clock ISUZU TROOPER 1998 Service Manual PDF
[x] Cancel search | Manufacturer: ISUZU, Model Year: 1998, Model line: TROOPER, Model: ISUZU TROOPER 1998Pages: 3573, PDF Size: 60.36 MB
Page 2554 of 3573

LIGHTING SYSTEM8A–15
Ashtray Illumination Bulb
Removal
1. Disconnect the battery ground cable.
2. Removal eight screws to remove the instrument
cluster panel(1).
3. Remove the ashtray(5).
4. Remove four screws to remove the audio box(4).
5. Remove two screws to remove the ashtray guide(2).
6. Turn the socket counterclockwise to remove it then
pull out the bulb(3).
742RS001
Installation
To install, follow the removal steps in the reverse order.
Glove Box Illumination Bulb
Removal
1. Disconnect the battery ground cable.
2. Open the glove box lid, and then pull out the bulb(1).
805RS004
Installation
To install, follow the removal steps in the reverse order.
Page 2557 of 3573

8A–18LIGHTING SYSTEM
Lighting Switch (Combination Switch)
Removal
1. Disconnect the battery ground cable.
2. Remove the instrument panel driver lower cover(5).
Refer to the Instrument Panel Assembly in Body
Structure section.
3. Remove seven screws to remove the steering
cowl(4).
4. Disconnect the SDM (air bag controller) connector
located at lower of the instrument panel driver lower
cover.
5. Remove four fixing screws and disconnect the driver
inflator module connector to remove the driver inflator
module(3).
CAUTION: When carrying a live inflator module,
make sure the bag opening is pointed away from
you. In case of an accidental deployment, the bag will
then deploy with minimal chance of injury. Never
carry the inflator module by the wires or connector
on the underside of the module.
When placing a live inflator module on a bench or
other surface, always face the bag and trim cover up,
away from the surface. This is necessary so that a
free space is provided to allow the air bag to expand
in the unlikely event of accidental deployment.
6. Remove the steering wheel(2).
Refer to the Steering Wheel in Steering section.
7. Disconnect the SRS coil assembly connector,
remove four fixing screws to remove the SRS coil
assembly(1).
8. Disconnect the lighting switch connector, remove four
fixing screws to remove the lighting switch(6).
825RS039
Installation
To install, follow the removal steps in the reverse order,
noting the following points.1. Check to see if the vehicle is in the straight driving
condition and turn the rotary section of the SRS coil
assembly provided to the upper surface of the lighting
switch (combination switch) counterclockwise fully
until it stops.
Then from where it stops, turn it back about 3
rotations to set the alignment marks(7) together
before installing the steering wheel.
825RW099
2. Tighten the steering shaft nut to the specified torque.
Torque: 34 N·m (3.5 kg·m/25 lb ft)
3. When connect the double lock type of inflator module
connector, insert the connector completely and lock
at outside.
Imperfect locking may cause malfunction of SRS
system circuit.
4. When installing the steering cowl(11), be sure to pass
the harnesses through the route as shown in the
figure so that the starter switch harness(8), the
combination switch harness(9) and inflator module
harness(10) will not get caught.
431RW014
Page 2559 of 3573

8A–20LIGHTING SYSTEM
Stoplight Switch (W/O Cruise Control)
Removal
1. Disconnect the battery ground cable.
2. Disconnect the connector(3), loosen the lock nut(1)
and then remove the stoplight switch(2) by turning it.
310RS007
Installation
To install, follow the removal steps in the reverse order,
noting the following points.
1. Check to see if the brake pedal has been returned by
the return spring to the specified position.
2. Turn the stoplight switch(1) clockwise until the tip of
the threaded portion of the switch contacts the pedal
arm(2).
3. Turn the switch counterclockwise until the space
between the tip of the threaded portion and the pedal
arm is 0.5 to 1.0 mm (0.02–0.04 in.).
310RS006
Page 2560 of 3573

LIGHTING SYSTEM8A–21
Brake Switch (W/Cruise Control)
Removal
1. Disconnect the battery ground cable.
2. Disconnect the connector(1), loosen the lock nut(3)
and then remove the brake switch(2) by turning it.
310RW010
Installation
To install, follow the removal steps in the reverse order,
noting the following points.
1. Check to see if the brake pedal has been returned by
the return spring to the specified position.
2. Turn the switch clockwise until the tip of the threaded
portion of the brake switch contacts the pedal arm.
3. Turn the switch counterclockwise until the space
between the tip of the threaded portion and the pedal
arm is 0.5 to 1.0 mm (0.02–0.04 in.).
310RS003
Turn Signal Switch (Combination Switch)
Removal and Installation
Refer to the removal and installation steps of the Lighting
Switch (Combination Switch) in this section.
Page 2584 of 3573

