brake JEEP COMMANDER 2008 1.G Repair Manual

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission MopartATF+4 Automatic Transmission Fluid
Transfer Case (NV140 Single Speed
Only)MopartATF+4 Automatic Transmission Fluid
Transfer Case (NV245 Two Speed
Only)MopartNV 247/245 Transfer Case Lubricant
Axle Differential (Front-Rear) MopartSynthetic Gear & Axle Lubricant SAE 75W-140 (API-GL5) or
equivalent with friction modifier additive.
Brake Master Cylinder MopartDOT 3 Brake Fluid, SAE J1703 should be used. If DOT 3, SAE
J1703 brake fluid is not available, then DOT 4 is acceptable. Use only rec-
ommended brake fluids.
Power Steering Reservoir This system requires the use of MopartHydraulic System Power Steering
Fluid (P/N 05142893AA) or equivalent, which meets DaimlerChrysler Ma-
terial Standard MS-10838.
MAINTAINING YOUR VEHICLE 437
7

²Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
²Under no circumstances should oil change intervals
exceed 6,000 miles (10,000 km) or 6 months, whichever
comes first.
Your dealer will reset the oil change indicator message
after completing the scheduled oil change. If this sched-
uled oil change is performed by someone other than your
dealer the message can be reset by referring to the steps
described under ªOil Change Requiredº in ªUse Factory
Settingsº of the EVIC section in this manual.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and other electrical items for correct
operation.
MAINTENANCE SCHEDULES 441
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

At Each Oil Change
²Change the engine oil filter.
²Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
NOTE:** Vehicles built with the 4.7L engine are
equipped with sixteen spark plugs, one set is located on
the top of the engine under the coils and the second set is
located on the side of the engine.
The spark plugs located under the coils are a standard
plug and must be change every 30,000 miles (50 000 km)
The spark plugs located on the side of the engine are a
premium plug and must be changed every 102,000 miles
(170 000 km).
442 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change the engine oil and engine oil filter. 6,000 10 000 6
Rotate tires. 6,000 10 000 6
If using your vehicle for any of the following: Dusty
or off-road conditions. Inspect the engine air cleaner
filter, replace if necessary.12,000 20 000 12
Inspect the brake linings, replace if necessary. 12,000 20 000 12
Inspect the front & rear axle fluid, change if using
your vehicle for police, taxi, fleet, off-road or frequent
trailer towing.18,000 30 000 18
Inspect the CV joints. Perform the first inspection at
12,000 miles (20 000 km) or 12 months.24,000 40 000 24
Inspect exhaust system. Perform the first inspection at
12,000 miles (20 000 km) or 12 months.24,000 40 000 24
Inspect the front suspension, tie rod ends and boot
seals, replace if necessary.24,000 40 000 24
MAINTENANCE SCHEDULES 443
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake System)............188,302
Adding Fuel........................... 341
Adding Washer Fluid..................... 177
Adjustable Pedals....................... 135
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 393
Air Conditioner Maintenance............... 397
Air Conditioning........................ 259
Air Conditioning, Operating Tips............ 269
Air Conditioning, Rear Zone................ 267
Air Conditioning Refrigerant............... 398
Air Conditioning System.................. 259
Air Filter.............................. 393
Air Pressure, Tires....................... 316
Airbag................................ 48
Airbag Deployment....................... 55
Airbag Light.......................57,71,188
Airbag Maintenance....................... 57
Alarm, Panic............................ 24
Alarm (Security Alarm).................20,189Alarm System (Security Alarm)............... 20
Alignment and Balance................... 321
Alterations/Modifications, Vehicle............. 9
Antenna, Satellite Radio................... 250
Antifreeze (Engine Coolant)................ 435
Disposal............................ 405
Anti-Lock Brake System (ABS)............139,302
Anti-Lock Warning Light.................. 188
Anti-Theft System.....................20,189
Appearance Care........................ 415
Assist, Hill Start........................ 148
Audio Systems (Radio).................... 239
Auto Down Power Windows................ 32
Automatic Dimming Mirror................. 78
Automatic Door Locks..................... 29
Automatic Headlights.................... 126
Automatic Temperature Control (ATC)......... 260
Automatic Transmission................283,411
Adding Fluid......................... 412
458 INDEX

Fluid and Filter Changes................. 411
Fluid Level Check................... 411,412
Fluid Type........................... 411
Special Additives...................... 414
Torque Converter...................... 288
Autostick............................. 285
Auxiliary Electrical Outlet (Power Outlet)...... 169
Auxiliary Power Outlet................... 169
Battery............................... 395
Emergency Starting..................... 374
Keyless Transmitter Replacement (RKE)....... 25
Saving Feature (Protection)............... 125
Belts, Drive............................ 392
Belts, Seat.............................. 39
Body Mechanism Lubrication............... 399
B-Pillar Location........................ 311
Brake Assist System...................... 141
Brake Control System, Electronic............. 139Brake System........................... 407
Anti-Lock (ABS)....................139,302
Hoses.............................. 408
Master Cylinder....................... 408
Parking............................. 300
Warning Light........................ 187
Brake/Transmission Interlock............... 283
Break-In Recommendations, New Vehicle........ 69
Bulb Replacement.....................427,428
Calibration, Compass..................... 204
Camera, Rear........................... 157
Capacities, Fluid........................ 435
Caps, Filler
Fuel................................ 341
Radiator (Coolant Pressure)............... 404
Car Washes............................ 415
Carbon Monoxide Warning...............70,337
Cargo Area Features...................... 174
INDEX 459
10

