transmission fluid filter JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide GRAND CHEROKEE 2002 WJ / 2.G JEEP JEEP https://www.carmanualsonline.info/img/16/7175/w960_7175-0.png JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide

Page 1538 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide CONDITION POSSIBLE CAUSES CORRECTION
SHIFTS DELAYED OR
ERRATIC (SHIFTS
ALSO HARSH AT
TIMES)1. Fluid Level Low/High. 1. Correct fluid level and check for leaks if low.
2. Fluid Filter Clogged. 2. Repla

Page 1540 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide CONDITION POSSIBLE CAUSES CORRECTION
BUZZING NOISE 1. Fluid Level Low 1. Add fluid and check for leaks.
2. Shift Cable Mis-assembled. 2. Route cable away from engine and bell
housing.
3. Valve Body Mi

Page 1560 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide (32) Install valve body as follows:
(a) Align and carefully insert park rod into pawl.
Rod will make click noise as it enters pawl. Move
rod slightly to check engagement.
(b) Align and seat valve body

Page 1575 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide PRESSURE TEST
Overdrive clutch Fourth gear only Pressure should be 469-496 kPa (68-72 psi) with
closed throttle and increase to 620-896 kPa (90-130
psi) at 1/2 to 3/4 throttle.
Line pressure (at
accum

Page 1584 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide (8) Engine starts must be possible with shifter
lever in PARK or NEUTRAL gate positions only.
Engine starts must not be possible in any other gate
positions other than PARK or NEUTRAL.
(9) With shifte

Page 1586 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide REMOVAL
(1) Hoist and support vehicle on safety stands.
(2) Remove transmission fluid pan and filter.
(3) Disengage wire connectors from pressure sen-
sor and solenoid (Fig. 75).
(4) Remove screws hol

Page 1587 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide (6) Push pressure sensor into governor body.
(7) Lubricate o-ring, on pressure solenoid, with
transmission fluid.
(8) Align pressure solenoid to bore in governor
body (Fig. 80).
(9) Push solenoid into

Page 1588 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide (3) Install new oil seal in housing using Seal
Installer C-3995-A (Fig. 84).
EXTENSION HOUSING SEAL
REMOVAL
(1) Raise vehicle.
(2) Mark propeller shaft and axle yoke for align-
ment reference.
(3) Dis

Page 1589 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide (1) A result of restricted fluid flow through the
main and/or auxiliary cooler. This condition is usu-
ally the result of a faulty or improperly installed
drainback valve, a damaged main cooler, or se

Page 1590 of 2199

JEEP GRAND CHEROKEE 2002 WJ / 2.G User Guide PROCEDURE TWO
(1) Start engine and apply parking brake.
(2) Shift the transmission into DRIVE for approxi-
mately 2 seconds.
(3) Shift the transmission into REVERSE for
approximately 2 seconds.
(4) Sh
Page:   < prev 1-10 11-20 21-30 31-40 41-50 50 next >