ENTERTAINMENT8C±1
BODY AND ACCESSORIES
ENTERTAINMENT
CONTENTS
Service Precaution 8C±1. . . . . . . . . . . . . . . . . . . . . .
Cigarette Lighter 8C±2. . . . . . . . . . . . . . . . . . . . . . . .
General Description 8C±2. . . . . . . . . . . . . . . . . . . . .
Removal 8C±2. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8C±2. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Digital Clock 8C±3. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8C±3. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8C±3. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rod Type Antenna 8C±4. . . . . . . . . . . . . . . . . . . . . .
Removal 8C±4. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8C±4. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Auto Antenna 8C±5. . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description 8C±5. . . . . . . . . . . . . . . . . . . . .
Removal 8C±5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Installation 8C±5. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Antenna Rod 8C±6. . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8C±6. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8C±6. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio 8C±7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8C±7. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8C±7. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Speaker 8C±8. . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8C±8. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8C±8. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Speaker 8C±9. . . . . . . . . . . . . . . . . . . . . . . . . . .
Removal 8C±9. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation 8C±9. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Service Precaution
WARNING: I F S O E Q U IPPED WITH A
SUPPLEMENTAL RESTRAINT SYSTEM (SRS),
REFER TO THE SRS COMPONENT AND WIRING
LOCATION VIEW IN ORDER TO DETERMINE
WHETHER YOU ARE PERFORMING SERVICE ON OR
NEAR THE SRS COMPONENTS OR THE SRS
WIRING. WHEN YOU ARE PERFORMING SERVICE
ON OR NEAR THE SRS COMPONENTS OR THE SRS
WIRING, REFER TO THE SRS SERVICE
INFORMATION. FAILURE TO FOLLOW WARNINGS
COULD RESULT IN POSSIBLE AIR BAG
DEPLOYMENT, PERSONAL INJURY, OR
OTHERWISE UNNEEDED SRS SYSTEM REPAIRS.
CAUTION: Always use the correct fastener in the
proper location. When you replace a fastener, use
ONLY the exact part number for that application.
ISUZU will call out those fasteners that require a
replacement after removal. ISUZU will also call out
the fasteners that require thread lockers or thread
sealant. UNLESS OTHERWISE SPECIFIED, do not
use supplemental coatings (Paints, greases, or other
corrosion inhibitors) on threaded fasteners or
fastener joint interfaces. Generally, such coatings
adversely affect the fastener torque and the joint
clamping force, and may damage the fastener. When
you install fasteners, use the correct tightening
sequence and specifications. Following these
instructions can help you avoid damage to parts and
systems.
Page 2586 of 3573

ENTERTAINMENT8C–3
Digital Clock
Removal
1. Disconnect the battery ground cable.
2. Remove the front console assembly(1).
Refer to the Instrument Panel Assembly in Body
Structure section.
3. Remove the lower cluster assembly(2).
Refer to the Instrument Panel Assembly in Body
Structure section.
4. Remove the instrument panel driver lower cover
assembly(3).
Refer to the Instrument Panel Assembly in Body
Structure section.
821RW024
5. Remove the instrument panel cluster assembly(4).
Refer to the Instrument Panel Assembly in Body
Structure section.
6. Disconnect the connector and push the lock from the
back side of the instrument panel cluster assembly to
remove the digital clock(5).
821RW034
Installation
To install, follow the removal steps in the reverse order,
noting the following point.
1. Push in the switch with your fingers until it locks
securely.
Page 2587 of 3573

8C–4ENTERTAINMENT
Rod Type Antenna
Removal
1. Disconnect the battery ground cable.
2. Turn the antenna rod(1) counterclockwise to remove
it.
3. Remove three screws and nine clips to remove the
fender inner liner(2).
4. Disconnect the feeder cable connector at the inside of
the vehicle, remove the housing bracket screw, turn
the lock nut counterclockwise to remove it together
with the base mold and then remove the housing(3).
890RS004
Installation
To install, follow the removal steps in the reverse order.
Page 2589 of 3573

8C–6ENTERTAINMENT
Antenna Rod
Removal
1. Disconnect the battery ground cable.
2. Remove the antenna nut(1).
3. Until the lower part of the antenna rod(4) is removed
from the bezel part, rotate the antenna motor in an
ascending way, and expand the rod.
4. Turn the antenna top(2) counterclockwise.
5. Remove the contact sleeve(3).
6. Remove the antenna rod(4).
890RW076
Installation
To install, follow the removal steps in the reverse order,
nothing the following points.
1. Rotate the antenna motor in a descend way, and push
in vertically until the antenna rod is in the complete
state of storage.
2. After ending the installation, confirm that the antenna
rod works correctly.
Page 2595 of 3573