Electronic Brake Control System............. 139
Anti-Lock Brake System................. 139
Brake Assist System.................... 141
Electronic Roll Mitigation................ 142
Electronic Stability Program............... 143
Traction Control System................. 140
Electronic Roll Mitigation (ERM)............. 142
Electronic Speed Control (Cruise Control)...... 136
Electronic Stability Program (ESP)............ 143
Electronic Throttle Control Warning Light...... 194
Electronic Vehicle Information Center
(EVIC).............................192,195
Emergency, In Case of
Freeing Vehicle When Stuck............... 289
Hazard Warning Flasher................. 366
Jacking............................. 368
Jump Starting......................... 374
Tow Hooks.......................... 377
Emission Control System Maintenance......386,440Engine
Air Cleaner.......................... 393
Block Heater......................... 280
Break-In Recommendations................ 69
Compartment...................382,383,384
Compartment Identification.........382,383,384
Cooling............................. 401
Exhaust Gas Caution................38,70,337
Fails to Start.......................... 279
Fuel Requirements..................333,435
Multi-Displacement..................... 306
Oil ..............................389,435
Oil Change Interval.................... 390
Oil Disposal.......................... 391
Oil Filter............................ 391
Oil Filter Disposal...................... 391
Oil Selection.......................... 435
Oil Synthetic......................... 391
Overheating.......................... 367
462 INDEX

Battery Saver......................... 125
Brake Assist Warning.................152,193
Brake Warning........................ 187
Bulb Replacement...................... 428
Center Mounted Stop................... 434
Courtesy/Reading..................... 130
Cruise.............................. 193
Daytime Running...................... 128
Dimmer Switch, Headlight.............124,129
Electronic Stability Program (ESP)
Indicator........................152,189,193
Electronic Throttle Control Warning......... 194
Fog ..........................128,194,431
Four-Wheel Drive Indicator............... 193
Fuses............................... 419
Hazard Warning Flasher................. 366
Headlight Switch...................... 125
Headlights........................... 428
Headlights On With Wipers............... 126High Beam Indicator.................... 187
Illuminated Entry....................... 21
Instrument Cluster..................125,127
Interior..........................127,130
Lights On Reminder.................... 128
Low Fuel............................ 195
LowTire ............................ 190
Malfunction Indicator (Check Engine)........ 187
Oil Pressure.......................... 189
Passing............................. 129
Reading............................. 130
Rear Servicing........................ 432
Rear Tail............................ 432
Seat Belt Reminder..................... 193
Security Alarm (Theft Alarm).............. 189
Service.............................. 428
Service Engine Soon (Malfunction Indicator) . . . 187
Side Marker.......................... 432
SmartBeams.......................... 126
INDEX 467
10

Tire Pressure Monitoring (TPMS)........... 190
Tow/Haul Indicator.................... 192
Traction Control....................152,189
Turn Signal..................124,129,430,432
Vanity Mirror.......................... 81
Voltage............................. 195
Load Floor, Cargo....................... 174
Loading Vehicle......................... 344
Tires ............................... 311
Locks................................. 28
Automatic Door........................ 29
Child Protection........................ 30
Door................................ 28
Power Door........................... 29
Lower Anchors and Tether for CHildren
(LATCH)............................64,65
Lubrication, Body....................... 399
Luggage Rack (Roof Rack)................. 177
Lumbar Support........................ 109Maintenance Free Battery.................. 395
Maintenance Procedures................... 389
Maintenance Schedule.................... 440
Malfunction Indicator Light (Check Engine) . . 187,386
Manual, Service......................... 452
Master Cylinder (Brakes).................. 408
Memory Feature (Memory Seat)............. 118
Memory Seat........................... 118
Memory Seats and Radio.................. 118
Mini-Trip Computer...................... 200
Mirrors................................ 78
Automatic Dimming..................... 78
Electric Powered....................... 80
Electric Remote........................ 80
Exterior Folding........................ 80
Heated.............................. 81
Outside.............................. 79
Rearview............................. 78
Vanity............................... 81
468 INDEX

Overheating, Engine...................192,367
Owner's Manual (Operator Manual).......... 452
Paint Care............................. 415
Paint Damage.......................... 415
Panic Alarm............................ 24
Park Sense System, Rear................... 153
Parking Brake.......................... 300
Passing Light........................... 129
Pedals, Adjustable....................... 135
Personal Settings........................ 205
Pets.................................. 69
Pets, Transporting........................ 69
Phone, Cellular.......................... 82
Phone, Hands-Free (UConnectŸ)............. 82
Placard, Tire and Loading Information......... 311
Polishing and Waxing..................... 415
Port
Universal Serial Bus (USB)................ 239USB ................................ 239
Power
Distribution Center (Fuses)............... 422
Door Locks........................... 29
Inverter............................. 170
Lift Gate............................. 36
Mirrors.............................. 80
Outlet (Auxiliary Electrical Outlet).......... 169
Seats............................... 110
Steering..........................305,398
Sunroof............................. 165
Windows............................. 31
Pregnant Women and Seat Belts.............. 47
Preparation for Jacking.................... 370
Pretensioners
Seat Belts............................. 46
Programmable Electronic Features............ 205
Programming Transmitters (Remote Keyless
Entry)................................. 21
470 INDEX