safety stop → full close) of sun roof is
controlled by the control unit in accordance with
signals received from safety stop switch and limit
switch.
Page 3078 of 3573
WIRING SYSTEM 8D – 485
Circuit Diagram (RHD)
D08RW649
2
B-37
B-37
1
4 3 B-37
B-37
6H-21
3.0
B/Y STARTER SW
(IG1)BATT.(+)
C-4 10A
ELEC.
IGN.C/B-2 30A
P/W, P/S, S/R0.85
L/W
3.0
B/L
2.0
L/B 2.0
L/B
2.0
L/B
0.5
B0.5
Y/R0.5
Y/B
0.5
Y/B0.5
L/Y1.25
L1.25
Y
0.5
L/Y
2.0
L/B 0.5
L/WB-19
BODY-RH 1.25
B 0.3
B
POWER
WINDOW
RELAY
SAFETY
STOP
SWLIMIT
SWSUN ROOF
SWSUN ROOF
MOTOR
A
3
H-45
4
H-21
2.0
B
BODY-LH 4
H-23
POWER WINDOW
SW6
H-454S-5
0.5
B
2.0
B
2.0
B
B
A
B
1 S-2
3
S-2
2 1 5S-5 2.0
L/B
B-2
L-1
OPEN
CLOSE0.5
B L-13
L-1 1
H-452
H-45 2
S-4
3
S-5
6
S-5OPEN
SUN ROOF CONTROL UNIT
CLOSE
1
S-5
4
S-4
1S-32
S-3
M
Page 3080 of 3573
WIRING SYSTEM 8D – 487
D08RW947
Circuit Diagram (LHD)
2
B-37
B-37
1
4 3 B-37
B-37
6H-21
3.0
B/Y STARTER SW
(IG1)BATT.(+)
C-4 10A
ELEC.
IGN.C/B-2 30A
P/W, P/S, S/R0.5
L/W
3.0
B/L
2.0
L/B 2.0
L/B
2.0
L/B
0.5
B0.5
Y/R0.5
Y/B
0.5
Y/B0.5
L/Y1.25
L1.25
Y
0.5
L/Y
2.0
L/B 0.5
L/WB-18
BODY-LH 1.25
B 0.3
B
POWER
WINDOW
RELAY
SAFETY
STOP
SWLIMIT
SWSUN ROOF
SWSUN ROOF
MOTOR
A
3
H-45
4
H-21
2.0
B
BODY-RH 4
H-23
POWER WINDOW
SW6
H-454S-5
0.5
B
2.0
B
2.0
B
B
A
B
1 S-2
3
S-2
2 1 5S-5 2.0
L/B
B-1
L-1
OPEN
CLOSE0.5
B L-13
L-1 1
H-452
H-45 2
S-4
3
S-5
6
S-5OPEN
SUN ROOF CONTROL UNIT
CLOSE
1
S-5
4
S-4
1S-32
S-3
M
Page 3085 of 3573
8D – 492 WIRING SYSTEM
5. Power Source Circuit Diagnosis
•IS THERE ANY CONTINUITY BETWEEN THE TERMINALS
OF C/B-2 (30A)?
YES
•IS FUSE C-4 (10A) NORMAL? PUSH IN THE RESET BUTTON OF CIRCUIT BREAKER
AND CHECK THE CONTINUITY AGAIN
IF THERE IS NO CONTINUITY AFTER PUSHING RESET
BUTTON, REPLACE IT WITH NEW ONE
NO
YES
•IS THE POWER WINDOW RELAY NORMAL? REPLACE THE FUSE
NO
YES
•
•TURN THE STARTER SWITCH ON
IS THE BATTERY VOLTAGE APPLIED BETWEEN 1 B-37
AND THE GROUND OR 2 B-37 AND THE GROUND?
NO
REPLACE THE RELAY
YES
REPAIR A POOR CONNECTION OF THE CONNECTORS
OR AN OPEN CIRCUIT BETWEEN 3 B-37 AND B-19 (OR B-18 )GROUND IT SECURELY
NO
YES
•IS B-19 (OR B-18 ) GROUNDED SECURELY?
NO
REPAIR A POOR CONNECTION OF THE CONNECTORS
OR AN OPEN CIRCUIT BETWEEN FUSE C-4 (10A) AND
1 B-37 OR 1 H-14 AND 2 B-37
Page 3196 of 3573
8F±1 BODY STRUCTURE
BODY AND ACCESSORIES
BODY STRUCTURE
CONTENTS
Service Precaution 8F±3. . . . . . . . . . . . . . . . . . . . . .
Frame 8F±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description 8F±3. . . . . . . . . . . . . . . . . . . . . .
Frame Dimensions (L W B) 8F±4. . . . . . . . . . . . . . .
Frame Dimensions (S W B) 8F±5. . . . . . . . . . . . . . .
General Description 8F±6. . . . . . . . . . . . . . . . . . . . .
Front Bumper 8F±6. . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±6. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±7. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±7. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Bumper Slider Bracket 8F±7. . . . . . . . . . . . . .
Removal 8F±7. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±7. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Bumper 8F±8. . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±8. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±8. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±9. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Location (W/Rear Combination Light
and License Light) 8F±10. . . . . . . . . . . . . . . . . . . .
Removal 8F±10. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±11. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Location (W/Rear Combination Light) 8F±12
Removal 8F±12. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±13. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Bumper Slider 8F±14. . . . . . . . . . . . . . . . . . . . .
Removal 8F±14. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±14. . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description 8F±15. . . . . . . . . . . . . . . . . . . . .
Cowl Cover 8F±15. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±15. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±15. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±16. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Hood 8F±16. . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±16. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±16. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Bulge 8F±17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±17. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±17. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±17. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Hood Hinge 8F±18. . . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±18. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±18. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±18. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Hood Lock 8F±19. . . . . . . . . . . . . . . . . . . . . . . Parts Location 8F±19. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±19. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±20. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator Grille And Front End Lower Panel 8F±20.
Parts Location 8F±20. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±20. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±21. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Fender Panel 8F±22. . . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±22. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±22. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±23. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Body Mounting 8F±24. . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±24. . . . . . . . . . . . . . . . . . . . . . . .
Removal (No.1 ± No. 2) 8F±24. . . . . . . . . . . . . . . .
Removal (No. 3 Ð No. 6) 8F±25. . . . . . . . . . . . . . .
Installation 8F±26. . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description 8F±27. . . . . . . . . . . . . . . . . . . . .
Body Dimension 8F±28. . . . . . . . . . . . . . . . . . . . . . . .
Instrument Panel Assembly 8F±48. . . . . . . . . . . . . . .
Parts Location 8F±48. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±49. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±53. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cross Beam Assembly 8F±54. . . . . . . . . . . . . . . . . . .
Parts Location 8F±54. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±54. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±55. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Door Assembly 8F±56. . . . . . . . . . . . . . . . . . . .
Parts Location 8F±56. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±56. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±56. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Door Assembly 8F±57. . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±57. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±57. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±58. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Strikers 8F±58. . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjustment 8F±58. . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Check Arm Assembly (Front & Rear) 8F±59. .
Parts Location 8F±59. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±59. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8F±60. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Window Regulator, Glass And Glass
Run 8F±60. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts Location 8F±60. . . . . . . . . . . . . . . . . . . . . . . .
Removal 8F±60. . . . . . . . . . . . . . . . . . . . . . . . . . . . .