8DÐ2 WIRING SYSTEM
General Description . . . . . . . . . . . . . . . . . . 8DÐ272
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ273
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ275
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ279
AntiÐLock Brake System (ABS) . . . . . . . . . . 8DÐ284
General Description . . . . . . . . . . . . . . . . . . 8DÐ284
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ285
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ291
A/T Shift Lock . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ298
General Description . . . . . . . . . . . . . . . . . . 8DÐ298
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ299
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ300
Windshield Wiper/Washer . . . . . . . . . . . . . . 8DÐ303
General Description . . . . . . . . . . . . . . . . . . 8DÐ303
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ304
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ305
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ308
Rear Wiper/Washer . . . . . . . . . . . . . . . . . . . . 8DÐ316
General Description . . . . . . . . . . . . . . . . . . 8DÐ316
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ317
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ319
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ323
Headlight Wiper/Washer . . . . . . . . . . . . . . . 8DÐ329
General Description . . . . . . . . . . . . . . . . . . 8DÐ329
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ330
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ332
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ336
Rear Defogger . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ342
General Description . . . . . . . . . . . . . . . . . . 8DÐ342
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ343
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ344
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ347
Audio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ350
General Description . . . . . . . . . . . . . . . . . . 8DÐ350
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ351
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ355
Cigarette Lighter and Digital Clock . . . . . . . 8DÐ359
General Description . . . . . . . . . . . . . . . . . . 8DÐ359
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ360
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ361
Power Door Mirror . . . . . . . . . . . . . . . . . . . . 8DÐ364
General Description . . . . . . . . . . . . . . . . . . 8DÐ364
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ365
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ368
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ373
AntiÐTheft System with Keyless Entry . . . . 8DÐ380
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ381
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ392
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ399Meter and Warning/Indicator Light . . . . . . 8DÐ410
General Description . . . . . . . . . . . . . . . . . . 8DÐ410
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ411
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ429
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ445
A/T Shift Indicator . . . . . . . . . . . . . . . . . . . . . 8DÐ464
General Description . . . . . . . . . . . . . . . . . . 8DÐ464
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ465
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ467
Heater and Air Conditioning . . . . . . . . . . . . 8DÐ471
General Description . . . . . . . . . . . . . . . . . . 8DÐ471
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ472
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ474
Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ484
General Description . . . . . . . . . . . . . . . . . . 8DÐ484
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ485
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ486
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ489
Seat Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ493
General Description . . . . . . . . . . . . . . . . . . 8DÐ493
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ494
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ495
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ498
Power Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ500
General Description . . . . . . . . . . . . . . . . . . 8DÐ500
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ501
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ503
Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ507
Shift on the Fly System . . . . . . . . . . . . . . . . 8DÐ513
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ514
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ516
Torque on Demand (TOD) . . . . . . . . . . . . . . 8DÐ538
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ539
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ542
Supplemental Restraint System (SRS)Ð
AIR BAG . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ543
General Description . . . . . . . . . . . . . . . . . . 8DÐ543
Circuit Diagram. . . . . . . . . . . . . . . . . . . . . . 8DÐ544
Parts Location . . . . . . . . . . . . . . . . . . . . . . . 8DÐ548
Connector List . . . . . . . . . . . . . . . . . . . . . . . . 8DÐ550
Page 2619 of 3573

8DÐ26 WIRING SYSTEM
Fuse Box
This illustration is based on RHD
C/B-1 C/B-2
C-10
C-20C-9 C-8 C-7 C-6 C-5 C-4 C-3 C-2 C-1
C-19 C-18 C-17 C-16 C-15 C-14 C-13 C-12 C-11
C-21 C-22 C-23 C-24
FUSE BOX
RHDNo.
C-1
C-2
C-3
C-4
C-5
C-6
C-7
C-8
C-9
C-10
C-11
C-12
C-13
C-14
C-15
C-16
C-17
C-18
C-19
C-20
C-21
C-22
C-23
C-24LHD
10A STARTER RELAY
15A SEAT HEATER
10A TURN, BACK
10A ELEC. IGN.
15A FRT WIPER AND WASHER
10A RR WIPER AND WASHER
10A H/LAMP WIPER
15A ENGINE
15A IGN. COIL (GASOLINE)
15A FUEL CUT (4JG2)
10A METER, GAUGE
10A AUDIO, MIRROR
20A CIGARETTE
10A ANTI-THEFT
15A STOP, A/T CONT.
20A TELEPHONE
10A CLOCK, ROOM
25A RR DEFOG.
20A DOOR LOCK
25A BLOWER
10A AIR CON.
10A SRS-110A STARTER RELAY
15A SEAT HEATER
10A TURN, BACK
10A ELEC. IGN.
15A FRT WIPER AND WASHER
10A RR WIPER AND WASHER
10A H/LAMP WIPER
15A ENGINE
15A IGN. COIL (GASOLINE)
15A FUEL CUT (4JG2)
10A METER, GAUGE
10A AUDIO, MIRROR
20A CIGARETTE
10A ANTI-THEFT
15A STOP, A/T CONT.
20A TELEPHONE
10A CLOCK, ROOM
25A RR DEFOG.
20A DOOR LOCK
25A BLOWER
10A AIR CON.
10A SRS-1 FUSE
RHDNo.
C/B-1
C/B-2LHD
30A P/W, P/S, S/R 30A P/W, P/S, S/R—— CIRCUIT BREAKER
—
—
——
—
—
810RV026